2015 Ford Escape Fuel System Problems

My 2015 Ford Escape experienced sudden power loss while trying to proceed at a Stop Light in Irving, Texas on [XXX}. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Coolant leaking into cylinder causing misfire. The reason why the coolant is leaking into the chamber is because of a manufacturers defect. The engine block has impurities that eventually rusted away causing pinholes between the cylinder and coolant. This is a well known issue with mechanics. If someone has this issue and does not know the engine can seize or blow causing the engine to not work. If this happens while on a highway the potential for an accident goes way up. Please make Ford make this right. I have had this defect verified by a certified Ford dealership and two independent mechanics. This is a costly repair due to the entire engine being defective from the bad casting.

Malfunctioning Canister Purge Valve. There was a recall for the Ford Focus but not the Escape. We have an Escape in the same date range as the Focus recall and are having the same issue. Our Purge Valve is malfunctioning and needs to be replaced.

The vehicle has completely shut off while driving on several occasions now. The first time it happened we had it towed and ended up replacing the battery. The 2nd time we put it back to park and restarted the vehicle and assumed it was just a fluke. It has happened 2 more times now within the last few weeks and it is a very serious concern. Mechanics have no idea what is happening or what's causing the issue. I have done some research and it seems this is a common issue with this vehicle. There needs to be a recall/fix for this problem as it could cause an accident and cost someone their life. We do not feel safe driving the vehicle anymore.

The contact owns a 2015 Ford Escape. The contact stated that she was unable to refuel the vehicle. The contact stated that upon inserting the nozzle, the gas pump stopped pumping continuously. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that fuel tank solenoid was filled with dirt. Additionally, the fuel tank assembly and related parts needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 54,000.

I was driving all of a sudden I hear a loud noise in the rear passenger side. Then the car stalled in the middle of the road. I let it sit for a minute it will start up. The next day check engine light came on went to the auto part store they read the code... P1450 fuel tank vacuum. I've seen where Ford focus had this issue and a recall was issued, also people with the same vehicle as me had or having the same issue. This very dangerous especially if you driving on the highway. Good thing I was on a side road. A recall needs to be issued for this. Have not had repaired yet. It's the holiday weekend. I uploaded the pic of the code

Our 2015 Escape is having the same problem as the recall recently released for the 2020-23 models. We are getting terrible fuel smell inside the vehicle. Getting unsafe to drive.

As I was slowing my vehicle died without warning, I had to quickly put in park to restart. Everything died. The car did restart but I almost got reared from the car behind me. I have heard like a roaring sound at times comming from the back area. I keep gas at no less the 1/4 tank so I know the gas is fine. My engine light come on and go off after awhile, now my ABS and AWD and On Hill Start is deactivate is comming on. I’m 65 and I had hoped this would be a safe vehicle for me, with very few problem but it looks like this is not the case. I have only had this vehicle 3 months I need your help to resolve this issue Please. Thank You

While driving I hear a pump sound and my car will die , I stop traffic all behind me until I can get it started again

Car won’t start after filling with fuel

CAR IS LOSIING PRESSURE AND SEEMING LIKE ITS GOING TO STALL WHILE IN MOTION. IT JUST HAPPENS RANDOMLY. THERE WAS A RECALL ON THIS VERY PROBLEM BACK IN 2015 BUT THE FORD DEALERSHIP SAYS ITS NOT COVERED. UPDATE- THE DEALERSHIP IS SAYING ITS THE PURGE VALVE BUT ARE STILL SAYING ITS NOT COVERED UNDER THE 2018 RECALL

INITIALLY THE CAR WOULD SHIFT HARD WHICH THEN WOULD LOOSE POWER, HESITATE, THEN STALL. AFTER STALLING WOULD NOT START. THE PROBLEM HAPPENS SEEMINGLY INTERMITTENTLY. THE FORD DEALER REPLACED THE FUEL SENSOR, BUT WITH IN A YEAR THE SAME THING HAPPENED. THE FUEL SENSOR WAS AGAIN REPLACED A SECOND TIME AND IN LESS THAN 6 MONTHS IT HAPPENED AGAIN. INITIALLY IT SEEMED LIKE IT WAS THE TRANSMISSION, BUT THEN IT FEELS LIKE THE FUEL IS NOT BEING INJECTED PROPERLY WHILE IN MOTION AND AFTER STOPPING.

I WAS DRIVING TO PICK UP SOME DINNER FOR ME AND MY WIFE WHEN A HUMMING NOISE CAME ON FROM THE BACK PASSENGER SIDE OF THE VEHICLE. AS I SLOWED DOWN THE CAR SHUT OFF. THE HUMMING NOISE IS NOT THE FIRST TIME I HAVE HEARD IT. NOT ONLY THAT EVERY TIME I REFUEL MY VEHICLE IT STRUGGLES TO START WHICH I HAVE TO GIVE IT GAS TO TURN OVER.

The contact owns a 2015 Ford Escape. The contact stated that while his wife was driving approximately 35 MPH, the vehicle would experience a sudden surge in engine revs then immediately began operating like the engine was misfiring and the vehicle would eventually stall. The contact stated that his wife noticed that the check engine warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed and determined that the evaporator purge cannister valve needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was taken to the same dealer and diagnosed with the same failure but was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000.

TL* THE CONTACT OWNS A 2015 FORD ESCAPE. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE FUEL TANK HAD A VACUUM EFFECT AND THE FILLER NECK WAS REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO DOGGETT FORD (9225 NORTH FWY, HOUSTON, TX 77037, (800) 801-9906) WHERE IT WAS DIAGNOSED THAT THE CANISTER PURGE VALVE FAILED. THE CONTACT DISCOVERED THAT THE MANUFACTURER ISSUED AN UNKNOWN RECALL ON THE FORD FUSIONS, BUT NOT THE FORD ESCAPES EVEN THOUGH THE FAILURES WERE THE SAME. THE MANUFACTURER STATED THAT THERE WAS NO RECALL AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 79,000.

CAR WAS PUT IN PARK, THE ENGINE WAS THEN TURNED OFF. THE KEY WAS REMOVED AND THE VEHICLE BEGIN TO ROLL WHILE EXITING THE CAR. DISPLAY SHOWS GEAR POSITION IS IN D.THE PHYSICAL POSITION OF THE SHIFTER IS IN PARK.. APPEARS SIMILAR TO A RECALL FOR A SHIFTER BUSHING FOR 2013-2014 FORD ESCAPES.

I AM VERY ANGRY. I OWED THIS CAR LESS THAN TWO YEARS AND EVEN BOUGHT THE BODY WRAP AND POWERTRAIN BUMPER TO BUMPER WARRANTY YET THE PURGE VALE WENT BAD. FORD CALLS IT A VALVE YET THE MANUFACTURER OF THE PART CALLS IT A TUBE, SO THE WARRANTY WILL NOT COVER IT. I SEE THIS VERY PART IS THE SAME FOR THE FORD FUSION FOR THE SAME YEAR, YET ITS NOT COVERED WITH A RECALL....WHY.

2015 FORD ESCAPE STALLING IN TRAFFIC. MY CAR THAT HAS LESS THEN 60K MILES ON IT STALLED IN TRAFFIC 2X IN THE PAST 14 DAYS. I WAS TRANSPORTING PASSENGERS THE FIRST TIME THROUGH DOWNTOWN DENVER AND THE CAR JUST STOPPED RUNNING. I HAD IT TOWED TO THE DEALERSHIP WHERE THEY HAD IT 5 DAYS AND FIXED THE FUEL PRESSURE SENSOR. I PICKED UP THE CAR AND IT HAD NEW ISSUES, AS WELL AS THE ORIGINAL PROBLEM. I WAS DRIVING IT LESS THEN 24 HOURS LATER MERGING ON THE HIGHWAY WITH PASSENGERS IN MY CAR AND IT JUST STOPPED RUNNING. THE CAR HAS BEEN BROKEN DOWN FOR 12 DAYS NOW.

The contact owns a 2015 Ford Escape. The contact stated that while driving at various speeds, the vehicle would shudder and then stall with the check engine warning light illuminated. The contact also stated that the vehicle would drain fuel at a rapid pace and that a loud, humming sound was coming from the engine while driving. The contact had taken the vehicle to an independent mechanic who replaced the fuel pump however, despite the repair, the failure persisted. The contact had called a dealer in her area and was informed that they could not offer any assistance. The manufacturer had also been notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was unknown.

MY FORD ESCAPE 2015 WAS STALLING ONLY AT LOW SPEEDS DIAGNOSTICS AT THE FORD DEALER SHOWED NOTHING. TOOK TIME TO GET BACK TO THE DEALER FOR SECOND TIME--THE DEALER WAS NOT HONEST WITH US. I TOOK COMPLAINTS FROM OTHER ESCAPE OWNERS THAT WAS HAVING STALLING PROBLEMS. IT WAS A NIGHTMARE IN THAT CAR NOT KNOWING IF IT WAS GOING TO STALL AT HIGHER SPEEDS. LUCK WAS WITH US THE DEALER FOUND THE PROBLEM (1 BU5Z*9F972*B SENSOR FUEL INJECTOR) AT MY COST. I WOULD NOT RECOMMEND A FORD TO ANYONE. ON MANY JEFT TURNS IT STOPPED ON CITY STREETS.