2017 Ford Escape Complaint Log

The contact owns a 2017 Ford Escape. The contact stated that while the vehicle was parked, while attempting to leave the residence, the vehicle made an abnormal sound. The contact stated that the check engine warning light was illuminated. The vehicle was driven to a dealer to be diagnosed. The contact was informed that there was coolant intrusion into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.

The vehicle lost power while driving nearly causing a rear end collision. There was no warning when incident occurred. Check engine light illuminated with code for misfire on number 1 cylinder and misc misfire. After this happened I’m constantly adding coolant to engine. When I first start the vehicle coolant smell and steam from tail pipe. Did not take to dealership because of cost involved for verification and dealership said new engine would cost approx 10000.

Coolant intrusion due to design flaw...motor is skipping really bad and running extremely rough

The car only has 95k miles on it and i maintain it very well and the now i have a coolant cylender and i am going to need a new engine

Engine coolant is leaking into cylinder 2 After diagnosis from Goodyear, car was brought to Huntersville Ford where they ran their own diagnostics and obtained the same coolant leakage. The mgr there deemed the car undriveable. This is a known engine issue with 2017 Ford Escapes!

The contact owns a 2017 Ford Escape. The contact stated that while having the vehicle inspected, the check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that there was coolant intrusion into engine and the engine could be damaged. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that there was no warranty coverage on the vehicle. The contact was then referred to the NHTSA Hotline. The failure mileage was approximately 47,000.

The contact owns a 2017 Ford Escape. The contact stated while operating the vehicle, the message "Service Engine" was displayed. The vehicle was taken to the local mechanic to be diagnosed. The contact was informed that there was coolant inside the engine cylinders, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 67,245.

The contact owns a 2017 Ford Escape. The contact stated on several occasions while starting the vehicle, the check engine warning light illuminated. The contact stated that while driving on several occasions at various speeds, the vehicle was shaking violently before the vehicle lost motive power. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced due to coolant intrusion into cylinder #2. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

The contact owns a 2017 Ford Escape. The contact stated there was heavy white smoke coming from the exhaust pipe at start-up. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic and a dealer, and a diagnostic test was performed. The contact was informed that coolant had leaked into cylinder #2. The contact was informed by the dealer that the engine needed to be replaced. The contact's wife called the manufacturer and was referred to the NHTSA Hotline to report the failure. The vehicle was not repaired. The failure mileage was approximately 69,500.

The contact owns a 2017 Ford Escape. The contact stated that while cold starting the vehicle, the engine was idling roughly. The contact stated while driving approximately 30 MPH, the check engine warning light illuminated. The contact stated that the message “Stop Driving – Engine Overheating” was displayed and an audible chime was heard. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and retrieved DTC codes: P0302 and P0306; and determined that coolant was leaking into the engine block. The vehicle was not repaired. The contact then stated that while driving approximately 35 MPH, the "Stop Driving" warning light flashed on the instrument panel. The contact stated that the vehicle lost motive power and failed to accelerate above 10 MPH. The contact drove the vehicle back to the residence. The contact had not taken the vehicle to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to Technical Service Bulletin Number: 22-2134 Coolant Intrusion into the engine block (Engine and Engine Cooling). The manufacturer was not informed of the failure. The failure mileage was 70,517.

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The engine coolant system failed due to coolant intrusion into the engine cylinders, a known defect in the 1.5L EcoBoost engine. This caused white exhaust smoke, engine misfires, overheating, and eventual engine failure. The vehicle is currently undriveable and available for inspection upon request. A Ford dealership diagnosed the issue and provided a written estimate for full engine replacement. 2. How was your safety or the safety of others put at risk? The vehicle experienced loss of engine power, stalling, and overheating while driving, posing a significant safety risk on the road. There were instances where I felt unsafe continuing to drive the vehicle, and I was concerned about the possibility of engine failure while driving at highway speeds or in high-traffic conditions. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. The issue has been diagnosed and confirmed by Colorado Engine, which provided an $11,000 estimate for a complete engine replacement due to coolant intrusion. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been discussed with a certified Ford dealership. I have not involved police or insurance representatives at this time. 5. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Yes. Symptoms included: Low coolant warnings (despite no visible leak) White smoke from the exhaust Rough idling, engine shaking, and occasional stalling Intermittent engine overheating warnings These symptoms began in late May 2025, roughly 3 years after I purchased the vehicle from CarMax. The issues progressively worsened until the vehicle became undriveable.

Service engine light came on and I called Ford Service to get the car inspected. I had to wait a few days until there was an opening in the service department. I continued to drive car but engine stopped in the middle of my road while backing out of my driveway several times. I live on a busy street but luckily no cars when this happened. When Ford finally inspected vehicle I was informed that the engine needs to be replaced due to head gasket leaking into engine. I have an extended warranty but it won't cover replacing the engine because this is a known problem with these engines so a loop hole was written into warranty. The Ford service department indicated that this is a known factor for 2017 Ford Escapes and I am surprised there is no recall as my engine stopped while in the roadway.

My mom has always kept up all maintenance and car has never produced a check engine light. When driving to work the other day she started having engine problems. Had it immediately towed to the Ford dealership and they said the engine was blown. The technician says he sees it quite often on this model car from water leaking into engine. The technician tried to get ford to fix it but to no avail. The car has 54,000 miles on it and 3 months over the 7 year warranty. I see many other postings on this car and it is time for someone to do something. No car should only go 54,000 miles when well taken care of. Thanks

Engine are now failure due to coolant intrusion from the manufacturing defect in the cylinder walls. It is currently in the service department of 5 star ford in Dallas TX on president george bush turnpike. The coolant leak caused the engine to overheat and put my family’s life in danger while the vehicle was being operated on roadways. The failure has been confirmed by the dealership and they have refused to pay for the cost of the repairs. They are demanding that we pay $10000 for a new engine and have been unwilling to help in any way. Warning message did not appear until the engine was completely overheated and faulty.

The contact owns a 2017 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a misfire in cylinder #2. The contact was informed that the purge valve needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the dealer where it was diagnosed with engine and transmission failure. The contact was informed that the engine and the transmission needed to be replaced. The vehicle was being repaired. The contact was informed that the repair would take approximately three weeks. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 120,632.

I was driving down the road and my vehicle stalled out and had little to no acceleration Was stuck in the middle of an intersection until I could move it to a parking lot putting my safety at risk. Dealer (Brondes Ford Toledo) ran codes, yet would not tell me the codes after they tried to charge $11,000. No Warning lights yet, had engine lights on until the dealer replaced Fuel vapor assembly and crankcase pressure sensor a little less than 30 days beforehand. After service Ford said it was good to go and stated this could not have been related to the bushing already recalled.

UNKNOWN. 2017 Ford Escape transmission went bad at 70k miles. After the June 2022 recall by ford on the Escapes transmission, the issues went downhill since then. It cost $8k to replace the transmission or $7k to rebuild the transmission according to Ford. Ford knows its transmissions in the older model escapes are faulty yet still would charge consumers an arm and a leg to replace or rebuild it. An investigation should be conducted into this transmission issue regarding the 2017 Escape and other 2013 - 2019 Escape models. It is not right to rip off consumers.

The contact owns 2017 Ford Escape. The contact stated that the vehicle was experiencing excessive coolant consumption, and there was white smoke coming out of the exhaust pipe while starting the vehicle and while driving. Additionally, the contact stated that the engine was running rough, and the vehicle almost stalled while driving. The vehicle was taken to an independent mechanic, where the coolant hoses, the radiator cap, the spark plugs, the ignition coils, and other unknown parts were replaced; however, the failure persisted. The contact stated that while at a complete stop, the engine was running rough and the vehicle almost stalled. The contact stated that upon depressing the brake pedal and the accelerator pedal simultaneously, the contact was able to continue driving; however, the failure recurred and the vehicle almost stalled while decelerating. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The failure mileage was approximately 185,000.

2017 Ford Escape, only owner, just out of warranty. Service engine light came on and vehicle seemed to have an odd sound when first started in the mornings, took to dealership and was told cause was cylinder 4 misfire, had low coolant and the pressure test showed cooling system-coolant intrusion into cylinder 4. I was given an estimate of $7300 to replace short block per TSB 22-2322. My vehicle has a little less than 40,000 miles on it, and just had an oil change with inspection about a month and half ago with no issues found. Don’t know how I can have a cracked block with less than 40,000 miles. I believe this to be a factory defect, and have seen many other complaints online about the same issue. I did see that Ford had a recall for this same issue on the 2017 Ford Escape ecoboost.?.?.? I believe there should be a recall on my vehicle also. I have maintained my vehicle and do not drive it hard.

The contact owns a 2017 Ford Escape. The contact stated while driving 35-40 MPH, the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a misfire in the engine. The mechanic cleared the check warning light; however, the failure recurred while driving. The vehicle was taken to a local independent mechanic, where it was diagnosed with coolant intrusion into the engine. The mechanic determined that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 51,000.

The contact owns a 2017 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with timing belt, water pump, and engine failure. The contact was informed that the timing belt, the engine, and the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair was not covered under warranty or recall. The failure mileage was approximately 93,000.

I have a 2017 Ford Escape with a 1.5L engine. I bought the car 4 years ago certified pre-owned from a ford dealer. Four weeks ago I brought my car to another dealer (one that was recommended) because I was experiencing problems starting my car, a pop up message saying “Engine Fault - Service Now”, and some vibrations while driving the car. But no check engine light or any other problems. That ford dealer when I brought it in said they could not duplicate the problems I was expecting after 2 days of testing and gave the car back to me. Two weeks later and I get the same problems but worse. I start seeing some smoke coming from my exhaust when starting the car, engine light came on and the last straw was a pop up message saying “High Engine Temp - stop car safely” and the car would not excel over 12 mph. So I took it to my local mechanic since I could not drive it far and they said to bring it to my dealer because they thought I needed my Powertrain Control Module repaired. I had it towed to a new dealer (closer to me) than the first one who diagnosed it saying I needed my long block engine replaced due to a coolant intrusion. They said it would cost at least $10,000 and recommended I get rid of it and offered me $500 for them to buy it. After doing my research I can see that this is a huge problem with ford and that there were 2 customer stratification programs done to fix the issue. Luckily the dealer I purchased the car from completed the first customer satisfaction program 19B37 on July 15 2020 but did not complete customer satisfaction program 21N12 prior to me purchasing it because the car was not showing any problems. Now, my car is showing those problems but Ford has told me since my warranty expired 6 months ago I am no longer able to get the repair covered. But my mileage is way under the 84,000 mileage cap. I am planning to call the three dealers I have dealt with now to see if there is anything they can do for me. Any other advice would be greatly appr

My engine light went on Tuesday, [XXX], while driving on [XXX] in Los Angeles. The vehicle wouldn’t accelerate and the engine started to shake. Reducing my speed I was able to make it to my destination INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Escape. The contact stated that the vehicle was running roughly after a cold start. The contact stated that while driving at approximately 35 MPH the vehicle was losing power. The contact said when she depressed the accelerator pedal the check engine light was flashing and the vehicle was not gaining forward momentum. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the spark plugs needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was again exhibiting the same failure symptoms and was taken back to the same dealer. The dealer diagnosed the vehicle and determined that coolant had intruded into the engine block. The dealer recommended that the engine be replaced. The vehicle was not repaired. The contact had researched online and related the failure to a known problem with coolant intrusion into the engine block. The manufacturer was informed of the failure and referred the contact to the Safety Hot Line to file a complaint. The failure mileage was approximately 36,000.

The vehicle began idling rough when starting and was also blowing white exhaust smoke, which triggered an engine code. We took the vehicle to a local mechanic who ran the engine codes that had been pulled from the vehicle and determined that it was related to a TSB that involved coolant leaking into the engine possibly due to an intake manifold bolt backing out which caused damage due to coolant subsequently leaking into the engine. We took to our dealer who advised us that Ford will not do anything for us due to vehicle not being under warranty, even though this was an ongoing concern that Ford was aware of for quite some time.

The contact owns a 2017 Ford Escape. The contact stated that white smoke was coming from the exhaust pipe with several warning lights illuminated. The crankshaft position sensor, power control module short circuit sensor, and other warning lights are illuminated. The contact had reset the sensors however, the failure persisted. The contact stated that the coolant was leaking however, there was no location of the leak. The contact stated that driving and then shifting into the park(P), the vehicle went into LIMP Mode. The vehicle was returned to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer had referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 80,000.

Engine started misfiring, check engine light came on while driving on the highway. It was barely running, had to pull over 2 lanes to the narrow shoulder in traffic. No warning until it happened. Never had a check engine light before on this vehicle. P0302 misfire. Was told the engine needs to be replaced at 79,000. There was a recall for this exact problem yet my VIN was not included and i never got any mail stating this could happen.Very sudden and dangerous problem, lucky i was able to pull over out of traffic.

The contact owns a 2017 Ford Escape. The contact stated that while his son was driving approximately 65 MPH, the check engine warning light illuminated, the vehicle started losing motive power and stalled. The vehicle was later towed to the local dealer who diagnosed that the engine had failed due to coolant intrusion into cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 86,020.

On a routine drive, my 2017 Escape SE, traveling at 68 mph on cruise control made a quick thud sound and instantly became unresponsive to gas pedal depression, and immediately began to slow down from 68mph, rapidly slowing to 30-35mph with fast moving traffic behind me. My Escape and displayed an Engine light that flashed continuously, and I drifted over to the shoulder and came to a stop noticing the rough and choppy engine operation. upon the use of a general OBD II scanner, P0300, P0301, P0302, P0303 were displayed as the cause for the engine light illumination. The vehicle was towed to a repair shop (receipt attached) and the spark plugs, coils were replaced at a cost upwards of $500. Upon the Escape being returned to me and its initial 50 miles driven, once again the engine light illuminated and the code P0302, P0303 were read once again as well as “Multi cylinder misfires detected” The vehicle vibrated violently, and accelerated was deeply compromised resulting in a near miss accident from the rear, and subsequently not being able to accelerate through an intersection. This was another safety issue as opposing traffic in all directions were required to go around my disabled vehicle at risk of collision with my vehicle. Vehicle was then taken to a Ford authorized dealership for inspection and possible repairs. At that time I was informed coolant had been leaking into cylinder 2 & 3 causing continued and extensive damage to the internal working components of my 1.5L Ecoboost engine. The repair required and sugggested was a Long Block Replacement with an estimated cost of $10,000+, surpassing the value of the vehicle three times over. I took the vehicle home and parked it, and bought a 2018 Ford Escape, and was unable to use my 2017 Escape as a trade in as it was considered a worthless vehicle due to its disrepair. Ford knows about this issue and refused assistance or advice knowing this problem exists and affects most of their vehicle lineup

What component or system failed or malfunctioned, and is it available for inspection upon request? Engine developed a coolant leak into the cylinders, filling them with fluid and causing loss of engine power and constant misfires. How was your safety or the safety of others put at risk? Vehicle suddenly lost power while driving due to the engine overheating caused by running dry of coolant. Was able to maneuver car into a nearby parking lot. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Check engine light came on shortly before engine began overheating.

The contact owns a 2017 Ford Escape. The contact stated that on several occasions when started, the vehicle ran rough. The check engine warning light was illuminated. The vehicle was taken to an AutoZone where a handheld diagnostic machine determined a failure in cylinder #3. The vehicle was taken to an independent mechanic but was not diagnosed; however, the spark plugs were replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 88,700.

The contact owns a 2017 Ford Escape. The contact stated while the vehicle was parked, the contact noticed a failure with the engine while attempting to start the vehicle. The contact stated that the vehicle lost motive power with the check engine warning light illuminated. The vehicle was towed to the dealer where it was diagnosed as a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure a case was opened. The contact was referred to the NHSTA Hotline for assistance. The failure mileage was approximately 158,000.

I am having coolant leaking into my engine. This is a known issue and with only 60k miles I am already have that issue and it was confirmed by my local Ford dealer.

Engine was overheating, found out no coolant in overflow, no engine code shown, took to Ford dealership. They found system was clearing out the codes and found coolant leaking into engine. Was quoted 10, 661.29 to replace engine They said my engine wasn't covered under the current recalls on the engines that are leaking coolant into the engine. They know of this problem, but mine wasn't one of them I attached the receipt from Lasco Ford that has details on it. Please let me know if you weren't able to view the receipt. Thank you

The contact owns a 2017 Ford Escape. The contact stated while driving approximately 30 MPH, the vehicle was making abnormal sounds and was shaking abnormally. The contact stated that the engine hot message was displayed, and several unknown warning lights were flickering on and off. The contact was informed that the water pump and thermostat needed to be replaced. The vehicle was repaired; however, the failure occurred. The vehicle was driven back to the independent mechanic, and the contact was informed that the water pump needed to be replaced again. The vehicle was repaired; however, the failure reoccurred. The vehicle was driven back to the independent mechanic, and the contact was informed that there was fluid leaking from the bottom of the vehicle. The contact was informed that the radiator needed to be replaced and coolant added. The vehicle was repaired; however, the failure recurred. The contact stated that coolant was added constantly for the vehicle to operate as needed. The manufacturer was not notified of the failure. The failure mileage was approximately 70,600.

It has a known defect that causes coolant to leak into the engine's cylinders, which can cause corrosion, oil dilution, and contamination, which results in engine failure. Ford failed to disclose these defects creating a safety risk, because of the lack of coolant created by these leaks causes overheating, cylinder head cracking and engine failure, or engine fires. After the check engine light came on, the vehicle was inspected by the manufacturer, they then replaced the ignition coil and spark plug for the number 3 cylinder. They had to do this twice because upon leaving the dealership, the check engine light came on again and they said they could only use OEM parts. The 3rd time the engine light came on, it was inspected again by the manufacturer, it was then disclosed about the known defect that the coolant leaking into the engine's cylinders causes engine failure.

Engine coolant leak: Car has always been well maintain, but all of sudden I am starting to have a coolant leak. From what I have read it is very common and require a motor replacement.

The contact owns a 2017 Ford Escape. The contact stated that while the vehicle was idling in stop-and-go traffic, the check engine warning light illuminated, and the engine started running hot. The contact was able to pull over and check the coolant level and became aware that the coolant reservoir was nearly empty. The contact refilled the coolant reservoir, and the vehicle was taken to the dealer where it was diagnosed that there was coolant intrusion in cylinder #2, causing engine failure. The contact was informed that the engine needed to be replaced. The dealer informed the contact that the failure was related to the Technical Service Bulletin, NHTSA ID:10214126 (Engine and Engine Cooling); however, the VIN was not included. The contact was referred to the manufacturer. The manufacturer was made aware of the failure and confirmed that the VIN was not included in the TSB. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 88,000.

The engine was misfiring/car was jerking under light load acceleration causing the inability to maneuver the car as expected. The coolant temperature spiked causing me to have to pull over abruptly and this could have caused an accident. Ford knows that their 1.5L ecoboost motors suffer from a design flaw that causes the engines to fail from coolant intrusion into the cylinder but there has not been a formal recall for this issue. There were no CEL, only an message that said 'engine fault - service now"

The contact owns a 2017 Ford Escape. The contact stated while driving 25 MPH, the engine warning light illuminated. The vehicle hesitated and was slow to respond. The vehicle was taken to the local dealer, where it was diagnosed and determined that there was an indication of coolant intrusion in the engine. The vehicle was not repaired. The manufacturer was contacted, and the contact was informed that there was no recall coverage for the failure. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 52,533.

The contact owns a 2017 Ford Escape. The contact stated while driving 35 MPH, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who determined that coolant intrusion had damaged the engine. The contact was informed that the short block needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 78,000.

We have only had our 2017 Ford escape for less than two years. We are the second owners of the vehicle and have maintained its prestigious service record with none stating that the transmission was or is faulty. Woke up one morning, driving to work and all of a sudden I go to press the gas and it felt like I hit a brick wall. It was the scariest thing! My head almost hit the steering wheel!!! I was NOT expecting that at all! Took it to our mechanic on a trailer and they stated that the transmission did NOT even come up on the diagnostic computer. They informed me that they tested the fluid and that was OK. They called me to come pick it up. I told them there’s no way it’s OK because of what happened. My dad went and picked it up he was only a minute or two down the road and it happened to him . He called our mechanic back, put it back on my dad‘s trailer with help from a friend. Got it back to their service department and again hooked it up to the computer and it did not say the transmission. But with the mechanics expertise, it was the transmission. They also stated that for this particular vehicle you cannot “rebuild the transmission” it is a “throwaway transmission” and you have to buy a whole new one. This is a huge safety concern. Like I mentioned, it felt like hitting a brick wall. It just completely stopped with no indication that there’s even a transmission issue or signal on my dashboard and now this is going to cost about $7000 to replace. We have to get it fixed. When we purchased the vehicle a year and a half ago it was over $20,000. This is a major issue for me and my family because we will not be able to afford this, but this needs to get fixed somehow. If someone in your department can escalate this and give me a call I would greatly appreciate it. We can provide any documentation needed from two different Mechanic shops. The place where we bought it where I get it regularly maintained, and the mechanic that informed us that it is the transmission.

Barber Ford in Holland reported that the transmission has failed at 66,000 miles. Looking online this seems to be a common issue.

Coolant intrusion verified by Ford dealership (at 90k) which should fall in line with their recall but am being told to pay for repairs out of pocket. symptoms appeared around 36k miles and I took it to dealership to inspect and they told me they could not reproduce and could find no faults.

The lug nuts were swollen

The contact owns a 2017 Ford Escape. The contact stated that while the vehicle was parked and attempting to start the vehicle, the vehicle failed to respond as intended with the check engine warning light illuminated. The contact stated that several days later while attempting to start the vehicle, there was a considerable amount of white smoke coming from the exhaust pipe. The contact inspected the coolant reservoir and became aware that the coolant reservoir was empty. The contact refilled the coolant reservoir; however, two days later the coolant reservoir was empty again. The vehicle was taken to a local dealer where it was diagnosed with a coolant leak. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,000.

Coolant leaking into the cylinder compartment (cylinder 3) and Ford refuses to fix it even though it is a known issue. The service technician at the Ford dealership acknowledges that this is a widespread issue for the EcoBoost engines. There is a service bulletin that was put out but Ford acknowledging the issue https://static.oemdtc.com/TSB/MC-10214126-0001.pdf

The contact called on behalf of his daughter who owns a 2017 Ford Escape. The contact stated while driving at an undisclosed speed, the engine was misfiring. The contact stated that the failure persisted and the engine overheated. The contact was able to pull the vehicle to the side of the road, where white smoke was coming from the front of the vehicle near the engine compartment. The vehicle was taken to a local dealer where it was diagnosed with coolant intrusion into cylinder #1. The vehicle was not repaired and remained with the dealer. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.

Coolant leak causes miss fires should be a recall on this

The contact owns a 2017 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed with coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 46,000.