2001 Ford Excursion Engine Problems

TL* THE CONTACT OWNS A 2001 FORD EXCURSION. WHILE TRAVELING AT 70 MPH, THE SPEED BEGAN TO REDUCE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THREAD GAVE WAY ON THE MOTOR HEAD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.

#7 SPARK PLUG BLEW OUT OF THE SPARK PLUG HOLE. SPARK PLUGS WERE LAST REPLACED BY A LOCAL FORD DEALER IN 2011. INTERNET RESEARCH SHOWS THIS FAILURE AND DEFECTIVE CYLINDER HEADS TO BE COMMON IN THIS ENGINE, V-10 6.8L.

A SPARK PLUG BLEW OUT OF THE ENGINE. WHILE I REALIZE THAT THERE WAS NO COLLATERAL DAMAGE THIS TIME, MY TRUCK HAS NINE MORE OPPORTUNITIES TO DO IT AGAIN. MY DAUGHTER AND 4 YEAR OLD GRANDSON WERE STRANDED ON THE SIDE OF THE ROAD IN 32 DEGREE TEMPS. HER CELL PHONE HAD DIED AND SHE HAD TO WALK TO A PHONE (CHILD IN TOW). THERE IS ENORMOUS PROOF THAT THIS IS A RAMPANT PROBLEM WITH FORD ENGINES AND HAS COST CONSUMERS THOUSANDS OF DOLLARS TO REPAIR YET YOU CHOOSE NOT TO HOLD THEM LIABLE AND HAVE EVEN ALLOWED THEM TO COVER UP A PROBLEM. WHY? HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/FORD_SPARK.HTML HTTP://WWW.CONSUMERAFFAIRS.COM/NEWS04/2007/05/FORD_TECHS_SPARK_PLUGS.HTML *JS

THE SPARK PLUG BLEW OUT OF THE ENGINE. THIS CAUSES DAMAGE TO THE HEAD AND BLOW THE IGNITION COIL TO BITS. AFTER LOOKING ONLINE THIS APPEARS TO BE A VERY COMMON PROBLEM. *TR

TL* THE CONTACT OWNS A 2001 FORD EXCURSION. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V553000 (ENGINE AND ENGINE COOLING:ENGINE:DIESEL) AND WAS REPAIRED. AFTER THE REPAIR, THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

TL*THE CONTACT OWNS A 2001 FORD EXCURSION LIMITED. THE CONTACT STATED THAT THE VEHICLE STALLED, SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 07V553000 ( ENGINE AND ENGINE COOLING:ENGINE:DIESEL). THE DEALER WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE CONTACT WAS WAITING FOR A DIAGNOSTIC TESTING APPOINTMENT. THE MANUFACTURER WAS NOTIFIED AND ADVISED THE CONTACT TO CALL NHTSA. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 98,000.

I HAVE A FORD EXCURSION 2001 V10 WITH 123K I WAS SITTING AT A STOP LIGHT WITH VERY LITTLE ENGINE TORQUE AT THE TIME WHEN I HAD A "SPARK PLUG BLOW OUT" THE SPARK PLUG WAS BLOWN OUT OF THEIR HEAD AND IN TURN TOOK OUT THE COIL.. WHEN THIS HAPPENED IT FILLED THE ENGINE COMPARTMENT WITH GAS FUMES AND THE SPARK PLUG WAS STILL ATTACHED TO THE CABLE AND PROVIDING A SPARK. WITH THE SPARK I FEEL THERE COULD HAVE BEEN A FIRE IN THE ENGINE COMPARTMENT BUT BECAUSE I WAS ABLE TO TURN OFF THE TRUCK AS SOON AS IT HAPPENED THERE WAS NO FIRE. FORD KNOWS OF THIS PROBLEM BECAUSE THEY HAVE A REPAIR KIT WITH A INSERT TO PUT IN THE HEAD TO REPAIR IT. THE FORD DEALER REPAIRED IT AT A COST OF $344.18 BUT I WAS TOLD THAT THIS IS COMMON IN MOST OF THE TRITON ENGINES FORD HAS. I THINK THERE COULD HAVE BEEN A FIRE UNDER THE HOOD HAD IT NOT BEEN THAT I WAS SITTING AT A LIGHT AND TURNED IT OFF AS SOON AS IT HAPPENED. *TR

WHILE DRIVING ON A TWO-LANE COUNTRY ROAD AT APPROXIMATELY 40 MPH, A LOUD EXHAUST SOUND STARTED COMING FROM THE ENGINE. A VISUAL INSPECTION REVEALED THAT A SPARK PLUG HAD BEEN BLOWN COMPLETELY OUT OF THE ENGINE AND THE COIL AND WIRE HAD BEEN DAMAGED. TRUCK MUST BE TOWED TO DEALER FOR REPAIR. ONLINE RESEARCH REVEALS THIS TO BE AN EXTREMELY COMMON PROBLEM WHICH THE DEALER HAS FAILED TO ADDRESS OR REMEDY.

MY 2001 FORD EXCURSION EJECTED A SPARK PLUG FROM THE CYLINDER HEAD. THIS IS THE SECOND TIME THAT THIS HAS HAPPENED. AFTER RESEARCH, I HAVE LEARNED THAT THIS IS A COMMONG DEFECT. *TR

2001 FORD EXCURSION 5.4L TRITON V8. AT 89,000 SPARK PLUG BLEW OUT OF CYLINDER. IN SHOP NOW FOR FIX. I READ IT IS A HUGE ISSUE WITH FORD. *TR

FORD - SPARK PLUG BLOW OUT: YESTERDAY MY 2001 EXCURSION WITH A 5.4 TRITON V8 ENGINE BLEW A SPARK PLUG RIGHT OUT OF THE ENGINE. IT BLEW OUT WITH SUCH FORCE, THE BOOT AND CAP/ COIL SNAPPED IN TWO (THE SCREW IS STILL ON TIGHT). THE TREADS OF THE OLD PLUG HAVE NO (NONE, ZERO) SIGNS OF DAMAGE, SO HOW DOES A SPARK PLUG THAT IS SCREWED IN JUST BLOW OUT. OUR LOCAL MECHANIC STATES "THIS IS COMMON ON MANY FORD TRITON ENGINES. THE HEAD HEATS UP AND EXPANDS, SINCE THERE ARE MINIMAL THREADS HOLDING THE PLUG IN PLACE, DURING THE COMBUSTION CYCLE, THE PLUG JUST BLOWS COMPLETELY OUT." I THOUGHT HE WAS GIVING ME A LOAD OF NON-SENSE, THUS SIMPLY PREPARING ME FOR THE SURE TO BE HUGE UP-COMING BILL. HOWEVER, ONCE I RESEARCHED THIS ON-LINE, IT ONLY TOOK JUST A FEW MINUTES TO DISCOVER MANY, MANY PEOPLE HAVE EXPERIENCED THE SAME THING, ON SEVERAL DIFFERENT YEAR, MAKE AND MODEL VEHICLES INVOLVING FORD'S TRITON ENGINES. I HAVE ALWAYS BEEN A FORD GUY. I DEALT WITH THE CRUISE CONTROL ISSUE AND SUCH BUT THIS ONE TAKES THE CAKE. DURING THESE HARSH ECONOMIC TIMES FORD NEEDS TO STEP UP AND DO THE RIGHT THING OR THEY WILL NEVER SEE ME, ANY OF MY RELATIVES OR FRIENDS AT ANY OF THEIR DEALERSHIPS AGAIN! WE WILL GO ELSEWHERE AND LET FORD LEARN A THING OR TWO ABOUT A VERY VALUABLE LESSON REGARDING SIMPLE ECONOMICS CALLED "SUPPLY AND DEMAND" OR LACK THEREOF FOR ANY OF FORD'S PRODUCTS (CARS, TRUCKS, T-SHIRTS, LOGO STICKERS, ETC). FORD OWNERS EXPERIENCING THIS SAME ISSUE NEED TO STAND UP, BE HEARD AND MORE IMPORTANTLY TO HAVE THIS PROBLEM FIXED BY THOSE RESPONSIBLE FOR CREATING THE ISSUE - FORD! *TR

2001 FORD EXCURSION SHUTS OFF WHILE DRIVING OR STOPPED. IT WAS TAKEN TO LOCAL DEALER AND WAS TOLD THERE WERE NO RECALLS AND THAT EVERYTHING WAS FINE. THIS HAPPEN ON AVERAGE 2 A WEEK. FROM THAT POINT TO PRESENT. THE VEHICLE IS A PSD AND HAD ITS CSP REPLACE SEVERAL TIMES. THIS PROBLEM HAS HAPPEN WHILE STOPPED AT STOP LIGHT, DRIVING 65MPH, PULLING A TRAILER AND IS NOW PUTTING NEEDLESS PERSONS AT RISK. I HAVE PERSONALLY REPLACED THE CPS, THE VALVE COVER GASKETS, THE PCM HAS BEEN CHECKED AND THE DEALER STILL STATES THERE IS NOTHING WRONG WITH THE EXCURSION. *TR

TURNED CAR OFF, WENT INTO SCHOOL. WHEN WE CAME OUT IT WAS ON FIRE. VEHICLE IS TOTAL LOSS, ITEMS LOST NOT COVERED BY INSURANCE NO VEHICLE TO DRIVE AS INSURANCE HAS STILL NOT SETTLED CLAIM. *TR

TL*THE CONTACT OWNS A 2001 FORD EXCURSION. THE CONTACT STATED THAT THE VEHICLE WOULD FAIL TO START OCCASIONALLY. IN ADDITION, WHILE DRIVING BETWEEN 60-70 MPH, THE VEHICLE WOULD STALL. THE FAILURE OCCURS DURING NORMAL DRIVING OR CHANGING LANES. SOMETIMES THE VEHICLE WILL IMMEDIATELY RESTART. THE VEHICLE IS DIFFICULT TO PULL TO THE SHOULDER DUE TO THE LACK OF POWER STEERING AND BRAKES WHEN THE FAILURE OCCURS. THERE ARE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DIAGNOSE THE FAILURE. THE VEHICLE IS CURRENTLY AT THE DEALER. THE FAILURE MILEAGE WAS 100,000.

WE HAVE A 2001 EXCURSION, APPARENTLY ACCORDING TO THE LOCAL DEALERSHIPS OWNER, IT IS A COMMON PROBLEM FOR PLUG BLOWOUTS AND HEAD BLOWOUTS IN THESE V10 VEHICLES. IF THIS WAS THE CASE AND FORD MOTOR COMPANY ACTUALLY MAKES A SPECIAL REPAIR KIT FOR THESE ISSUES, WHY WERE THE CONSUMERS NOT NOTIFIED OF THIS DEFECT BY RECALL NOTICE? THIS ISSUE WILL COST UPWARDS OF 300$ OF WHICH WE DO NOT HAVE TO FIX, DUE TO FORDS ERROR IN REPORTING THIS DEFECT. WE SPOKE DIRECTLY TO THE OWNER OF A LOCAL FORD MOTOR COMPANY AND WERE TOLD THAT THIS IS A COMMON SAFETY ISSUE. *TR

ON AUG 29,2008 MY 2001 FORD EXCURSION CAUGHT ON FIRE I WAS NEVER CONTACTED MY A FORD DEALER OR MY INSURANCE COMPANY THAT THERE WERE A RECALL ON FORD SUV MY SUV ARE TOTAL LOST DUE TO THIS FIRE AS I LOOK UNDER FORD FIRE RECALL THERE ARE A RECALL ON FORD SUV DUE TO FIRE. *TR

FORD TRITON 6.8L V10 SPARK PLUG EJECTION FORD INSISTS THE PROBLEM IS DUE TO IMPROPER TORQUING OF NEW PLUGS OR ANY NUMBER OF OTHER REASONS. HOWEVER MANY PEOPLE HAVE HAD THE ORIGINAL FACTORY SPARK PLUGS EJECT FROM THE ENGINE, WHICH INDICATES THERE IS A DEFECT WITH THE ENGINE & CYLINDER HEAD DESIGN. *TR

SPARKPLUG BLEW OUT OF THE ENGINE HEAD WHILE DRIVING RESULTING IN A LOSS OF POWER AND VERY NOISY CONDITION. THIS IS THE SECOND TIME IN 6 MONTHS THAT I HAVE HAD THIS SAME PROBLEM. THE LAST TIME WAS OCTOBER OF 2007. THE TWO INCIDENTS DO NOT INVOLVE THE SAME CYLINDER OF THE ENGINE BUT THEY ARE ON THE SAME HEAD. THE REPAIR WILL COST ABOUT $500 DOLLARS AND COST ME THE LOSS OF MY VEHICLE FOR 2 DAYS. THIS IS AN ISSUE WITH ALL FORD 5.4L AND 6.8L ENGINES. MY BROTHER HAS A 5.4 V-8 AND HAS HAD THE SAME PROBLEM TWICE IN HIS VEHICLE. FORD IS AWARE OF THE CONCERN BUT REFUSES TO DO ANYTHING TO HELP BECAUSE IT INVOLVES SOMEWHERE AROUND 17 MILLION ENGINES AND IS NOT COST EFFECTIVE. IN MY ESTIMATION, IF FORD DOES NOT WANT TO ISSUE A RECALL, WHICH I CAN UNDERSTAND BECAUSE IT WOULD BE AN ASTRONOMICAL AMOUNT OF WORK AND MONEY, THEN THEY SHOULD AT LEAST BE REQUIRED TO HELP WITH THE COST OF THE REPAIR. THE ISSUE IS CAUSED BY THE DESIGN OF THE ALUMINUM HEAD AND THE AMOUNT OF THREADS. ONLY ABOUT THREE THREADS HOLD THE PLUG IN THE HEAD. *TR

2001 FORD EXCURSION V10. EXHAUST MANIFOLD BOLTS BREAKING ON BOTH BANKS OF ENGINE. RUST AND CORROSION LOOKS TO BE THE CAUSE. VEHICLE HAS ONLY 61,000 MILES ON IT. THIS IS A BIG PROBLEM WITH FORD V10 ENGINES AS THERE ARE MANY INSTANCES THAT CAN BE FOUND ON THE INTERNET. EXHAUST GASES CAN AND DO LEAK BECAUSE OF THE BOLTS BREAKING. THIS RELEASES UN-TREATED EXHAUST GAS INTO THE ATMOSPHERE, HYDROCARBONS AND NITRATES OF OXYGEN ARE THE WORST AND NORMALLY WOULD BE TREATED BY THE CATALYTIC CONVERTER. FORD WILL NOT REPAIR THE CONDITION UNDER ANY WARRANTY. I BELIEVE THAT THIS SHOULD BE A RECALL AS THE EFFECT OF THE PROBLEM IS A PUBLIC HEALTH ISSUE. *TR

I HAVE HAD TWO SPARK PLUGS EJECT FROM THE CYLINDER HEAD ON MY FORD EXCURSION. THE FIRST PLUG EJECTED ABOUT THREE MONTHS AGO. ON THE 24TH OF FEBRUARY 2008 A SECOND SPARK PLUG EJECTED THE CYLINDER HEAD. THE FIRST PROBLEM WAS REPAIRED AT A FORD DEALERSHIP, COSTING ME $350.00 TO REPAIR. I AM CURRENTLY WAITING FOR A FORD REPRESENTATIVE TO CONTACT ME ABOUT THE SECOND FAILURE. THE REASON THIS IS HAPPENING IS BECAUSE THERE ARE ONLY APPROXIMATELY THREE THREADS TAPPED INTO THE HEAD TO HOLD THE PUG IN. A TYPICAL CYLINDER HEAD USUALLY HAS AT LEAST 1/2 OF AN INCH OR ABOUT 7-8 THREADS TO HOLD THE PLUG IN. THIS IS, IN MY OPINION, AN ENGINEERING DEFECT WITH FORD BEING LIABLE FOR THE DEFECT FROM FACTORY. THERE IS A SAFETY HAZARD ASSOCIATED WITH THIS. WHEN THE SPARK PLUG EJECTS FUEL VAPOR IS BLOWN OUT OF THE SPARK PLUG HOLE DURING THE COMPRESSION STROKE. IF THE COIL PACK COMES APART, AS WAS THE CASE IN THE FIRST FAILURE, THAT FUEL VAPOR HAS THE POTENTIAL TO IGNITE AND CAUSE A FIRE. *TR