2000 Ford Expedition Visibility & Wipers Problems

WINDSHIELD LEAKS ONTO FUSE BOX & GEM MODULE, CAUSING ENGINE TO CUT OFF WHILE MOVING CREATING DANGEROUS SITUATION. *TR

2000 EDDIE BAUER EXPEDITION, THE PAINT ON THE HOOD HAS STARTED TO START CHIPPING AND STARTED PEELING OFF, THREE WEEKS AGO. THERE IS A HUGE DIFFERENCE IN THE PAINT ON THE HOOD AND THE PAINT ON THE REMAINDER OF THE VEHICLE. THIS VEHICLE HAS BEEN IN GREAT SHAPE, UNTIL I NOTICED THAT THE PAINT WAS COMING OFF. THE SOLUTION TO THIS SITUATION IS THAT IT IS GOING TO HAVE TO GO THE SHOP FOR THEM TO REPAINT ON THE HOOD. I HAVE NOT DONE ANYTHING ABOUT THIS AS OF YET. I HAVE SEEN WHERE FORD IS AWARE OF THIS MISTAKE IN DEFECTIVE PAINT AND THEY ARE NOT FIXING IT FOR CONSUMERS. *TR

ALL FOUR WINDOWS WOULD NOT GO DOWN ON VEHICLE. WENT TO CAR LOT TO HAVE IT CHECKED OUT. MECHANIC FIXED THE PROBLEM. WENT BACK TO WORK. I GOT OFF AT 5:00PM. WENT HOME AND PARKED THE VEHICLE. 2 HOURS LATER A NEIGHBOR TOLD ME THAT THE VEHICLE WAS ON FIRE AFTER BEING PARKED FOR HOURS. *TR

TL* THE CONTACT OWNS A 2000 FORD EXPEDITION. THE CONTACT STATED THE WINDSHIELD IS LEAKING, CAUSING WATER TO GET INTO THE ELECTRICAL SYSTEM AND MALFUNCTIONING EVERY ELECTRICAL COMPONENT. THE CONTACT CALLED THE MANUFACTURER REGARDING THE WINDOW WHO THEN CONTACTED THE DEALER, WHO STATED THE WINDOW SEAL AND COMPUTER NEEDS TO BE REPLACED. THE DEALER ALSO INFORMED THE TO CONTACT THEY CAN ONLY REPAIR A COMPONENT AT NO COST UNDER A RECALL. THE CONTACT STATED THE MANUFACTURER SHOULD BE RESPONSIBLE FOR THE REPAIRS BECAUSE THIS IS A KNOWN SAFETY ISSUE WITH THIS YEAR MAKE AND MODEL. THE FAILURE MILEAGE WAS 120,000.

TL*THE CONTACT OWNS A 2000 FORD EXPEDITION. WHILE DRIVING 45 MPH THE DAY AFTER A HEAVY RAINSTORM, THE BRAKES FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED. AFTER APPROXIMATELY 100 FEET, THE VEHICLE FINALLY CAME TO A STOP. THE CONTACT PROCEEDED TO HIS DESTINATION AND APPLIED THE BRAKES AGAIN, BUT THE SAME FAILURE RECURRED. WHILE DRIVING ON TWO SEPARATE OCCASIONS ON THE SAME DAY, TWO OTHER VEHICLES PULLED OUT IN FRONT OF HIM, WHICH ALMOST CAUSED A CRASH. THE FOLLOWING DAY, HE CALLED THE DEALER AND INFORMED THEM OF THE FAILURES AND WAS ADVISED TO BRING IN THE VEHICLE FOR REPAIR. THE DEALER STATED THAT THE CAUSE OF THE FAILURE WAS DUE TO WATER INTRUSION THROUGH THE WINDSHIELD, WHICH VOIDED THE WARRANTY. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COST OF THE WINDSHIELD DEFECT. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 95,000 AND CURRENT MILEAGE WAS 96,000.

IT STARTED THIS SUMMER IT HAD RAINED PRETTY GOOD WHILE I WAS OUT I CAME HOME A FEW HOURS LATER I GOT INTO THE VEHICLE I HEARD SOMETHING THAT SOUNDED LIKE SOMETHING WAS FRYING DOWN CLOSE TO THE BRAKES BUT I DIDN'T KNOW WHERE ,I COULD HEAR IT AND SMELL IT,I THOUGHT THE TRUCK WAS GOING TO BLOW UP,SO I DIDN'T DRIVE IT FOR A WHILE,(SCARED )ABOUT A WEEK OR SO I DECIDED TO TRY IT AND EVERYTHING WAS FINE,BUT AS SO AS IT RAINED IT STARTED ALL OVER AND I WENT ON WITH IT LIKE THAT UNTIL NOVEMBER WE WERE PLANNING A TRIP FOR THANKSGIVING AND WANTED TO BE SAFE ON THE ROAD ,SO WE PUT IT IN THE SHOP,NOVEMBER 2009 ,THE DISTRIBUTION BOX (PDB),ELECTRONIC MODULE(GEM)/FUSE BOX SHORTAGE,A GOOD WEEK LATER IT RAINED AND THE RADIO WENT OUT ,THEN THE TRUCK WOULDN'T START, I GOT TOAD HOME,CONTACTED THE MECHANIC,TO FIND OUT ITS NOT HIS FAULT(THE MECHANIC) ,ITS THE DEALERS FAULT(FORD) THE WATER IS COMING IN THROUGH THE WINDSHIELD SO I'M OUT OF POCKET FOR EXPENSES FOR PARTS AND LABOR AND THE PROBLEM IS NOT RESOLVED. *TR

DRIVER'S SIDE WINDOW ADJACENT TO THIRD SEAT (CARGO AREA) OF 2000 FORD EXPEDITION SHATTERED FOR NO APPARENT REASON; WINDOW WAS OPEN FOR VENTILATION PER DESIGN (TEMPERED GLASS WINDOW PIVOTS OPEN ABOUT 3" VIA ELECTRIC ACTUATOR). SPEED WAS 65 MPH UNDER CALM CONDITIONS, SMOOTH ROAD SURFACE. I INITIALLY BELIEVED I HAD SUFFERED A COMPLETE LEFT/REAR TIRE FAILURE AS THERE WAS A VERY LOUD "BANG" AND A LARGE AMOUNT OF DEBRIS HURLED INTO ADJACENT TRAFFIC LANE. APPROXIMATELY 1/4 OF THE VOLUME OF SHATTERED GLASS WAS HURLED INTO THE PASSENGER COMPARTMENT, PRIMARILY IN THE THIRD ROW. FORTUNATELY I WAS ALONE IN THE VEHICLE; ANYONE IN THIRD ROW WOULD HAVE, AT A MINIMUM, SUFFERED LACERATIONS AND LIKELY EYE INJURY. *JB

ELECTRICAL PROBLEMS ON 2000 FORD EXPEDITION. BLINKER LIGHTS INOP. SPEEDOMETER TUNING ON AND OFF, RADIO STATION/CLOCK LIGHTS DON'T WORK. RADIO SOMETIMES WONT WORK. REAR WINDSHIELD WIPERS DON'T WORK. *NM

MY 2000 FORD EXPEDITION HAS CAUSED US NUMEROUS HEADACHES AND NEAR ACCIDENTS AS A RESULT OF RAIN ENTERING THE VEHICLE DUE TO A DEFECTIVE WINDSHIELD INSTALLATION. ONCE THE RAIN WATER ENTERS THE DRIVER SIDE DASH PANEL ( UNDERSIDE ) AND COMES IN CONTACT WITH ELECTRICAL COMPONENTS MOUNTED THERE, NUMEROUS FAILURES OCCUR, SUCH AS : WINDSHIELD WIPERS QUIT WORKING, INTERIOR AND DASH PANEL LIGHTS FLASH ON AND OFF, AND EVENTUALLY QUIT WORKING. THE SAFETY SWITCH WHICH ALLOWS THE VEHICLE TO BE PLACED IN DRIVE WHILE DEPRESSING THE BRAKE ALSO FAILS ONCE THE VEHICLE IS TURNED OFF. THESE PROBLEMS ARE NOT JUST A NUISANCE, BUT A SAFETY HAZARD, AND AFTER SPEAKING TO OTHER EXPEDITION OWNERS AND READING NUMEROUS COMMON STORIES OF THE SAME PROBLEM, I FEEL THAT THIS IS A MANUFACTURER'S DEFECT AND SHOULD BE RECALLED AND REPAIRED ACCORDINGLY. IN CLOSING I WOULD LIKE TO STATE THAT MY WIFE WAS DRIVING ON A VERY BUSY INTERSTATE IN THE RAIN WHEN SHE EXPERIENCED OUR LATEST FAILURE. ALTHOUGH THERE WAS NO ACCIDENT, IT WAS DEFINITELY A CLOSE CALL, AND COULD HAVE BEEN POTENTIALLY FATAL. WE MAY NOT BE SO LUCKY THE NEXT TIME.... *JB

WATER IS LEAKING IN FROM THE WINDSHIELD ACCORDING TO THE DEALERSHIP. THE WATER IS THEN ENTERING THE VEHICLE AND AFFECTING THE FUSE BOX AND THE GEM MODULE. IT DOES VERY WEIRD THINGS TO THE ELECTRICAL COMPONENTS OF THE VEHICLE, WINDSHIELD WIPERS QUIT WORKING WHILE DRIVING DOWN THE ROAD, RADIO TURNS OFF ONCE VEHICLE IS PUT IN DRIVE, RUNNING LIGHTS DO NOT WORK, BATTERY DIES, JUST TO NAME A FEW THE LIST GOES ON AND THE CONSEQUENCES ARE VERY DANGEROUS IN SOME CASES. HAVE YOU EVER BEEN DRIVING DOWN INTERSTATE IN THE RAIN AND THEN ALL OF A SUDDEN HAVE NO WIPERS. LET ME TELL YOU NOT GOOD. THE DEALER WANTS AN ARM AND A LEG TO FIX IT, MONEY I DO NOT HAVE AFTER SPENDING 15K ON A VEHICLE. SO HELP ME ANYTHING HAPPENS AS A RESULT OF THE FAILURE AND THERE WILL BE A LAWSUIT. TAKE A LOOK AROUND ON THE INTERNET AND THERE ARE HUNDREDS MAYBE THOUSANDS COMPLAINING ABOUT THE SAME ISSUE. SOMETHING MUST BE DONE. *NM

DT*: THE CONTACT STATED THE AIR CONDITIONER BLOWER DID NOT DEACTIVATE, WHILE THE VEHICLE WAS ON OR OFF. THE DEALERSHIP DETERMINED THE WINDSHIELD HAD A LEAK, CAUSING WATER TO GET INTO THE GEM MODULE. THE WINDSHIELD AND GEM MODULE NEEDED TO BE REPLACED.

DT*: THE CONTACT STATED THE WINDSHIELD LEAKS WHEN IT RAINS AND WATER GETS INTO THE FUSE BOX CAUSING THE DASH LIGHTS TO ILLUMINATE. ALSO, THE FUSE BOX IS CORRODED AND RUSTING. THE DEALER DETERMINED THERE IS NO RECALL FOR THIS PROBLEM.

DT*: THE CONTACT STATED IN WET CONDITIONS THE VEHICLE SURGES. THE VEHICLE WAS TAKEN TO THE DEALERSHIP NUMEROUS TIMES FOR INSPECTION. THE DEALERSHIP DETERMINED THE WINDSHIELD WAS NOT THE CORRECT SIZE FOR THE VEHICLE WHEN MANUFACTURED. THE MANUFACTURER WAS ALERTED.

DT: CONTACT STATED WHENEVER IT RAINED 2000, FORD, EXPEDITION LEAKED RAIN WATER. THE RAIN LEAKED IN ON RIGHT SIDE OF THE VEHICLE AROUND THE BOTTOM OF THE WINDSHIELD ABOVE THE DRIVER'S DASHBOARD. THE LEAK SHUT OFF THE ELECTRICAL SYSTEM. THIS WAS OBSERVED ON JANUARY 2, 2006. THE VEHICLE HAS BEEN TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE CONTACT WAS TOLD BY THE MECHANIC THAT THIS WAS A MANUFACTURING DEFECT.*AK

I RECEIVED INFO FROM NHTSA THAT THERE ARE PERFORMANCE ISSUES REGARDING MY FORD EXPEDITION. THESE INCLUDE THE FAILURE OF REAR WINDSHIELD WIPER TO WORK AND FAILURE OF RADIO LIGHTS. *NM

I NOTICED WHEN EVER I DROVE MY CAR IN THE RAIN WATER WOULD LEAK ON MY RIGHT LEG AND FOOT, MY WIPERS, RADIO AND CLOCK WOULD STOP WORKING AND I HEARD A SIZZLING NOISE IN THE LEFT DASH AREA. I ALSO WAS UNABLE TO USE MY KEYLESS REMOTE, THE ALARM WOULD GO OFF EVERY TIME. I BROUGHT MY 2000 EXPEDITION TO HAYWARD FORD TO HAVE THEM CHECK AND REPAIR THE PROBLEM IN MARCH OF THIS YEAR. THEY COULD NOT FIND ANYTHING LEAKING, OR THE SIZZLING NOISE I HEARD IN THE DASH, HOWEVER THEY DID TELL ME THERE WAS A DAMAGED JUNCTION BOX AND KEPT MY CAR FOR 5 DAYS (THEY WERE WAITING FOR THE PARTS TO COME), WELL AFTER 5 DAYS OF HAVING A RENTAL THAT ALSO COST ME MONEY, I WENT AND PICKED UP MY EXPEDITION. IT MADE NO SENSE TO ME TO HAVE THE JUNCTION BOX REPLACED SINCE THEY COULD NOT FIND WHERE THE LEAKING PROBLEM WAS. ON JUNE 8, 2005 I BROUGHT MY EXPEDITION INTO ANOTHER FORD DEALER (THE FORD STORE SAN LEANDRO) HOPING THEY COULD FIND THE PROBLEM. WELL THEY FOUND THE PROBLEM, THEY SAID THE WINDSHIELD WAS LEAKING AND HAD CAUSED DAMAGE TO THE CENTRAL JUNCTION BOX AND GEM MODULE. THIS WAS ALSO WHY I WAS UNABLE TO USE MY KEYLESS REMOTE. I WAS ALSO INFORMED THAT THESE REPAIRS WERE NOT COVERED BY ESP WARRANTY. I WAS TOLD THAT THIS WAS A CIRCUMSTANTIAL ISSUE. THEY ALSO HAD TO REPLACE THE WINDSHIELD BECAUSE WHEN THEY REMOVED IT, IT BROKE. SO $1,327.78 AND EIGHT DAYS LATER MY EXPEDITION WAS REPAIRED. BUT WHEN THEY REPLACED THE WINDSHIELD, THEY SCRATCHED MY DASH BOARD IN TWO PLACES. HAVING READ AN ARTICLE ON CNN.COM, "FEDS PROBE FORD SUV WATER-LEAK REPORTS", I WOULD LIKE TO HAVE MY COSTS RE-IMBURSED,AS THIS SHOULD BE A RECALL ITEM.

2000 EXPEDITION HEATER BLOWER HAD TO BE MANUALLY TURNED OFF AFTER KEYS WERE REMOVED FROM IGNITION. WHEN ATTEMPTED TO START VEHICLE IT WOULD NOT START. *TS THE FUSE BOX WAS RUSTED, CORRODED AND FULL OF WATER. THIS WAS THE RESULT OF THE WINDSHIELD NOT BEING SEALED PROPERLY. *NM

I OWN 2000 FORD EXPEDITION. JUST FOUND OUT THE WINDSHIELD IS LEAKING, CAUSING WATER TO GET INTO FUSE BOX AND GEM MODULE UNDER DASH CAUSING MAJOR ELECTRICAL PROBLEMS. THE 4-WAY FLASHERS CAME ON WHILE DRIVING; THE BLOWER STAYED ON EVEN AFTER REMOVING THE KEY FROM THE IGNITION, ETC. HAD WINDSHIELD REPLACED TODAY AND IT ONLY TOOK 1 MINUTE TO BREAK THE SEAL. THE REPAIR GUY SAID IT SHOULD TAKE AT LEAST 20 MINUTES AND THAT IF WE WOULD HAVE HAD A WRECK THE WINDSHIELD WOULD HAVE FALLEN OUT. I'VE DONE EXTENSIVE RESEARCH ON INTERNET AND FOUND THIS IS A VERY COMMON PROBLEM IN 1997-2001 F150'S, EXPEDITIONS AND NAVIGATORS, BUT ESPECIALLY THE 2000 EXPEDITION. THE SEAL USED BY FORD AROUND THE WINDSHIELD DRY ROTS CAUSING THE LEAK. SERVICE MAN AT FORD ACKNOWLEDGED THE PROBLEM BUT SAYS NO RECALL HAS BEEN ISSUED. *AK

(1) DURING NORMAL OPERATION OF THE VEHICLE, THE INTERIOR POWER FAILED. I HAD NO WINDSHIELD WIPERS, NO RADIO, NO AC, AND NO CONTROL OVER POWER WINDOWS. (2) IT HAPPENED TO BE RAINING AND I HAD TO PULL THE VEHICLE OVER INTO A PARKING LOT SINCE THE WIPERS WOULD NOT WORK. I CHECKED THE FUSES AND ALL WERE IN WORKING ORDER. AFTER TURNING THE CAR OFF AND THEN ON AGAIN, I REGAINED ELECTRICAL POWER. (3) AUTO MECHANIC LOOKED AT VEHICLE AND ONLY DETERMINED THAT BATTERY COULD BE REPLACED. (4) PROBLEM HAS RETURNED AND CONTINUES TO OCCUR AT DIFFERENT TIMES. I TURN CAR OFF AND THEN BACK ON TO REGAIN ELECTRICAL POWER

WHEN I TURNED ON IGNITION WIPERS STARTED TO OPERATE WITHOUT BEING TURNED ON. SMOKE BEGAN BLOWING FROM VENT AREA. I TURNED OFF IGNITION AND ALL ELECTRICAL. WIPERS AND WASHER FAILED TO OPERATE. WIPER MOTOR CONNECTOR CAUGHT FIRE AND BURNT OUT WIPER MOTOR. REPAIRED AT "RON BORTNICK FORD" UPPER MARLBORO MD. 20772. *LA