2016 Ford Expedition Electrical System Problems

On Apil 6 about 6:15 am I was on my way to work. And I start smelling what appears to be a gas smell and I wasn’t quite sure what was coming from so I cracked the window a little bit and said that I would try to check it when I got to work seeing that I was only roughly about 10 minutes away from work and out the corner of my right eye I noticed a flicker of light and it appeared to be flames coming from the passenger side of my vehicle under the dashboard around the blow motor area and the fuse box panel. I immediately poured over, turned the car off and the heat off that I had on because it was cold that morning popped the hood to ensure there was no fire coming from the hood ran around to the passenger side, noticed there was flames coming from underneath and beside panel, where the fuse box was ran to the back of my truck grabbed about a water and attempted to pour bottle of water on the cover of the box where I saw the flames coming out heard the sizzle realize it was electrical fire so I stopped using the water at that point realized there was a SUV that pulled up next to me which was a off duty police officer he said he saw the smoke call for the fire department at that time. I grabbed some fiber tiles that I use when I’m washing my car. I bought a handful of those up and pulled the cover off the fuse box and I start padding out the fire until I was able to get the fire out. Fire department came assessed. The vehicle said that the fire was put out successfully didn’t see any more source of the fire they left the scene as well as the police officer contacted my insurance company. They told the vehicle to my residency. The insurance damage of investor came out on April 10 and assessed contacted me on April 13 and told me the vehicle was totaled and the root cause was the climate control blower motor They had caught fire and caused enough damage that it will be too expensive to repair the entire vehicle..

Blower motor which was under recall was repaired by dealership 4/18/25 continued to work intermittently following repair. As of inspection today, 10/2/2025 at same dealership, blower motor speed controller wiring harness/assembly has since gotten hot enough to melt wiring. Wiring assembly and speed controller must now be replaced by dealership at a cost of 352.56 which is not covered under the blower motor recall but should be.

Rear camera is inoperable or intermittent. It has been for over a year. Ford finally issued a recall notice I believe in September 2025. They have still not corrected the problem or even sent a letter confirming when it will be completed. I feel there should be reasonable time limit for them to repair my car.

Vehicle was taken to Chipola Ford for Blower Motor Recall April 2025 and was replaced under recall. Since then, the blower motor intermittently fails and and no air will come out of the dash. The wiring for the blower motor under the dash gets extremely hot when the blower motor fails.

Camera goes blank when backing up

The front AC stopped blowing and it got excessively warm in the cab. I thought it may be the blower motor and wanted to start with fuses. Under the hood was so hot that when I tried to pull our a fuse my nails melted. Since then, sometimes it blows sometimes it doesn't but it does seem to be emanating excess heat. I'm unsure of true date of occurrence as I just purchased the vehicle on

The Backup camera. It Shows that blue or in and out quickly causing it not to work most of the time. The 2015 has a recall for this exact thing but not 2016.

Rear-view camera is intermittently failing and often completely inoperative. Vehicle is under an active Ford safety recall for the rear-view camera, but there is currently no remedy available. The failure occurs while reversing and eliminates rear visibility, creating a clear safety risk of collision or injury to pedestrians or property. The issue has persisted without resolution despite the active recall. This vehicle is regularly driven and the defect materially impacts safe operation.

Rear camera fails intermittently. Phone stopped connecting through BlueTooth. Tried different phone. Still won’t connect. Tried resetting to factory settings. Nothing. Blower fan only works on 1 speed. Changed blower motor and wiring harness. Still not working. Changed the ccm73. Still won’t work. I accidentally found what I thought was a recall on APIM but dealer says there is no recalls.

The blower motor harness melted for the second time. The blower motor was replaced with the recall part and it has melted again. This is causing the blower motor to cut off at any given moment. I must then reach under the dash and push the wires in order for the blower motor to work again. I have read that this is a known problem in expeditions. Why isn’t this part under recall? Does the blower motor cause the harness to melt? I believe it is the cause.

Sudden feel of a misfire putting truck into reverse, definitely caught my attention as vehicle has under 140k miles! Just had new Ford spark plugs and lifetime warrantied coil packs in the last 20 to 25k! it's had at least two if not three oil changes in the last 20k to 30k miles! Put vehicle into drive same felling of a misfire and doesn't take long it flashes the check engine light at me so I turn around to head back home and haven't really made it but around the corner and the car completely stalled out going by the neighbors house lost steering and brakes and noticed a very distinct smell of plastic/electrical burning! I pop the hood in total disgust and can't even see clearly enough to see the issue at the moment! A friend pulled in front my residence as I'm shaking my head and in tears! He points out a cracked and melted number one coil pack! Instantly replaced with nothing was wrong with the previous coil pack that nothing was wrong with but was unsure of the history! I now have a paperweight King Ranch Expedition! I'm not to familiar with this current what looks to fixing to be a recall anyway for what sound like the same overall issue as these 2020 and newer models that the fixing to hit! I have repaired my 02' Impala of a recall before I new it was a recall! Once I received the recall the issue of sudden loss of control of vehicle and engine shut down was already fixed by myself but out of curiosity I took the car in on a scheduled appointment to the GM Chevy dealer nearest me to fix the issue under recall that was already fixed! They placed plastic sleeves overs my keys and said done deal! I explained that that will not fix anything safely or permanently concerning these cars issues! Voiced my concern there at the dealership, with GM and this organization that I hope that no more loss of life would come from those! My current 2 recalls for my vehicle involved in my complaint today is a weeks if not months long wait to get vehicle back on one and no known

The contact owns a 2016 Ford Expedition. The contact stated that the vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, while the dealer was in the process of performing the front blower motor replacement, the mechanic became aware that the front blower motor had melted and determined that the front blower motor resistor and pigtail needed to be replaced as well. The dealer assessed an additional fee for the additional repairs. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. A case was opened. The failure mileage was approximately 117,832. The contact stated she tried to get the recall repaired, but there are no parts available to repair the recall.

The contact owns a 2016 Ford Expedition. The contact stated the vehicle was repaired under an unknown recall for a connector that was left hanging down. The contact stated the connectors that were left hanging occasionally sparked and caused a burning odor. The local dealer was contacted, but the vehicle was not diagnosed or repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 165,335.

The contact owns a 2016 Ford Expedition. The contact stated while driving approximately 35 MPH, the blower fan stopped functioning. The contact stated that failure was intermittent at first but became a recurring failure while driving at various speeds. There was no warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact had recently checked the wiring harness on the blower fan and became aware that there were burn marks on the wiring harness connector possibly caused by a short circuit. The manufacturer was informed of the failure. The failure mileage was approximately 133,000.

The contact owns a 2016 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact took the vehicle to the local dealer and had the recall repair completed. The vehicle was repaired; however, four days after the repair, the air conditioning failed to operate properly. The contact took the vehicle back to the local dealer, where it was diagnosed with needing the blower motor to be replaced a second time. The vehicle was repaired but while being serviced the dealer informed the contact that the failure had recurred. The dealer informed the contact that the pigtail needed to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 137,415.

The contact owns a 2016 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

The rear actuator has gone out 4 years in a row and breaks within less than a year from getting repaired by ford dealers only. The rear camera is always blacking out too. This also has to be replaced each year and a half for the past 5 years.

In June 2023 there was a strong burning smell in our 2016 Expedition's cabin. We took the vehicle to a mechanic and they found that a small fire had started around the blower motor that burned up the wires in/around the blower motor. The mechanic replaced the control board and harness. They replaced parts AAABL3Z-19E624-B and AAAFLlZ-188518-G. Then in August 2023 I received a recall notice from Ford for the blower motor. This was the first correspondence I had received from Ford that the blower motor had been recalled. I contacted a Ford dealer, Apple Ford Lincoln in Apple Valley, MN, on August 9th and requested reimbursement for the above parts along with a replacement of the blower motor under the recall. I have been calling and emailing the dealer weekly since August 9th and continue to be told the blower motor under the recall has been on backorder for months with no ETA on the part. On the morning of 10/16/2023, I smelled a burning smell in the cabin of the vehicle similar to the smell from June 2023 and the smell was still present after the vehicle sitting for 3 hours after driving. I would appreciate support with this issue.

The contact owns a 2016 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle started smoking behind the glove box. The contact related the failure to NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, the part to do the recall was not yet available. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000. Parts distribution disconnect.

The contact owns a 2016 Ford Expedition. The contact received notification of NHTSA Campaign Number: 22V648000 (Visibility, Electrical System) however, the part to do the recall repair was unavailable. The contact stated that while attempting to defrost the windshield, the blower was inoperable. The contact stated that the blower had not worked for several months. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the blower failed and needed to be replaced. The dealer replaced the blower motor with a spare blower motor that was in the shop. The vehicle had been partially repaired. The contact stated that the replacement blower also failed and was no longer operational. The vehicle had not been repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 116,467. Parts distribution disconnect.