2016 Ford Expedition Engine Problems

The contact owns a 2016 Ford Expedition. The contact stated while starting the vehicle, the engine made a knocking sound. No warning light was illuminated. The contact related the failure to the cam phasers; however, the vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 148,000.

The contact owns a 2016 Ford Expedition. The contact stated that while reversing at an undisclosed speed, the rearview camera was intermittently inoperative. While driving at an undisclosed speed, the accelerator pedal was depressed, and there was an abnormal sound coming from the engine compartment. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The vehicle was taken to a dealer, where it was diagnosed and determined that the engine fan needed to be replaced; however, parts were not available for the repairs. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

I experienced the same problem you are investigating in F-150’s: I was traveling on the highway at 75 miles per hour on cruise control - there was a really loud thunk and the Expedition unexpectedly downshifted to a lower gear, I hadn’t touched anything and there was no warning. It was really scary and has made me doubt the safety of this Expedition.

The contact owns a 2016 Ford Expedition. The contact stated that the vehicle was making an abnormal rattling sound on cold starts. The contact stated that the failure recurred while driving from a complete stop and while coming to a stop. The contact also stated that the vehicle was experiencing rough idling. Additionally, the contact stated while driving at approximately 35 MPH, the vehicle inadvertently stalled. The check engine warning light was illuminated. The vehicle was taken to P&B Auto Repair Shop, where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 128,000.

The contact owns a 2016 Ford Expedition. The contact stated that while her husband was driving approximately 30 MPH, a loud explosion sound came from the engine compartment and engine oil began to leak from the vehicle. The vehicle was later towed to the local dealer who diagnosed that the turbo line had failed causing the turbo to strike the engine, creating a hole in the engine block. The contact was informed that the engine and turbo needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 120,000.

The throttle body failed, and my car lost power as I was turning into traffic on the road outside of my subdivision. My car went from approximately 45-50 miles an hour to no acceleration. My car would only go forward at the speed at which it idles. It was very dangerous to me and to others because it was a sudden power failure. The problem was reproduced by the local Ford dealer. I don't know if the component has been inspected by anyone. The first time it happened, there was an orange wrench on my dash with "See Owner's Manual" under it. This happened at least three times before we took it to our local Ford dealer. The dealership said they couldn't find anything wrong with my car and that I should "drive it till it broke".

Warped exhaust manifold leaking exhaust into main cabin, broken studs on engine block. Thousands of incidents of reported online.

The contact owns a 2016 Ford Expedition. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle lost motive power. The contact stated that the failure occurred while driving in the mountains and the vehicle was stuck in the middle of the road. The contact stated that after several attempts, the vehicle restarted. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure had occurred several times; however, the vehicle was taken to the dealer and the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was unknown.

I was driving at ~40 mph and the car suddenly lost power and decelerated. The wrench dash light came on. The car was forced into limp mode. The p2112 code showed on my OBD scanner. The code indicates a throttle body actuator stuck closed. The car started to run very rough, was stuck in 2nd gear and would only do 5 mph. Upon turning off and restarting vehicle the wrench light turned off and the throttle response was normal. I will have to replace the throttle body at my expense as the car is past warranty. I will keep the part for inspection. The road was relatively empty so it did not cause an accident. In heavy traffic at highway speeds this might have caused an injury wreck. The sudden deceleration without any brake lights could easily result in a rear end collision. If the deceleration happened in the middle of an intersection, a side impact or offset front collision could be the result. I have multiple scan tools and am quite proficient at using them. I also have access to the ford service manuals for my vehicle. No one has inspected the part. The vehicle had no warning lamps prior to incident. The wrench light came on at the same time the car suddenly decelerated.

The contact owns a 2016 Ford Expedition. The contact stated that an unknown fluid was leaking from the vehicle in two locations. The engine warning light was illuminated. The vehicle was taken to an independent mechanic and informed about a possible catalytic converter failure. The mechanic blew out the parts. The vehicle was taken to the local dealer, where it was diagnosed that the valve cover gasket was fractured, and the catalytic converter and vacuum pump needed to be replaced. The dealer informed the contact that the parts were not available. The dealer used silicon to secure the valve cover gasket. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 125,000.

The contact owned a 2016 Ford Expedition. The contact stated while driving at 20 MPH and the air conditioner stopped functioning. The contact heard a popping sound coming from the vehicle, the contact pulled over on the side of the road and noticed smoke was coming from under the glove department of the front passenger side. The contact proceed to check under the hood and did not see any smoking coming from under the hood. After closing the hood, the contact noticed flames coming from under the glove department on the passenger side, the contact attempted to pull the carpet to stop the flames but it was too late the vehicle was already in flames. The fire department was able to extinguish the fire, the fire department determined that the fire was caused by the air condition blower on the passenger side. A police report was filed. There were no injuries reported. The vehicle was towed, and it was deemed a total lost by the insurance company. The manufacturer was contacted, and they stated that they would contact the contact back. The failure mileage was 120,000.

2016 Ford Expedition with 55k miles. Engine blown, hole in side of block. Mechanic has said Ford is backordered 6 months for engines, with 400 in backorder in my region alone. Clearly there is an engine flaw and this engine needs to be recalled.

Exhaust manifold is separating from the engine, causing a chirping noise and allowing exhaust to escape without passing through the muffler.

Water/condensation build-up in charge air cooler collects in tubing and discharges into intake when quickly accelerating from a stopped position or “punching it” to pass a slower vehicle in traffic. This causes my vehicle to go into limp mode and lose all power which can be extremely dangerous in high traffic conditions.

75k Miles, 2016 Expedition Known Throttle body issue. Engaging the "Limp Mode" Happened several times before we could get it into the dealership. Each time was at different speeds and conditions.(** Who by the way told us to just keep driving it until our dealership appointment arrived approx. 2 weeks later) Not thrilled about this issue. We purchased the vehicle as a family hauler and a road tripper. Do not like the idea of having my kids in the car and the potential of this happening in a dangerous area. Ford dealer replaced the unit 10/8/21 we will see if the replacement will be a permanent fix for the vehicle. It does seem like ford is dragging their feet on this and not issuing a recall.

TL* THE CONTACT OWNS A 2016 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED HOWEVER, THE FAILURE RECURRED SEVERAL TIMES. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

THE VEHICLE WAS IN MOTION, ON A CITY STREET LOST POWER ,SHUT DOWN BUT DIDN'T CUT OFF NO THROTTLE WHAT SO EVER.. I BELIEVE IT IS THE THROTTLE ACTUATOR CONTROL SERVICE CODE P2112

THIS IS THE 3 RD TIME THE WRENCH TROUBLE LIGHT CAME ON. THE CAR LOSSES ALL POWER AND CAN ONLY IDLE ( ROUGHLY ). SHUT ENGINE OFF FOR A FEW MINUTES AND CAR STARTS UP AND GOES JUST FINE. BROUGHT IT BACK TO DEALER AND THEY SAID NO CODE IS STORED. NOTHING THEY CAN DO ABOUT IT. I WAS TOLD THAT THE PROBLEM IS USUALLY A THROTTLE BODY BUT SINCE NO CODE THEY CAN'T REPLACE IT EVEN THOUGH I HAVE A FORD EXTENDED WARRANTY. SO I JUST WENT AND BOUGHT A THROTTLE BODY FOR $ 225.00 AND INSTALLED IT MYSELF . LET'S SEE WHAT HAPPENS . DATE INSTALLED 1/22/2019

THE " WRENCH " WARNING LIGHT CAME ON WHILE DRIVING ON A HIGHWAY AND THE CAR LOST POWER. THE CAR HAD TO BE TOWED . LUCKILY I WAS IN THE RIGHT LANE.

THE CAR LOSE POWER ON THE HIGHWAY, WERE YOU HAVE TO STOP THE CAR