1995 Ford Explorer Electrical System Problems

95 FORD EXPLORER PARKED IN CARPORT WITH ENGINE SHUT OFF FOR 5 MIN WHILE CARRIED GROCERIES UP STAIRS - I HAD LEFT DOG IN CRATE TIL FINISHED UNLOADING BUT WHEN I CAME DOWN NOTICED ELECTRICAL SMELL, GOT OUT LOOKED AROUND CAR BUT DID NOT NOTICE ANY BURNING, GOT DOG OUT AND RETURNED IN THREE MINUTES TO FIND KEY NO LONGER UNLOCKED DOOR AND COULD NOT SEE THROUGH WINDOWS - WHEN DOOR WAS OPENED SMOKE BELLOWED OUT, INTERIOR WAS COVERED WITH BLACK SOOT, A HOLE BIGGER THAN A BASKETBALL WAS BURNT OUT OF SEAT AND BACK OF DRIVER'S SEAT WAS PARCHED - HAD I NOT HAD THE WINDOWS COMPLETELY UP IT MOST LIKELY WOULD HAVE TO CONTINUED TO BURN. *TR

TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. IN ADDITION, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE COULD BE RESTARTED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

VEHICLE WAS PARKED ON A RESIDENTIAL STREET AND ENGINE HAD BEEN OFF FOR 30 MINUTES. DRIVER WAS SITTING IN VEHICLE MAKING PHONE CALLS WHEN HE SMELLED SMOKE AND SAW FLAMING WIRE UNDER DRIVER'S SEAT. DRIVER ESCAPED UNHARMED AND WAS ABLE TO REMOVE SOME CONTENTS BUT VEHICLE WAS FULLY ENGULFED IN FLAME WITHIN A FEW MINUTES, DESTROYING VEHICLE ENTIRELY, MELTING PAVEMENT, BURNING NEARBY GRASS AND TREES, AND MELTING BUMPER AND PAINT ON A NEARBY PARKED VEHICLE. FIRE DEPARTMENT ARRIVED TO EXTINGUISH VEHICLE. *TR

MY VEHICLE 3RD BRAKE LIGHT IS OUT ALL OF A SUDDEN DON'T DRIVE IT OFTEN AND SORELY SURPRISE THAT IT WOULD JUST BE COMPLETELY OUT. IT IS EXPENSIVE TO REPLACE AND SHOULD BE OPERABLE TO THE LIFE OF THE VEHICLE. AS IT STANDS WON'T PASS INSPECTION AND SHOULD BE A RECALL ON IT. THANKS *KB

1995 FORD EXPLORER EDDIE BAUER. HEADLIGHTS WENT OUT, FOUND OUT THROUGH RESEARCH THAT IT IS THE LAMP OUTAGE MODULE LOCATED IN THE CONSOLE OF THE CAR. ALMOST STARTED A FIRE, COMPLETELY MELTED MODULE AND AFFECTED OTHER AREAS OF THE ELECTRICAL SYSTEM, VERY DANGEROUS AND NO RECALL THAT I CAN FIND. PART IS DEALER ONLY AND 90.00. *KB

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP MULTIPLE TIMES. ALTHOUGH, AN UNDETERMINED NUMBER OF PARTS WERE REPLACED THE STALLING CONTINUED. AFTER CONDUCTING RESEARCH ON THE INTERNET THE CONTACT DETERMINED THE PROBLEM IS WITH THE IGNITION MODULE. UPON INSPECTION THE DEALER DETERMINED THERE IS NO PROBLEM WITH THE IGNITION MODULE.

SMELL OF BURNING PLASTIC FILLED CABIN OF VEHICLE AND FLOOR UNDER DRIVERS FEET GOT HOT. DISCONNECTED BATTERY AND SENT TO GARAGE. *JB

INTERMITTENT STARTING PROBLEMS AND STALLS WHILE DRIVING

MY 1995 EXPLORER WAS SITTING AND AT 12:30AM, WHEN IT CAUGHT ON FIRE AND BURNED. THE FIRE STARTED UNDER THE HOOD, AND THE VEHICLE WAS A TOTAL LOSS. THE INCIDENT OCCURRED ON THE EVENING MARCH 23. THIS WAS THE SAME EVENING THAT FORD RECALLED THE EXPEDITION FOR THIS VERY SAME TYPE OF PROBLEM, A COLD VEHICLE CATCHES FIRE UNDER THE HOOD. THIS WAS WHAT OUR EXPLORER DID AS WELL. HOWEVER WHEN WE CALLED FORD THEY SAID THAT THE EXPLORER WAS NOT ON THE RECALL.*AK

AFTER OPERATING THE HEATER A FIRE OCCURRED UNDER THE HOOD. IT BURNED THE PLASTIC CASE AROUND THE HEATER CORE AREA. I WAS ABLE TO PUT OUT THE FIRE WITH A FIRE EXTINGUISHER. I CONTACTED THE LOCAL FORD DEALERSHIP AND WAS TOLD THAT NO RECALLS HAD BEEN ISSUED ON MY VEHICLE (1995 FORD EXPLORER VIN# [XXX]). THE SERVICE TECH AT THE DEALERSHIP SAID THAT THE HEATER CORE COULD NOT HAVE CAUSED THE FIRE AND THAT PERHAPS A MOUSE HAD BUILT A NEST INSIDE AND THAT COULD HAVE BEEN THE CAUSE. HE DID NOT MENTION ANY SERVICE BULLETINS REGARDING ELECTRICAL PROBLEMS IN THE DASH,A/C/,HEATER AREA THAT I LATER FOUND ON THE INTERNET. HE SUGGESTED I BRING THE CAR IN FOR REPAIR. NEEDLESS TO SAY I AM NOT TAKING IT TO THE DEALERSHIP. I DO HAVE AN APPOINTMENT FOR MONDAY (1/24/05) AT A REPAIR SHOP. I WILL KNOW MORE ABOUT COSTS TO REPAIR AND THE EXTENT OF THE DAMAGE THEN. I FEAR DRIVING THE CAR KNOWING IT COULD CATCH FIRE AGAIN AND AM USING A LOANER CAR FROM A FRIEND AT WORK.*JB UPDATED 07/24/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

WHILE DRIVING AT 30 MPH VEHICLE CAUGHT ON FIRE IN THE STEERING COLUMN. *AK

WHILE DRIVING, THE VEHICLE CAUGHT ON FIRE, WHICH STARTED UNDERNEATH THE DASHBOARD. THE DEALER WAS NOTIFIED. *AK THE CONSUMER SUPPLIED A FIRE REPORT. *SCC *JB

THE ELECTRICAL MODULE FAILED. *JB

WHILE APPLYING JUMPER CABLES TO THE BATTERY OF ANOTHER VEHICLE CABLE STARTED SMOKING, AND PLASTIC MELTED FROM THE WIRES. DEALERSHIP WAS AWARE OF THE PROBLEM.*AK

CONSUMER STATES THE THIRD BRAKE LIGHT ON THE REAR DOES NOT WORK, HE STATES WHEN THE SERVICE TECHNICIAN DROVE VEHICLE INTO BAY TO BE SERVICED, THE BRAKE LIGHT FLASHED ON FOR THE FIRST TIME IN SEVERAL MONTHS, WHICH POSSIBILY MEANT THERE WAS A SHORT IN THE LIGHT, ALSO THE HEAD LIGHTS FLICKER BADLY, ESPECIALLY ON ROUGH PAVEMENT. *JB

ON SERERAL OCCASIONS THE ENGINE HAS EITHER STOPPED RUNNING OR RUN VERTY ROUGH, SUCH THAT IT CAN ONLY BE KEPT RUNNING BY STEPPING ON THE ACCELERATOR. IT USUALLY OCCURS AFTER STOPPING FOR A SHORT PERIOD OF TIME AND THEN RESTARTING. THE DEALERS SERVICE DEPARTMENTS HAVE BEEN UNABLE TO IDENTIFY THE CAUSE.

VEHICLE MAY STALL WHILE DRIVING AND NOT RESTART. *AK

COMPUTER CONTROLLING ENGINE FAILS WHEN OUTSIDE TEMPERATURE IS WARM-NORMAL WHEN COOL. *AK

ON 3/10/00 NOTICE A BURNING SMELL, GOT WORSE THROUGH THE WEEK, HAD THE HEATER CORE CHECKED WAS FINE($375). ON 3/18/00 WIFE WAS DRIVING HOME AND THE SMELL WAS SSSOOOOO BAD, CHECKED SMOKE WAS COMING FROM BEHIND GLOVE COMPARTMENT, HEADLIGHTS BLEW OUT BUT ALL FUSES ARE FINE, ALSO THE SMELL WAS ALWAYS WORSE WITH THE HEAT ON, NOW THE SMOKE SEEMS TO HAVE STOPPED, BUT THE TRUCK SMELLS SOOO BAD, CAN NOT GET IT IN TO THE MECHANIC UNTIL MONDAY 3/20/00, I SAW THERE WAS AN FIRE EARLIER FROM UNDER DASH IN COMPLAINTS SECTION AND THOUGHT THIS SHOULD BE REPORTED!! *AK

O/D AND INDICATOR LIGHT NOT OPERATIVE. 4WD INDICATOR LIGHTS BLINK OR DO NOT OPERATE. DEALER SAYS SHORT IN WIRING COMPONENTS IN SHIFT SELECTOR ASSEMBLY IS CAUSING PROBLEMS. REPLACING ENTIRE ASSEMBLY.