2000 Ford Explorer Suspension Problems

TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE BEING INSPECTED BY A LOCAL MECHANIC FOR ROUTINE TIRE MAINTENANCE, THE MECHANIC STATED THAT THE FRONT AXLE WAS FRACTURED DUE TO CORROSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 71,000.

TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING 5 MPH, THE CONTACT HEARD A LOUD KNOCKING NOISE COMING FROM THE FRONT SUSPENSION. HE EXAMINED THE VEHICLE AND NOTICED THAT THE FRONT STABILIZER BAR LINK FAILED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER AND THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 85,500. UPDATED 1/6/09 *CN THE FRONT STABILIZER BAR LINK FAILED. THE CAUSE OF THE FAILURE WAS DUE TO CORROSION. UPDATED 01/14/09. *JB

BEARING BROKE ON FORD EXPLORER. WHEEL WAS ALMOST OFF THE VEHICLE. FORTUNATELY GOING SLOW. *TR

IN EARLY SEPTEMBER, MY TRANSMISSION LOCKED UP WHILE ON A TRIP WITH MY FAMILY. THE MILEAGE AT THE TIME WAS UNDER 85,000 MILES. IT COST ME OVER $1500 TO HAVE A REBUILT TRANSMISSION INSTALLED. APPARENTLY, OTHER FORD EXPLORER XLT OWNERS HAVE HAD THE SAME ISSUE. IN ADDITION, SEVERAL MONTHS LATER, BOTH WHEEL HUB ASSEMBLY'S HAVE GONE BAD TO THE TUNE OF OVER $800. THE MILEAGE IS STILL UNDER 90,000. I HAD TO TAKE THE VEHICLE IN AGAIN TODAY AND FOUND OUT THAT A BALL JOINT HAS GONE BAD NEAR THE WHEEL HUB ASSEMBLY AND IT'S GOING TO COST AROUND $250 TO REPLACE THAT. IT'S UNFATHOMABLE THAT FORD WOULD BE ALLOWED TO PUT OUT SUCH A SHODDY VEHICLE THAT FALLS APART ONCE YOU GET OVER 80,000 MILES USAGE. *TR

CONSUMER LEFT FRONT TIRE BLEWOUT AND SHREDDED CAUSING CONSUMER TO REPLACE TIRE WITH SPARE. *TS THE TIRE BLEWOUT PRIOR TO THE CONSUMER RECEIVING THE RECALL NOTICE. THE AIR BAG LIGHT AND DOOR AJAR LIGHT ILLUMINATED. LEFT SIDE WHEEL BEARING SHOT AND THE RIGHT SIDE WAS GOING BAD. REAR BRAKES SHOT. *NM

WHILE DRIVING VEHICLE MAKES A CLANKING NOISE. THE VEHICLE TAKES UP TO 2-5 SECONDS UPON CHANGING GEARS TO REVERSE. GOING UP HILL IT WILL DOWN SHIFT VERY HARD AS IF THE FLOOR BOARD IS BEING KNOCKED OUT. THE DIFFERENTIAL, AND REAR END WERE REPLACED. *AK

I HAVE A 2000 EXPLORER 4WD AND LOWER BALL JOINT ON THE DRIVERS SIDE IS SQUEELING REALY BAD. I WAS TOLD TO REPLACE FOR $400.00. THIS IS JUST ANOTHER PROBLEM I'VE HAD WITH THIS SUV. THE TRANSMISSION HAD A BAD VALVE BODY GASKET ANOTHER $300.00. IT'S ONLY GOT 39000 MILES. WHAT ELSE CAN GO WRONG...SORRY THAT'S A BAD QUESTION. NEEDLESS TO SAY I'LL BE SELLING THIS ONE SOON.*AK

THE FRONT WHEEL BEARING HAS CORRODED. PLEASE PROVIDE ADDITIONAL INFORMATION. *JB *MR

THE CONSUMER WAS DRIVING WHEN SHE HEARD A LOUD NOISE WHILE TURNING INTO HER DRIVEWAY. THE VEHICLE WAS SMOKING AND CAUGHT ON FIRE. THE FIRE WAS PUT OUT WITH A GARDEN HOSE. THE VEHICLE WAS TOWED TO THE DEALER. THE WHEEL BEARINGS WERE FOUND TO BE DEFECTIVE. ON THE NEXT INCIDENT, THE CONSUMER TOOK THE VEHICLE TO THE MECHANIC TO HAVE THE FRONT END ALIGNED, WHEN THE VEHICLE WAS INSPECTED THE BALL JOINT FELL OFF INTO THE MECHANIC'S HAND JULY 8, 2004. *LA ALL OF THE PROBLEMS HAD BEEN ON THE DRIVERS SIDE. THERE WERE ALSO PROBLEMS WITH THE ENGINE. *SC *JB

THE BALL JOINTS ON MY 2000 FORD EXPLORER NEED TO REPLACED AFTER ONLY 42,000 MILES. IT IS MY UNDERSTANDING BALL JOINTS SHOULD LAST A MINIMUM OF 100-150,000 MILES.*AK

WHILE DRIVING AT ANY SPEED CONSUMER HEARD A LOUD NOISE COMING FROM UNDER THE FRONT END. DEALER INSPECTED VEHICLE SEVERAL TIMES, BUT COULD NO DUPLICATE OR CORRECT THE PROBLEM. *AK

WHILE DRIVING AT ANY SPEED FRONT END MADE NOISE . DEALER REPLACED THE UPPER BALL JOINTS,AND AN INDEPENDENT SHOP REPLACED THE ROTORS. BUT THE NOISE WAS STILL OCCURRING. *AK

WHILE DRIVING AT ANY SPEED THE VEHICLE WOULD SHAKE AND JERK. THE DEALERSHIP HAS BEEN CONTACTED. PLEASE ADD ANY ADDITIONAL INFORMATION. *NLM

WHILE DRIVING AT ANY SPEED AND WITH NO WARNING VEHICLE WILL HEAVILY JERK, AND THEN ENGINE CHECK LIGHT WILL COME ON AND STAY ON THE REMAINDER OF THE TIME VEHICLE WAS BEING OPERATED. DEALER NOTIFIED.*AK

WE PURCHASED THIS VEHICLE 1/03 WITH 39,000 MILES ON IT. 3/03 THE IDLE AIR CONTROL VALVE WENT BAD AND HAD TO BE REPLACED. THEN 7/03 THE ENTIRE TRANSMISSION HAD TO BE REPLACED BECAUSE SLIPPING FROM 2ND TO 3RD GEAR. THIS COST $1,800 TO FIX. THE VEHICLE ONLY HAD 43,000 MILES ON AT THAT TIME. NOW IT IS 1/04 AND THE TRUCK IS BACK IN THE SHOP FOR AN IDLE PROBLEM ONCE AGAIN AND THE VEHICLE JERKS AND BUCKS WHEN GOING DOWN THE ROAD AT 35-40 MPH. THIS IS A VERY UNSAFE SITUATION AND FORD SHOULD BE REPLACING ALL THE IAC VALVES UNDER A RECALL BECAUSE THERE ARE AN ABUNDANCE OF EXPLORER OWNERS WHO THIS HAS HAPPENED TO AROUND THE 39,000 -43,000 MILES MARK! *AK

08-14-02 (39685 MILES) - REPLACED IDLE AIR CONTROL VALVE - $215.87 03-14-03 (46676 MILES) - REPLACED CONTROL ARM AND BALL JOINTS- $770.82 I FEEL THAT THE ABOVE MENTIONED REPAIRS THAT WERE MADE TO MY 3 YEAR OLD VEHICLE ARE A RESULT OF POOR CRAFTSMANSHIP AND QUALITY WHEN THE VEHICLE WAS MADE, AND THAT THESE CURRENT PROBLEMS ARE EVIDENCE OF "INFANT MORTALITY". THE FORD MOTOR COMPANY HAS REFUSED TO ACCEPT ANY FINANCIAL RESPONSIBILITY AND DID NOTHING MORE THAN RECEIVE MY COMPLAINT. *JB

THE VEHICLE EXPERIENCED THE SAME PROBLEM AS THE RECALL ON THE SUSPENSION. DEALER WILL NOT REPAIR BECAUSE VIN# WAS NOT INCLUDED. *NLM

RIGHT FRONT HUB BEARING CRACKED, CONSUMER LOST CONTROL OF VEHICLE. WHEEL WAS SLANTED TO THE GROUND. DEALER CONTACTED. *AK *JG

WHILE TRAVELING ON HIGHWAY VEHICLE WILL SWAY TO LEFT AND RIGHT OF HIGHWAY. DEALERSHIP IS AWARE OF PROBLEM. *AK

WHILE DRIVING AND MAKING A LEFT HAND TURN VEHICLE HESITATES AND VIBRATES IN FRONT END. DRIVER STATES IT FEELS LIKE GEARS ARE NOT ENGAGING PROPERLY. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK