2013 Ford Explorer Suspension Problems

The contact owns a 2013 Ford Explorer. The contact stated that the vehicle was taken to the dealer for a recall repair related to a possible rear suspension toe link fracture. The contact stated that while his son was driving 55 MPH, a month and half after the recall repair, the rear driver's side tire had a blowout, causing the vehicle to swerve and to drift into another lane. The contact stated that there was no oncoming traffic during the failure. The driver was able to pull over to the right side of the road. The contact then met his son on the side of the road, and the contact replaced the rear driver's side tire with the spare tire. The contact then drove to the residence and inspected the tire. The contact noticed that the inner side edge of both rear tires were prematurely worn. The contact related the failure to the recall repair. The dealer was notified of the failure, but no assistance was provided. The vehicle was not diagnosed or repaired. Landmark Ford, Inc. (2401 Prairie Crossing Dr, Springfield, IL 62711); was contacted and the contact was informed that the previous dealer did not complete the alignment during the recall repair, causing the premature wear of the tires. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 248,995.

When Driving I started noticing that my steering wheel what getting harder to turn and it felt like it was lagging control. I could still turn and maneuver the steering wheel but the control overall was defiantly not safe. I stopped in at our mechanic and they test drove it. He stated that yes something was definably wrong with the steering system and he said it was hopefully the u-joint for control arm. We made any appointment for the next following week. I drove my explorer with extreme caution and the steering issue just got worse. I noticed that I now have a griding noise coming from my steering when I turn. This is a safety issue because it just going to seize up and I will not have any control over my vehicle. When I did finally did get my explorer into the mechanic the next following week he stated that I needed a new rack and pinion. I only have 140000 miles on my explorer. The cost was astronomical!!! $1700 for the rack and Pinon $600 in labor and a wheel alignment. and don't forget tax. That was a shocker!! I cant afford that kind of out of pocket expense. My vehicle vin does not fall into the recalled safety notice however this seems to be a big issues with the 2013 Ford Explores. My safely overall is the main issued!! I expect ford to follow through in how they manufacture its vehicles and maintenance products. Please include all explorers in the recall!!!!

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

See attached document for complaint.

My vehicle was purchased new from Ford dealer with factory tow option, which comes with an undercarriage cover with integrated air scoop to help cool engine & transmission while towing. This cover (Ford # BB5Z-9910494-A) is designed with quarter tern thumb screws to hold it on to the undercarriage. While driving on highway, this part fell off and was not recovered. Now my vehicle is at risk of serious damage to either transmission or engine, or both in not having this key part. The weak design for fastening this metal part to the vehicle is a serious safety hazard, and Ford should provide a resigned replacement part through recall.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. Additionally, the steering wheel was loose while driving. The vehicle was taken to an independent mechanic, who diagnosed that the front axle needed to be replaced. The vehicle was not repaired. The contact stated that the transfer case had previously been replaced. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 198,000.

I started to notice a slight “slipping” or “sliding” feeling when driving on wet roads or if I hit a pothole or man cover just right. Then while my kids and I were on vacation over Christmas break, I hit a small wet spot on the road and began to fishtail. Luckily we avoided an accident. I was unable to drive over 20mph without feeling like I would lose control. When we had it checked by a mechanic we were told it the toe link on both rear tires were snapped, an issue Ford has recalled several times, as recently as 2020. We spoke with a Ford mechanic and were told my vehicle didn’t have any active recalls related, the toe link had been recalled previously but was supposedly fixed in 2019, just months before the most recent recall. As a result, we had to pay the almost $600 repair bill.

While driving in the rain the rear end was sliding thought I was going to lose control. It was also happening when driving on rough roads or bumps. Rear Tires are also wearing out quickly.

Noise in the rear suspension

The contact's father-in-law owns a 2013 Ford Explorer. The contact's father-in-law received notification of NHTSA Campaign Number: 20V675000 (Suspension). The contact stated that while her father-in-law was driving at an undisclosed speed, the rear end of the vehicle was sliding. The vehicle was towed to the dealer, where it was diagnosed that the rear toe link was fractured, the rear wheel knuckles were seized, and the rear passenger's side wheel bearing was loose; however, the dealer declined to perform the recall repair. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to tow the vehicle to another dealer and file a complaint with the NHTSA Hotline. The failure mileage was approximately 160,000.

The rear subframe fractured while driving nearly causing a wreck. The rear of the vehicle jerked violently to the right. If this had been on the highway I believe it would have cost the car to spin out. At the dealership it was found that the rear subframe was rusted out where the recalled to link attached. I tried to get part from the dealership but they said it was already disposed of i do have several pictures of the rusted frame. There were no symptoms until it broke.

The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the PTU. The contact was also informed that the rear differential needed to be refilled. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V537000 (Suspension), but the VIN was not included. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 93,000.

This winter I began starting my vehicle and letting it warm up before driving it. After letting it run approximately 10 to 15 minutes, I opened my door and to get in and there was a very strong exhaust smell inside. I would have to roll my windows down to clear the cabin of the fumes. This happened every single time I would let it sit and warm up. There is also something happening with what I believe is my drive-train. There is a lot of different noises (squealing/whining, grinding (metal to metal), clanking and thumping) when I give it gas after sitting at a light. As soon as I step on the gas pedal it makes all the above noises and jerks, then acts like it doesn't want to go. It finally kicks in then goes. Once it kicks in, it drives just fine. The noise sounds like its coming from the undercarriage and sometimes the rear end. I am not driving the vehicle now, it is parked in my driveway, so I am currently without transportation. There is also a very loud popping noise coming from the front end. I was told this could be ball joints or possibly stabilizers.

The contact owned a 2013 Ford Escape and requested to be removed from the recall notification lists.

The contact owns a 2013 Ford Explorer. The contact stated when the vehicle was taken to the local dealer to be inspected for a vibration and unknown noises, the check engine warning light illuminated. The vehicle was repaired for the check engine fault. The contact also stated while driving approximately 25 MPH and making a left turn and occasionally while reversing the vehicle, the vehicle would vibrate abnormally. The contact related the failure to the suspension. The manufacturer was notified of the failure. The approximate failure mileage was 163,000.

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension) however, the part to do the recall repair was not yet available. The local dealer was contacted and the dealer had rescheduled the appointment twice. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2013 Ford Explorer. The contact stated that while having routine maintenance performed by an independent mechanic, she was informed the brake pads and rotors needed to be replaced. Additionally, the suspension was compressed onto the tire. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.

The contact owns a 2013 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension) however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact indicated that while driving over a bump in the roadway, there was a clunking sound coming from underneath the vehicle. The cause of the failure was not determined. VIN tool confirms parts are not available. The failure mileage was 112,000.

The contact owns a 2013 Ford Explorer. The contact stated that after the vehicle was serviced under NHTSA Campaign Number: 21V746000 (Suspension) the vehicle experienced rear-end stability issues causing the vehicle to fishtail while driving at various speeds. The vehicle was taken back to the dealer. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 111,000.

The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 75 MPH, the vehicle became difficult to maneuver and the front passenger’s side of the vehicle crashed into the shoulder lane wall. No warning lights were illuminated. The air bags had not deployed. No injuries were sustained; however, medical attention was sought. A Police report was not filed. The vehicle was towed to a dealer where it was diagnosed that the axle on the front passenger’s side wheel was cracked and needed to be replaced. The dealer informed the contact that the engine mounts also needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 133,000.