2014 Ford Explorer Suspension Problems

There is a strong fuel order coming from passenger side after every fuel fill, affects everyone in the car while moving, especially affecting my grandchildren and my family. Backup camera rarely comes on while backing up, gives a black screen which can cause accidents especially in reverse. Rear driver side makes loud squeaky sound while driving over speed bumps slowly or bumpy roads. I purchased this vehicle used June 2025. It has an active molding recall that hasn't been fixed and I have contacted a Ford dealership last year.

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

I’m still waiting for the current recall to be corrected. The suspension is worn out. Replaced rear shocks, front struts, lower control arm. This is the worse automobile I’ve ever owned. If possible, I will never buy another ford. The car’s rear back up camera has been replaced and has stopped working again.

The contact owns a 2014 Ford Explorer. The contact stated while driving at various speeds, the vehicle was driving rough. In addition, while driving at various speeds, the vehicle vibrated abnormally; however, when the vehicle shifted to neutral(N), the vibration ceased. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently all four tires were damaged. The vehicle was taken to Costco and all four tires were replaced. The contact had previously received notification of NHTSA Campaign number: 21V537000 (SUSPENSION) and the vehicle was repaired. The contact related the failure to the recall. The manufacturer was made aware of the failure and informed the contact that the Extended Warranty had expired. The contact attempted to have an alignment performed but was unable to find a repair facility to perform the alignment. The manufacturer was contacted and informed the contact that the vehicle was still under warranty; however, the adjustable arm needed to be upgraded at the owner’s expense to repair the vehicle. The vehicle was not repaired. The failure mileage was approximately 90,000.

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the low tire pressure warning light illuminated. The contact also stated that when she inspected the vehicle, she became aware that the steel belts were hanging from the interior of the rear tires. The contact took the vehicle to an independent mechanic where it was diagnosed as a failure with the rear alignment. The contact was informed that the rear toe link needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was made of the failure and the contact was referred to NHSTA Hotline for assistance. The failure mileage approximately was 120,000.

The contact owns a 2014 Ford Explorer. The contact stated the vehicle was registered from the Chicago plant and the vehicle resided in Northern Nevada, 30 minutes from Lake Tahoe. The contact stated the vehicle was susceptible to corrosion due to the weather in Northern Nevada. These vehicles may have rear toe links that received excessive electrocoating (e-coat) corrosion protection, which could cause the e-coat to become brittle and break away when contacted by road debris. The contact notified the dealer who referred the contact to the manufacturer. The contact referenced Ford Customer Satisfaction Program: [XXX] (Rear Toe Link Replacement) and NHTSA Campaign Number: [XXX] (Suspension) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the issue and referred the contact to NHTSA Hotline. The contact had not experienced a failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

under the program of 15N01 the 2014 Ford Explorer is not part of it and it should be as my vehicle is experiencing the same issues. The program currently ends for vehicles manufactured January 2014 and mine was manufactured in April of 2014. I would like this added so my vehicle can be repaired under the program. The make, model and body styling is the same as previous years and has the same parts.

The contact owns a 2014 Ford Explorer. The contact stated received notification of NHTSA Campaign Numbers: 21V537000 (Suspension) and 20V675000 (Suspension). The contact stated that the vehicle was taken to the dealer for the scheduled recall repairs, and the contact was informed that the toe links could not be replaced due to the knuckles needing to be replaced prior to completing the recall repair. The contact stated that the dealer contacted the manufacturer and the manufacturer verbally agreed to complete the recall repair by replacing both parts and scheduled the service for a later date. The vehicle was taken to the dealer for the rescheduled appointment and the contact was informed by the dealer that the manufacturer declined the recall repairs as well as replacing the knuckles. The manufacturer was not made aware of the failure. The failure mileage was unknown.

See attached document from complainant

The contact owns a 2014 Ford Explorer. The contact stated that the sunroof motor had failed due to water intrusion. The vehicle was taken to an independent mechanic, where the sunroof motor was replaced. Additionally, the contact stated that after parking the vehicle in the independent mechanic parking lot on another occasion, he noticed a steal band underneath the rubber of the rear tires. The mechanic informed the contact that the suspension had failed, which was damaging the rear tires. The vehicle was being diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,745.

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle made abnormal sounds and was vibrating abnormally. Additionally, the tires experienced a loss of traction while turning. The vehicle was taken to an independent mechanic, who replaced the CV joints twice; however, the failure recurred. The vehicle was then taken to the dealer, where the steering rack and bushings were replaced, and an alignment was performed. The failure recurred, and the vehicle was taken back to the dealer, where it was determined that the CV joints needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the VIN was not included in an unknown TSB. The failure mileage was approximately 200,000.

The contact owns a 2014 Ford Explorer. The contact stated while inspecting the vehicle, the tech stated that the toe link needed to be replaced. The vehicle was taken to the dealer and the dealer repaired the vehicle under NHTSA Campaign Number: 21V537000 (Suspension). The vehicle was taken to the inspection center again and the tech stated that the toe link needed to be replaced once again and advised the contact to take the vehicle to the dealer for assistance. The vehicle was taken to the dealer and the dealer stated that the rear passenger’s side knuckle needed to be replaced and stated that the vehicle had exceeded the 6 marks for warranty coverage. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was 123,000.

The contact owns a 2014 Ford Explorer. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 19V435000 (Suspension). The technician then became aware that the front alignment needed to be adjusted due that the rear alignment adjustment. The vehicle was not repaired. The manufacturer was contacted but declined to perform the alignment. The approximate failure mileage was 100,000.

I had the toe link recall performed in 2022. Since that time, I have replaced brakes twice, tires twice (two full sets in less than 50k miles), control arms, sway bars, and bushings. The car will not come into alignment. There is ample evidence all over the internet that the toe link recall has been a failure. There are numerous stories just like mine of secondary suspension issues and burning through tires, especially in the rear, at an alarming rate. To my knowledge Ford has done nothing to correct the issues with the toe link, once and for all. To my knowledge, Ford is not reimbursing owners for the related losses they experience because of the issue with toe links.

The rear suspension on this vehicle stinks! I've done 2 recalls for the toe links. Now I've had to replace the rear wheel bearings. They were both bad! Niw that's done, i've a really bad(dangerous) swaying problem! The darn thing won't hardly stay on the road! I had to go to the VA for a dr appt last week in Huntington WV. On the way home i hit a downpour. I was lucky to get pulled over! The thing hydro-planed and bucked all over the road. I was only going about 40-45mph! The toe and camber are way out on the driver side rear, and the passenger side isn't much better... Those aren't the only problems. There's quite a list with this piece of junk! From the cat converters to the rear door locks, there's always been issues. I'm the second driver. I'm on disability and drive nowhere. Especially doing/driving cazy/ abusive. My dad was the other driver until he passed in 2018, and he was just an old preacher. He never hit 75mph in the thing, though he put alot of highway miles on it. I've never been above like 78 - 80mph in it... We both were/are very proactive as far as maintenence... There ought to be a lemon law...

I have been trying to get the recall done for a year and a half only to be told the parts are not available. Just got a letter from Ford that parts were available so I called for appointment. Guess what! No parts. Year and a half and still no parts. This is a real safety issue. There have been known s accidents caused by this part failure yet after all this time I'm told no parts. Crazy!!

The contact owns a 2014 Ford Explorer. The contact stated that while driving over bumps in the roadway at various speeds, a jolt could be felt from the rear end of the vehicle. The contact then received a recall notice for NHTSA Campaign Number: 21V537000 (Suspension) which she linked to the failure. The contact took the vehicle to a dealer for the repair; however, upon return of the vehicle, the contact was informed that she needed to replace a knuckle assembly on the toe link that was not covered under a recall. The contact was assured that the vehicle was safe to drive and she was referred to the manufacturer for assistance. The contact then stated that while driving 65 MPH, she drove over a bump in the roadway and the entire rear end of the vehicle slid into the opposite lane of traffic and almost caused an accident. The contact then read her service report which stated that the recall was not serviced since the assembly knuckle was not replaced. The manufacturer was notified of the failure and offered no assistance. The contact was then transferred to the NHTSA to file a complaint. The vehicle was not repaired. The failure mileage was 108,000.

N/A

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA campaign number: 21V537000 (Suspension) however, the part to do the recall was unavailable. The contact called the local dealer who stated that the parts were not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension) however, the part to do the recall repair was not yet available. The local dealer was contacted and an appointment was scheduled; however, the appointment was rescheduled for a later date. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.