2017 Ford Explorer Complaint Log

The contact owns a 2017 Ford Explorer. The contact stated that while approaching a stop light the vehicle was shaking violently. The contact shifted into neutral, and the shaking stopped. While shifting into drive or reverse, the vehicle shuddered and was shaking and then stalled. There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed that the torque converter was faulty, and the transmission cooler line and plate needed to be replaced. The dealer informed him that the transmission line was contaminated. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred him to the NHTSA Hotline. The failure mileage was approximately 96,626.

The contact owns a 2017 Ford Explorer. The contact stated while driving 65-70 MPH, the engine seized. The contact was able to veer to the side of the roadway. The contact stated that upon attempting to restart the vehicle, the message "No Oil Pressure" was displayed. The vehicle was towed to the dealer, where it was diagnosed that the head gasket was blown, causing coolant and oil to mix. The dealer diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 141,000.

The driver side exterior black glossed facia on the "A" frame broke off while I was driving on the freeway at 80 miles per hour (speed limit). I did not see where it went, and luckily there were no cars behind me, but in a different situation it could have caused serious accidents. Much like their existing recall to replace roof racks. I called the dealer to get it replaced, and their response was "oh, ya this thing falls off all the time." There was no indication that it was loose.

When driving the vehicle, it displayed a dashboard message "Engine Coolant Over Temperature". The vehicle was brought to the local Ford dealer where it is routinely serviced. Grapevine Ford identified that the water pump needed replacing. The part was $419 but it required 14 hours of labor to install it for a labor charge of $3,425. While the part failure isn't common but it can happen, 14 hours of labor to replace it is the real issue This is clearly an extremely serious design issue. What can the consumer do? A vehicle is needed & the repair was authorized. Reviewing the NHTSA website, multiple similar complaints were found. However, none of them referenced the extremely high labor charge to replace the water pump, which is the real issue.

Front windshield pillars came off auto while driving. The passenger side flew off in July 2022 and the driver side came off in July 2023. Nether hit a car behind us but it happened on the freeway so could not stop to find the piece. We had the passenger side replaced by Vroom auto shop and just ordered a non OEM part for the driver side. If we have Ford replace it the cost is about $500 EACH.

The contact owns a 2017 Ford Explorer. The contact stated while driving 35 MPH, the vehicle shutoff without warning. The contact coasted the vehicle into a neighboring driveway, and the vehicle was later towed to the residence. The contact had several independent mechanics inspect the vehicle and each diagnosed the vehicle with transmission failure. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The contact was referred to the NHTSA Hotline for additional assistance. The vehicle was not repaired. The failure mileage was unknown.

We notice we were getting a warning about our battery about a year ago, so we took it to Ford and they said they couldn’t find any issues. We found a mechanic in town who looked at it with a volt meter an instantly noticed that the red power cable coming from the battery had burst through the casing that once held it. Now we have an exposed power cable that could potentially catch on fire if fluids from the engine were exposed to it. We first knew something was wrong when the doors would not unlock properly. And while driving we would get a battery warning. Ford told us during our warranty period that they didn’t find anything wrong when this should have been noticed instantly. This is a serious fire hazard. The vehicle was inspected by the manufacturer but a lack of knowledge by their mechanics has led to us filling this report.

The front windshield side trim piece detached from my vehicle while driving and was hanging on by a tiny piece of rubber. I had to pull over on the interstate to pull it off which was very dangerous.

Component: Passenger side windshield trim Safety Risk: I was traveling on the interstate between 70-75mph when the trim flew off. It went directly in the path of the vehicle behind me causing them to swerve. They nearly hit the vehicle in the left lane by doing so. Problem confirmed: No, just happened and have not contacted dealership yet Component inspected: No, was destroyed after being run over multiple times in rush hour traffic Warnings, messages, or symptoms: Just as it was happening there was a clicking or smacking sound then it went. Maybe 30 seconds between sound and part flying off.

At 28,000 miles, the vehicle emitted black smoke from the exhaust. Despite the mechanic’s efforts to identify the issue, no diagnostic codes were detected. Currently, the vehicle has accumulated 100,000 miles. The engine suddenly lost the ability to accelerate beyond 20 miles per hour. After several months of repairs involving multiple turbo replacements, it was determined that the engine was severely damaged and should have been replaced over 50,000 miles ago. The engine was subsequently replaced, but only a year later, it failed again. After replacing the first engine, the vehicle’s performance deteriorated significantly. The vehicle required another visit to the shop for several months, resulting in another engine replacement. Over the course of several months, the vehicle lost all power and exhibited difficulty shifting into reverse. Consequently, it failed to reverse and was involved in an accident.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, she noticed a thick cloud of gray smoke coming from the exhaust pipe and that had spread throughout the neighborhood. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that an unknown fluid had leaked into the engine. The contact was informed that the turbo charger oil supply tubes needed to be replaced. The vehicle was not repaired. Upon research, the contact referenced NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling) then notified the undisclosed dealer of the failure and the recall. The contact was informed that the VIN was not included in the recall and advised the contact to notify the manufacturer. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in the recall. The contact was referred to the NHTSA Hotline. The failure mileage was approximately 90,000.

Coolant was found to be infiltrating cylinders 2 & 3 of the engine. The engine was idling roughly and just about died before the check engine light came on. The service center did a pressure check and used a bore scope to confirm that there was coolant in the cylinders. My understanding of this problem is that the engine begins to misfire as coolant and oil mix and the cylinder walls start and other components deteriorate. When deterioration is bad enough the engine can quit. This can happen at any time including at high speeds on the highway. I'm not totally sure how long the rough idling had been going on, but the incident where the engine almost died and the check engine light came on was at about 80,000 miles. My guess is that the rough idling started around 70,000 miles -- give or take. Ford has not yet done a diagnostic teardown to determine how the coolant is infiltrating the cylinders, but it is a known problem for other sizes of the Ecoboost engine. I have the 2.3L Ecoboost. There was a recall on the 1.6L Ecoboost and there is a class action lawsuit for the 1.5L, 1.6L, and 2.0L versions of the engine.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the driver's side and passenger's side windshield exterior A-pillar trims had separated from the vehicle. The local dealer was contacted, and it was confirmed that the part was not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 100,000.

The passenger side of windshield trim flew off on highway when driving. There was no indication or evidence that it was loose or coming off.

For the third time in six months I had an unintended acceleration when stopped and shifting from drive to reverse or the other way. The rpm’s go way up, if I didn’t have my foot on the brake the vehicle may have crashed, injured someone, etc. Ford dealer was not helpful at all, saying they had no prior reports. I had same problem on previous Explorer but traded it in.

Before the safety recalls for the rear suspension the vehicle made a loud noise almost like helicopter blades from the rear. It stopped after the recall was fixed but has started again. The air bag light has been on since about a month after I bought the vehicle. After about 9 attempts of taking it to the ford dealership for them to look at it with no luck I believe it’s due to a broken seatbelt in the rear that nobody has a part for.

Driver side windshield trim detached from vehicle while driving at highway speed. Do not have the actual trim, have photographs of the A-post where trim detached. Safety of other drivers at risk due to part flying off vehicle at highway speeds. A quick Google search shows this as an issue for many drivers. No inspection of the issue completed. No warning lamps or messages. Rubber trim around windshield began to degrade and rattle could be heard on occasion at highway speeds.

windshield trim coming off before 5 year mark. had part of the trim come off and go flying along making a bad sound at highway speeds. had a about a 1 feet chunk fly off and hit the car behind me on the interstate.

2017 ford explorer. Driving down the interstate and the window trim around front window starts flying off. It’s completely dry rotted. No warning, have not taken it to the dealership because they charge $150 just for diagnostic.

The contact owns a 2017 Ford Explorer. The contact stated while driving 70 MPH, there was a loud banging sound coming from outside the driver's side door. The contact steered the vehicle to the side of the road and observed that the keypad had detached and was hanging on by the wires. The contact continued to drive, and the keypad detached from the vehicle. The vehicle was taken to a dealer where it was diagnosed that the keyless entry pad needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving at approximately 75 MPH, the passenger’s side A-Pillar trim detached. The contact pulled over to the side of the road and reattached the A-pillar trim using duct tape. The vehicle was not diagnosed or repaired. The contact purchased an aftermarket part to repair the vehicle himself. The manufacturer was notified of the failure. The failure mileage was approximately 70,000. VIN tool confirms parts not available.

The contact owns a 2017 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the front driver’s and front passenger’s side A-pillar trims detached. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000. VIN tool confirms parts not available.

My door do not lock/unlock automatically. It started with one door. Then that door started working and another door stopped working. Then that started working and a different door stopped working. This cycle kept happening until all doors stopped working. Then they started working again and then stopped working again. On several occasions the locks I couldn't unlock door with the key or open the door from the inside with handle/button or lever. Also tried to lock car manually only for the lever to pop right back up. So my car was left unsecured on many occasions. Door problems Started may of 2022 until recent

The contact owns a 2017 Ford Explorer. The contact stated while driving approximately 70 MPH in a rainstorm, the rear of the vehicle started to violently fishtail from side to side. The contact stopped and inspected the vehicle but found no failure. The vehicle was later re-inspected, and the contact discovered that the rear tires showed severe treadwear. The contact stated that the failure had occurred previously while his wife was driving the vehicle. The cause of the failure was not yet determined. The local dealer was contacted, and a service appointment was scheduled. The manufacturer was not yet contacted. The failure mileage was 38,000. The contact stated that the vehicle needed an alignment and two new rear tires. The vehicle was repaired and the contact has it in their possession again.

Black plastic surround trim pieces of windshield and side door pillar are coming unglued and flying off at cruise speeds on highway without any warning or indication that it is about to happen. This presents a startle-effect distraction to the driver, possibly leading to lose of control of vehicle and/or impact hazards to following vehicles and pedestrians. Vehicle was taken to dealer for inspection and repair, and we were advised by the Maintenance Advisor to be on the look-out for a possible recall from Ford because they had been receiving a lot of these types of complaints. This has happened three separate times on this vehicle, each side of the windshield separated, and one side pillar is separating now.

The windshield trim, A post, drivers side is loose and in jeopardy of falling off. I am going to have this repaired. But, should this come off during driving it could affect another driver. I have seen multiple vehicles like mine missing these pieces. Please investigate and see if a recall is needed to avoid accidents on our freeways.

The contact owns a 2017 Ford Explorer. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to an independent mechanic, where the vehicle was diagnosed, and it was determined that the head gasket had blown/failed coolant leaked into cylinder # 4. The vehicle was not diagnosed or repaired. Ford Corporate was contacted and informed of the problem as dealership did not manufacture the vehicle. Upon investigation, the contact associated the failure with TSB: 19-2346; however, the VIN was not included. The manufacturer had been informed of the failure. The failure mileage was approximately 95,000.

1 week ago the check engine light came on as the car was very heated. Coolant was used and the warning went off. A few days later the car was taken to have an oil change and we realized the coolant level was low and there was old coolant fluid dried onto the underneath of the car and a bead of coolant seen. The car was taken to the garage and a leak was found in the water pump, with coolant leaking from the seep whole. The water pump is located underneath the engine which requires an expensive long process to remove the engine and other parts to fix. The car is only 6 years old with 83K miles and a major component has failed which can not be easily accessed. The water pump has now been moved to another location in more recent models. There is a class law suit in process involving many people to address this design flaw and safety hazard. One website alone has over 100 people complaining about this issue with many cars seizing completely on roads whilst in use. There is no recall currently for this problem but dealerships, auto shops are aware of the problem.

Car overheating, coolant holder looks empty, I added coolant and it overflowed. Once I opened the air tank all the coolant came up from below and over flowed. Took to Ford of West Covina and they said I have a water pump leak. Yet I see no leaking ever in my garage or driveway. Car is fairly new and I always take it to get serviced on time and I am very caring to my cars. I took my car for service on 2/23/2023 to Ford of West Covina where I have always gone to and they didn’t tell me anything was wrong with my vehicle, but now looking at the after visit summary paper work it says coolant leak. The service team told me my vehicle was in good condition when I picked my car up.

My wife took her 2017 Ford Explorer XLT to South Carolina from Florida. Upon her return last night, on 5 Jun 23 she was driving through Georgia and she heard a vibration coming from the drivers side windshield and then all of a sudden it stopped. When she parked inside our garage she noticed the drivers side A Pillar moulding trim piece had departed the vehicle and was missing. PN is BB5Z-7803145-AA.

As I was driving 70mph on the interstate my driver’s side windshield pillar molding flew off.

Since June 5th, 2023, I have had to have the passenger side windshield pillar mount trim replaced 3 different times due to clips breaking and the trim piece begins to become unattached when driving. It was replaced again yesterday and not even 2 hours after it was replaced, the top clip that is attached to the trim piece and clicks into the body of my car, it already broke off from the trim piece and the top of the trim piece is loose again. This is absolutely unacceptable and a major safety issue.

My Wife, child, and I, were driving down the interstate and the exterior driver side panel by the windshield flew just flew off. When we stopped at a gas station it looked like serious deterioration to the seal and clips that held it together was present. The clips were all broken. On this same trip, we began to hear what sounded like bees buzzing in the dash. We stopped again to worry that something had to be going wrong. We did some research on the spot, and it seems to be the windshield cowl. After getting home it we did more research and it looks like these are very common issues, but when we talk to Ford, they just dismiss our concerns and tell us it's not covered under warranty. even though it's an apparent quality control issue on their part. We bought this vehicle used about 5 months ago and have put less than 5 thousand miles on it. We do not have the panel that flew off as we were unsure what had happened until we stopped down the road many miles at the next exit. The car itself is available to be inspected. Our safety was affected because this panel could have hit a motorist or become a road hazard.

Regarding ***IMPORTANT SAFETY RECALL*** 25V347. The B-pillar trim appliqués on my 2017 Explorer have detached completely from the vehicle - both of them, before the recall notice was received in June 2025. It’s now the end of January 2026 & still no fix for this SAFETY recall! How is a car piece detaching from a vehicle & becoming a projectile on a busy highway not a priority!!! Now I’m reading that there won’t be a fix until the end of 2026-absolutely outrageous. And yes, Ford dealer workers at 2 separate dealers confirmed that they are ‘waiting on Ford’ to supply the parts.

Hankook Ventus S1 Noble 2 P255R20 A/S BSW Tires 23,041 miles 2017 Ford Explorer Sport. These are the tires that came on the vehicle, there is only 23,041 miles on the vehicle and the tires are prematurely wearing on the outerside of all 4 tires. Chunks of the tire is pealing off. Hazardous to drive. The vehicle is not out of line, tires are rotated on schedule, and tire pressure maintained. Looks like defective tires, need to be investigated as safety recall. Ford Motor Company is aware of the problem and stated that we need they have a problem with those tires pealing and wearing out, most people have to replace around 20,000 to 30,000 miles. VERY DANGEROUS! I have safety inspections that shows tire are perfect.

The contact owns a 2017 Ford Explorer. The contact stated that the engine overheating message was displayed on the instrument panel. Upon inspection, the contact discovered that the coolant level was low, and added coolant to the reservoir. The vehicle was taken to two independent mechanics and was informed that the water pump had failed, causing a coolant leak. The manufacturer was notified of the failure and referred the contact to the dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 80,000.

2017 Ford Explorer 92,361 miles. Car started over heating going 45 miles per hour. Pulled over and then had car towed to the mechanic. Mechanic said water pump was done and coolant had leaked in to the engine and engine was destroyed. Car needs a whole new engine replacement. This is happening with many Ford Explorers and Ford refuses to recall them or do anything about it!

This vehicle has many blind spots and the blind spot alert only works sometimes. The locks only work sometimes too. It consistently does not lock the passenger side door with the lock or the key fob. When I was in traffic someone was able to open the door.

Right side pillar trim detached at 70 mph on freeway causing other vehicles to avoid flying debris.

Windshield trim flew off driving down the interstate, hit my side mirror, and passenger window. The trim piece put my family and me in a dangerous situation. It could have easily broken the window. No warning.

The contact owns a 2017 Ford Explorer. The contact stated while driving 60 MPH, she heard an abnormal sound and noticed that the sunroof glass panel had shattered without impact. The contact took the vehicle to the local dealer, where it was diagnosed with needing the sunroof glass panel to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 71,000.

The windshield trim on the drivers side flew off while I was driving on the highway unexpectedly and startled me. I was driving at 75mph and could have easily lost control of my vehicle. This is very dangerous! While searching for how to fix it online, I read that this is VERY common! How is this not a recall? This is awful!

When you hit the button to close the hatch whether it be by the hatch button, dash button or key fob button if something is in the way it doesn’t stop closing. So if your arm or a small child’s head, arm it would just keep closing. If it can’t latch it does go back up but that is only when it goes all the way down.

The contact owns a 2017 Ford Explorer. The contact stated that the rubber on the window trim between the passenger’s side front door and windshield had started to separate. One day while driving at highway speeds, the window trim detached from the vehicle. The contact stated that the rubber on the driver side window trim had also started to separate. The contact believed that the panel would also detach. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

As I was driving on the freeway, the windshield trim panel flew off my car. This put the safety of the cars behind me in jeopardy as it did or could have hit them or caused an accident by people attempting to avoid running over it in the road. I took my car to a Ford and they said this car is notorious for having this problem and they see it all the time. The previous owner of this car said that the trim on the opposite side had flown off too and had to have It replaced as well.

Yesterday I was driving on the highway and the molding next to windshield driver's side of the car flew away. We heard a loud nose when we stopped, we saw that the molding was complete gone. It could have hit another vehicle or a person

The contact owns a 2017 Ford Explorer. The contact stated that the vehicle had experienced unintended surging and engine revving. During the failure the driver had difficulty stopping the vehicle while depressing the brake pedal. The contact stated that the failure had occurred while driving at various speeds, and also while the vehicle was stationary and idling. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The VIN was not available. The failure mileage was 35,000.

The contact owns a 2017 Ford Explorer. The contact stated that while driving at an undisclosed speed, the passenger’s side windshield trim detached. Additionally, while driving at 80 MPH, the driver’s side windshield trim detached. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was 126,415.

The contact owns a 2017 Ford Explorer. The contact stated while starting the vehicle, the vehicle was shaking violently. The contact stated that the engine failed to turn over after several attempts while starting the vehicle. There was an abnormal rotten and sulfur odor entering the cabin of the vehicle from the front end of the vehicle. The vehicle was overheating with the check engine warning light illuminated. The catalytic converter had failed due to oil leaking from the turbo charger onto the catalytic converter. The contact was informed that the catalytic converter and turbo charger needed to be replaced. The vehicle had not been repaired. The contact became aware of NHTSA Campaign Number: 16V925000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer was not made aware of the failure. The approximate failure mileage was 155,000. The consumer is requesting that their VIN be included in the recall that applies to the turbo charger failure. The vehicle has not been repaired.

Outer plastic A-Pillar Trim detaching from body of vehicle, putting other drivers at risk of vehicle parts coming off and hitting vehicle or causing accident