2018 Ford Explorer Complaint Log

Description In some of the affected vehicles it may be possible that some of the exterior a-pillar applique trim clip attachments are not properly engaged due to improper assembly or repair. If this occurs, the a-pillar applique trim, which borders the right and left side of the windshield, may be loose, missing or become detached. Safety Risk An exterior a-pillar trim part that detaches while driving can create a road hazard for other road users, increasing the risk of a crash. I bought the car Jauary 19, 2024. The parts to fix this was supposed to be here by fall of 2024. This is affecting my job and will not be able to work soon. I do uber and they want this fixed or they will cancel me.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and Jarrett Scott Ford of Plant City (2000 E Baker St, Plant City, FL 33563); were made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and informed the contact that the vehicle might be able to be repaired in September of 2025. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving at approximately 60 MPH, the passenger’s side A-pillar trim was blown off the vehicle by the slipstream. The contact stated that the driver's side trim was loose. The failure mileage was approximately 18,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at various speeds, there was wind entering the cabin of the vehicle from the windshield. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was unknown. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the trim on the driver's and the passenger's side of the windshield was deteriorating and detaching from the vehicle. The dealer was contacted and informed the contact that the manufacturer was advising vehicle owners experiencing the failure to tape the trim pieces until the remedy was available. The manufacturer was made aware of the issue. The failure mileage was approximately 30,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact had been calling the local dealer to schedule an appointment for over 9-months and the contact was informed that parts were not yet available. The contact had not experienced a failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not informed of the lack of parts.

The contact owns a 2018 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 26V101000 (Suspension); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was contacted and confirmed that parts were not yet available for the recall repairs. The manufacturer was not made aware of the issues. The contact had not experienced a failure.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the A-pillar trim detached and blew off the vehicle. The vehicle was previously repaired for a similar failure; however, the failure reoccurred. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was 168,706.

See attached document for complaint

Was driving on the high way and the B pillar trim detached and was hanging by the wire. No damage was done to this area prior and appears the adhesive gave out. Due to incident back lift gate is inoperable and displays as open.

The passenger windshield trim piece blew off my vehicle on the interstate yesterday and caused the vehicle behind me to swerve to try to avoid it. Looking through my rear view mirror, the driver appeared to lose control due to over correction. The driver avoided a collision and crash, but it looked hairy for a few moments. The driver's side trim piece blew off my vehicle last year. After Googling, I see that this is a very common problem that should be addressed, in my opinion, with a recall due to safety.

I purchased the 2018 Ford Explorer and it worked fine there were no issues when I bought it on 7/8/2024 as of 2/14/25 the coolant leaks and I have been adding coolant like crazy. Are there any defective parts on the 2018 Ford Explorer? I had only a 90 day warranty through CARMAX.

I was driving on the freeway when one of my A pillers flew off and cause the person behind me to loose control of their car. About 5 min later the other a piller flew off almost causing an accident with a semi and trailer.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

After dealer inspection of my 2018 Ford Explorer, I was informed that the rear knuckles needed replacement due to cracked bushing. I was informed that this is a safety issue that needs to be addressed immediately, at a cost of $2400.00. After some cursory research I found that there was a recall for 2011-2017 Ford Explorers with the same issue, but not for 2018. This is obviously a known problem and should be addressed for 2018 vehicles.

I use this car for business as part of my income. Ford has issued an Advance Recall Notice. In January 2024. I have not been able earn money because of the recall notice. Manufacturer recall number: 24S02 NHTSA Recall number: 24V031 From legal advice, the Advance Recall Notice is for the dealers and is not an Official Recall Notice. Since the notice, I have been unable to rent out my vehicle. That's 15 months ago with no income. Now I have another Advance Recall Notice on my other vehicle a 2020 Expedition Max Limited. I need to make a living. What actions can be taken.? I've called numerous times first to times, no answer phone just rang after initial message. The following times, a human answered after message but i was disconnected or inadvertently put on hold. Then steered to this page. Looking for some assistance.

The contact owns a 2018 Ford Explorer. The contact stated that the vehicle was parked when there was heavy rain in the area. The contact stated that after the heavy rain passed when they were placing items in the back seat, they noticed that water was in the cup holder. The contact discovered a crack in the sunroof allowing water to enter the vehicle. The contact stated that the failure recurred multiple times. The contact was concerned that there was no impact on the sunroof to have caused it to crack. The vehicle was taken to a dealer where the vehicle was diagnosed with a cracked sunroof frame. The vehicle was not repaired and remained at the dealer. The manufacturer was notified of the failure. The failure mileage was 99,000.

Front hood paint bubbling, corrosion and peeling

The contact owns a 2018 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal cracking sound coming from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.

This recall was opened in Jan 2024. It’s been almost two years and parts still not available. I use my vehicle for business as part of Turo and they deactivated this vehicle in 2024 and won’t let me add it back until repaired. I have loss of income around 25,000 due to this. Easy remedy still no fix.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, there was a whistling sound coming from the front windshield. The contact stated that the trim had detached and flown off the vehicle, and there was a constant rattling sound coming from the windshield. The vehicle was taken to the dealer, where the contact was informed about an open recall on the VIN. The contact was informed that parts were not yet available. An alternate dealer was contacted, and the contact was informed that parts were not yet available. The contact later received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the parts were not available. The manufacturer was not made aware of the failure. The failure mileage was approximately 45,000.

January 2023 - vehicle shifts hard, revs high between shift points, almost jumps between shifts. Trouble code p0757- shift solenoid “b” stuck open. 85,000 miles. Cost to fix $900. December 2023 - same code, same symptoms. Now entire transmission needs to be replaced at a cost of $6600. 100,000 miles.

The contact owns a 2018 Ford Explorer. The contact stated that while driving approximately 55 MPH, the passenger’s side trim detached from the vehicle. The trim struck the front windshield of another vehicle, causing the other driver to lose control of the vehicle and the vehicle spun out. The contact was unsure if the front windshield was cracked due to the impact. There were no reported injuries. The contact called the local dealer and was referred to a Collision Center for assistance. The vehicle was not diagnosed or repaired. The Collision Center was contacted and provided an estimate for the repair. The manufacturer was contacted, opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 99,800. The VIN was not available.

Heat stopped working in Dec. Had it checked by local mechanic coolant very low but couldn’t find leak. Heat was working and no check engine light ever went on. About month later had car back for oil change and mechanic found leak, again no check engine or warning ever came on. Finally got appt at ford dealer $3000 to repair and was told would take 11 hrs. Ten days later car was supposed to be fixed. Pick up car. Next day when heat was put on there was a terrible burning rubber smell and now a very load noise which wasn’t there when vehicle was dropped off

Radio and back up screen stop working 1 month after purchase.

On the exterior this car has a plastic A-pillar cover on both sides of the windshield, i already had one fly off on expressway ( luckily didnt hit anyone or cause an accident) i replaced the one, but now the other side is coming loose as well, not sure if its a defect in the clips or the design , but the dealer doesnt acknowledge this to be a problem, there happily charging 600.00 to replace each A-pillar and they keep coming loose

I have a 2018 Explorer that may be involved in the Ford recall for the windshield trimpieces that may come loose. I may not have that issue but I have an issue with trim pieces separating from both the drivers and front passenger doors.

Both right and left side exterior A-pillar trim parts detached while driving. 2018 Ford Explorer.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

My screen went black for my Ford Explorer. I have no access to climate controls, backup Camera, radio, GPS, etc. My local Ford dealership said there was a recall pending but that’s been a few months now. It’s very dangerous driving like that with my 4 and 2 year old in the car.

Driver door keypad detacted from pillar. Rear lift gate will not open with button on lift gate, key fob or switch in dash board.

While driving on the interstate the piece of trim along the passenger side windshield flew off. No warnings. I am unsure if it caused any damage to anyone driving near me. It took me a moment to realize what had happened. I took the car to Ford repair where they had to replace the pillar molding, pillar molding hardware kit, and pillar molding mount bracket.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, the contact noticed that the passenger's side A-pillar trim had detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

The contact owns a 2018 Ford Explorer. The contact stated while driving at approximately 50 MPH, there was an abnormal sound as if there was something striking the windshield. The contact became aware several months later that the exterior A-Pillar trim was loose. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 140,000. VIN tool confirms parts not available.

[XXX] ur complaint I can't figure out where one files a complaint on an outstanding recall. Ford keeps sending notices, but is obviously not serious about fixing the issue, as its been going on approaching 3 years. If you call their hotline, it cuts you off after entering the recall number, saying there's no available fix at the moment. However, by searching some dealers around the nation, the parts are out there to purchase, but our two local dealers say they've seen nothing and advise using two sided tape in the meantime. How can such a basic part be so difficult to have available in under 2 - 3 years time? Our pillar piece has been barely hanging on for almost 2 years. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Explorer. The contact stated that while attempting to shift to revere, the vehicle jerked and hesitated before shifting into reverse. The contact stated that after shifting to drive, the RPM revved; however, the vehicle failed to accelerate as needed. The contact released the accelerator pedal, shifted to neutral and back to drive while slowly depressing the accelerator pedal for the vehicle to operate as needed. The contact stated that afterwards while driving 20 MPH or more, the vehicle sputtered and was making an abnormal grinding sound. While idling, the vehicle started shaking violently. The contact stated that the “WRENCH” and check engine warning lights were illuminated. The vehicle was taken to the dealer who was unable to identify the cause of the failure. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the transmission had failed due to failed spark plugs and filters. The mechanic also stated that there was a significant amount of rust on the engine. The vehicle had not been repaired. The contact became aware of a Customer Satisfaction Program: 10181988 (Power Train) and Technical Service Bulletin 10184634 (Engine and Engine Cooling, Power Train) and linked the TSB and CSP to the failure. The manufacturer was made aware of the failure and confirmed that the VIN was not included in a recall, Customer Satisfaction Program 10181988 (Power Train), and Technical Service Bulletin 10184634 (Engine and Engine Cooling, Power Train). The manufacturer opened a case for the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 65,000.

Our radio and back up assistance screen just stop working

Torque converter and transmission problems cause the vehicle to stutter upon acceleration or not accelerate at all. Gear shifts can be erratic. No CEL or DTCs appear in the OBD system. I was barely able to proceed through an intersection until the transmission finally engaged fully and I was able to accelerate correctly. Ford is aware of the problem as proven by TSBs 20B27 and 20N07 but refuse to fix my vehicle as I am just outside of the expiration window and apparently my VNI does not fall within the TSB program, even though my car's problems are identical to the TSB description. This transmission problem is a huge safety concern for anyone driving Ford's using the 6F35 transmissions. The contact stated it was confirmed the torque converter failed and shed debris throughout the entire transmission. This cause multiple non-accelerations at stop signs and red lights, gear slipping when trying to accelerate, failure to engage first gear, and random RPM drops while lightly accelerating.

Torque converter issues as outlined here: [XXX] Almost was in accident due to loss of power and slow take off from issue with transmission torque converter. Engine shaking bad when in drive or reverse while stopped. Caused two motor mounts to be damaged. One split open and leaked fluid. Those have already been replaced. Less than 60k miles this should not be an issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Windsheild trim is breaking into pieces on the sides and coming off.The bottom trim going across the hood is getting wavy and cracking and not laying flat on the surface anymore. It is also starting to break away. Dealer said no repairs for this are covered under warranty and if I want it fixed its very expensive.

Windshield molding is defective due to cracking and splitting. Whistling sounds while driving. Danger of molding coming off and causing an accident. I took it to the dealer and having it replaced. Very costly. I understand this is under investigation but not recalled yet. Please advise.

The contact owns a 2018 Ford Explorer. The contact stated that while her husband was reversing from the garage, the liftgate malfunctioned and opened. The driver opened the driver's side door and struck the door frame. The door frame was damaged. There were no warning lights illuminated. Additionally, the contact stated that while driving at an undisclosed speed, the liftgate failed to open. The contact had to place the vehicle in the park position for the tailgate to open. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 24,000.

The contact owns a 2018 Ford Explorer. The contact stated that due to sunlight exposure, the outer layer of the dashboard peeled off and continued to expand near the location of the air bags. The contact was concerned that the defect might cause an air bag deployment malfunction in the event of a crash. The vehicle was taken to the local dealer, and the contact was informed that the entire dashboard needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 45,000.

Cowl trim on front windshield is detaching from the windshield and flapping while vehicle in operation. Concerned this will fly off the vehicle snd possibly land on another traveling vehicle and possibly cause an accident. This just started making a buzzing noise approximately two weeks ago and after further investigation the trim is literally coming off the windshield in pieces. No warning lights just a noise from the dash. Pictures can be provided.

The NHTSA has opened an investigation into 2011-2019 models experiencing an issue with the windshield trim panel. The trim panels are cracked and disintegrating and pieces are missing posing a hazard while the vehicle is being operated at highway speeds.

The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 80 MPH, the vehicle stalled without warning. The contact stated that she was able to coast the vehicle off the roadway safely. The vehicle was then towed to an independent mechanic where the failure could not be duplicated; however, the failure recurred. The contact stated that while driving at an undisclosed speed, the vehicle stalled without warning. The contact stated that a message then flashed on the instrument panel “Full Accessory Active”. The contact stated that the following day, she attempted to start the vehicle, but the engine failed turnover. The contact stated that she waited approximately 30 minutes to an hour and was able to restart the vehicle. The vehicle was taken back to the independent mechanic, but the failure could not be duplicated. The failure recurred. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was provided a case number and advised to contact the NHTSA Hotline. The failure mileage was approximately 79,008.