2019 Ford Explorer Complaint Log

The A-pillar passenger side flank flew off while driving.

I took my vehicle last year to the dealership to report the safety concern I had with a loose piece under my hood causing a flapping sound while driving. They determined the exterior a pillar was warped, loose and missing pieces. I received the recall in the mail a few weeks later, although they will not set up an appointment for me to resolve this issue. Not only does it state this is a potential safety concern, it has already been established this piece is defective on my vehicle. I also drive fellow associates around to meetings in my vehicle and it is putting them in danger along with myself and is bringing concerns it has not yet been addressed. The recall was sent to me a few weeks later on 01/26/2024.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE). The contact stated that the passenger's side A-pillar was loose. The vehicle was taken to the dealer, and the contact was informed that the part to do the recall repair was not yet available. The vehicle was not repaired. Most recently, the contact noticed that the driver's side A-pillar trim was loose. The vehicle was not repaired after the most recent failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 40,000. The VIN was not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that both the driver's side and the passenger's side windshield exterior A-Pillar trims had separated from the vehicle. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 99,000. VIN tool confirms parts not available.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the exterior B-Pillar trim detached. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 24V031000 (Structure). The manufacturer was notified of the failure but provided no assistance because the recall did not include the B-Pillar. The failure mileage was 96,000.

The contact owns a 2019 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the driver's side and passenger's side windshield exterior A-pillar trims had detached and were making an abnormal sound while driving. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 39,000. VIN tool confirms parts not available.

It has been more than a year later, Ford has not resolved the issue with the exterior A-Pillar. The response at the dealership has been, A) we do not have the parts or B) If you pay for them out of pocket, we can fix the issue. Which tells me they can fix the issue but chose to not do so because they are banking on owners paying for this recall. What recourse do I have?

The trim that is on either side of the front windshield has come loose. The one on the driver side came loose while I was on the interstate and struck the vehicle behind me. It caused the driver to lose control and spin out. Fortunately, it did not cause a collision, but it could have caused a loss of life, we were travelling at highway speeds. The trim on the passenger side was still on the vehicle, but it had popped loose and was sticking up at an odd angle. I removed it to prevent the same thing from happening.

[XXX] � [XXX] [XXX] ⸻ To Whom It May Concern, My name [XXX], and I am writing to file a formal complaint against Ford Motor Company and multiple associated dealerships for gross negligence, financial harm, and discriminatory practices related to a recall repair that began in 2023 and has yet to be properly resolved. I own a 2019 Ford Explorer, VIN [XXX]. In 2023, I brought my vehicle to Wayne Akers Ford in West Palm Beach due to a torque converter recall. Before the issue was fixed, their transmission technician was fired, and I was redirected to Mullinax Ford. That began a two-year ordeal of being passed around between dealerships, misdiagnosed, and ignored while the original issue persisted. Alpaca Ford on 10th Avenue witnessed the malfunction twice but refused to repair it. I was told by Lenny, the Service Manager, and the Advisor Manager to “monitor the mileage” and report back — a delay tactic that eventually allowed them to deny my repair once the issue persisted at under 30 miles. When I returned with proof, they claimed the warranty had expired. This was caused entirely by their inaction and misguidance. To make matters worse: •I was forced to pay $1,300 for motor mounts that didn’t resolve the issue, despite telling them repeatedly it was unrelated. Ford covered a portion, but I was left to pay $897 out of pocket. •Tim Olsen at Wayne Akers Ford has refused to provide my refund and is now ignoring all calls and communication. •Ford’s corporate customer service has been involved from the beginning and failed to intervene effectively — despite acknowledging the situation. •I recently left a Google review describing my experience at Mullinax Ford, including my repeated denial of loaner vehicles while white customers were offered them freely. After posting the review, I was retaliated against — they refused to continue working on my car and told me to “come pick it up” without completing r INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Nov of 2023, overheated but no leak from engine was found and no antifreeze in radiator. TOOK to Mckie Ford they replaced the valve and noted thst there was antifreeze in the valve chamber and stated we needed a new engine. We purchased a new engine had it installed in Jan 2024 we paid for new engine. When we should not have as we did research on the engine and it was faulty but no recalls were in place at that time so we joined a claims action suit to help recover costs..

I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns but there was only one. You almost can not hear it when inside of the car and it makes me think that others may not hear it if there is an emergency. I have owned close to 70 cars and I have never had a car with one horn. A moped has a louder horn. In my opinion Ford should not have tried to save $5 that could cause an accident. I had to order Ford part number GB5Z-13832-A which are the dual horns found on the other model years. My safety and the safety of other 2019 Ford Explorer owners is at risk because of this.

The contact owns a 2019 Ford Explorer. The contact stated while driving 25 MPH, the exterior A-pillar trim detached from the vehicle. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure; however, was unable to confirm when the part would become available. The failure mileage was 85,000. VIN tool confirms parts not available.

Doing 70 mph and trim along passenger windshield broke in half and flew off

See attached document for complaint.

The contact owns a 2019 Ford Explorer. The contact stated while driving approximately 65 MPH, the passenger’s side B-pillar trims blew off the vehicle by the slip stream. The contact stated that the vehicle was taken to a local dealer who replaced the trim. The contact stated that the trim on the driver's side B-pillar was now loosened. The contact called the dealer and was informed that the B-pillar trim was not included in NHTSA Campaign Number: 24V031000 (Structure); and would be an out-of-pocket expense for the repair. The contact was concerned that the B-pillar trims should also be recalled due to the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 76,000.

coolant leaking into engine 2.3l eco boost

VEHICLE SHIFTS ROUGH. I WAS TOLD BY FORD THAT I NEED TO REPLACE MY BATTERY EXCEPT I DO NOT HAVE ANY BATTERY ISSUES AT ALL. ALSO WHEN I PUT MY VEHICLE IN PARK IT ROLLS FORWARD A LITTLE.

The B-pillar trim piece has become detached from the vehicle due to broken clips and when driving it appears as if it will fall off. Ford will not address the issue, other then using two sided adhesive tape which needs to be replaced continuously. The clips that hold the trim in place are broken and this is common on many explorers. There are other body trim pieces which have been recalled for and this needs to be added as well. The A-pillar trim was recently a recall item and this is just as much a hazard.

The driver's side exterior windshield moulding detached from the vehicle traveling at interstate speed (75 mph) and struck the driver's door above the window. The apparent cause of detachment was failure of the retaining clips and adhesive that holds the external piece to the internal rubber moulding.

Driver side pillar molding next to the windshield flew off unexpectedly while driving on the highway.

The contact owns a 2019 Ford Explorer. The contact stated that the windshield cowl panel had partially separated from the vehicle. Additionally, the contact stated that the failure had caused the vehicle to make abnormally loud air pressure sounds while driving. The vehicle was taken to the dealer, where it was determined that the windshield cowl panel needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 54,271.

Windshield trim falling off and deteriorating - windshield rattling - took to dealer to replace windshield trim - paid 642.00 to replace deteriorated trim - want a recall on this as it is very dangerous/ I also want reimbursement of 642.00 for repair

The contact owns a 2019 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormal rattling sound coming from the windshield. The vehicle was taken to a dealer, and the contact was informed that the exterior A-pillar trim retention clips were loose and needed to be replaced, and the contact was provided an estimate for the repair. The contact then received notification of NHTSA Campaign Number: 24V031000 (Structure); however, parts for the recall were not yet available. The dealer was notified of the failure, and the contact was informed that parts were not yet available. The manufacturer was made aware of the failur,e and the contact was provided the same information from the dealer. The vehicle was not repaired. The failure mileage was 64,000.

Rear toe link and bushing issues. I have the same car as my sister. She has a 2016 with the same rear toe link as my 2019 and her car is covered under the recall and mine isn't.

When the vehicle is in outside in the direct sunlight, the extreme heat causes the fuel pump driver module to fail. When this module fails, it cause the vehicles fuel pump to stop sending fuel to the motor which causes the vehicle to turn off or run extremely rough, while driving and or stationary. The moduel has been replaced by world ford Pensacola once, and twice by an ASE Certified Master Mechanic, on 3 separate occasions.

The contact owns a 2019 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle shuddered while shifting gears. The vehicle was taken to the dealer, who informed the contact that the power transfer unit (PTU) needed to be replaced. The vehicle was repaired. The contact related the failure to the Customer Satisfaction Program: 20B27. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

The contact owns a 2019 Ford Explorer equipped with Hankook Tires, Tire Line: Ventus S1 Noble 2, Tire Size: 255/50/R20, DOT Number: (Unavailable). The contact stated that the tread on all four tires were extremely low. The vehicle was taken to a tire shop where the tread depth was measured. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in TSB: SSM46905 and advised the contact to call the NHTSA Hotline for assistance. The failure mileage was approximately 19,700.

Windshield trim piece (passenger side) detached from vehicle while travelling at 40 mph.

Passenger's side A pillar trim piece broke and flew off at highway speed. This seems to be a previously identified manufacturer's defect not yet recalled.

Windshield and door trim is coming unglued and flaps while driving normal highway speeds.

Passenger side window trim blew off at highway speed without warning. Have not had it to the dealer yet as this appears to be a problem for the Explorer. I am not sure where the piece ended up. There was not a vehicle immediately behind the car so I don’t believe it struck anyone.

We were traveling on I90 west of Sioux Falls, SD. 06-01-2023. There is a 14 mile stretch that is under construction and the traffic is head to head in that stretch. We met a semi that created a gust of wind that blew the front window trim off the passenger side of the vehicle. I do not know where the trim went once it exited the vehicle. It was in an area where construction workers were working along side of the road and there was a line of cars behind us.

The bottom part that holds the windshield down is coming off. My windshield sounds like it is going to fly off when I drive. It makes a constant loud noise when driving. This has been an ongoing issue for almost 2 years. Ford told me they couldn’t do anything about it.

When the temperature outside is higher than an estimated 80 degrees the Battery indicator appears on the dash and the Ford Pass app tells me that there is a Charge System Fault. "The Battery light indicates that your vehicle has a concern with the 12-volt charging system." I have had a Ford Dealer check into this when I was under lease and they said they were unable to duplicate the warning. I also had an independent service center look into this and we decided to replace the battery and the battery terminals. However the alert still appears in the higher temperatures after making the change. I have seen this alert more than a dozen times having leased the vehicle from Ford from April 2019-April 2022 then purchasing the lease in April 2022. The date below indicates the last date the alert occur (5/12/23)

While driving on highway I-20 at 80 miles per hour, the trim panel around the windshield detached. The panel detached on the drive side but the passenger side is already detaching from the bottom part.

The contact owns a 2019 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle shuddered. The contact stated that while coming to a stop the vehicle shuddered and hesitated to resume driving. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who informed the contact that the torque converter needed to be replaced. The vehicle was not repaired. The contact related the failure to TSB Number: 20N07 (2.3L Engine and 6F35 Transmission). The manufacturer was not made aware of the failure. The approximate failure mileage was 82,000.

I have a 2019 Ford Explorer. I have seen that serval people have reported the front windshield trimming flying off going down the road for no reason. I recently had to replace both of my window trimming because this happened to me. One flew completely off going down the interstate and the other one came off but lucky did not fly off with traffic around. This is very dangerous not only for the owner of the vehicle but other vehicles around when it flys off. I have contacted FORD and they do not want to reimburse me for the amount of money I have spent to get this fixed. This is not a default on the owners end, it is a FORD default. I feel as if Ford needs to reimburse. Again, this could be very dangerous for other drivers on the road when these prices fly off. Safety first.

The windshield piece flow off while we were traveling around 45mph. We did not know what happened until the next day when we saw it missing.

The rear camera failed and it was discovered a corroded connector and cable. This is causing rear camera to fail. Ford helped with the repair cost however, the entire cable was replaced. Waited 5 months. This is a common problem and FORD should cover the refund and recall. The cameras are on a recall but not the cables that are causing the camera to fail. The repair costs like $2000. Ford did help. This is a manufacturer defect and the problem is common. Please see pictures and the video link. https://youtu.be/ewz_OeFO_6M

OEM Ford Gen 4 SYNC 3 Nav APIM suddenly started sporadically functioning. Contacted Ford after viewing multiple recalls from previous years Ford vehicles with exact issue. After being told there was no recall on my 2019 Explorer, was given a quote of $170.00 to diagnose issue, $900 + for APIM module, plus installation and programming. We purchased a re-programmed APIM module and installed. Problem is now corrected. Recall needs entered on this unit. Attaching photos of front & back of bad unit: WY1W748K GR26A KB5T-14G370-DCA SERIAL NO. 205831 MFG - JANUARY 2019 ASSY NO. MAJ0673GX PANASONIC AUTOMOTIVE SYSTEMS MODEL FA-170-BCAR-HS IFT# RCPPAFA16-2032 FCC ID: ACJ-FA-170-BCARHS IC ID: 216B-FA170BCARHS ANATEL ID: 05008-16-09014 CMIIT ID: 2016AJ4795

I have been waiting on parts for the A-Pillar trim recall for a couple years. I've checked with 3 different local Ford dealers and have been told these parts are still back-ordered. This is a safety issue as the trim can detach while driving at higher speeds on the interstate.

The front window side panel is in the process of coming off on both side it’s already detaching from the top of both side & im afraid it’s gonna hot someone if it flies off I started to notice this a little after I got the car & im noticing more & the dealer ship saw it when I got the car & said it’s not on recall

The contact owns a 2019 Ford Explorer. The contact stated that while the vehicle was at a complete stop, the vehicle shuddered. Additionally, the vehicle hesitated to accelerate while driving. No warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the VIN was not included in Customer Satisfaction Program: 20N07 (Transmission Extended Warranty Coverage) and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 80,000.

The contact owns a 2019 Ford Explorer. The contact stated while driving 40 MPH, the side trim on the passenger’s side windshield detached from the vehicle. The dealer was contacted and made aware of the failure. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 76,000.

The horn/horns stopped working. There just was no more sound. No wreck or jolts. Just no sound. Pressed all angles and area of horn “button” but not even a hint of horn sound. Horn fuse and horn relay are both good.

I bought Ford Explorer 2019 brand new. I think first week of January 2023 My wife mention 3 times the car lost power and powertrain light on. She was afraid this happens in the freeway so I took to Ford dealer and they took around 3 month to repair.

Windshield trim panels flying off vehicle while driving down the road