2020 Ford Explorer Electrical System Problems

Three alerts appeared on my dash after starting my car. These alerts are “Pre-Collision Assist Not Available,” “Service AdvanceTrac,” and “4WD Fault Service Required.” This has been an ongoing issue with this vehicle which directly affects the safety of drivers. After discussing with other consumers, this system failure is happening more and more. While these alerts are displayed, the front end collision assist is completely nonfunctional, thus increasing the risk of an accident. The Advanced Traction Control System is also nonfunctional. Based on other consumers with the same experience, the only solution is to replace the AWD module.

The contact owns a 2020 Ford Explorer. The contact stated that while driving approximately 65 MPH, the vehicle lost automotive power and stalled. The contact stated that there was an abnormal whining sound coming from the vehicle prior to the vehicle stalling. The vehicle was stopped and there was an abnormal burning rubber odor inside the cabin of the vehicle. The contact stated that the messages “Charging System Fault” and “Service Steering” were displayed. The contact stated that unknown warning lights were illuminated. The vehicle was towed to the residence. The contact stated that her husband replaced the battery and the alternator, however the failure persisted, and the vehicle was losing automotive power. The vehicle had not been taken to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 19V687000 (Electrical System). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was 113,849.

The back camera screen went blue, even though I already replaced the camera as per the previous recall. This time, the entire screen went blue.

I previously reported a safety issue re. Brakes not working in park. Vehicle rolled back and car almost hit mom and young daughter walking behind vehicle in parking lot. When I brought it to BellFord in [XXX] they told me it was not covered under the recall since it wasn’t being caused by rear axle. Instead they wanted to charge me $3,000 to diagnose their manufacturing defect. In addition when I notified Ford rep who never said anything other then I must get car diagnosed and pay for it and then “we will see .” Ford complaint XXX and I believe this is the NHTSA Complaint # XXX. Here is my initial Ford complaint Cxh-XXX was closed without explanation no one could tell me why no one had contacted me. I am very concerned that Ford is not taking responsibility for defective cars. My car now has only 47k. Brake issue. I had to replace front boots due to leaking and front axle was leaking. I had that fixed and now rear back up camera isn’t working. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a leaking antenna (likely the "shark fin" or roof antenna base) on my 2020 Ford Explorer. This has caused significant electrical issues, leading to safety concerns like malfunctioning lights, infotainment, or even stalling, the water shorting wiring harnesses or modules located in the roof or headliner area. This should be a recall, but rather it is a known problem where water intrusion damages sensitive electronics, necessitating immediate professional inspection and repair to prevent further damage and ensure safety, as electrical failures can be dangerous. My GPS and satellite do not work because of this and I am being charged significantly by the dealership because I have to repair this or the damage will become more severe. The antenna's base seal can fail, allowing water to seep into the roof, drip down the pillars, and saturate the headliner and wiring harnesses. Common Symptoms: Interior lights, instrument cluster, or dashboard warnings. SYNC system freezing or failing. Windows, locks, or other accessories malfunctioning. Even potential water on the front passenger floor. Safety Risks: Loss of Control!!!!!!! Malfunctioning lights (headlights, brake lights) or sudden power loss can create dangerous driving conditions. Reduced Visibility: Issues with the infotainment screen or instrument cluster can distract the driver. System Failures: Critical safety systems, if affected by water, could fail unexpectedly. I barely get car washes or anything. This is certainly a manufacturers issue & poor design or cheap casing/ seals that leak and corrode too easily. This problem is a known weakness for the 2020 Explorer, often requiring a thorough inspection beyond just the antenna itself, as water can travel far from the entry point. And sure enough I have plenty of damage that I should not have to pay for. This is not a fluke, there are forums all across the internet about this. Please help! This is truly unfair to the customers.

**Upon request, all failed components can be inspected anytime for any reason. From this date (01/23/26) forward. If any repairs or replacementa had been rectified by Ford, receipts of the repair(s) will be provided regardless. I cannot recall exactly when these issues started so my ball park is 5/11/22. That is literally 2 years of driving the car from the show room. I was getting some lights on my dash that I have lost all functions with the vehicle ...ie: drivers assistance, airbags, up hill decent, pre- collision, no driving modes and the car felt normal. I was still under warranty so the repair that was done was an update to the BCM (is what I am told.) So the mechanic did a reprogram to the module. About a year I noticed I was then getting check headlamp notification pin my dash. I check the lamps and all seemed to be just fine. Also I was dealing with a dead battery all the time. at least once a month. But I was told I needed to drive the car more often. No matter still getting a dead monthly battery and here and there "check headlamp". Approx last year 2025, I realized. it was really dark driving the SUV. I get out and long behold the low beam headlamp was out. Played with switches..nothing. Checked into just getting a new one. its is a STAGGERING 1.5K!!!!PER HEADLamp! Well, the cops pull me over 4 times. For a headlight with LEDs why am I even having to price this? This Platinum trim just h I 5 years old and I cant believe all the problems. Along with that I found that this is considered something for the owner has to replace due to owners maintenance. No. THIS NEEDS TO BE RECALLED. SHOULD HAVE ALREADY BEEN RECALLED. THE DEAD BATTERY. WELL...I know am out of all warranties to the vehicle AND FORD IS SHUTTING THE DOOR IN MY FACE for any "goodwill repairs" (So far) As of this very moment, I have a dead 2020 Ford Platinum Explorer. Heads Lamp is still out. Yet there is a recall on a backup camera. Complete joke and this is literally disappointing.

Air Conditioner turns ON by itself even after being manually TURNED OFF, happened multiple times. This occurred with the manual start and the vehicle running / moving.

What component or system failed or malfunctioned, and is it available for inspection upon request? Sunroof headliner assembly failed. The headliner fabric detached and came off the track without an prior misuse or manual operation, it simply fell loose on its own. The material is now sagging and when trying to use the sunroof the fabric hangs in the line of vision causing a safety hazard. How was your safety or the safety of others put at risk? While the issue did not cause an immediate accident, the loose headliner obstructs visibility while trying to use could become a distraction to the driver.IT blocks the driver's line of sight or interferes with airbags in an emergency. Has the problem been reproduced or confirmed by a dealer or independent service center?The failure occurred spontaneously and I have a appointment to take the dealership for further inspection. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No formal inspection has been completed at this time. The issue will be presented to a Ford service center for further evaluation. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No warning lights or messages appeared prior to the failure. The issue occurred suddenly and without any prior indication. The fabric and track system separated unexpectedly during normal stationary conditions.

When driving the vehicle's instrument panel cluster randomly goes blank. When it does so, all of the items related to speed control, lighting, turn signals, etc. become non-operational. Additionally, the driver has no idea what his/her speed is nor any other information about the operation of the vehicle. It is very unsafe.

Vehicle: 2020 Ford Explorer XLT Date of Incident: October 24 2025 Approx. Mileage: 82000 Affected Component: Visibility / Defroster / Rear Window Glass Description of Problem: While the rear defroster was on, the rear window of my 2020 Ford Explorer XLT suddenly made a popping noise and began to spider-crack from a point near the defroster grid. There was no external impact to the glass. The cracking continued slowly across the entire rear window after the noise. The event occurred on October 24 2025. The vehicle was parked outdoors in normal fall weather conditions in Pennsylvania, and the rear defroster had been turned on to clear condensation. This appears to be a rear defroster thermal event, similar to issues described in Ford’s Customer Satisfaction Program N192265660, which addressed defroster overheating and rear-window damage in certain Ford vehicles. The defect presents a safety concern, as the rear glass integrity is compromised and visibility is reduced. I have photographs of the crack pattern and plan to have the the window replaced by safelite. It is not safe to drive to a dealership. Please investigate this potential manufacturing or electrical defect affecting 2020 Ford Explorer models.

Parking brake won't disengage. Cannot drive or reverse

Vehicle was engaged in park with parking brake on, I put my foot on brake applying pressure & shifted out of park to drive. As I disengaged parking brake vehicle pushed forward 10 feet forcing me to take my foot off brake & reapply pressure to stop vehicle.

Water has been leaking on my passenger side front floor, and now the blower motor has completely seized. Ford quoted me over $1,000 for a blower motor! I have requested asking for satisfaction warranty for this to be covered via email, with no response. Blower motors should not go bad this soon. I have no way to defrost or defog my windows. This is a major safety concern

The contact owns a 2020 Ford Explorer. The contact stated while driving at an undisclosed speed, the brake pedal was depressed, and then the contact depressed the accelerator pedal, and the engine seized. No warning light was illuminated. The contact attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with a failed power control module. The contact was informed that the power control module needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced an unknown recall; however, the VIN was not included in the unknown recall. The failure mileage was approximately 90,000.

First my radio will not come on when you first start the explorer. Then you turn it off and turn it back on then the radio will start to work. Then blind spot stop working will the radio. They said they fix the problem by updating the software in the radio. That work for a week then it happen again now they said it's the audio control Module need to be replace. And the battery will drain over night they said the recall is for other fords not mine. I paid for a new battery and alternator. But they said my explorer not on the list.

Put vehicle in reverse camera camera on then went black and the backup lights went out while trying to move resulting in hitting a pole.

The contact owns a 2020 Ford Explorer. The contact stated that while driving at various speeds, several DTC were displayed. The contact stated that the messages “Service 4WD”, “Service Advancetrac”, “Cruise Control not Available”, “Collision Alert”, and “Traction Control” were displayed. The vehicle was not yet diagnosed. The contact stated that several months ago the vehicle was repaired for the same failures. The contact stated that the failure persisted. The manufacturer was not contacted. The failure mileage was approximately 80,000.

Back latch is getting stuck in secondary position when released. Module is intermittently not communicating.

The button to adjust rear view side mirrors malfunctioned. The side mirrors no longer adjust or respond to the button.

Vehicle came into our shop with the charging system fault light on. Upon checking for codes BCM battery code B11D9:09:0A was present. During diagnosis the technician found that the battery cable was rubbing against the floorboard of the vehicle causing arching/welding of the positive battery against the floorboard of the vehicle leaving visible damage to the vehicle.