There are 8 owner-reported electrical system complaints for the 2023 Ford Explorerin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2023 Ford Explorer. The contact stated that while driving at an undisclosed speed, the steering wheel became inoperable. There were several unknown warning lights illuminated. The vehicle was taken to the dealer, where the vehicle was diagnosed and determined that the wiring harness located on the passenger’s side of the vehicle needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 44,500.
Error codes such as blind spots detection with traffic and a couple other codes that is stored in view status area in oasis
The contact owns a 2023 Ford Explorer. The contact stated while driving 15-20 MPH, the vehicle stalled on several occasions. The vehicle was restarted after fifteen minutes. The vehicle failed to unlock from inside or outside with the key. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the ground wire had caused the failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 10,000.
At a stop light and all of the power in the vehicle went out and Explorer would not start. Hazards would not turn on and doors (besides driver door) would not unlock. Got out of the vehicle to try the fob and white smoke came billowing out from engine. Fire department and police were called. No warning lights or messages were seen on vehicle. Vehicle only has 10K miles on it. Vehicle was taken to dealership for diagnostics.
drivers side second row captain seat makes ticking noise under the seat. if I put weight on seat it stops. it is intermittent. Im concerned it might be electrical. I have a video but unable to download. I can send if there is an email to send to.
The contact owns a 2023 Ford Explorer. The contact stated while his wife had parked and remained in the vehicle, and while driving at various speeds, several unknown warning lights illuminated. The contact stated that a dealer was contacted. The vehicle was taken to the dealer and the contact was informed that the Cross-traffic monitor and Blind Spot monitor had failed. The contact was informed that the software was updated; however, the failure persisted. The vehicle was not repaired. The manufacture was notified of the failure and opened a case. The contact was referred by the manufacturer to the NHTSA Hotline to report the failure. The approximate failure mileage was 33,000.
Vehicle wouldn't start using push button start, several modules/components reported errors: traction control, parking break, steering, shifting. The vehicle drove fine less than 24 hours prior to 3/3/2024. Following a week at the dealership, Ford Motor Company and the Ford dealership determined the main wiring harness was the culprit. If the wiring harness fails while the vehicle is in motion/operation, that could result in a serious safety issue.
The contact owns a 2023 Ford Explorer. The contact received notification of NHTSA Campaign Number: 25V442000 (BACK OVER PREVENTION). The contact received Customer Satisfaction Program (CSP): 24B47 in August 2024. However, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Most recently, the contact stated that when the vehicle was started, the navigational system displayed a black screen, compromising the functions on the screen. No warning lights were illuminated. The contact stated that the Ford App on the cellphone failed to sync with the vehicle as intended. The message "Unable to Connect" was displayed on the App. While attempting to remotely start the vehicle, the message "Temporarily Unavailable – Unable to Connect" was displayed. The vehicle was taken to the dealer several times to be diagnosed, and it was determined that the software and screen had failed. The vehicle was not repaired. The manufacturer was notified of the failure and sent an Over-the-Air software update; however, the sync failed to connect as intended. The failure mileage was approximately 3,000.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on May 4, 2026