1996 Ford F-150 Speed Control & Cruise Problems

The contact owned a 1996 Ford F-150. The contact received notification of NHTSA Campaign Number: 05V017000 (Vehicle Speed Control). The contact stated that while parked in the driveway, she observed fire between the finder and the hood. The heat from the fire rippled the front of the garage causing property damage. The vehicle was not diagnosed and the origin of the fire was not determined. The fire was extinguished by the fire department. The vehicle was towed to an unknown impound lot. It was unknown if a police report or fire department report was filed. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 58 MPH, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE CONTACT WAS ABLE TO KEEP THE VEHICLE UNDER CONTROL AND COASTED ONTO THE ROAD SHOULDER. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE THROTTLE FAILED. THE CONTACT CLEANED THE THROTTLE AREA AND DISCONNECTED THE CRUISE CABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 195,000.

TL* THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 05V388000 (VEHICLE SPEED CONTROL) AND THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. FOUR YEARS LATER, THE NEW PARTS THAT WERE PLACED ON THE VEHICLE UNDER THE RECALL BEGAN TO OVERHEAT AND SMOKE WHENEVER THE VEHICLE WAS PARKED. THE VEHICLE HAD NOT BEEN INSPECTED BY A DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 167,000. UPDATED 06/01/11*LJ UPDATED 1/18/2012 *LN THE CONSUMER STATED THE CONTROL VALVE WAS REPLACED ON 4/26/11

1996 FORD F-150 TRUCK BURST INTO FLAMES WHILE IT WAS TURNED OFF AND WAS SITTING FOR 5 DAYS. FIRE INSPECTOR DETERMINED THE ORIGIN OF FIRE WAS AT THE MASTER SOLENOID OF THE BRAKE SYSTEM. THE CRUISE CONTROL, WHICH HAD STOPPED WORKING ONE WEEK PRIOR TO THE EVENT, RESTS ON THE MASTER BRAKE SOLENOID.. THE CRUISE CONTROL HAS BEEN RECALLED ON THIS VEHICLE. THE OWNER HAD NOT RECEIVED A RECALL FROM THE FORD COMPANY. THE TRUCK IS A TOTAL LOSS WITH BOTH ENGINE AND CAB COMPLETELY ENGULFED IN FLAMES. THE HOUSE THAT WAS APPROX. FIVE FEET AWAY WAS DAMAGED. *TR

A FIRE OCCURRED UNDER THE HOOD OF OUR 1996 FORD F-150, DESTROYING THE WHOLE FRONT END AND INTO THE CAB. TRUCK IS A TOTAL LOSS. NO ONE WAS HURT, AND IT WAS PARKED ON MY JOB PARKING LOT, AWAY FROM ANY CLOSE VEHICLES. I HAD JUST DRIVEN TO WORK. I ARRIVED TO WORK AS A SECURITY OFFICER AT 11:20P.M. AND AT 12:50A.M. THE TRUCK WAS IN FLAMES. WE BOUGHT IT USED IN MARCH 2008 AND HAD NEVER HEARD OF ANY RECALLS OR ANY DEFECTS. IT WAS A VERY CLEAN, WELL KEPT TRUCK. WE RECEIVED ONE RECALL NOTICE IN LATE NOVEMBER EARLY DECEMBER 2008(DURING HOLIDAYS) ABOUT A SPEED CONTROL SWITCH. THE LETTER STATED THAT THE VEHICLE COULD IGNITE AT ANY TIME. IT GAVE NO WARNING SIGNS TO LOOK FOR AND STATED IF WE COULD NOT GET IT IN RIGHT AWAY TO PARK IT AWAY FROM ANY DWELLINGS. MY HUSBAND IS DISABLED, HE COULDN'T JUST RUN DOWN THERE, AND IT WAS THE HOLIDAYS AS WELL. I LOOKED UP THE RECALL ONLINE AFTER THE FIRE, AND IT STATED THE POTENTIAL FOR A FIRE WAS SMALL, AND IT GAVE WARNING SIGNS TO LOOK FOR ON THE VEHICLE. WHY WEREN'T THOSE WARNINGS EXPLAINED IN THE RECALL NOTICE?? TO OUR KNOWLEDGE, THE TRUCK WAS 12 YEARS OLD AND RAN LIKE A NEW ONE. HOW COULD IT HAVE BEEN OVER-LOOKED ALL THOSE YEARS? THIS WAS DEVASTATING TO US, IT COULD HAVE BEEN MUCH WORSE AND KILLED SOMEONE. THE TRUCK WAS 3/4 FULL OF FUEL. *TR

TL*THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL). HE TOOK THE VEHICLE TO THE DEALER, BUT THEY DID NOT HAVE THE PART TO PERFORM THE RECALL REPAIR. THEY DID NOT KNOW WHEN THE PART WOULD BE AVAILABLE AND COULD NOT PROVIDE MUCH INFORMATION. A FEW DAYS LATER, THE VEHICLE CAUGHT FIRE. THE FIRE AND POLICE DEPARTMENTS WERE CALLED TO THE SCENE. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED TO A YARD. THE FAILURE AND CURRENT MILEAGES WERE 170,000.

1996 FORD F150 PICKUP. BURNED UP SETTING IN DRIVEWAY. *TR

TL* - THE CONTACT OWNS A 1996 FORD F-150. THE CONTACT STATED THE VEHICLE CAUGHT ON FIRE ,AND HE FELT THAT THE FAILURE WAS RELATED TO RECALL#05V388000, SPEED CONTROL DEACTIVATION SWITCH. THE CONTACT HEARD THAT THEY WILL NOT HONOR THE RECALL UNLESS THE CONTACT PAID FOR THE LABOR.*AK

DENTON, TEXAS. RECENTLY PURCHASED USED 1996 FORD F 150 TRUCK, SAT IN WORK PARKING LOT UNDER A SHADE TREE FROM 7:30 AM-3:15 PM...AND ENGINE COMPARTMENT BURST INTO FLAMES, DESTROYING THE TRUCK. I WAS NOTIFIED AT 3:20 THAT MY TRUCK WAS ON FIRE WHICH WAS NOT ABLE TO BE PUT OUT WITH HAND EXTINGUISHERS. FIRE DEPT WAS CALLED, BROKE WINDOWS TO PUT OUT FIRE INSIDE THE CAB. TRUCK WAS TOTALLY BURNED OUT FROM CAB FORWARD. POLICE WERE CALLED, BUT REFUSED TO COME. FIRE MARSHALL IN DID NOT RESPOND TO CALL. MESSAGE WAS LEFT ON ANSWERING MACHINE. SHADE TREE WAS BURNED, BUT VEHICLES NEARBY WERE MOVED PRIOR TO ANY INVOLVEMENT. NO PERSONAL INJURIES OCCURRED. *NM

TL*THE CONTACT OWNS A 1996 FORD F150. THE CONTACT STATED THAT SHE HAS BEEN WAITING TWO YEARS FOR FORD TO REPAIR THE CRUISE CONTROL ON HER VEHICLE. NHTSA CAMPAIGN ID NUMBER 05V388000 (VEHICLE SPEED CONTROL) WAS ISSUED IN 2005 AND THE CONTACT HAD THE CRUISE CONTROL DEACTIVATED IN MAY OF 2006. SHE CALLED FORD SEVERAL TIMES TO FIND OUT WHEN THE PARTS WOULD BE AVAILABLE FOR THE RECALL REPAIR. THE DEALER KEEPS PROVIDING DIFFERENT DATES AND THE PARTS ARE STILL UNAVAILABLE. WHEN THE CONTACT WAS RECENTLY INFORMED THAT HER LOCAL DEALER DID NOT HAVE THE PARTS, FORD PROMPTED HER TO CONSULT OTHER DEALERS; HOWEVER, NONE WERE IN CLOSE PROXIMITY. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND POWERTRAIN WERE UNKNOWN. THE CURRENT MILEAGE WAS 140,000.

THE CRUISE WAS NOT WORKING IN OUR 1996 FORD PICKUP. WE HAD DROVE IT THAT NIGHT AND HAD GOTTEN HOME ABOUT 10:00 P.M. AND ABOUT 3:00A.M. WE HEARD A LOUD BANG. THE GARAGE WAS ON FIRE. WE REPORTED IT TO FORD MOTOR CO. WITH NO RESPONSE FROM THEM, EXCEPT WE THEN RECEIVED A RECALL NOTICE. *TR

DT: THE CONTACT STATES HIS VEHICLE CAUGHT FIRE IN THE ENGINE COMPARTMENT WHILE THE ENGINE WAS TURNED OFF. THE VEHICLE HAD BEEN PARKED FOR APPROXIMATELY AN HOUR AND A HALF. THE FIRE SPREAD DAMAGING TWO ADDITIONAL VEHICLES THAT WERE PARKED NEARBY. THE FIRE DEPARTMENT CAME AND DISTINGUISHED THE FIRE. THE VEHICLE WAS DEEMED TOTAL LOSS BY THE INSURANCE AGENCY. AFTERWARDS HE RECEIVED A RECALL LETTER NHTSA CAMPAIGN ID NUMBER 05V017000 INVOLVING THE SPEED CONTROL DEACTIVATION SWITCH. NO REPAIRS COULD BE MADE DUE TO THE EXTENSIVE DAMAGE. *NM

MY CLIENT'S 1996 FORD F-150 CAUGHT FIRE AND WAS COMPLETELY DESTROYED WHILE IT WAS PARKED IN HIS DRIVEWAY; ITS VIN IS: [XXX] -- HE REQUESTS AN INVESTIGATION OF THE SAME OR MORE INFORMATION AS TO FORDS POLICY AS TO VEHICLES DESTROYED BY FIRE BEFORE THE RECALL.*JB UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DT: THE CONTACT STATES THERE IS NHTSA RECALL 05V388000 CONCERNING THE VEHICLE SPEED CONTROL DEACTIVATION SWITCH . THE PART NEEDED TO REPAIR HIS VEHICLE IS NOT AVAILABLE AT THE LOCAL DEALERSHIP. THE CONTACT SPOKE TO MANUFACTURER, WHO CONFIRMED THAT THE PARTS WERE NOT AVAILABLE AT THIS TIME. *AK

FAULTY CRUISE CONTROL SWITCH FIRE ON MY 1996 FORD F-150 PICK-UP. THE FIRE STARTED THIS MORNING ABOUT 2 HOURS AFTER I GOT TO WORK TODAY. THIS IS THE SAME PROBLEM THAT I AM AWARE OF WITH THE 2000 F-150'S BUT MY TRUCK IS A 1996 AND I HAVE NEVER HAD TO REPLACE THE SWITCH. I BOUGHT THE TRUCK IN 1997 WHEN IT WAS ABOUT A YEAR OLD. THE FORD-SMART WEB SITE SAID TO CONTACT YOU IF ANY OTHER YEARS THAN 2000 HAD THIS SAME PROBLEM. *JB

DT: 1996, FORD F150 PICKUP TRUCK CAUGHT ON FIRE WHILE PARKED OUTSIDE OF THE GARAGE AND THE ENGINE WAS NOT RUNNING. THE TRUCK HAD NOT BEEN DRIVEN FOR AT LEAST 2 HOURS PRIOR. THE LAST TIME IT DRIVEN WAS ON SHORT TRIP TO A LOCAL GAS STATION IN WHICH THE FUEL TANK WAS FILLED UP. CONSUMER WAS NOTIFIED BY A PASSING DRIVER, WHO WAS IN THE NEIGHBORHOOD AND KNOCKED ON THE DOOR TO ALERT THEM, THAT TRUCK PARKED IN THE DRIVEWAY ON FIRE. CONSUMER'S HUSBAND AND THE PASSER BY TRIED TO PUT OUT THE FIRE WITH A WATER HOSE AND FIRE EXTINGUISHERS. HOWEVER, THEY WERE UNSUCCESSFUL. THE FIRE DEPARTMENT CAME AND PUT THE FIRE OUT. THE FIRE BEGAN ON THE LEFT FRONT DRIVER'S SIDE NEAR STEERING WHEEL. THE FIREMEN NOTED IT SMELLED ELECTRICAL IN NATURE, AND THAT THE HEAT FROM FIRE WAS MOST EXTENSIVE AND CONTAINED IN HEAT ON THE DRIVER'S SIDE. THE CAB WAS BURNED EXTENSIVELY. THE BED WAS INTACT, AND NO FIRE WAS ABLE TO REACH TO THE GASOLINE TANKS. THE HEAT FROM FIRE WAS SO EXTENSIVE THAT LEFT DRIVER'S SIDE TIRE MELTED AS WELL AS THE INTERIOR. CONSUMER SPOKE TO FORD ON 4 DIFFERENT OCCASIONS , WHO PROMISED THAT SOMEONE WILL CONTACT CONSUMER THROUGH THEIR LEGAL DEPARTMENT AND SOMEONE MAY COME OUT AND LOOK INTO THE CAUSES OF THE FIRE AND DAMAGES. BUT THIS HAS YET TO HAPPEN. NO REPAIRS WERE DONE. THE VEHICLE WAS TOTALED. . THERE WAS ONLY 68,000 MILES ON THE VEHICLE. *AK

1)CRUISE CONTROL STOPPED WORKING SEVERAL MONTHS AGO 2)1996 F-150 PARKED IN DRIVE WAY, GOT IN TRUCK AND COULD NOT GET OUT OF PARK. LOOKED UNDER HOOD, FOUND CRUISE CONTROL SWITCH AND ELECTRICAL CONNECTOR BURNT UP. THE BRAKE RESERVOIR WAS SEARED FROM CRUISE CONTROL BURNING UP. IF IT HAD BURNED THRU THE RESERVOIR, THE TRUCK MIGHT HAVE CAUGHT ON FIRE. 3)TRUCK HAS NOT BEEN FIXED YET, DEALER SAID I SHOULD CONTACT FORD, EMAILED FORD ABOUT FIXING TRUCK, NO RESPONSE YET

I HAVE A 1996 F-150 THAT THE CRUISE CONTROL QUIT WORKING ONSEVERAL MONTHS AGO. YESTERDAY, THE FUSE THAT SUPPLIES POWER TO THE "BRAKE PRESSURE SWITCH" BLEW. I FOUND BRAKE FLUID IN THE ELECTRICAL CONNECTOR OF THE "BRAKE PRESSURE SWITCH." WHY IS THIS VEHICLE NOT PART OF THE RECALL FOR THIS PART? MY DEALER SYAS HE HAS A REPLACEMENT SWITCH, BUT I AM HESITANT TO BUY. THINK I'LL JUST LEAVE IT UNPLUGGED FOR NOW.

1996 FORD F150 HAD MADE A SHORT TRIP TO HOME DEPOT. APPROXIMATELY 1 HR. LATER I SMELLED WHAT SEEMED LIKE BURNING TAR. I LOOKED AND THERE WAS A LARGE AMOUNT OF SMOKE COMING FROM UNDER MY HOOD.. UPON INSPECTION I FOUND THE CRUISE CONTROL BRAKE SWITCH SMOKING PROFUSELY, A SMALL FLAME. AND EXTREMELY HOT. I UNPLUGGED IT AND THE IMMEDIATE PROBLEM STOPPED.. THE SWITCH IS BURNT AND MELTED. IF I HAD NOT BEEN OUTSIDE AND FOUND THIS EVEN 5 MINUTES LATER. I WOULD NOW HAVE A BURNED TRUCK. THIS IS THE SAME SWITCH THAT FORD HAS RECALLED ON THE 2000 MODELS.AND ADMITTED TO HAVING A PROBLEM AS FAR BACK AS THE 97 MODELS. BUT NOT ON 96. I HAVE CHECKED THEIR WEB SITE AND THERE IS NO RECALL ON THIS YEAR. I WILL BE TAKING IT TO THE LOCAL FORD DEALERSHIP SOON.. BUT WAS WONDERING IF YOU HAD ANY MORE COMPLAINTS ON THIS MODEL FOR THIS PROBLEM.

DT: CALLERS TRUCK BURNED UP. NO WARNING OF ANY KIND. LOCAL DEALER SAID THERE WAS NO RECALL OR ANYTHING ON TRUCK. MANUFACTURER HAS NOT BEEN CONTACTED YET. FIRE DEPARTMENT CAME AND PUT FIRE OUT. REPORT FILED WITH FIRE DEPARTMENT. TRUCK WAS TOTALED.*AK THE FIRE WAS A RESULT OF THE CRUISE CONTROL DEVICE. *JB