2000 Ford F-150 Brakes Problems

This vehicle, as do all, have dual master cylinders, great, always have a front or rear brake system function in an emergency, but this vehicle also has FLEXIBLE to hard lines from master cylinder to ABS unit. I was driving down our long downhill driveway, pressed on the brake pedal, heard a pop and pedal went to the floor, NO brakes at all and buy the time I got to the emergency brake, which did little to stop the truck, I was out in the road. Glad I wasn't out on a highway doing 50MPH. Examined what had happened and the brake line from the master cylinder to ABS unit split where the flexible line joined the hard line, and when that line breaks, no brakes at all, no backup safety system. Don't know how the flexible lines ever passed safety requirements when manufactured, but they certainly shouldn't be on a truck that's 23 years old and all should be replaced with hard lines.

MY ABS LIGHT KEEPS COMING ON AND THEN IT WILL GO OFF. *TR

S10 APPROPRIATE HANDLING- LETTER TO THE SECRETARY FROM RE EXPRESSING CONCERNS REGARDING BRAKE LINE CORROSION. *KB THE CONSUMER STATED HE REPLACED ONE INCH OF THE BRAKE LINE AFTER HE ALMOST EXPERIENCED COMPLETE BRAKE FAILURE. THE OTHER LINES ARE STILL SEVERELY CORRODED AND WILL FAIL SOON. *JB

I WAS DRIVING ON THE HIGHWAY ONTO THE OFFRAMP, WHEN I GOT TO THE END, I HAD NEARLY 100% BRAKE FAILURE. I MANAGED TO DODGE A SEMI BY PULLING ON THE SHOULDER AND USING THE EMERGENCY BRAKE. THE BRAKE LINE HAD CORRODED FROM FROM TO BACK. I LOOKED ON THE NHTSA WEBSITE AND SEE A LOT OF THESE ISSUES, BUT SINCE THE GREAT MOUNDS OF NHTSA SEEM TO BELIEVE NEARLY TOTAL BRAKE FAILURE IS NOT AN ISSUE, I JUST REPLACE THE PART OF THE LINE THAT IS LEAKING. IT WILL VERY LIKELY FAIL AGAIN SOON, BUT I KNOW THAT IT THAT WAS A PROBLEM, THEN NHTSA WOULD DO ITS JOB AND PUSH A RECALL. JUST ANOTHER CASE OF NHTSA DECIDING WHICH CONSUMERS SHOULD BE PROTECTED UNDER THE LAW AND WHICH ONES SHOULD HAVE THEIR LIVES PUT AT RISK. I GOT A NOTE FROM [XXX] AT NHTSA CLAIMING THEY MIGHT CONDUCT A STUDY, BUT GIVEN THAT A 10 MONTH STUDY BY NHTSA WAS INSUFFICIENT TO DETERMINE THAT GASOLINE SPILLING OUT ONTO THE HIGHWAY MAY POSE A CONSUMER RISK, I'M BETTING THIS WILL GO NO WHERE. TAX DOLLARS AT WORK!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE BRAKES LINES BLEWOUT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT THEN NOTICED THAT ALL OF THE BRAKES LINES ON THE VEHICLE WERE RUSTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND ALL OF THE BRAKE LINES WERE REPLACED UP TO THE MASTER CYLINDER. THE FAILURE AND CURRENT MILEAGES WERE 89,000.

WAS GOING TO FORD DEALER FOR GAS TANK STRAP RECALL DUE TO STRAPS THAT HAVE POOR CORROSION PROTECTION. AS I WAS ENROUTE TO DEALER I APPLIED MY BRAKES DUE TO A CAR RUNNING A STOP SIGN AND MY BRAKES GAVE WAY AND I JUST MISSED A SERIOUS ACCIDENT. I CHECKED MY BRAKE LINE WHERE THE LEAK WAS AND DUE TO VERY POOR RUST THE LINE BLOW OUT. I ASK THE DEALER WHEN PERFORMING THE RECALL REPAIR COULD HE FIX THE LINE AND WAS STATED A 600.00 CHARGE. WHILE AT THE DEALER I CALLED FORD VP OF CUSTOMER SERVICE FRED TONEY WHO THEN SENT ME TO MR. FEDDERS. I TALKED TO A PERSON FROM HIS OFFICE AND TOLD THEM THAT FORD HAS A BIG PROBLEM ON BRAKE LINES RUSTING AND BECAUSE OF THAT I JUST MISSED HAVING A SERIOUS ACCIDENT. I ASK FORD TO FIX THE LININGS AT NO CHARGE AND TAKE THE LINE FOR OBSERVATION. I WAS TOLD THAT SINCE THE TRUCK IS 10 YEARS OLD AND HAS 200,000MILES ON IT THEY WILL NOT DO ANYTHING. I STATED THAT FORD HAS NO PROBLEM REPAIRING THE GAS STRAPS OF A 10 YEAR OLD TRUCK. ANYWAY HAD MY TRUCK TOWED TO MY MECHANIC AND REPAIRED. THEY REPLACED THE FRONT LINES AND INTERMEDIATE BRAKE LINES DUE TO POOR CORROSION. I WAS TOLD MY PASSENGER SIDE LINE AND BOTH REAR LINES ARE IN GREAT SHAPE, NO RUST AND COATED. I TOLD FORD ABOUT THIS AND SAID I WANT A FORD REP TO INSPECT MY COATED BRAKE LINES. AND MY DEFECTED LINE WHICH I KEPT FOR PROOF. I ASK FORD WHY SOME LINE WERE COATED AND SOME WERE NOT. I WAS TOLD THAT FORD DOES NOT COAT THE LINES. WE HAVE A SERIOUS PROBLEM HERE AND COULD RESULT IN MANY DEATHS. IF THE OTHER LINES WERE COATED I WOULD HAVE NOT HAD THIS PROBLEM. FORD JUST WROTE THIS WHOLE THING OFF. I EXPECT NHTSA TO GET BACK TO ME AS SOON AS POSSIBLE. I EXPECT MY TRUCK TO BE INSPECTED AND THE LINE THAT I HAVE KEPT TO BE INSPECTED. I AM NOW NOTIFYING NHTSA AND FORD HAS BEEN NOTIFIED ABOUT THIS PROBLEM AND IS ON RECORD IN THE EVENT NOTHING IS DONE AND PEOPLE GET KILLED THE PARTIES WILL HAVE A PROBLEM. *KB

MY TRUCK FRONT CROSS MEMBER THAT SUPPORTS RADIATOR AND THE BODY TO THE FRAME IS JUST ABOUT RUSTED GONE. DEALER STATED THAT TRUCK IS 11 YEARS OLD AND WILL NOT FIX. I AM SENDING THIS FOR RECORD IN THE EVENT I AM KILLED DUE TO ANY FAILURE. HAVE READ TWO CASES ON YOUR WEBSITE. ONE IS A 2000 F-150 THAT A CROSS MEMBER SUPPORT RUSTED OUT IN 2003 WITH 48,000 MILES. ANOTHER WAS A 2000 F-150 THAT HAD A TAG ATTACHED TO THE FRAME STATING DEFECTIVE MATERIAL DO NOT USE! L/S PERFORMANCE *AK. I EXPECT A FULL INVESTIGATION ON THIS AND WANT MY VEHICLE INSPECTED. THE CONSUMER WAS INFORMED THE BRAKES LINES NEEDED TO BE REPLACED AS THE VEHICLE WAS UNSAFE TO DRIVE. UPDATED 01/06/12 *TR

BRAKE FAILURE WHILE DRIVING DUE TO CORRODED BRAKE LINE ABOVE FUEL TANK. NO WARNING LIGHTS PRIOR TO OR AFTER FAILURE. *KB

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN SMOKE WAS EMITTED FROM UNDER THE HOOD. THE CONTACT AND THE DRIVER EXITED THE VEHICLE AND THEN NOTICED FLAMES COMING FROM UNDER THE HOOD. THE DRIVER WAS ABLE TO EXTINGUISH THE FIRE WITH A FIRE EXTINGUISHER AND THE FIRE DEPARTMENT DID NOT REPORT TO THE SCENE. THE VEHICLE WAS TOWED TO AN AUTO SHOP WHERE THE TECHNICIANS STATED THERE WAS AN ELECTRICAL SHORTAGE IN THE MASTER CYLINDER THAT CAUSED THE FIRE. THE INSURANCE COMPANY STATED THAT AN INSPECTOR WOULD INVESTIGATE THE VEHICLE TO DETERMINE IF THE VEHICLE COULD BE REPAIRED OR WOULD BE DEEMED AS DESTROYED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE ABS BRAKE LIGHT WOULD ILLUMINATE SPORADICALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE ABS MODULAR NEEDED TO BE REPLACED. THE DEALER ADVISED THAT THE VEHICLE COULD BE DRIVEN, BUT WOULD HAVE TO BE DRIVEN SLOW IN INCLEMENT WEATHER BECAUSE THE MODULE FAILED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 143,000. UPDATED 01/24/12*LJ UPDATED 01/25/12

MY SON WAS INVOLVED IN AN ACCIDENT ON 4/22/2010 WHILE DRIVING A 2000 FORD F-150 4X2 TWO DOOR PICKUP TRUCK. SIDE MARKS AT THE SCENE REVEALED THAT THE F-150'S ANTI-LOCK BRAKES DID NOT ENGAGE CAUSING THE TRUCK TO SLIDE RESULTING IN A FAILURE TO STOP IN TIME TO AVOID THE ACCIDENT. THE AIR BAG DID NOT DEPLOY AFTER THE FRONT-END IMPACT AND THE SEATBELT DID NOT LOCK CAUSING MY SON TO BE THROWN FORWARD HEATING HIS HEAD ON THE SUN VISOR AND SNAPPING HIS HEAD BACKWARD ROLLING HIS FACE INTO THE ROOF OF THE TRUCK AND INJURING HIS NECK. HE ALSO BRUISED SOME RIBS ON THE STEERING WHEEL AND JAMMED SEVERAL FINGERS. THE SEATBELT DID KEEP HIM FROM BEING EJECTED FROM THE VEHICLE BUT BY NOT ENGAGING, CAUSED UNNECESSARY INJURIES. HAD HE BEEN DRIVING AT A HIGHER RATE OF SPEED AT THE TIME OF THE IMPACT HE INJURIES WOULD HAVE BEEN FAR MORE SERIOUS AND EVEN LIFE THREATENING. WE PURCHASED THIS F150 ON 1/19/2010 FROM THE CITY OF MOUNT JULIET, TN. THE VEHICLE WAS WELL MAINTAINED BY THE CITY ACCORDING TO THE VEHICLE MAINTENANCE RECORDS. WE REQUEST TO HAVE A NON-PARTIAL EXPERT EXAMINE THE VEHICLE TO DETERMINE THE CAUSE OF THE SAFETY FEATURES FAILURE TO DEPLOY ON THIS VEHICLE. *TR

TL*THE CONTACT OWNS A 2000 FORD F-150. THE VEHICLE WAS PARKED FOR SIX HOURS BEFORE CATCHING FIRE. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. A POLICE REPORT WAS FILED. THEY STATED THAT THE FIRE WAS DUE TO BRAKE FLUID LEAKING FROM THE MASTER CYLINDER. THE CURRENT AND FAILURE MILEAGES WERE 127,000. UPDATED 02-14-08 *BF UPDATED 02/14/08 *TR

TL*THE CONTACT OWNS A 2000 FORD F-150. WHILE DRIVING 60 MPH, THE METAL BRAKE LINE TO THE REAR BRAKES RUSTED THROUGH AND BEGAN SQUIRTING BRAKE FLUID EVERYWHERE. THE BRAKES EXTENDED TO THE FLOOR WHEN DEPRESSED AND WOULD NOT WORK PROPERLY. HE WAS ABLE TO DRIVE THE VEHICLE HOME AND REPAIRED THE BRAKE LINE HIMSELF. THE CURRENT MILEAGE WAS 61,230 AND FAILURE MILEAGE WAS 61,210. UPDATED 12/06/07

A 2000 F150 4X4 WITH FOUR WHEEL ABS. MY MOTHER WAS DRIVING THE TRUCK AND WHEN SHE PARKED IN HER DRIVEWAY SHE HEARD A STEADY LOW TONED CLICKING SOUND FROM UNDER THE HOOD. SHE CALLED HER NEIGHBOR OVER TO LOOK IN FEAR OF NOT KNOWING WHAT THE UNUSUAL SOUND WAS. HE FOUND THE NOISE WAS COMING FROM THE ABS CONTROL UNIT UNDER THE HOOD AND THAT IT WAS EXTREMELY HOT. HE BURNED HIS FINGERS DISCONNECTING THE ELECTRICAL HARNESS FROM THE UNIT. THE NOISE STOPPED AND THE ABS (AMBER) LIGHT IS ON WITH THE WIRES UNPLUGGED. THIS IS ALL AT THE SAME TIME MY '01 MUSTANG GT BULLIT HAD A MAJOR PROBLEM WITH ITS ABS SYSTEM, REF.ODI #10361861 AS PREVIOUSLY SUBMITTED. I HAVEN'T HAD THE SYSTEM CHECKED BUT THOUGHT IT ODD THAT BOTH VEHICLES HAD OVERLY EXPENSIVE ABS MALFUNCTIONS AT THE SAME TIME. *TR

2000 WINDSTAR. ABS LIGHT KEEPS COMING ON. HAVE HAD CAR LOOKED AT 4 TIMES AND TOLD "PROBLEM" (A SEAL IN THE MECHANISM) WAS REPLACED AND PROBLEM FIXED. BUT IT'S NOT - ABS LIGHT KEEPS COMING ON. EXPENSIVE TO "FIX". ALSO, BRAKE FLUID LEAKS AND HAVE HAD TIMES WHEN DRIVING AND BRAKE PEDAL GOES ALL THE WAY TO FLOOR WITHOUT WARNING AND DELAYED STOPPING. LUCKILY HAVE NOT HAD ACCIDENTS WHEN THIS HAS HAPPENED. HAVE ALSO HAD BRAKE PADS WEAR OUT - NO PRE-WARNING ON THIS MODEL WINDSTAR WHEN BRAKE PADS ARE WEARING OUT. HAD TO HAVE BRAKE PADS REPLACED, AND ROTORS REPLACED - AGAIN AND EXPENSIVE FIX TO A PROBLEM WITHOUT WARNING. ALSO, BRAKES KEEP SQUEALING WHEN BRAKES APPLIED - AM TOLD THIS IS AIR IN THE LINES (HAVE BEEN TOLD THAT LINES FLUSHED BUT PROBLEM STILL KEEPS HAPPENING). ALSO, WHEN STEERING AFTER THE LAST TIME ABS LIGHT PROBLEM "FIXED" THERE IS A GRATING STEERING NOISE WHENEVER WHEEL IS TURNED. WARRANTY HAS RUN OUT - BUT PROBLEM WITH ABS STILL EXISTS AND I CAN'T AFFORD ANOTHER $700. BILL TO "FIX" PROBLEM. 2000 WINDSTAR SHOULD BE RECALLED FOR THIS ABS PROBLEM AND IT SHOULD BE FIXED FREE OF CHARGE BY FORD. AM VERY DISAPPOINTED AND FRUSTRATED WITH THIS PROBLEM - AND FEEL THAT I AND MY CHILD ARE DRIVING IN AN UNSAFE VEHICLE.

DT: THE CONSUMER STATES THAT THE CRUISE CONTROL SWITCH LEAKED BRAKE FLUID BACK UP THROUGH THE CONTROLS ON THE TOP OF THE STEERING COLUMN AT THE FLASHERS. AS A RESULT IT SHORTED THE CONTROLS OUT. THE CONSUMER HAD THE CRUISE CONTROL MODULE TAKEN OUT BY THE DEALERSHIP. THE CONSUMER NOTICED OIL AT THE FLASHERS ABOUT 3 OR 4 WEEKS AGO, AND DID NOT KNOW WHAT IT WAS. THE CONSUMER HAD NO TURN SIGNALS OR BRAKE LIGHTS, AND THAT IS WHEN HE TOOK THE VEHICLE TO THE DEALERSHIP. THE DEALERSHIP CHECKED FOR RECALL AND DID NOT FIND ANY RECALLS ON THE TRUCK. CONSUMER WAS INFORMED THAT THE SAME SWITCH WAS IN HIS VEHICLE THAT WAS BEING RECALLED ON OTHER TRUCKS. THE CONSUMER HAS HAD SENSOR PROBLEMS WITH THE CHECK ENGINE LIGHT ON THE DASHBOARD. THIS HAS BEEN REPLACED TWICE. THE VEHICLE IS REGULARLY MAINTAINED. THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER. THE CONSUMER IS WRITING FORD AND THE ATTORNEY GENERAL A LETTER INFORMING THEM FAULTY DEFECTS IN THESE VEHICLES. *AKTHE CONSUMER WOULD LIKE TO SEE SOMEBODY DO SOMETHING FOR A CHANGE FOR THE COMMON MAN. THE CONSUMER WAS TOLD BY A MECHANIC IF HE WOULD HAVE REPLACED THE FUSE, THE CONSUMERS TRUCK WOULD HAVE BURNT DOWN.*AK *JB

ABS WARNING LIGHT CAME ON. DIAGNOSIS WAS FAULTY HYDRAULLIC CONTROL UNIT. SINCE IT OCCURED AT 61,615 MILES AND STILL ON ORIGINAL BRAKE PADS/LININGS AND TIRES I FEEL FAILURE WAS PREMATURE. HAPPENED SHORTLY AFTER RECAL FOR SPEED CONTOL DISTURBED BRAKE SYSTEM. REPAIR COST FOR DIAGNOSIS AND EXTIMATE FOR REPAIR $475+ SO REPAIRS HAVE NOT YET BEEN DONE.

AT 102,000 MILES THE ANTI-LOCK BRAKE SYSTEM LIGHT CAME ON. I TOOK THE VEHICLE TO THE FORD DEALER AND HE SAID THE WHOLE ANTI-LOCK SYSTEM HAD CORRODED AND WOULD HAVE TO BE REPLACED TO THE TUNE OF $1000. THIS WAS JUST AFTER FORD HAD FIXED BALL JOINTS AND COMPLETELY RUSTED EMAERGENCY BRAKE CABLES UNDER EXTENDED WARRANTY AT 99,900 MILES.

THE ABS SENSOR CONTINUES TO STAY ON, THE TURN SIGNALS AND OVERHEAD CONSOLE FAIL INTERMITTENTLY. DEALER STATES THEY CANNOT DUPLICATE THE PROBLEM.*AK

THE CONSUMER'S 2000 FORD F150 HAS HAD THREE SET OF ROTORS AND THE TRUCK ONLY HAS 62000 MILES. *NM CURRENTLY THE VEHICLE NEEDS ANOTHER SET OF ROTORS. *SC *JB