2006 Ford F-150 Complaint Log

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT A SENSOR WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,069. UPDATED 04/10/15*LJ UPDATED 11/5/2015*JS

PART #4L3Z 9D370 A (CONTROL UNIT) THIS IS THE FUEL PUMP DRIVER MODULE ON A 2006 FORD F150 THAT FAILED BECAUSE THE SHELL THAT HOLDS THE MICRO CHIPS RUSTED OUT. THIS SHOULD BE NOTED TO FORD MOTOR COMPANY BECAUSE IS A COMMON PROBLEM IN COLD WEATHER STATES. P.S. REPAIR COST AT FORD DEALERSHIP $458.78. *TR

MY STEERING WHEEL IS STIFF. AND HARD TO TURN THE MECHANIC SAID IT IS A RECALLED RACK AND PINION. *TR

VEHICLE STARTED MISSING AND BUCKING. BROUGHT INTO MECHANIC AND WAS TOLD THIS IS A VERY COMMON PROBLEM WITH TRITON 5.4L ENGINE. NEEDS SPARK PLUG CHANGE AND CHANCES ARE THEY WILL BREAK OFF IN ENGINE WHILE CHANGING (WHICH 5 OUT OF 8 DID). TOTAL COST A SHAMEFUL $800 (ESTIMATE WAS BETWEEN $600-$1200). MECHANIC PULLED OUT MANY PRIOR INVOICES FROM OWNERS WITH THE EXACT SAME ISSUE. THE SPARK PLUGS IN THESE ENGINES SHOULD BE RECALLED. *TR

ENGINE HAD BLOWN A PLUG OUT ABOUT 300 MILES AGO ON THE NUMBER 3 WAS REPAIRED WITH REPAIR KIT NEW PLUG AND COIL WAS PUT ON. WAS TRAVELING STARTED UP HILL ENGINE BEGAN TO MISS DROVE 20 MILES TO DESTINATION HAD TRUCK TESTED AT ADVANCE AUTO PARTS READOUT STATED MISFIRE ON CYLINDER 1 AND 3 AND BAD COIL ON 3. REPLACED COIL 3 AGAIN TOOK TO MECHANIC HIS COMPUTER READ OUT WAS NUMBER 8 COIL WAS BAD REPLACED IT ENGINE CONTINUED TO MISS TOOK IT TO THE MECHANIC HE CHANGED ALL THE PLUGS THE 2ND PLUG ON DRIVERS SIDE WAS LOOSE AND READY TO BLOW OUT AND HE TOOK THE NUMBER 3 PLUG OUT THAT HAD BEEN REPLACED PRIOR THE WHOLE BOTTOM OF PLUG WAS MELTED COULD HAVE RESULTED IN A FIRE LOOKED DOWN IN ENGINE WITH CAMERA THE PISTON WAS DESTROYED. THIS PROBLEM IS FROM THE FACTORY INSTALLED PLUG BLOWING OUT AND FRAGMENTS GOING INTO ENGINE. NOW I HAVE TO REPLACE MY ENGINE 2500 OUT OF MY POCKET D/T POOR HEAD DESIGN FORD IS WELL AWARE OF THIS PROBLEM AND REFUSES ANY ASSISTANCE FORD ACTUALLY HAS EXCLUDED BLOWN PLUG REPAIR FROM THEIR WARRANTY. WHEN YOU PURCHASE A NEW VEHICLE YOU EXPECT TO GET MORE THAN 106000 MILES. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE TIRES NEEDED TO BE REPLACED AND ALIGNED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,270.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

WENT TO STOP FOR TRAFFIC LIGHT APPLIED THE BRAKES AND VEHICLE TOOK OFF///////SLAMMED ON BRAKES TO TRY TO STOP AND SLAMMED IN PARK .CAME WITH IN INCHES OF CRASHING INTO CAR IN FRONT OF ME. TODAY IS SEPT.1ST HAVE NOT DRIVEN TRUCK AGAIN////// CALL FORD CORP. THEY WILL NOT PAY TO CHECK OUT TRUCK. AT 3100 MILES HAD TO REPLACE TIRES. ORIG. HAD DRY ROT,,,,,, *TR

ENGINE STARTED MAKING A LOUD NOISE UPON INSPECTION OF ENGINE FOUND THAT THE BACK SPARK PLUG ON PASSENGER SIDE HAD BLOWN OUT FROM HEAD AND OF COURSE STRIPPED THE TREADS FROM THE HEAD THE SPARK PLUGS ARE THE ONES THAT CAME FROM FACTORY THEY HAVE NEVER BEEN REMOVED OR REPLACED VEHICLE WAS PURCHASED NEW AFTER REVIEWING INFORMATION ON THE INTERNET THIS SEEMS TO BE A MAJOR PROBLEM WITH FORDS 4.6 AND 5.4 ENGINE AS WELL AS RESULTING IN FIRES AND CONSIDERING FORD MAKES A REPAIR KIT. IF THIS HAS EFFECTED THIS MANY VEHICLE SHOULDN'T FORD FOOT THE BILL. *TR

GAS AND BRAKE PEDAL ARE TOO CLOSE TOGETHER. YOU COULD STILL BE GIVING IT GAS WHILE YOU ARE PUSHING ON THE BRAKES. I SEE HUNDREDS OF COMPLAINTS ABOUT THIS ONLINE.I WAS PULLING INTO A PARKING SPOT WHEN I THOUGHT I WAS APPLYING THE BRAKES THE OTHER HALF OF MY FOOT WAS ON THE GAS CAUSING ME TO JUMP THE CURB AND CRASH INTO A WALL. *TR

THE ELECTRIC WINDOWS AND DOOR LOCKS AND MIRROR ADJUSTMENTS ALL STOPPED WORKING ON MY 2006 F150. AFTER DOING SOME LOOKING I FOUND THAT THE WIRE HARNESS THAT RUNS TO THE DOOR HAS MOST OF THE WIRES BROKEN OR BREAKING IN HALF THUS LEAVING BARE WIRES EXPOSED AND A POSSIBLE FIRE HAZARD THE WAY IT LOOKS TO ME. *TR

TRUCK STUTTERED & STALLED, WOULD NOT RESTART. TOWED FORD TO DEALER. FAILURE CAUSED BY CORRODED, CRACKED FUEL PUMP MODULE. THE MODULE BODY IS MADE OF AN ALLOY METAL MATERIAL, AND THE MODULE IS BOLTED DIRECTLY TO THE STEEL FRAME NEAR THE GAS TANK, MOISTURE AND DIS-SIMILAR METALS (ELECTROLYSIS) CAUSED RAPID DETERIORATION OF MODULE BODY. THIS POOR DESIGN CAUSES THE VEHICLE TO SHUT DOWN AT ANY SPEED/SITUATION, LOSS OF POWER STEERING & BRAKES WOULD OCCUR. RESULT COULD BE DEATH OF OCCUPANTS OR THOSE PERSONS AROUND TRUCK WHEN ENGINE SHUT DOWN OCCURS *TR

AS A PART OF REGULAR MAINTENANCE I ALWAYS HAVE WELL IN ADVANCE PERFORMED SCHEDULED MAINTENANCE ON MY 06 F-150.ON AUG 23 2013 I HAD MY ROTORS AND BRAKE PADS ALL REPLACED AS WELL AS HAVING A HI PRESSURE BRAKE FLUID CHANGE PERFORMED AS PART OF THIS AS SUGGESTED BY THE BILL CURRIE FORD DEALERSHIP IN TAMPA. THE TRUCK HAD 83,996 MILES ON IT AT THIS TIME OF SERVICE. THE TRUCK WAS RARELY DRIVEN AFTER THAT AND USED ONLY ON SHORT TRIPS.OF 10-20 MILES OR LESS AFTER HAVING THE BRAKES SERVICED. FRIDAY JULY 18TH 2014..THE TUCK HAD ONLY APPROX. 2000 ADDITIONAL MILES ON IT AFTER THE BRAKES WERE SERVICED AT BILL CURRIE FORD.I AND A FRIEND WERE DRIVING TO PICKUP A WASHING MACHINE ABOUT 30 MILES AWAY. WITHOUT WARNING. UPON RETURNING THE RIGHT WHEEL BEGAN PULLING TO THE RIGHT AND SMOKE AND A RUBBER AND PLASTIC SMELL ACCOMPANIED BY SMOKE STARTING RISING FROM THE RIGHT WHEEL WELL WHICH WAS SCOTCHING HOT. THE HEAT WAS SO INTENSE THAT WHEN WE STOPPED THE PLASTIC WHEEL COVER FELL OFF BECAUSE ITS WAS MELTED.IT WAS TAKEN TO THE DEALERSHIP WERE THE ORIGINAL WORK WAS PERFORMED. I WAS INFORMED IT WAS THE CALIPER,THAT IT HAD SEIZED AND THAT AFTER ALREADY HAVING REPLACED THE FRONT ROTOR SEVERAL THOUSAND MILES BEFORE//THE RIGHT ROTOR AND CALIPER AND BRAKE LINE WOULD NOW HAVE TO BE REPLACED AGAIN..BECAUSE THEY SAID.."WE CAN'T TELL WHEN A CALIPER WILL FAIL". NOW IT HAS COST ME $2,300,00 TO GET MY BRAKES DONE..WHEN INITIALLY THEY WERE STILL IN SAFE LIMITS.WE WERE LUCKY THIS DIDN'T CAUSE A FIRE OR CAUSE THE TIRE TO BLOW OUT WHILE ON THE HIGHWAY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.

I WAS TRAVELING AT APPROXIMATELY 55MPH WHEN THE VEHICLE STARTED TO SPUTTER, AND AS I BEGAN TO SLOW DOWN AND TRIED TO PULL OVER TO THE SIDE OF THE ROAD BEFORE THE TRUCK QUIT ON ME. I TRIED TO START IT BACK UP IN ORDER TO GET OFF THE MAIN ROAD BUT THE VEHICLE DIDN'T START. I ENDED UP HAVING THE VEHICLE TOWED TO THE LOCAL SHOP AND AFTER A DIAGNOSIS THAT COST $124.95 THEY FOUND OUT THAT THE FUEL PUMP DRIVER MODULE WHEN BAD. THE FUEL PUMP DRIVER MODULE COST $234.44. SO ALL TOGETHER WITH PARTS, LABOR AND TAX IT COST ME $496.88 WITHOUT INCLUDING THE COST TO HAVE THE VEHICLE TOWED. THE FUEL PUMP DRIVER MODULE IS BOLTED DIRECTLY TO THE FRAME CROSS MEMBER, AND WITH MINNESOTA WINTERS SNOW AND ROAD SALT GET TRAPPED BETWEEN THE TWO PARTS. THE PART WILL EVENTUALLY RUST, CRACK, AND THEN THE FUEL PUMP DRIVER MODULE GOES BAD. IT WAS NICE TO SEE THAT THE REPLACEMENT PART HAS A PLASTIC HOUSING WITH A COUPLE SPACERS TO MOVE IT AWAY FROM THE CROSS MEMBER TO POSSIBLY ELIMINATE THIS PROBLEM. FORD HAD TO KNOW ABOUT A PROBLEM WITH THIS COMPONENT OTHERWISE THEY WOULDN'T HAVE CHANGED THE DESIGN RIGHT? *TR

MY TRUCK WAS NOT INVOLVED IN AN ACCIDENT. I HAVE 74,000 MILES ON MY TRUCK AND THE TRANSMISSION IS STARTING TO SLIP. WITH THIS LOW MILEAGE THIS SHOULD NOT BE HAPPENING. *TR

UPON ATTEMPTING TO START MY 2006 FORD F150 SUPER CREW CAB VEHICLE (5.4L), THE ENGINE WILL ATTEMPT TO CRANK OVER BUT WILL NOT TURN ON. UPON FURTHER DIAGNOSIS, IT WAS DETERMINED THAT THE FUEL PUMP MODULE IS NOT WORKING. IT BECAME COMPLETELY RUSTY AND EXHIBITS HOLES THROUGHOUT THE SURFACE OF THE MODULE. THIS APPEARS TO BE AN EXTREMELY COMMON PROBLEM THAT FORD IS VERY WELL AWARE OF AND HAS NOT ADDRESSED THE PROBLEM. I THINK A CIVIL CLASS ACTION LAWSUIT SHOULD HELP THEM WITH THEM MAKE THE RIGHT DECISION TO REPAIR THE MODULE AT NO COST TO THE CONSUMER. THIS IS AN EXTREMELY FRUSTRATING ISSUE THAT FORD HAS KNOWN ABOUT FOR SEVERAL YEARS. UPON SPEAKING WITH FORD DIRECTLY, I WAS ADVISED THAT THEIR HAS BEEN RECALLS FOR THAT EXACT PART BUT NOT FOR THE 2006 FORD F150. COMPLETELY UNACCEPTABLE AND INEXCUSABLE. THIS WILL BE MY LAST FORD PURCHASE. I'VE BEEN A FORD MAN ALL MY LIFE. NOT ANYMORE.... *TR

TL-THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING 5 MPH THE BRAKE WOULD NOT ENGAGE, IT WAS VERY HARD TO APPLY. THE CONTACT HAD TO APPLY THE MANUAL BRAKE TO STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THE BRAKE BOOSTER VACUUM HOSE HAD COLLAPSED. THE CONTACT WAS MADE AWARE OF A RECALL NOTIFICATION UNDER NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC),HOWEVER, HIS VIN WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS INFORMED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

AT VERY LOW MILEAGE I CANNOT UNDERSTAND WHY I WAS HEARING A WHINING NOISE THAT APPEARED FROM COMING THE REAR OF MY TRUCK. I WAS ADVISED THAT THE GEARS WERE BREAKING DOWN AND SHOULD BE REPLACED. THE GEAR AND PINION WERE REPLACED. SEEMS TO BE FIXED. AGAIN AT 57814 MILES? *TR

Received notification by mail from your department about a recall on my trucks spark plugs breaking in the head .Took vehicle to local ford dealer and was told the vehicle was required to have over 100 thousand miles before the plugs would be replaced under recall . Now my vehicle has over 150 thousand miles and when I went to the same dealer I was told there wasn’t a recall on this truck . My documents I received from your department was lost during hurricane Sally. This is a well known recall every local mechanic knows about .

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING UPHILL, THERE WAS A ENGINE MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL DIFFICULT TO TURN AND CAUSING THE VEHICLE TO LOSE CONTROL AND DRIVE INTO ON COMING TRAFFIC NEARLY CAUSING A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED THAT A LOWER JOINT IN THE STEERING COLUMN SHAFT SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 58,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT BUCKLE MALFUNCTIONED AND CAUSED THE BUCKLE NOT TO LATCH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN VERIFIED THE FAILURE AND REPLACED THE SEAT BELT BUCKLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 63,900. UPDATED 6/10/14*CN UPDATED 8/23/2017*CN

APRIL 14, 2014 AFTER LEAVING MY DOCTORS OFFICE I BUCKLED MY SEATBELT AS REQUIRED BY FEDERAL LAW I MADE ONE LEFT HAND TURN AND STOPPED FOR A RED LIGHT AS I BEGAN MY TURN TO THE RIGHT WHEN LIGHT CHANGED THE SEALBELT CAME LOOSE FROM THE BUCKLE. THE TOP OF THE BUCKLE WAS STUCK DOWNWARD AND WOULD NOT RELEASE FOR ME TO BUCKLE IT AGAIN. WHEN RETURNING HOME I CALLED MIKE SHAD FORD IN JACKSONVILLE FLORIDA WHERE I PURCHASED IT. I WAS TOLD MY TRUCK WAS OUT OF WARRANTY AND THEY WOULD REPLACE IT FOR $294.71 DOLLARS IT WAS NOT ON A RECALL LIST. I THEREFORE CALLED FORD MOTOR COMPANY AND TRIED TO EXPLAIN TO THE YOUNG LADY WHOM ANSWERED THE PHONE WHAT HAPPENED TELLING HER IT NEEDED TO BE PUT ON A RECALL LIST SHE REFUSED TO LISTEN AND HUNG UP. I THEN CALLED THE NHTSA AND REPORTED IT TO THEM. I AM SURE I AM NOT THE ONLY ONE WHO PURCHASED THAT YEAR TRUCK THAT THIS HAS HAPPENED TO. I FEEL THAT FORD SHOULD HAVE REPLACED MY PART FREE OF CHARGE HOWEVER THEY DID NOT. SO I PAID FOR THE NEW PART AND IT WAS INSTALLED BY A TRAINED FORD TECHNICIAN. I FEEL I SHOULD BE REIMBURSED BY FORD IF NOT THE DEALER. COMPLAINT NUMBER BY NHTSA 10584144. *JS

VEHICLE ENGINE SUDDENLY SHUT DOWN. THE PROBLEM WAS THE FUEL CONTROL MODULE, FORD PART # 9D370, ALUMINUM CASING CORRODED THROUGH EXPOSING THE INTERNAL CIRCUIT BOARDS. THIS IS A COMMON OCCURRENCE FOR THE 2004 THROUGH 2006 F150 AND CAN CAUSE A VERY DANGEROUS SITUATION IF IT SHUTS DOWN WHILE IN TRAFFIC AT HIGHWAY SPEEDS. *TR

I WAS DRIVING DOWN US 281(BUSY 3 LANE HIGHWAY) IN SAN ANTONIO AND THE ENGINE SHUT OFF CAUSING ME TO COAST TO A STOP IN THE MIDDLE OF TRAFFIC. ONCE I GOT OFF OF THE ROAD, THE ENGINE STARTED UP LIKE NOTHING WAS WRONG. AFTER I INSPECTED THE FLUIDS AND SAW EVERYTHING CHECKED OUT, I GOT BACK ON THE HIGHWAY ONLY TO HAVE THE ENGINE SHUT OFF AGAIN. I CALLED FORD TO SEE IF THERE WAS AN ISSUE REPORTED OR A RECALL, AND THERE WAS NOTHING. I FOUND OVER 300 COMPLAINTS ON VARIOUS FORUMS BY TYPING IN --2006 F150 FAILSAFE--IN THE SEARCH ENGINE. I THINK THIS IS A REAL SAFETY ISSUE THAT FORD NEEDS TO ADDRESS BEFORE SOMEONE GETS KILLED ON THE ROAD. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN STOPPED AT A RED LIGHT MY ENGINE BEGAN TO REV. AT VERY HIGH RPM'S AND THE TIRES BURNED OUT WHEN I SHIFTED THE TRANSMISSION INTO NEUTRAL. I PURCHASED THIS TRUCK IN DEC. 2013 AND THIS WAS APPROX. THE 7TH INCIDENT OF SUDDEN ACCELERATION. IT SEEMS TO ONLY HAPPEN WHEN STOOPED OR SLOWING DOWN. ANY HELP IN THIS MATTER WOULD BE DEEPLY APPRECIATED. THANKS IN ADVANCE. *TR

ALL THE GAUGES IN MY TRUCK STOPPED WORKING. FIRST THE SPEEDOMETER THEN ALL THE GAUGES. AT FIRST THEY JUST FLUCTUATED THEN THEY ALL STOPPED. THEN THE LIGHTS STARTED FLASHING ON AND OFF INSIDE THE VEHICLE. THEN THE FUEL SENSOR WARNING STARTED BEEPING FOLLOWED BY THE SEATBELT BEEPER. OCCASIONALLY THE ENTIRE DASH GOES BLANK FOLLOWED BY A TEST SCREEN ON THE DASH. ALL INTERIOR ELECTRICAL SYSTEMS SHUT OFF FOR ABOUT TWO TO THREE SECONDS THEN COME BACK ON WHILE DRIVING. VERY WORRIED THAT THE VEHICLE WILL JUST STOP WHILE DRIVING. *TR

THE ENGINE BEGAN TO TICK ON TOP. LATER IT BEGAN TO TICK ON THE BOTTOM. THE ENGINE LIGHT CAME ON AND I HAD IT CHECKED. THE CODE SAID IT WAS A CAM SENSOR. AS IT TURNED OUT THE ENGINE WAS NOT GETTING THE PROPER AMOUNT OF OIL DUE TO A CLOGGED A OIL PORT RESTRICTION. END RESULT HAD TO REPLACE THE ENGINE. WHILE AT THE SERVICE CENTER ANOTHER TRUCK CAME IN WITH THE SAME PROBLEM WITH SIMILAR MILEAGE. NOW MY SON WHO HAS A 2005 FORD F150 IS EXPERIENCING THE SAME ISSUES WITH HIS TRUCK WITH 96000 MILES THAT'S THREE THAT I KNOW OF. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A DELAYED RESPONSE. THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE RECURRED BECAUSE THE RECALL REMEDY FAILED TO CORRECT THE PROBLEM. THE CONTACT DIAGNOSED THE VEHICLE AND REPLACED THE MANIFOLD HOSE HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE INSIDE OF THE VEHICLE, SHE WOULD SMELL GASOLINE FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000. *TR

I BROUGHT MY TRUCK IN TO MY LOCAL FORD DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. IT IS A 2006 F150 4.6L - AFTER HIS INSPECTION, THE MECHANIC STATED THAT THE BOTTOM OF THE #2 SPARK PLUG (MANUFACTURE INSTALLED) HAD DISINTEGRATED AND FELL INTO THE HEAD CAUSING SO MUCH DAMAGE TO THE #2 CYLINDER THAT I HAVE TO REPLACE THE ENTIRE ENGINE AT A COST OF OVER $6,000 PLUS TAX. IT WILL TAKE OVER A WEEK TO FIX AND I DO NOT HAVE ANOTHER VEHICLE. I WOULD LIKE FORD TO REIMBURSE ME FOR THE EXPENSE. I HAVE WRITTEN TO THEIR "CUSTOMER CARE"( [XXX]) DEPARTMENT, BUT HAVE HAD NO HELPFUL OR SATISFACTORY RESULTS. THIS IS A KNOWN ISSUE AS FORD HAS ISSUED A TSB AND DEVELOPED A TOOL TO ASSIST WITH THE REMOVAL OF FAULTY SPARK PLUGS. *TR

WHILE DRIVING THE FORD 2006 F150 IT JUST STARTED RUNNING SLUGGISH AND STOPPED. I WAS ABLE TO GET OFF THE SIDE OF THE ROAD. *TR

I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE FUEL ODOR WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOTIFIED REGARDING THE DEFECT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 84,000.

WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT. *TR

THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR

MY FACTORY TIRES, BF GOODRICH LONG TRAIL T/A, ON MY FORD F-150 KING RANCH BOUGHT NEW IN 2006 LASTED ONLY 21,428 MILES. THEY GAVE ME A LOUSY $236. AND IT COST ME $708.TO REPLACE ALL 4. NOW, 18,270 MILES LATER THERE ARE LESS THE 4/32 LEFT ON THE TREAD. ON A RECENT OIL CHANGE, A DEALER WOULD NOT ROTATE MY TIRES BECAUSE OF THE WARE. NOW I AM BEING TOLD - SORRY NO WARRANTY LEFT! - I AM LIVID! CAN ANYTHING BE DONE? *TR

TRUCK WAS AT DEALERSHIP FOR REPAIRS, WHEN I WAS TOLD NOT TO HAVE REPAIRS DONE BECAUSE THE FRAME IS CRACKED AND RUSTED THRU. THEY SAID THE VEHICLE IS UNSAFE TO DRIVE. THE TRUCK IS NOW WORTHLESS. IN MY 50 YEARS OF OWNING AND DRIVING NUMEROUS VEHICLES IN THE NORTHEAST, I NEVER HAD A RUSTED FRAME ISSUE. FORD WILL NOT HELP NOR INVESTIGATE THE SITUATION. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 35 MPH, ANOTHER VEHICLE WENT THROUGH A STOP SIGN AND CRASHED INTO THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT MENTIONED THAT THE AIR BAG SENSOR WAS ILLUMINATED BEFORE THE CRASH OCCURRED. THE CONTACT SUSTAINED WHIP LASH AND OTHER MINOR INJURIES, ONE OF THE PASSENGERS SUSTAINED LEG INJURIES, A SECOND PASSENGER SUSTAINED NECK INJURIES AND THE THIRD PASSENGER SUSTAINED MINOR INJURIES AND ABRASIONS. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER WAS NOTIFIED OF THE CONCERNS WITH THE AIR BAG FOR SEVERAL MONTHS BEFORE THE CRASH OCCURED TO NO AVAIL. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS) BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 144,000. UPDATED 8/14/14*CN UPDATED 08/27/2014 *JS

HANKOOK DYNAPRO AS P255/65SR17 SEPARATED AT APPROX. 10,000 MILES. POTENTIAL FOR ACCIDENT SINCE IT WAS A STEERING TIRE. PURCHASED AT PEPBOYS STORE # 661 TUCSON, AZ. *TR

SHUTTERS UPON ACCEL. REAR CLUTCH PATCH REPLACED. RETURNED 04/28/2014 FOR SAME PROBLEM. THE 3RD TIME I RETURNED ON 05/29/2014. AGAIN THE SHUTTERING CONTINUES..THIS PROBLEM WAS SINCE BEEN FIXED. HOPEFULLY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND THE ENGINE EXHIBITED A LOUD NOISE. ADDITIONALLY, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO STATED THAT THE SPARK PLUG HAD MELTED DUE TO THE HEAT FROM THE HEAD GASKET. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 40,000.

WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD. *TR

MY 2006 FORD F150 FX4 HAS STALLED ON THE HIGHWAY AT TWO DIFFERENT TIMES IN THE LAST 9,000 MILES. I AM DRIVING AT NORMAL SPEEDS, WITH NORMAL WEATHER CONDITIONS, HALF TANK OF GAS, AND I WAS COASTING AS HIGHWAY SPEEDS SLOWED - AS I WENT TO HIT THE ACCELERATOR TO SPEED UP, I LOST THE ABILITY TO ACCELERATE. FIRST THE WRENCH DASH LIGHT CAME ON, THEN I NOTICED STEERING WAS SLIGHTLY DIFFICULT AND THEN THE BATTERY AND TRANSMISSION LIGHT CAME ON. I GOT THE VEHICLE TO THE SIDE OF THE ROAD, BUT I DID NOT LOSE HEADLIGHTS, RADIO, HEAT, OR POWER. I TURNED THE TRUCK OFF AND WAITED 2 MINUTES, THEN IT STARTED BACK UP - A LITTLE DIFFICULT ON THE STARTER, BUT IT WORKED. I HAVE READ NUMEROUS CHAT FORUMS ONLINE WITH USERS HAVING THIS SAME ISSUE WITH 2006 V8'S IN THE F150. WHAT IS FORD DOING ABOUT THIS? MY VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND CARED FOR. FROM WHAT I READ THIS IS A FUEL PUMP CONTROL PANEL ISSUE WITH CORROSION OF DISSIMILAR METALS - WHERE IS THE RECALL? *TR

WHEN DRIVING HOME, CHECK ENGINE LIGHT STARTED FLASHING, IMMEDIATELY STOPPED AND HAD VEHICLE TOWED TO A WELL REPUTABLE SHOP FOR DIAGNOSIS AND REPAIR. WAS DIAGNOSED WITH TWO FUEL INJECTORS FAILING AND NEEDING REPLACED ALONG WITH ALL SPARK PLUGS NEEDED REPLACED. 6 OF THE 8 PLUGS SNAPPED IN HALF AND NEEDED TO BE BURROWED OUT ON TOP OF IT COSTING $90 PER PLUG DRILLING OUT. TOTAL FOR REPAIRS CAME TO $2300. BUT AFTER REPAIRS WERE COMPLETED I STILL DO NOT HAVE A RUNNING VEHICLE. THE ENGINE STARTS BUT OIL PRESSURE DROPS AFTER 5 MINS OF RUNNING. I WOULD LOVE TO FIND A SOLUTION TO THIS, IF THIS IS COMMON OR NOT. AND IF SO, WHY IS IT NOT RECALLED? *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKES FAILED WHILE DRIVING 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE BOOSTER FAILED. THE CONTACT SPOKE TO THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:08V208000(SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 101,000.

WHEN I STARTED THE TRUCK, A SPARK PLUG BLEW INTO THE HEAD. THE MECHANIC AT THE FORD DEALERSHIP TOLD ME THIS WAS A COMMON PROBLEM WITH THESE TRUCKS. THE REPAIR COST ME $3,448. TO REPLACE THE HEAD. IF FORD IS AWARE OF THIS PROBLEM, THE VEHICLES SHOULD BE RECALLED AND THE PROBLEM CORRECTED. MY FAMILY WAS LEFT STRANDED 7 HOURS AWAY FROM HOME, HAD TO RENT A VEHICLE TO GET HOME AND THEN TWO WEEKS LATER, HAD TO RETURN TO DEALERSHIP AND PICK UP THE TRUCK. SO STRESSFUL AND EXPENSIVE. JUST GLAD WE WERE IN A TOWN WHEN THIS HAPPENED! *TR