2016 Ford F-150 Brakes Problems

Multiple front brake line ruptures on 2016 F150 putting safety at risk. 7/26/2023 front passenger side brake line rupture while driving requiring new brake line. 4/6/2026 front driver side brake line rupture while driving requiring new brake line, replaced front passenger side brake line again because it was cracked and about to rupture again. Ford is using defective brake lines, brake lines should not be considered a routine maintenance item like a car battery. This is putting my family at risk and other drivers.

Truck was repaired under recall 20S31 to repair the master cylinder issue in November 2020. Just the other day the master cylinder went out again and my brakes went out while driving. There clearly was an inadequate repair and Ford so far is not open to covering the expensive repair costs to this critical safety issue.

I was in a parking lot moving a trailer to a different spot when all the sudden my foot on the brake goes to the floor. I wasn't even on the brakes hard. I then check my truck and I see my passenger front wheel is covered in brake fluid and a large puddle underneath it. I then took off the wheel and saw that the brake hose had a split so I replaced it. The split is at the top of the brake hose When doing research I saw that other ford vehicles of the same years had break issues so I thought I would make a report. The ford edge in particular

MY 2016 F150 HAD A RECALL (22S11 IN MAR 11,2022 WHICH THEY REPLACED THE MASTER CYLINDER ON MY TRUCK. THIS WEEK 10/16/2025 I NOTICED MY BRAKES ARE FAILING AGAIN, THE PEDAL GOES ALLMOST TO THE FLOOR. I WILL HAVE TO HAVE THEM REPAIRED AGAIN. DON'T KNOW IF DEALER WILL REPAIR FREE OF CHARGE?

The contact owns a 2016 Ford F-150. The contact stated that while her son was driving at an undisclosed speed, an unknown brake message was displayed on the instrument panel. In addition, the failure progressed, and the brake pedal felt loose, and the vehicle would not come to a stop as intended while the brake pedal was depressed. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Numbers: 20V332000 (Service Brakes, Hydraulic) and 22V150000 (Service Brakes, Hydraulic); however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 152,000.

Sudden and without any warning, complete catastrophic brake failure while stopped attempting to pay at the pay station to exit a parking garage. My truck was fully stopped, in drive with my foot on the footbrake pedal, and started moving forward and suddenly lurched thru the parking exit gate and damaging it and the front end of my truck. Fortunately, no one was crossing on the sidewalk in front my truck or they would have been injured or worse, or we would have T-boned by oncoming traffic on the street. There was brake fluid in several areas where I parked the vehicle on the street after moving from the parking garage. There was a "low brake fluid warning light" after having the truck towed to Haley Ford in Chester, VA. There were warnings prior to the accident. The truck had had a "The Works" service done at Haley Ford the week prior. Haley Ford claims the front brake lines were leaking and need to be replaced after their "diagnostic" inspection.

Emergency/parking brake locks up on its own and causes the rear caliper to become extremely hot and causes poor breaking performance.

Driving down the highway at a high rate of speed had to press on my brakes and the front passenger brake hose blew out. Severe brake fluid loss .

Brake pedal goes all the way to the floorboard causing me to cast through a red light. Problem is persistent.

I have now had two brake lines burst (both in the front) which resulted in loss of braking ability. The first incident was in March of this year, and the second was in October of this year. This has cost me at least $800 in repairs plus towing costs.

My 2016 F 150 has just 23,000 miles on it, always garaged and is in next to new condition. One day I went to start it, applying the brakes as you have to, they were firm until the vehicle started. Once started the brake pedal went right to the floor! I checked everything I could to see if the brake fluid was low or possibly a leak but nothing was visibly wrong. I took it in and sure as heck it was as I thought was the worst case scenario, the master cylinder. $800 later I was back on the road. The repair shop told me this must be a frequent problem as their distributor had several on hand. To me this is very dangerous and definitely should be a recall defect that should be reimbursable to the owner by Ford!

The contact owns a 2016 Ford F-150. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop as intended. Additionally, the brake warning light was illuminated. The contact stated that the brake pedal was depressed to the floorboard; however, the failure caused the vehicle to not stop at a stop light. The vehicle was slowly driven to an independent mechanic and the independent mechanic refilled the brake fluid. The contact stated that the brake fluid level was below the normal level within two minutes. The vehicle was diagnosed with brake master cylinder failure. The contact was informed that the brake master cylinder needed to be replaced. The vehicle was not repaired. The dealer was made aware of the failure. The contact was advised to take the vehicle to the dealer for a diagnostic test. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 70,480.

The contact owns a 2016 Ford F-150. The contact stated that while driving approximately 50 MPH, the transmission unexpectedly downshifted. The contact was able to pull over to a nearby parking lot, and the vehicle was turned off and restarted to continue driving. The vehicle was taken to the dealer, who was unable to diagnose or repair the vehicle. The vehicle was taken to another dealer, Sea Breeze Ford (1701 NJ-35, Wall Township, NJ 07719), who diagnosed that the brakes might have caused the failure. The dealer replaced the brake pads and rotors on all four wheels. The manufacturer was informed of the failure and confirmed that the vehicle was not under a recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 335,000.

Rupture of soft brake line approximately 1/2 inch below crimp near the connection to hard brake line. Pedal immediately went to floor and lost nearly all braking.

* Brake hose, right front wheel * Wasn't able to stop truck, Made a emergency entrance into a parking lot. * Problem has not been confirmed by a dealer or service center, only a parts store as I used their parking lot to pull into to stop. * No inspection yet on part. * Yes, Low oil light for brakes while driving and brake pedal was going to floor right when brakes failed. Lost of brakes while driving from a ruptured brake line hose on right front wheel. Truck has less than 74,000 miles.

When braking, the brake pedal goes to the floor and makes stopping the vehicle difficult. There is no sign of leaks from the lines, and is acting like the open recall on other VIN numbers on this model however Ford does not have an open recall on this VIN. The recall is the brake booster leaking into the master cylinder.

The contact owns a 2016 Ford F-150. The contact stated that while driving at 5 MPH, the contact approached a stop sign and depressed the brake pedal. However, the brake pedal was inoperable and the vehicle did not stop. Due to the brake pedal failure, the contact rear-ended the vehicle in front of him. No damage was done to either vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to contact NHTSA to report the failure. The failure mileage was approximately 104,000.

Front left brake hose burst at 116000 miles. Appears to be a manufacturer defect. There is no evidence of any physical damage. This is happening way too ofter on these vehicle for it not to be a defect. I will be replacing the part this week and will save the old one in case you want to see it. My wife was actively driving the vehicle when it failed but was able to stop the vehicle without damaging anything.

I was driving at 75 mph on the freeway when suddenly I lost acceleration and the ability to accelerate. There was a message "Hill Descent Control". I did not have time to see if it said error or failure. Then "Check Manual". I was very lucky to get 3 lanes over to get off to the side of the road without being rear ended. I turned the vehicle off in order to regain my composure, then back on with no warning messages. I drove home slower.

The right front brake hose split, leading to a complete loss in braking capability while the truck was moving. The brake went to the floor with no braking. I have looked online and found multiple cases of this brake hose splitting in exactly this place. Fortunately, I was able to safely come to a stop.