There are 6 stored owner reports matching the fuel system leading-label group for the 2020 Ford F-150 in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 6 of 6 matching reports.
Open the full vehicle complaint log (all categories)Check engine light turn on with the code P0087. The truck don't turn on quickly. Lose power at high demand or RPM.
Driving at highway speeds and my truck began to shake violently and very loud banging sound. Slowed down to pull over on the highway. Found driveshaft broken in half with gas dumping out of the fuel tank. Broken driveshaft damaged heat shield for gas tank, punctured gas tank and dented/broke clips on exhaust. Very lucky back driveshaft didn’t hit pot hole and leaking gas didn’t start a fire. Stranded on side of road for hours. Sent my vin to the dealership and they said my was not under the recall #21S56 even tho it was built after known driveshaft issue and clearly the insulator caused the issue.
The transmission slips when giving it gas. I lose power when I excelerate Sometimes. Sometimes the truck excelerates when I'm not giving It throttle. Transmission jumps all over. The transmission seems to be very rough shifting back and forth
On or about April 2024, the "check engine" light came on in my 2020 Ford F-150. My vehicle was just becoming due for re-registration. I had the code for the check engine light checked at my parts dealer and double checked at the maintenance facility I was having services done. The check engine code was for the catalytic converter. I had the catalytic converter and O2 sensors replaced at my service provider, the check engine light was extinguished and the codes had been removed, the vehicle emissions no longer reported on the service/inspection station and the vehicle passed the emissions/safety check for re-registration. In less than one month, the check engine light came on again, with the exact same codes that identify the catalytic converter failing. Both the parts dealer and the service provider tell me that it's impossible. Further checking by the service provider with Ford motor Company service center have told my service provider that my vehicle needs to have the onboard computer system erased and re-installed at my cost because only Ford has the program to do it at their service centers exclusively. This problem seems to be appearing with other Ford vehicles of the same year and engine size. I personally stood in line behind another man who was reporting a problem with his vehicle with the check engine light. Jokingly, I made the comment, "It must be a Ford" and he turned around and asked me "How did you know?" His vehicle is a 2020 Ford van that was parked outside next to my truck. It also has a 5.0 liter V8. Currently, I am awaiting an appointment at either Casa Ford or Visa Ford, the earliest opportunity for them to reprogram the onboard computer system.
Noticed significant gasoline leak under fuel tank when the engine was running. From the ground, looked up and saw that fuel was leaking from a black fuel hose originating at the top of fuel tank and directed going toward the engine. The fuel hose had dropped below the top of the truck frame and chaffed against a frame mounting point wearing a hole in the hose. Suspect the hose was manufactured to long allowing the droop, or was installed incorrectly (not clamped to prevent droop), or the hose installation was just defective as the hose is to long and a clamp was not part of the vehicle design. My truck has about 23,500 miles and has only been operated on paved roads and used for either commuting or carrying light household loads.
On 8/26/22 I smelled gas after parking 2020 F150 with ~ 33,000 miles. I had filled the tank the previous day ( <20 miles driven since that time). I was in a marina parking lot at that point and dismissed the smell as perhaps someone spilling some fuel from a portable gas tank. Upon arriving home I again smelled a strong odor of gas and noted my fuel gauge registered 3/4 of a tank ( despite driving < 30 miles since refueling). A very brisk gas leak was evident under pressure from a fuel hose fitting. The high pressure stream abated with turning off the engine ( but a slow fuel leak was still notable.) The vehicle was towed to Ravenel Ford in Ravenel, S.C. awaiting inspection/parts. No warning lights. I did note the engine hesitated to start (which it never had done prior) before driving back home from the marina. I do not off-road with the truck and have not scraped any obstacles with the truck.
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: May 4, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.