1999 Ford F-250 Engine Problems

The contact owns a 1999 Ford F-250. The contact stated that the vehicle stalled while driving at various speeds. The contact stated that the check engine light illuminated for approximately 30 seconds. The contact would turn off and restart the vehicle and the vehicle would return to normal operation. The contact stated he took his vehicle to several independent mechanics and was informed that the camshaft sensor was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that similar vehicles were included in NHTSA Campaign number 07V553000 (Engine and Engine Cooling) however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was 300,000.

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 55 MPH, THE FUEL TANK DROPPED OUT OF PLACE WITHOUT WARNING. THE CONTACT HEARD A DRAGGING, SCRAPING SOUND UNDERNEATH THE VEHICLE. THE CONTACT PULLED OVER INTO A PARKING LOT AND DISCOVERED THE FAILURE. BRAD HOWELL FORD (2170 E BLVD ST, KOKOMO, IN 46902) AND THE MANUFACTURER WERE CONTACTED AND STATED THAT THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS SINCE THERE WERE NO RECALLS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE UNDER THE HOOD WHILE PARKED ON THE SIDE OF THE ROAD. THE FAILURE OCCURRED WITHOUT WARNING. THE CONTACT EXTINGUISHED THE FIRE WITH SNOW. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 69,000.

BLOWS SPARK PLUGS OUT & BREAKS COIL PACKS FROM SITTING STILL AT INITIAL TAKE OFF. HAS HAPPENED 4 PREVIOUS TIMES

I WAS HEADING BACK TO COLLEGE IN BROOKINGS SD, WHEN I WAS STOPPED WAITING FOR A TRAIN TO PASS. AFTER THE TRAIN PASSES I PUT IT FROM PARK INTO DRIVE AND RIGHT WHEN I STARTED MOVING I HEAR A LOUD POP. AFTER I DRIVE ANOTHER BLOCK TO A GAS STATION TO LOOK UNDER THE HOOD I CAME TO THE CONCLUSION THAT I HAD BLOWN A SPARK PLUG. AND IT TOOK OUT THE IGNITION COIL WITH IT AND STRIPED THE THREADS ON THE HEAD. ALONG WITH THAT THERE WAS GAS EVERYWHERE ON THE DRIVERS SIDE OF THE ENGINE BLOCK. THAT'S NOT ONLY SUCKS BECAUSE I HAD TO PAY TO GET IT FIXED, I'M IN COLLEGE I DON'T HAVE MONEY TO PAY FOR THIS. BUT IF THAT GAS WOULD HAVE HIT I SPARK MY TRUCK COULD HAVE BLOWN UP. PLEASE TAKE RESPONSIBILITY FOR UR MISTAKES FORD. *TR

SPARK PLUG NUMBERS 2 AND 7 BLEW OUT OF THE CYLINDER HEAD. NUMBER 2 BLEW OUT WHILE DRIVING DOWN THE HIGHWAY AND NUMBER 7 BLEW OUT STARTING OFF AT A GREEN LIGHT ON A MAIN STREET. THERE WAS A STRONG ODOR OF GAS WHEN THIS OCCURRED AND SERIOUS VIBRATION FROM THE ENGINE MISFIRING. THIS CREATED A POTENTIAL EXPLOSION HAZARD SINCE THE AIR/FUEL MIXTURE IS DESIGNED TO IGNITE FROM AN IGNITION SOURCE. THIS JEOPARDIZED MY SAFETY AS WELL AS THE SAFETY OF OTHERS AROUND MY VEHICLE. THIS IS A KNOWN PROBLEM TO FORD AND NEEDS TO BE ADDRESSED FOR ALL VEHICLES MANUFACTURED THAT ARE AFFECTED BY THIS PROBLEM. MILEAGE HAS NOTHING TO DO WITH THIS AS OWNERS OF THESE SPECIFIC VEHICLES WITH ALUMINUM HEADS HAVE HAD THIS ISSUE AT LESS THAN 100,000 MILES.

MY V-10 EJECTED A SPARK PLUG.

SPARK PLUG BLEW OUT OF HEAD WHILE DRIVING. ENGINE HAS 92000 MILES AND ORIGINAL SPARK PLUGS.

#6 SPARK PLUG BLEW OUT OF THE HEAD. I HAD IT REPAIRED TWO DAYS LATER. TWO DAYS AFTER THAT, THE #3 SPARK PLUG BLEW OUT OF THE HEAD WHILE I WAS DRIVING AT 25MPH. DURING BOTH INCIDENTS GASOLINE FUMES AND EXHAUST FILLED BOTH THE ENGINE COMPARTMENT AND THE PASSENGER COMPARTMENT.

THIS ENGINE WITH ALUMINUM HEADS BLEW OUT SPARK PLUG NUMBERS 2 AND 7. FIRST OCCURRENCE ON AUG 11 2015 AND THE NEXT JAN 14, 2016. THE FIRST INCIDENT OCCURRED DRIVING DOWN A HIGHWAY AND THE NEXT OCCURRED STARTING FROM A STOP LIGHT. THERE WAS A LAG IN POWER AND THEN A LOUD BANGING NOISE AND A STRONG ODOR OF GAS. THIS CREATED AN EXPLOSION HAZARD AS WELL AS PUT MY SAFETY IN JEOPARDY AS WELL AS THAT OF THOSE AROUND ME. SINCE THE AIR/FUEL MIXTURE IS BEING BLOWN OUT OF THE ENGINE ON THE COMPRESSION STROKE AND THE COIL FIRING NORMALLY THIS CREATED A DEADLY SITUATION. THIS PROBLEM IS KNOWN TO FORD AND THE COMPANY IS REFUSING TO DO ANYTHING ABOUT IT FOR ALL VEHICLES WITH THESE PARTICULAR ENGINES THAT ARE HAVING THESE PROBLEMS. THIS SHOULDN'T EVEN HAPPEN WITH AN ENGINE. IT'S A MANUFACTURE/DESIGN FAULT. IT NEEDS TO BE ADDRESSED AND FIXED. THE MILEAGE IS NOT THE ISSUE AS THESE OCCURRENCES ARE HAPPENING ON THE NEWER TRUCKS/SUVS AS WELL WITH WAY FEWER MILES. THAT SHOWS IT'S A MANUFACTURE/DESIGN FLAW AND A VERY SERIOUS ONE.

I WAS DRIVING DOWN INTERSTATE 75 AND SUDDENLY I LOST POWER AND HAD A EXTREMELY LOUD PIPING NOISE COMING FROM UNDER THE HOOD . I STOPPED IMMEDIATELY AND CHECKED UNDER THE HOOD I COULD NOT TELL WITH THE ENGINE OFF SO I RESTARTED IT AND INSPECTED IT AND FOUND THAT MY NUMBER 2 SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD AFTER BUYING A NEW COIL PACK AND SPARK PLUG SET I DISCOVERED THAT ALL THE THREADS HAD BLOWN OUT OF THE HEAD WITH THE SPARK PLUG AND AFTER CHANGING ONE OF THE OTHER SPARK PLUGS I FOUND THAT IT WAS BARELY HOLDING IN .I THINK THAT THE HEADS DESIGN WAS POOR AND WEAK AND IS S SAFETY HAZARD.

A MAJOR LOSS OF POWER WHILE TOWING A LOAD. THE LOSS WAS SIGNIFICANT ENOUGH THE FIRST TIME THAT THE TRUCK COULD NOT SHIFT INTO HIGHER GEARS. COULD ONLY MANAGE 55 MPH MAX. WHEN I ARRIVED HOME, TOOK IT TO MY LOCAL DEALER TO HAVE IT REPAIRED. THEY HAD IT FOR 10 DAYS AND WERE UNABLE TO LOCATE ANY PROBLEM. THEY REPROGRAMMED IT, AGAIN, AND GAVE IT BACK WITH A SIGNIFICANT BILL. THE PROBLEM PERSISTS. THE NEXT TIME I USED IT TO HAUL A LOAD, IT DID IT AGAIN, ONLY THIS TIME I WAS ATTEMPTING TO PASS. COULD NOT COMPLETE PASS AND FORTUNATELY WAS ABLE TO GET BACK IN BEHIND THE VEHICLE I WAS TRYING TO PASS AND AVOID A HEAD ON COLLISION. IT'S DANGEROUS! THE PROBLEM IS SUBTLY WORSENING. SINCE THAT LAST EPISODE I DID SOME RESEARCH OF MY OWN, BESIDES CONTACTING FORD CORPORATE DIRECT NUMEROUS TIMES AND THE DEALER, I DISCOVERED THERE IS A HISTORY OF ALL SORTS OF TROUBLE WITH THEIR V 10. I DISCOVERED LAST NIGHT THAT MANY OTHERS HAVE EXPERIENCED WHAT I AM ATTEMPTING TO CORRECT, ALL WITH THE SAME RESULTS, NO REPAIR. ALL FORD WOULD DO IS TO CONTINUE TELLING ME OVER AND OVER TO JUST GO TO MY DEALER AS THEY KNOW ALL. THEY DO NOT! I AM STILL IN CONTACT WITH MY DEALER REGARDING THIS PROBLEM WITH NO OPTIONS AVAILABLE. I AM ABOUT TO REPLACE A FEW PARTS MYSELF IN AN ATTEMPT TO CORRECT IT MYSELF. PER MY RESEARCH, IT BECAME VERY APPARENT THAT FORD'S COMPUTER FOR ENGINE OPERATION AND DIAGNOSIS IS FLAWED AS THERE WERE NEVER ANY NUMBER INDICATIONS REVEALED TO INDICATE THE SOURCE OF THE PROBLEMS, PER NUMEROUS OTHERS AS WELL AS MYSELF. IT IS NOW OBVIOUS THAT FORD IS WELL AWARE OF THIS PROBLEM BUT IS COVERING IT UP INSTEAD OF ADDRESSING IT. THIS PROBLEM ALSO APPEARS TO BE HAPPENING TO VEHICLES MUCH NEWER THAN MINE. THIS VEHICLE IS DANGEROUS WHEN UNDER LOAD. THERE MAY ALREADY HAVE BEEN ACCIDENTS CAUSED BY THIS CHRONIC PROBLEM, I DO NOT KNOW. BUT I DO KNOW THAT THIS VEHICLE IS A DISASTER WAITING TO HAPPEN. *TR

TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE DISPLAYED A REDUCTION IN POWER AND EXHIBITED A LOUD, ABNORMAL NOISE FROM THE ENGINE WITHOUT WARNING. THE SMELL OF GASOLINE WAS EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHO INSTALLED A NEW INSERT, CYLINDER HEAD, SPARK PLUG AND COIL. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 153,000. UPDATED 05/28/14*LJ

(1999 FORDS SUPER DUTY EXTENDED CAB 4X4 WITH 5.4) DRIVING HOME FROM WORK ON THE FREEWAY AND BANG SO PULLED OVER TO DISCOVER A BLOWN SPARK PLUG AND BROKEN COIL, HAD CAR TOWED HOME FOR $200 AND TAKING IT IN TO HAVE AUTOMOTIVE SHOP FIX THE BLOWN-OUT SPARK PLUG AND CHECK ALL OTHER PLUGS , WIRES, COILS, ESTIMATED AROUND $560 PLUS PARTS. THE SECOND BLOWN-OUT SPARK PLUG HAPPENED 47 DAYS LATER AND HAD TO TOW IT AGAIN NOW JUST SITTING IN THE DRIVEWAY. CAN'T AFFORD TO HAVE IT FIXED. FORD SHOULD HAVE RECALLED THIS DESIGN DEFECT ON THE HEADS. I HAVE READ THOUSANDS OF ARTICLES THAT THIS HAS HAPPENED TOO.BEEN A REAL EXPENSIVE FOR SOMEONE THAT DOE NOT HAVE MONEY FOR THESE KIND OF REPAIRS AND FORD JUST DOES NOT CARE, THEY WOULD RATHER YOU TAKE ITTO THERE SHOP AND CHARGE YOU $2,000 OR MORE TO HAVE IT FIXED. BS. I HAVE A 1972 RANCHERO ALSO AND I'M SO PISSED OFF I'M THINKING OF SELLING ALL MY FORDS AND BUY A MOPAR. I TELL EVERYONE ABOUT THIS DEFECT. *TR

HEARD A LOUD POP FROM UNDER THE HOOD WHILE DRIVING AT HIGHWAY SPEED. SOUNDED LIKE IT WAS RIGHT IN FRONT OF THE GLOBE BOX AREA. THE ENGINE EJECTED A SPARK PLUG WHICH IS A VERY COMMON FAILURE FOR TRITON ENGINES WITH ALUMINUM HEADS - THREADS FAILED THAT HOLD THE SPARK PLUG IN PLACE. I DID NOT HEAR ANY WARNING SOUNDS THAT A FAILURE WAS IMMINENT. THE PASSENGER SIDE OF THE ENGINE, SPARK PLUG CLOSEST TO THE FIREWALL WAS BLOWN OUT WHICH IS ALSO VERY COMMON. I SMELLED GASOLINE AND EXHAUST AND FORTUNATELY THIS FAILURE DID NOT RESULT IN A FIRE. *JS

MY TRUCK WAS PARKED AT WORK. WHEN I GOT IN THE TRUCK TO LEAVE I WENT TO START IT AND I HAD HEARD A LOUD BANG FROM UNDER THE HOOD FOLLOWED BY A CLATTERING SOUND. I OPENED THE HOOD AND FOUND THAT I HAD BLOWN A PLUG. THIS IS A KNOWN ISSUE FOR FORD 4.6L 5.4L 6.8L ENGINES. I KNOW THIS IS NOT THE FIRST TIME SOMEONE HAS REPORTED THIS ISSUE AND I THINK ITS ABOUT TIME A RECALL IS ISSUED FOR THIS PROBLEM. *TR

WHILE DRIVE THE ENGINE MADE A LOUD POPPING SOUND AND SHUT DOWN ENABLE TO START! *TR

SPARK PLUG "BLEW OUT"OF ITS HOLE CAUSING LOSS OF POWER AND SUDDEN CONSTERNATION. WAS PULLING AN LIGHT EMPTY TRAILER AND FORTUNATELY DRIVING WITH NO OTHER TRAFFIC AROUND. 5.4L TRITON V8 ENGINE, MANUAL TRANSMISSION. FACTORY TUNE-UP AND PLUG REPLACEMENT DONE ABOUT 20K MILES EARLIER, 5 YEARS AGO. *TR

FORD 1999 F250 5.4L TRITON V-8 BLEW SPARK PLUG. LOST POWER, CREATED ROAD HAZARD AND SCARED THE CRAP OUTTA ME WHEN IT BLEW. MADE IT TO SIDE OF ROAD SAFELY AND GOT TOWED. WENT ONLINE TO FIND OUT THIS IS A HUGE PROBLEM WITH THIS ENGINE AS WELL AS OTHER TRITONS. SPARK PLUG THREADS ARE VERY SHORT LENGTH. NOT JUST POORLY ENGINEERED BUT ENGINEERED TO FAIL. HAVE READ POSTS SAYING FIRES WERE CAUSED BY THIS PROBLEM WHEN FUEL MIXTURE EJECTED FROM HOLE CAUGHT FIRE FROM ARCING BLOWN PLUG. OTHERS CLAIM THE PLUG BLEW A DENT INTO HOOD. CANNOT IMAGINE THE DAMAGE TO AN EYE OR OTHER IF MECHANIC OR OTHER PERSON IS LOOKING DOWN INTO ENGINE LOOKING FOR REASON FOR TICKING NOISE, WHEN BAM, THE PLUG BLOWS OUT. FORD WILL FIGHT THIS TOOTH AND NAIL BECAUSE IT IS AN EXPENSIVE FIX. THEY MAKE TONS OF MONEY BY HAVING THEIR SHOPS PULL THE ENGINE AND REPLACE THE HEAD. PLEASE HELP US. *TR

TL* THE CONTACT OWNS A 1999 FORD F250 SD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR MAINTENANCE WHERE THEY DETECTED THAT THE ENGINE HEAD GASKET FAILED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 45,000. UPDATED 05/04/11 *BF THE HEAD GASKET WAS LEAKING OIL. UPDATED 12/19/11