1999 Ford F-250 Fuel System Problems

I was driving on the interstate going highway speed of 65 mph and the accelerator was stuck open and I could not slow down. The engine stayed at a high rpm. I had to press with a lot of force to slow down and come to a stop with the engine still at high rpm and had trouble stopping. Luckily, where I live there's not much traffic, and I made it to a shop with this issue. Upon investigating, the accelerator cable became frayed where it enters the sheath and gets stuck there. The Ford dealer didn't have a replacement in stock or any nationwide. So I went to a junk yard to find one and found the same vehicle that had the same frayed accelerator cable. I located a newer, second vehicle with less mileage with same cable that matched without any fraying. In the meantime, I ordered a new accelerator cable through Ford, but it was backordered several months and tied up in shipping. With this happening on these two same vehicles, I thought I should report it. Thank you.

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING 5 MPH, THE CONTACT HEARD SOMETHING SNAP ON HIS VEHICLE. THE CONTACT PULLED THE VEHICLE OVER AND DISCOVERED THAT THE REAR STRAP CONNECTED TO THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT WIRED THE TANK BACK INTO PLACE AND DROVE HOME. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL; THEREFORE, HE WOULD BE RESPONSIBLE FOR THE REPAIRS. A DEALER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE OPERATING THE VEHICLE AT HIGHWAY SPEEDS, BOTH FUEL STRAPS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE); ALTHOUGH, THE VEHICLE EXHIBITED THE SAME FAILURE AS LISTED IN THE RECALL CAMPAIGN. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

FILLED THE GAS TANK FULL THE DROVE DOWN THE STREET AT 45 MPH. ABOUT 1 MILE INTO THE DRIVE THE REAR FUEL TANK STRAP BROKE IN HALF AND THE REAR END OF THE FUEL TANK FELL TO THE GROUND SPILLING MOST OF THE FUEL. THE STRAP LOOK CORRODED.

REAR FUEL TANK STRAP FAILED, CAUSING FUEL TANK TO DRAG ON GROUND WHILE VEHICLE WAS IN MOTION. SEE SAFETY RECALL 11S21 WHICH RECALLED FUEL TANK STRAPS ON OTHER 1999 FORD TRUCKS INCLUDING F-150 AND F-250 LIGHT DUTY BUT NOT F-250 SUPER DUTY. RECALL SHOULD BE EXTENDED TO 1999 F-250 SUPER DUTY.

TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT THE STRAPS FOR THE FUEL TANK WERE RUSTED ALL THE WAY THROUGH. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. HOWEVER, THE REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE MILEAGE WAS UNKNOWN....UPDATED 06/03/15 *BF UPDATED 7/7/2015*JS

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE THE VEHICLE WAS ON A SERVICE LIFT UNDERGOING A ROUTINE OIL CHANGE, THE INDEPENDENT MECHANIC STATED THAT THE FUEL STRAP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK STRAPS WERE RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE MECHANIC STATED THAT THE FUEL LINE STRAP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

DIESEL FUEL TANK FELL DOWN BECAUSE OF RUSTED TANK STRAPS AND LEAKED 30 GALLONS OF FUEL ONTO ROADSIDE. 13 YARDS OF SOIL HAD TO BE ABATED FROM THE CONTAMINATED SITE. *TR

WE HAVE STARTED TO NOTICE THAT WHEN DRIVING AT A STEADY SPEED THE TRUCK WILL STALL AND LOSE POWER AS IF IT WAS OUT OF GAS. THIS HAS HAPPEN TOO MANY TIMES AND HAS BECOME SUCH A SCARE THAT WE ARE COMPLETELY PARANOID TO DRIVE THE TRUCK WITHOUT THE FEAR OF BEING REAR ENDED. AT TAKE OFF THE TRUCK WILL SOMETIMES JOLT FORWARD VIOLENTLY. WE HAVE NOTICED AND RECORDED THAT THESE PROBLEMS OCCUR ONLY WHEN THE TRUCK GETS TO HALF A TANK. THE PROBLEM HAS GOTTEN SO BAD THAT AFTER A COMPLETE FILL UP THE TRUCK WILL NOW JUST CUT OFF WHILE BEING OPERATED ON THE HIGHWAY AND HAVE TO BE RESTARTED. WE HAVE SEVERAL FORD VEHICLES BOTH PERSONAL AND FOR OUR FLEET VEHICLES. THE FUEL FILTERS ARE BECOMING COMPLETELY CLOG UP DUE TO THE POOR CONDITION OF THE FUEL TANKS THEMSELVES. WE HAVE SPENT COUNTLESS HOURS RESEARCHING THESE PROBLEMS, AND SPENT EXCESSIVE AMOUNTS OF MONEY TRYING TO FIX/REPAIR THESE PROBLEMS. IT SADDENS US THAT WE HAVE BECOME JUST ANOTHER ADDED UNSATISFIED LOYAL CUSTOMER TO FORD, WHOM HAS NO THOUGHT OF CORRECTING THIS PROBLEM. WE HAVE READ SO MANY OTHER COMPLAINTS AND THERE IS STILL NO HELP FOR US. IT JUST LEFT IN OUR HANDS TO TRY TO FIND A SOLUTION TO FIX THIS FAULTY PROBLEM SO WE DON'T GET OUT ON THE HIGHWAYS AND KILL SOMEONE AND OR OURSELVES WHILE OPERATING LOUSY FORD TRUCKS AND VANS! WE THINK IT IS TIME FOR FORD TO GIVE US SOME HELP!!!!!!! *TR

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT THE BOLT THAT HELD THE FUEL TANK FAILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE FILLER NECK AND THE FAILED BOLT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 250,000

GAS TANK STRAP BROKE ALLOWING THE GAS TANK TO FALL OUT OF PLACE ALMOST TOUCHING THE ROAD. HAD TO HAVE TRUCK TOWED IN. WOULD APPRECIATE YOUR HELP IN GETTING COSTS COVERED FOR THE REPAIRS FROM ANY RECALL ON THIS SAFETY HAZARD SINCE THE GAS TANK COULD HAVE EXPLODED. ANY HELP IN THIS MATTER WOULD BE GREATLY APPRECIATED. *TR

TL* THE CONTACT OWNS A 1999 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, SHE HEARD A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SHOULDER AND NOTICED THAT THE FUEL TANK WAS DETACHING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE DEALER STATED THAT THEY NEED TO REPLACE THE FUEL TANK STRAP AND THE BRAKE LINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY STATED THAT THERE WAS NO RECALL. THE FAILURE AND CURRENT MILEAGES WERE 81,000.

TL* THE CONTACT OWN A 1999 FORD F-250. THE CONTACT STATED THAT THE FUEL TANK STRAPS CORRODED AND CREATED A HOLE IN THE FUEL TANK. FUEL BEGAN TO LEAK AS A RESULT OF THE FAILURE. THE CONTACT RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 99V093001 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY), BUT THE DEALER WOULD NOT PERFORM THE REPAIRS DUE TO THE FUEL TANK LEAK. THE FAILURE MILEAGE WAS 160,000. UPDATED 02/09/12*LJ THE CONSUMER STATED FORD REPLACED TANK WHICH CAUSED STRAP FAUILRE. UPDATED 02/13/12

TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH HE HEARD A LOUD NOISE. HE NOTICED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH STRAPS WERE CORRODED. THERE WAS NO FUEL SPILLING OUT OF THE VEHICLE ONCE THE TANK FELL OFF. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THERE WERE NO RECALLS ON HIS VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 161,000.

1999 FORD F250 SUPERDUTY PICKUP GAS TANK STRAPS RUST AND FAIL FORD HAS RECALLED OVER 1 MILLION TRUCKS BUT NOT MINE EVEN HERE IN VT WHERE MY DEALER SAYS THE TRUCK IS UNSAFE FORD WILL NOT FIX IT. *TR

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC STATED BOTH FUEL TANK STRAPS HAD CORRODED AND ONE OF THE STRAPS WAS FRACTURED. AFTER THE FUEL STRAPS WERE REPLACED, THE CONTACT NOTICED THE FUEL GAUGE READING DECREASED. THE VEHICLE BEGAN LEAKING APPROXIMATELY 15 GALLONS OF FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE FUEL LINE HAD TO BE REPLACED. NHTSA RECALL CAMPAIGN NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) MAY BE RELATED TO THE FAILURE. THE TECHNICIAN STATED THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 216,776. THE ONE OTHER THING THAT WASN'T MADE CLEAR IN THE FIRST REPORT WAS THE TECHNICIAN DID NOT MAKE CLEAR THAT THE FUEL LINE CRACKED BECAUSE OF THE GAS TANK FALLING. UPDATED 10/26/2011 *LN *TR

TL* THE CONTACT OWNS A 1999 FORD F-250 SD. THE CONTACT STATED THAT WHEN EXITING HIS VEHICLE HE NOTICED THAT ONE OF THE FUEL TANK STRAPS HAD DETACHED FROM THE VEHICLE AND WAS COVERED WITH RUST. THERE WAS NO FUEL SPILLING FROM THE TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR HAD IT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THEY WOULD LOOK INTO IT. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 91,000.

1999 FORD 250 SUPER DUTY (NO INCLUDED IN CURRENT RECALL) FRONT FUEL TANK STRAP FAILED (BROKE), REAR STRAP VERY CLOSE TO BREAKING, PLASTIC FUEL TANK DROPPED APPROXIMATELY 6" WHEN FRONT STRAP FAILED. HAD REAR FAILED AS WELL, TANK WOULD HAVE DROPPED TO THE GROUND, WITH LIKELY ACCIDENT/FIRE. I HAVE REPLACED BOTH FUEL TANK STRAPS, REAR BROKE ON REMOVAL. *TR

TL* THE CONTACT OWNS A 1999 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT STATED THAT THE VEHICLE STALLED AS THE FUEL TANK STRAPS FRACTURED. AFTER INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE STRAPS WERE RUSTED AND CORRODED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 240,000. THE VIN WAS UNAVAILABLE.