2006 Ford F-250 Complaint Log

TL* THE CONTACT OWNS A 2006 FORD F-250 SUPERDUTY. WHILE DRIVING AT APPROXIMATELY 50 MPH ON AN UNEVEN ROAD, THE STEERING WHEEL BEGAN SHAKING. THE CONTACT WAS ALSO UNABLE TO SLOW THE VEHICLE DOWN SINCE WHEN THE BRAKE PEDAL WAS DEPRESSED, IT WOULD RELEASE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP BUT NO REPAIRS WERE PERFORMED WHEN THE COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE CURRENT MILEAGE WAS APPROXIMATELY 97,000.

TRUCK SHAKES VIOLENTLY WHEN HIT ROUGH SPOTS ON HIGHWAY (OVER 60MPH). OCCURS ON BRIDGES, POTHOLES, ROUGH AREAS, ETC. SHAKING IS SO VIOLENT VEHICLE IS ALMOST IMPOSSIBLE TO CONTROL AND MUST SLOW DOWN TO 40 MPH IN ORDER FOR SHAKING TO STOP. *TR

I BOUGHT MY 2006 FORD F250, 4X4, CREW CAB DIESEL TRUCK IN SEPTEMBER OF 2005. I NEVER HAD A PROBLEM UNTIL I REACHED ABOUT 23K MILES. I WAS DRIVING ABOUT 45 MPH ON A TWO LANE HIGHWAY WHEN I WENT OVER SOME SMALL BUMPS IN THE ROAD. THE FRONT END STARTED SHAKING SO VIOLENTLY THAT I HAD A HARD TIME HOLDING ON TO THE STEERING WHEEL. WHEN I CAME TO A STOP OFF THE ROAD, I LOOKED FOR OBVIOUS SUSPENSION PROBLEMS BUT FOUND NONE. I DID SOME INTERNET SEARCHING AND FOUND THE "DEATH WOBBLE" THAT IS COMMON WITH THIS TRUCK. I SAW THE B.S. ABOUT TIRE PRESSURE BUT THAT WASN'T IT. I TOOK THE TRUCK TO A FRONT END SPECIALIST IN BUSINESS FOR OVER 40 YEARS. HE SAID THAT IT WAS THE STEERING DAMPENER AND HE HAD REPLACED SEVERAL ON THE FORDS. HE REPLACED MINE AND I HAVEN'T HAD A PROBLEM SINCE. LIKE EVERYONE ELSE, I THINK THIS PROBLEM IS AN ACCIDENT WAITING TO HAPPEN. I WOULD NOT EVEN DRIVE THE TRUCK UNTIL THE SPECIALIST FIXED THE PROBLEM BECAUSE IT SCARED ME SO BAD. OTHER THAN THAT, I LIKE THE TRUCK. HOPE IT DOESN'T HAPPEN AGAIN. *TR

SINCE NEW THE TRUCK HAS EXPERIENCED VIOLENT AND UNCONTROLLABLE FRONT SUSPENSION SHAKING/BOUNCING/WOBBLING AFTER HITTING A SHARP BUMP AT HIGHWAY SPEEDS. INITIALLY, THE SHAKING WOULD ONLY LAST APPROXIMATELY 3 SECONDS, BUT RECENTLY THE SHAKING WAS SO SEVERE THAT I HAD TO SLOW THE VEHICLE TO 30-35 MPH BEFORE IT STOPPED. THE SHAKING WAS SO VIOLENT THAT I WAS CONVINCED THAT SOMETHING HAD BROKEN IN THE FRONT SUSPENSION, AND I IMMEDIATELY INSPECTED THE FRONT SUSPENSION AT THE NEXT EXIT. NOTHING OBVIOUSLY BROKEN WAS EVIDENT. I SEARCHED THE INTERNET AND DISCOVERED THAT THIS IS A COMMON AND DANGEROUS PROBLEM WITH THESE TRUCKS. I DROPPED THE TRUCK OFF AT THE DEALER. THEY ACKNOWLEDGED THEIR AWARENESS OF THE PROBLEM, BUT CLAIMED THEY WERE UNABLE TO DUPLICATE IT DURING THEIR ROAD TEST. THIS IS NOT SURPRISING, AS IT TYPICALLY ONLY OCCURS WHEN YOU HIT A SHARP BUMP OR SERIES OF BUMPS AT HIGHWAY SPEEDS. THEY PERFORMED SOME OF THE REPAIRS/ADJUSTMENTS SPECIFIED BY FORD'S TSB 07-10-10, BUT THE PROBLEM PERSISTS. THERE IS A SERIOUS AND DANGEROUS PROBLEM WITH A LARGE POPULATION OF FORD TRUCKS THAT MUST BE ADDRESSED BY FORD AT THIS POINT, I HOPE THAT NHTSA CAN CONVINCE FORD TO CORRECT THE PROBLEM BEFORE SOMEONE IS NEEDLESSLY KILLED. *TR

I WAS TAKEN BY EXTREME SHOCK WHEN THIS FIRST HAPPENED, CROSSED A PAVING JOINT ON THE HIGHWAY TRAVELING ABOUT 70MPH, IT FELT LIKE THE TIRES WERE SHAKING OFF, NO CONTROL FOR A FEW MOMENTS. I PULLED OFF THE HIGHWAY AT A SAFE LOCATION TO CHECK THE LUG NUTS...THEY WERE TIGHT. NOW THESE OCCURRENCES ARE HAPPENING AT GREATER FREQUENCIES AND AT LOWER SPEEDS (45MPH) THE SHAKING IS SEVERE AND UNCONTROLLABLE UNTIL YOU CAN SLOW DOWN ENOUGH FOR IT TO STOP. I ALMOST HAD A HEAD ON COLLISION THIS LAST WINTER. THE SHIMMY STARTED ON DRY PAVEMENT THEN WENT TO AN ICE PATCH. I SPENT A LOT OF MONEY ON THIS FIRST DIESEL I'VE OWNED AND I'LL TELL YOU I NEVER IMAGINED THE LOSS OF CONFIDENCE IN DRIVING A VEHICLE AS I HAVE EXPERIENCED WITH THIS ONE. I AM NOT A NOT A NEOPHYTE TO OWNING AND DRIVING TRUCKS, 4 WHEEL AND 2 WHEEL DRIVE, THIS ONE HOWEVER, IS A SCARY RIDE. LIKE MOST OF EVERYONE I KNOW, DISPOSABLE MONEY IS TIGHT AND I HAVEN'T GONE TO THE DEALER BECAUSE I ASSUMED WHATEVER WAS WRONG WOULD COST ME FAR MORE MONEY TO FIX THAN I COULD AFFORD. I WAS GLAD TO SEE A LETTER ARRIVE YESTERDAY TO ASSURE ME THAT I AM NOT THE ONLY PERSON OUT HERE HAVING PROBLEMS WITH THEIR FORD TRUCK. I HOPE THERE IS A RECALL ON THIS PROBLEM, I'D LIKE TO HAVE A SAFE VEHICLE TO DRIVE. *TR

THE COMPLAINT I HAVE IS REGARDING THE F-250 SHIMMY. I HAVE BATTLED THIS FOR 2 YEARS. THE VIOLENT RATTLE OF THE TRUCK IS GOING TO GET MYSELF OR SOMEONE HURT IF NOT CORRECTED. I WOULD INVITE ANY DOUBTERS TO DRIVE MY TRUCK. AT SPEEDS OF 65-70 MPH, YOU HAVE TO COME TO A COMPLETE STOP IN-ORDER FOR THE VIBRATION TO STOP. ON INTERSTATE TRAVEL, IT IS NOT EASY TO GET PULLED OVER WITH TRAFFIC BEARING DOWN. THE LETTER FORD DISTRIBUTED YESTERDAY IS VERY TELLING, THAT THEY DO NOT KNOW HOW TO FIX, OR DO NOT WANT TO SPEND THE MONEY FOR A RECALL. THIS VIOLENT VIBRATION IS A DANGER, AND CONTINUES TO WORSEN. PARTICULARLY WITH THE TERRIBLE SHAPE OF TODAY'S INFRASTRUCTURE. PLEASE HELP FORD OWNERS ASAP. *TR

VIOLENT SHAKING IN FRONT SUSPENSION AND WHEELS AFTER HITTING ROUGH PAVEMENT AT APPROX 65 MPH. TRUCK ALWAYS HAS EXCESSIVE WHEEL HOP BUT EXTREME SHAKING HAS OCCURRED 5 TIMES IN 66K MILES. FORD TECHNICAL BULLETIN USELESS FOR RESOLVING PROBLEM. DEALER SUGGESTED CHECK TIRE INFLATION, TOW SETTINGS, AND STEERING COMPONENTS. NO RESULTS. THIS IS A DEATH TRAP. IT SHOOK TWO DRINKS OUT OF THE CUPHOLDER. LOST STEERING ABILITY, CROSSED LANES AND STOPPED SHAKING ONLY AFTER COMING TO A COMPLETE STOP. *TR

VEHICLE BEGINS VIOLENTLY SHAKING WHEN A BUMP IS HIT IN THE ROAD, VEHICLE IS TEMPORARILY UNCONTROLLABLE UNTIL SPEED IS REDUCED. FORD HAS TOLD ME I NEED TO PURCHASED A 400 DOLLAR DAMPENER, HOWEVER THIS NEVER HAPPEN FOR THE FIRST FEW YEARS OF VEHICLE OWNERSHIP SO I AM CONFUSED AS TO WHY I SUDDENLY NEED TO PURCHASE NEW EQUIPMENT TO MAKE THE VEHICLE OPERATE IN A SAFE MANNER. *TR

MY '06 FORD F-250 HAS A DESIGN FLAW THAT CAUSES IT TO SHAKE VIOLENTLY AT SPEED AND REQUIRES TO ALMOST STOP TO CORRECT. VERY UNSAFE AND NOW ABOUT USELESS TO DRIVE. ARE THERE SIMILAR COMPLAINTS AND WHAT CAN BE DONE TO FIX THIS PROBLEM? THANKS, DANTE *TR

1. TRAVELING ON FREEWAYS, HIGHWAY, AND PUBLIC ROADS 2. SEVERAL TIMES A MONTH, VIOLENT SHAKING IN FRONT STEERING 3. OUR LOCAL DEALER REPLACED A STEERING STABILIZER STRUT ON THE FRONT AXLE OF THE AFFECTED VEHICLES. PROBLEMS STILL OCCURS I AM MECHANIC WITH ABOUT THIRTY YEARS EXPERIENCE AND I BELIEVE THE STEERING GEARS ON 2006-07 F-250 2X AND 4X IS DEFECTIVE. *TR

FORD F-250 SD SHAKING VIOLENTLY AFTER CROSSING A BRIDGE WITH UNEVEN SURFACES, BUMPS, POT HOLES. TOTALLY OUT OF CONTROL, LET OFF EXCELERATOR AND IT FINALLY STOPPED. *TR

WHILE TRAVELING AT SPEEDS BETWEEN 40 - 70 MPH ON HIGHWAY OR CITY STREETS VEHICLE FRONT END BEGINS TO SHAKE VIOLENTLY AND NEARLY LOOSES CONTROL OF STEERING SYSTEM. MISHAP OCCURS WHEN VEHICLE DRIVES ON UNEVEN PAVEMENT SURFACES OR WHEN IT STRIKES ROAD POTHOLES (SMALL AND LARGE). WHEN TRAVELING ON A BUSY INTERSTATE IN ORLANDO, FL THIS VIOLENT ACTION NEARLY CAUSED ME TO LOSE CONTROL OF THE VEHICLE ON SEVERAL OCCASIONS. MANY INTERNET FORD F250 FORUMS ARE CURRENTLY DISCUSSING THE SAME ISSUE AND IT APPEARS FORD IS ONLY OFFERING MINOR "BAND-AID" TYPE REPAIRS THAT ONLY CORRECT THE PROBLEM TEMPORARILY. PROBLEM SEEMS TO BE A DESIGN / ENGINEERING ISSUE. *TR

DAYS AFTER PURCHASING A USED 2006 FORD F250 4X4 DIESEL TRUCK, I EXPERIENCED A VIOLENT SHAKING/VIBRATION WHILE DRIVING ON AN INTERSTATE IN ORLANDO, FLORIDA. I WAS TRAVELING AT APPROXIMATELY 65 MPH WHEN I DROVE OVER A SEGMENT OF UNEVEN PAVEMENT. THE FRONT END OF THE TRUCK BEGAN TO SHAKE SO VIOLENTLY THAT I HAD TO QUICKLY REDUCE SPEED ON THE FAR LEFT (FAST) LANE OF THE INTERSTATE. A CONCRETE BARRIER TO MY IMMEDIATE LEFT DID NOT ALLOW ME TO PULL TO THE SHOULDER. SEVERAL VEHICLES TRAVELING IMMEDIATELY BEHIND ME WERE FORCED TO QUICKLY CHANGE LANES SO AS TO AVOID A REAR END COLLISION. AS I SLOWED TO ABOUT 35 MPH THE SHAKING STOPPED. THE SAME SITUATION OCCURRED DAYS LATER WHEN TRAVELING ON A CITY ROAD AT APPROX. 35-40 MPH. DEALERSHIP INSTRUCTED ME TO CHECK PSI IN TIRES. PSI WAS TOO LOW & I INFLATED TIRES TO PSI AS PER VEHICLE TAG ON INSIDE OF DRIVER DOOR PANEL. VIOLENT VIBRATION OCCURRED A THIRD TIME WITHIN DAYS OF PROPERLY INFLATING TIRES. AM CURRENTLY OUT OF THE COUNTRY FOR WORK; WILL FOLLOW UP WITH DEALERSHIP UPON RETURN IN APPROX. 2 WEEKS. *TR

I HAVE AN 06 FORD F 250 SUPER DUTY SUPER CAB XLT WITH AN 8 FOOT BED. I'VE HAD ISSUES WITH EXTREME HIGHWAY SHAKING. WHEN IT HAPPENS TO ME I'M USUALLY GOING OVER 60 MPH, AND IT HAPPENS WHEN I HIT A BUMP IN THE ROAD, TO ME IT FEELS LIKE IT IS COMING FROM THE BACK END OF THE VEHICLE,LIKE THE WHEELS ARE NOW BOUNCING INSTEAD OF ROLLING,THE SHAKING IS EXTREMELY VIOLENT,AND I HAVE TO SLOW DOWN TO APX. 40 OR LESS MPH TO MAKE IT GO AWAY. SOMETIMES IT WOULD LAST ALMOST A FULL 30 SECONDS,BUT I NEVER SEEM TO HAVE ANY STEERING ISSUES,THE VEHICLE IS STILL IN MY CONTROL,BUT MAYBE THAT'S BECAUSE MY INSTINCT IS TO JUST GO STRAIGHT AND SLOW DOWN. IN ANY CASE, I'VE HAD 2 PEOPLE WITNESS THIS WHILE IN THE TRUCK WITH ME AT DIFFERENT TIMES AND BOTH OF THEM TURNED WHITE WITH FEAR,THIS IS NOT JUST A LITTLE SHIMMY,LIKE AN UNBALANCED TIRE OR SOMETHING, IT IS A MAJOR DESIGN FLAW AND FORD BETTER DO SOMETHING ABOUT IT! *TR

AFTER LETTING 2006 F250 DIESEL WARM UP FOR APPROXIMATELY 5MINS, PROCEED TO GET ONTO I-35, ABOUT 5 MILES FROM THE HOUSE WHEN I SET THE CRUISE CONTROL FOR 70MPH EVERYTHING WAS FINE. WITHIN A MILE OF GETTING ON THE HIGHWAY, TRUCK HESITATED AND COMPLETELY STALLED. I MOVE THE VEHICLE ONTO THE SHOULDER OF THE HIGHWAY TO AWAIT A TOW. I TOOK IT TO A FORD DEALERSHIP WHERE THEY FOUND THAT THE FICM WAS BAD. A DAY AFTER I PICKED UP THE TRUCK, AGAIN, THE VEHICLE HESITATED FOR A SECOND BEFORE STALLING IN CITY TRAFFIC. I LOST POWER BRAKES AND POWER STEERING AND WAS VERY DIFFICULT TO GET OFF OF THE CITY STREETS. CURRENTLY TOWED TO THE DEALERSHIP AGAIN, WHERE THE ISSUE IS UNDER INVESTIGATION. CONCERN THAT IF SOMEONE OTHER THAN A 6'4" PERSON WAS DRIVING THIS 7500LB VEHICLE, THEY MAY NOT HAVE BEEN ABLE TO STEER THIS VEHICLE OUT OF THE TRAFFIC. I'VE HEARD OF COMMON COMPLAINTS WITH THE FICM/HPOP/EGR ISSUES WITH THESE TRUCKS AND AM SURPRISED THAT NO RECALL HAS BEEN CREATED BY FORD. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE FIRST BRAKES ENGAGED INDEPENDENTLY. THE BRAKE DISENGAGED AS THE ABS WARNING LIGHT ILLUMINATED. ON A SEPARATE OCCASION, THE REAR PASSENGER BRAKE ENGAGED INDEPENDENTLY AND EMITTED SMOKE. THE BRAKE UNLOCKED AFTER THE SYSTEM COOLED DOWN BUT THE ROTORS SHOWED SIGNS OF OVERHEATING. IN ADDITION, THE FRONT PASSENGER BRAKE OVERHEATED AND CAUSED THE PASSENGER SIDE TIRE TO BLOW. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AT THE FRONT PASSENGER SIDE CALIPER. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 75,000. THE VIN WAS NOT AVAILABLE.

MY FORD F-250 SUPERDUTY DIESEL OCCASIONALLY SHAKES EXTREMELY VIOLENTLY WITH TEMPORARY COMPLETE LOSS OF VEHICLE CONTROL WHEN DRIVING AT HIGHER SPEEDS AND CROSSING UNEVEN OBSTACLES SUCH AS BRIDGE GAPS AND SMALL ROAD DEVIATIONS. THE VEHICLE FEELS TO SHAKE VIOLENTLY IN THE FRONT END AND INHIBITS STEERING. THE SHAKE IS EXTREMELY VIOLENT IN NATURE WITH OSCILLATING LARGE AMPLITUDE DEFLECTIONS IN EACH WHEEL. *TR

VIOLENT FRONT END SHAKE AFTER HITTING SMALL POT HOLES OR BUMPS AT ANY SPEED, COMPLETE LOSS OF CONTROL OF TRUCK UNTIL COMING TO STOP. *TR

STEERING SHAKES UNCONTROLLABLE PUT ON NEW STABILIZER AT 31,000 HELPED A LITTLE AT 51,000 IT IS NOW UNSAFE TO DRIVE. IT IS NOW A KAMAKAZI TRUCK READY FOR ITS FINAL RIDE. THIS TRUCK SHOULD NOT BE ON THE ROAD. IT'S A 2006 FORD F250 SD 4X4. *TR

2006 FORD F-250 AMBULANCE AIRBAGS DID NOT DEPLOY. CONSUMER STATES THAT THE AMBULANCE WAS INVOLVED IN AN ACCIDENT AND THE AIRBAGS FAILED TO DEPLOY. HE STATES THAT THE AMBULANCE WAS GOING AROUND 50-55 MPH. *KB THE DRIVER OF THE AMBULANCE WAS INJURED, BUT NOT SERIOUSLY. THE DRIVER OF THE VEHICLE, THAT THE AMBULANCE HIT WAS KILLED. *JB

MY FAMILY AND I WERE TRAVELING DOWN INTERSTATE 40 NO FASTER THAN 65 MPH WE CAME OVER`A BRIDGE AND THE TRUCK STARTED SHAKING SO VIOLENTLY IT TOOK EVERYTHING MY HUSBAND HAD IN HIM TO KEEP THE TRUCK FROM TRAVELING INTO THE MEDIAN AND WE WERE IN THE SLOW LANE IF THERE HAD BEEN A VEHICLE BESIDE US WE WOULD HAVE COLLIDED THE TRUCK SHOOK SO HARD MY DOOR CAME OPEN IF I HAD NOT HAD MY SEATBELT ON I WOULD HAVE BEEN THROWN OUT ONTO THE INTERSTATE MY HUSBAND HAD TO APPLY THE BRAKES AND BRING THE TRUCK TO THE SIDE OF THE ROAD WE CHECKED ALL TIRES U BOLTS WHEELS EVERYTHING WE THOUGHT OF THIS WAS TERRIFYING TO MY HUSBAND ME AND OUR THREE BOYS I WILL NEVER HAVE THIS TRUCK ON THE INTERSTATE AGAIN. *TR

2006 FORD F250. CONSUMER STATES SEVERAL PROBLEM WITH VALVE STEMS. *TGW THE CONSUMER STATED HE HAD TO REPLACE THE VALVE STEMS SEVEN TIMES BECAUSE THEY WERE LEAKING BETWEEN THE WHEEL AND THE STEM. *JB

ON MY 2006 FORD F250 SD DIESEL I EXPERIENCE VIOLENT OSCILLATIONS OF THE STEERING WHEEL WHEN GOING OVER RR TRACKS OR BUMPS IN THE ROAD, LEADING TO A NEAR LOST OF CONTROL OF THE VEHICLE. AS A RESULT OF THIS THE FRONT TIRES ARE FLAT SPOTTED, AND UNEVENLY WORN. FORD CLAIMS THE PROBLEM IS RELATED TO LOW TIRE PRESSURE, BUT MY TIRE PRESSURE WAS AT THE MFG RECOMMENDATION. I HAVE READ NUMEROUS REPORTS THAT A STEERING DAMPENER IS REQUIRED AND NOT INSTALLED ON THE FORD SD TRUCKS. *TR

I AM THE ORIGINAL OWNER OF A 2006 FORD F250 PICKUP. I PURCHASED THE VEHICLE NEW IN 2006. AT APPROXIMATELY THE 30,000 MILE MARK THE TRUCK STARTED TO EXPERIENCE A SEVERE SHIMMY AFTER DRIVING OVER A BUMP. THIS WOULD OCCUR RATHER RANDOMLY AND APPARENTLY UNDER ONLY THE PERFECT "BUMP OSCILLATION." ONCE THE SHIMMY STARTED THE IT WOULD GET WORSE UNTIL THE VEHICLE WAS NEARLY STOPPED. VERY DANGEROUS AND UNNERVING. SINCE IT WAS RANDOM AND INTERMITTENT AND I WAS VERY BUSY I PUT OFF TAKING THE VEHICLE INTO THE DEALER UNTIL SEVERAL THOUSAND MILES HAD PASSED AND THE SHIMMY EPISODES GREW MORE FREQUENT. AS A FORMER MECHANIC (CURRENT OCCUPATION IS ENGINEER), I STAYED ON TOP OF MAINTENANCE AND TIRE PRESSURES. AT APPROXIMATELY 37,000 MILES I TOOK THE VEHICLE INTO THE LOCAL FORD DEALERSHIP WHERE I PURCHASED IT FOR EVALUATION AND REPAIR OF THE SHIMMY. EVEN THOUGH THE VEHICLE WAS BARELY OUT OF WARRANTY THE DEALER CHARGED ME APPROXIMATELY $1000 TO FIX IT. THE REPAIRS APPEARED TO CORRECT THE SHIMMY AS IT HAS NO DONE SO IN THE 10,000 MILES SINCE THE REPAIRS. ON 4-22-09 I RECEIVE A LETTER FROM FORD MOTOR COMPANY STATING THAT FOMOCO AND NHTSA ARE STUDYING THIS CONDITION. SINCE I HAD A DIRECT EXPERIENCE WITH THE SITUATION AND HAVE VALUABLE INSIGHT TO HOW VEHICLE OPERATE I THOUGHT I WOULD PASS ALONG MY EXPERIENCE. FORD DID NOT CARE TO HEAR ABOUT IT AS THEY WERE WORRIED ABOUT ME ASKING FOR MY REPAIR MONEY TO BE RETURNED. SO NOW I AM CONTACTING YOUR AGENCY. IT IS VERY CLEAR TO ME THAT THIS IS NOT A TIRE INFLATION OR A SUSPENSION MODIFICATION CAUSED ISSUE AS THE LETTER ELUDED TO SINCE MY TRUCK HAS ZERO MODIFICATIONS, WAS ON THE ORIGINAL TIRES WHEN IT SHIMMIED, WAS REPAIRED AND CEASED SHIMMYING ON THE ORIGINAL TIRES, AND HAS SUBSEQUENTLY HAD 4 NEW TIRES INSTALLED AND DOES NOT SHIMMY. THE PROBLEM IS IN THE FRONT SUSPENSION GEOMETRY. THIS IS A VERY DANGEROUS CONDITION AND NEEDS TO BE ADDRESSED WITH MORE THAN A LETTER OF NOTIFICATION TO CHECK INFLATION PRESSURE. PLEASE CONTACT ME. *TR

MY 2006 F-250 WILL SHAKE SO VIOLENTLY WHEN YOU HIT A BUMP AT 30 TO 65 MPH IT RIPS THE STEERING WHEEL OUT OF YOUR HANDS AND YOU HAVE TO HIT THE BRAKES SO HARD AND COME TO A STOP TO GET IT BACK IN CONTROL. REPLACED THE STEERING STABILIZER HAD ALIGNMENT AND STILL DOES IT. *TR

THERE EXISTS A FACTORY FAULT IN THE FORD SUPERDUTY TRUCK. THERE IS WHAT IS CALLED A DEATH WOBBLE THAT OCCURS ON ROUGHER ROADS WHEN TRAVELING 60 MILES PER HOUR OR UNDER. THE FRONT END WILL SHAKE VIOLENTLY AND UNCONTROLLABLY WHEN A BUMP IS HIT. I HAVE HAD IT IN TO FORD DEALERSHIPS 7+ TIMES FOR THIS AND THEY WILL NOT FIX OR REPLACE THE FAULTY PARTS. I HAVE STARTED A WEB LOG ON AOL REGARDING THIS AND AM ATTACHING THE LINK . HTTP://WWW.TOPIX.NET/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/T0SGDCTMOBHE5JER1 THERE ARE OVER 170 SIMILAR COMPLAINTS REGARDING THE SAME PROBLEM. FORD DENIES THE PROBLEM EXISTS. IT WILL KILL SOMEONE SOON, IT HAS ALMOST CASED 4 ACCIDENTS WITH MY TRUCK. *TR

I HAVE A 2006 F250 LARIAT CREW CAB 6.0. THERE ARE NO MODIFICATIONS FROM STOCK ON THE VEHICLE. I WAS AND CONTINUE TO RUN RECOMMENDED AIR PRESSURE IN THE TIRES. WHILE DRIVING THE VEHICLE AT A SPEED OF 50 MPH IN A SLIGHT TURN, IMMEDIATELY AFTER HITTING A DIP IN THE ROAD, I EXPERIENCED A VIOLENT SHAKE IN THE FRONT END. IT FELT AS THOUGH THE TIRES WERE HOPPING WHICH MADE THE TRUCK EXTREMELY HARD TO CONTROL. AS THE FRONT END HOPPED IT PUSHED THROUGH THE TURN. THIS SEEMS TO BE IN INTERMITTENT CONDITION BROUGHT ON BY SPEEDS OVER 40MPH, IN TURNING SITUATIONS, WHERE THERE IS A BUMP AND OR DIP IN THE ROAD. BASED ON MY RESEARCH LATELY THIS SEEMS TO BE A KNOW SAFETY ISSUE THAT FORD HAS CHOSEN TO IGNORE. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 65 MPH, THE VEHICLE SHOOK VIOLENTLY AND FELT AS IF IT WOULD FLIP OVER. IT TOOK A WHILE FOR THE CONTACT TO REGAIN CONTROL OF THE VEHICLE. THE DEALER TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. A REPORT WAS FILED WITH THE MANUFACTURER AND THEY STATED THAT THE DEALER WOULD CALL THE CONTACT WITHIN FOUR DAYS. THE FAILURE MILEAGE WAS 25,000 AND CURRENT MILEAGE WAS 30,000. UPDATED 12/30/08 *BF THE HORN WOULD RANDOMLY BLOW ON ITS OWN. UPDATED 01/05/09. *JB

RECURRING OSCILLATION IN THE STEERING. IT HASN'T CURRENTLY LED TO ANY WRECKS OR COMPLETE LOSS OF CONTROL. WE ATTEMPTED TO FIX IT BY PUTTING ON HEAVIER DUTY STEERING DAMPERS. THIS PROBLEM NEEDS TO BE ADDRESSED. THERE ARE HUNDREDS OF COMPLAINTS. IF YOU WILL FOLLOW THIS LINK YOU WILL SEE SOME OF THE MANY OTHER OCCURRENCES OF THIS EXACT PROBLEM: HTTP://WWW.TOPIX.NET/FORUM/AUTOS/FORD-F-250-SUPER-DUTY/T0SGDCTMOBHE5JER1 *TR

AT APPROXIMATELY 40K ON THE VEHICLE, A PROBLEM BEGAN TO OCCUR WHEN A BUMP IN THE ROAD WAS HIT, RESULTING IN THE FRONT WHEELS SHIMMYING LEFT TO RIGHT FOR ABOUT A SECOND. OVER THE NEXT FOUR MONTHS, THE PROBLEM INTENSIFIED, LEADING TO A SEVERE SHAKE EMITTING FROM THE FRONT LEFT WHEEL. FORD RECOMMENDED AN ALIGNMENT AND THE STEERING DAMPENER (WHICH WAS ALREADY INSTALLED). I REPLACED THE TIRES, DAMPENER, TRACK BAR AND BUSHING, WHICH SOLVED THE ISSUE FOR SEVERAL WEEKS, BUT SOON FOUND THAT I CORRECTED A SYMPTOM AND NOT THE TRUE PROBLEM. ABOUT THIS TIME I FOUND OUT ABOUT YOUR INVESTIGATION AND DECIDED TO DEAL WITH THE PROBLEM, SINCE NO ONE COULD DIAGNOSE THE ISSUE IN THE SHOP....HOPING YOUR INVESTIGATION WOULD PROVIDE A FIX. ON JANUARY 15TH, 2008 I EXPERIENCED AN ENCOUNTER WHERE THE SHAKE OCCURRED AND HIT BLACK ICE, RESULTING IN LOSS OF CONTROL, SPINNING AND LANDING IN A DITCH, CAUSING BODY DAMAGE. THE ONLY WAY TO STOP THE SHAKING IS TO ALMOST COMPLETELY STOP OR OVER CORRECT THE STEERING (IF THERE IS ROOM TO DO IT). SINCE THERE WAS NO OTHER VEHICLE INVOLVED THE STATE TROOPER DIDN'T MAKE A REPORT OF THE INCIDENT. THE PROBLEM STILL HAS NOT BEEN CORRECTED. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65 MPH, SMOKE EMITTED FROM THE EXHAUST PIPE AND THERE WAS A SUDDEN LOSS OF ACCELERATION POWER. THE VEHICLE WAS MOVED TO THE SHOULDER AND TOWED TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL INJECTORS AND TURBO HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

DEATH WOBBLE IN FRONT END OF THE TRUCK AT 40-45 .THE TRUCK HAS BEEN TO THE SHOP 4 TIMES FOR IT.*CN

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT WAS DRIVING 60 MPH OVER A ROAD BUMP WHEN THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST BUT THE DEALER WAS UNABLE TO DEFECT THE CAUSES OF THE FAILURE. THE MANUFACTURER SUGGESTED ADDING FRONT DAMPERS TO THE VEHICLE BUT THE VEHICLE WAS ALREADY EQUIPPED WITH STOCK DAMPERS THAT DID NOT NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS CONCERNED WITH THE POSSIBILITY OF LOSING CONTROL OF THE VEHICLE WHEN THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS 62,000.

2006 FORD F250 HAD VIOLENT SHAKING IN FRONT END AFTER HITTING BUMP AT 70MPH. LASTED APPROX 30 SECONDS. VERY DANGEROUS, SCARED TO DRIVE. FORD MOTOR CO CLAIMS NO PROBLEM. KEEP TIRES INFLATED. *TR

THE TRUCK (FORD 2006 F250) WAS SHAKING VIOLENTLY TO THE POINT OF ALMOST LOSING COMPLETE CONTROL OF IT. SHAKING DID NOT STOP UNTIL THE VEHICLE CAME TO A COMPLETE STOP. THIS VEHICLE IS DANGEROUS AND YOU NEED TO TAKE ACTION IMMEDIATELY. *TR

I HAVE A 2006 FORD F250 SUPER DUTY. TRUCKS SHAKES VIOLENTLY OUT OF CONTROL @ 40-50 MILES PER HOUR GETS WORSE UNTIL YOU COME TO AN IMMEDIATE STOP. PROBLEM HAS GOTTEN SO BAD IT WOULD HAPPEN THREE - FOUR TIMES EVERY TIME I WOULD DRIVE THE TRUCK. HAS BEEN TO SEVERAL SHOPS AND MANY THINGS DONE TO FIX THE PROBLEM BUT NOTHING WORKS. THE MORE RESEARCH I DO, THE MORE I FIND OUT IT LOOKS LIKE A MANUFACTURE/ENGINEERING DEFECT. I REALLY DON'T WANT TO GIVE UP MY TRUCK THAT I PLANNED AND BUDGETED TO KEEP FOR THE NEXT 10 YEARS. PLEASE HELP! *TR

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 40 MPH OVER A ROAD BUMP, THE STEERING WHEEL BEGAN TO EXHIBIT A VIOLENT VIBRATION. THE FAILURE RECURRED WHEN TRAVELING BETWEEN 40-60 MPH OVER A ROAD BUMP, POTHOLE OR UNEVEN ROAD SURFACES. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS UNAVAILABLE.

WHILE DRIVING HOME FROM WORK, I HIT A SMALL BUMP IN THE FREEWAY AT 65MPH AND NEARLY LOST CONTROL OF MY 2006 F-250. THE VEHICLE BEGAN TO SHAKE UNCONTROLLABLY AND VIOLENTLY. I TRIED TO REGAIN CONTROL OF MY DIRECTION WHICH ONLY HAPPENED AFTER I GOT BELOW 15 MPH. AFTER PULLING OFF THE HIGHWAY, I GOT OUT TO CHECK WHICH TIRE HAD BLOWN AND TO MY SURPRISE ALL WERE FINE. IF I HADN'T HAVE BEEN IN THE FAR RIGHT HAND LANE OF THE FREEWAY, I WOULD HAVE CAUSED AN ACCIDENT AND HURT EITHER MYSELF OR SOMEONE ELSE. THIS WAS NOT A TYPICAL VEHICLE RESPONSE AND WAS VERY LITERALLY A VIOLENT WHEEL HOP OR FRONT END SUSPENSION MALFUNCTION. I CONSIDER THIS TO BE A SERIOUS AND DANGEROUS ISSUE FOR F-250 OWNERS AND ALL WHO TRAVEL AROUND THEM. FORD NEEDS TO RE-CALL THESE FRONT END DEFECTS BEFORE SOMEONE GETS KILLED. AFTER A THOROUGH SEARCH OF THE INTERNET, I DISCOVERED A MOUNTAIN OF OTHER F-250 OWNERS WHO WERE AND ARE EXPERIENCING THE SAME PROBLEM WITH SIMILAR RESULTS, MOST CLAIMING THE SAME THING, THESE VEHICLES HAVE A MAJOR LEAGUE PROBLEM WITH THE FRONT END SUSPENSION WHICH WILL UNDOUBTEDLY COST SOMEONE THEIR LIFE SOMEDAY. WHAT IS THE NHTSA DOING TO BRING FORD TO THE TABLE AND GET THIS FIXED? IT'S TIME. *TR

MY WIFE AND I WERE DRIVING MY 2006 F-250 SUPER DUTY ON HWY 95 WHEN MY TRUCK FELT LIKE I WAS IN AN EARTHQUAKE. IT WAS THE WORST VIOLENT SHAKING I HAVE EVER FELT IN A VEHICLE. IT FELT LIKE ALL FOUR TIRES EXPLODED. SO I FOUGHT MY STEERING WHEEL AND BRAKE PEDALS TO SLOW THE TRUCK DOWN TO FINALLY SKIDDED OFF OF THE SIDE OF THE ROAD, WHILE CARS ARE GOING BY US 70 PLUS MILE PER HOUR, EVERYTHING INSIDE THE VEHICLE FELL OFF OF THE SEATS THE DRINKS IN THE CUP HOLDERS WENT FLYING. AFTER SEEING THAT ALL FOUR TIRES SEEMED FINE AND THAT WE DID NOT HIT ANYTHING ON THE ROAD, WE WERE SCARED TO DEATH TO DRIVE AGAIN. AFTER VISITED THE FORD DEALERSHIP THE NEXT DAY, THEY ARE STILL TRYING TO FIGURE OUT WHAT IS WRONG WITH THE VEHICLE, THEY SAID IT WAS THE TIRE BALANCE AND PRESSURE, BUT THERE IS NO WAY THIS WOULD CAUSE SUCH A VIOLENT DEATH SHAKING EXPERIENCE. AFTER DOING MY OWN RESEARCH, IT SEEMS THERE ARE THOUSANDS OF PEOPLE WITH THE FORD SUPER DUTY THAT ARE HAVING THIS SAME WORD FOR WORD PROBLEM. PLEASE HELP ME, BEFORE SOMEONE IS KILLED BY THIS FORD MISTAKE. I AM SCARED TO DEATH TO DRIVE MY BRAND NEW VEHICLE. THANK YOU VERY MUCH. *TR

WHILE DRIVING AT ROAD SPEED OF 50 MPH OR MORE THE STEERING WILL SHAKE AFTER HITTING A POT HOLE OR ROUGH PAVEMENT. THE SHAKING IS SO BAD THAT I HAVE TO PUT ON BRAKES TO REGAIN CONTROL OF THE VEHICLE. I HAVE HAD THE STEERING STABILIZER REPLACED BY THE DEALER AND I HAVE INSTALLED NEW TIRES. THE SHAKING HAS DECREASED, BUT STILL OCCURS AT A LESSER INTENSITY. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING 60 MPH, THE CONTACT REAR ENDED ANOTHER VEHICLE. THE ENTIRE FRONT END OF THE CONTACT'S VEHICLE WAS DESTROYED. NONE OF THE AIR BAGS DEPLOYED. TWO PASSENGERS WERE INJURED IN THE CRASH. SHE NOTIFIED THE MANUFACTURER, BUT THEY DID NOT PROVIDE ANY ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 60,000.

TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING 75 MPH OR ANY HIGH SPEED, THE VEHICLE SHAKES VIOLENTLY WHEN IT DRIVES OVER A BUMP IN THE ROAD. THE SHAKING IS UNCONTROLLABLE AND THE CONTACT CAN BARELY CONTROL THE VEHICLE. THE DEALER TEST DROVE THE VEHICLE AT LOW SPEEDS AND FOUND NO FAILURES. THE FAILURE MILEAGE WAS 12,000.

MY 2006 FORD F250 HIT A POT HOLD IN I-15 NEAR KAYSVILLE, SOUTHBOUND ON THURS. OCTOBER 4, 2007. I WAS TRAVELING AT 65 MPH IN THE MIDDLE LANE WHEN IT STARTED SHAKING VIOLENTLY AND ALL I HEARD WAS CAR TIRES SCREECHING. I THOUGHT I WAS GOING TO DIE. I WAS ABLE TO PULL THE TRUCK TO THE SHOULDER AND STOP. THIS HAS NOT BEEN THE FIRST TIME. THIS WAS THE EIGHTH TIME THIS HAS HAPPENED. THEN ABOUT TEN MINUTES LATER, ALMOST TO WORK, IT DID IT AGAIN ON I-80 WESTBOUND ALMOST TO 5600 WEST. I HAVE TAKEN IT IN TO TWO DEALERS WHO ONE, WILLEY FORD IN BOUNTIFUL, SAID THERE WAS SOME LOOSE BOLTS. THE OTHER DEALER ED KENLEY FORD IN LAYTON, SAID THERE WAS SOME BROKEN PARTS ON THE FRONT END. IT HAS SHOOK A LITTLE BUT NOW IS WORSE THAN EVER. I AM AFRAID TO DRIVE THIS VEHICLE ANY MORE AS IT WILL EITHER KILL ME OR ANOTHER DRIVER. I SUSTAINED A HEADACHE AND PULLED MUSCLE IN MY NECK AND A SORE BACK FROM YESTERDAYS INCIDENT. FORD NEEDS TO PULL THESE VEHICLES AND GET THEM REPAIRED OR REPLACED. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT NOTICED THAT ALL OF THE INSTRUMENT PANEL LIGHTS ILLUMINATED AND THEN DIMMED. SECONDS LATER, SMOKE APPEARED. SHE PULLED THE VEHICLE OFF THE ROAD AND IT CAUGHT FIRE. THE VEHICLE WAS COMPLETELY DESTROYED. A FIRE REPORT WAS FILED. SHE NOTIFIED THE DEALER AND MANUFACTURER, BUT THEY WOULD NOT PROVIDE ANY ASSISTANCE BECAUSE HER VEHICLE WAS NOT INCLUDED IN THE VEHICLE SPEED CONTROL:CRUISE CONTROL RECALL. THE RECALL NUMBER WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 26,000.

OWN A 2006 FORD F250 POWERSTROKE DIESEL. WHEN VEHICLE IS DRIVEN AT ABOUT 65-70MPH ON THE HIGHWAY IT TENDS TO START A VIOLENT SHAKE THAT CAN ONLY BE STOPPED BY SLOWING DOWN THE VEHICLE. I ALMOST GOT INTO A FATAL ACCIDENT. THIS HAS NOW OCCURRED ABOUT 7 TIMES. THE VEHICLE HAS ABOUT 24,000 MILES. *TR

I WAS DRIVING ON INTERSTATE AT 75 MPH WHEN I HIT A SMALL BUMP IN THE ROAD WHEN MY TRUCK WENT VIOLENTLY OUT OF CONTROL UNTIL I BROUGHT IT TO A COMPLETE STOP ALMOST CAUSING A FATAL ACCIDENT. *JB

I OWN A 2006 F250 DIESEL TRUCK THAT SHAKES VIOLENTLY WHEN YOU HIT EVEN THE SMALLEST OF POTHOLES. IT SHAKES SO VIOLENTLY THAT YOU HAVE TO COME TO A COMPLETE STOP, REGAIN CONTROL, AND THEN RESUME DRIVING. THIS IS ESPECIALLY HAZARDOUS ON THE SMALL COUNTY ROADS WE LIVE ON, AND WHEN YOU HAVE TO COME TO A COMPLETE STOP ON THE FREEWAY. WE HAVE TRIED TO GET IT FIXED AT THE DEALERSHIP, WHERE THEY ASSURE US THAT NOTHING IS WRONG WITH THIS DANGEROUS DEATH TRAP. I REFUSE TO ALLOW MY HUSBAND AND MY SON GET INTO A VEHICLE THAT WILL SHAKE VIOLENTLY OUT OF CONTROL INTO ONCOMING TRAFFIC, INTO A DITCH, OR OFF A BRIDGE. I AM ASHAMED THAT FORD WOULD BE AWARE OF THIS ISSUE, AND NOT RECALL THIS PROBLEM VEHICLE AS THERE ARE MANY OTHERS OUT THERE WITH THE SAME PROBLEM. I AM FURIOUS THAT I SPENT $48,000 ON A TRUCK THAT HAS 26,000 MILES ON IT AND HAS BEEN IN THE SHOP 3 TIMES TO HAVE THE SAME PROBLEM FIXED, SO IT IS COMPLETELY USELESS TO ME, NOT TO MENTION A DANGER TO MY FAMILY'S WELL BEING. WHAT IS IT GOING TO TAKE FOR FORD TO ADMIT THEIR TRUCKS ARE A HAZARD? HOW MANY PEOPLE ARE GOING TO HAVE TO DIE OR BE SEVERELY INJURED BEFORE THEY ADDRESS THIS PRESSING ISSUE??? *TR

2006 FORD F 250 SUPER DUTY FRONT END BOUNCES DANGEROUSLY. AUGUST 2007 THE TRUCK DID THIS 2 TIMES WHILE TRAVELING ON I25 IN NEW MEXICO. BETWEEN 9/21/07 AND 9/23/07 THIS HAPPENED 9 TIMES WHILE TRAVELING. THE TRUCK BOUNCES OUT OF CONTROL AND MOVES ACROSS TRAFFIC LANES. ENDANGERING EVERYONE'S LIVES TRAVELING ON THE ROAD. I FOUND OVER 138 CASES OF THIS REPORTED TO FORD AND THEIR RESPONSE IS TO BILL THE CUSTOMER FOR A REPAIR THAT HAS NOT WORKED IN ALMOST ALL OF THE REPAIRS SOME PEOPLE HAVE TAKEN THEIR VEHICLES TO FORD SEVERAL TIMES AFTER THE DEALER MADE AND THEN CHARGED THEM FOR THE TSB REPAIR. FORD IS ACCEPTING NO RESPONSIBILITY FOR THIS EXTREMELY DANGEROUS SITUATION. THESE VEHICLES 2005 ON ARE UNSAFE TO DRIVE ON THE ROAD. *TR

HIGHWAY DRIVING CONDITIONS AT 65 MPH , VIOLENT SHAKING OF THE TRUCK OCCURRED RESULTING IN DANGEROUS LOSS OF CONTROL OF THE VEHICLE. VEHICLE CAME TO A COMPLETE STOP TO END THE SHAKING. VEHICLE WAS TAKEN TO A FORD DEALER WHERE A STEERING DAMPER KIT WAS INSTALLED. *TR

WHILE DRIVING DOWN A FAIRLY SMOOTH HIGHWAY AT 55 MPH. MY 2006 FORD F250 SD POWERSTROKE STARTED SHAKING, AND THE STEERING WHEEL STARTING MOVING BACK AND FORTH RAPIDLY. I THOUGHT IT WAS A LOOSE WHEEL OR A FLAT, BUT IT WAS NOT. I HAD TO SLOW DOWN TO AROUND 45 MPH AND IT STOPPED. AFTER DOING SOME INVESTIGATING ON THE INTERNET I FOUND THAT THIS IS A VERY COMMON THING FOR THIS MODEL PICK-UP, AND THAT NOTHING IS BEING DONE TO CORRECT IT BY FORD. THIS HAS HAPPENED TO ME TWICE NOW, AND IT IS VERY SCARY. I HOPE THAT IT DOES NOT HAVE TO TAKE SOMEONE HAVING A FATAL ACCIDENT FOR FORD TO DO SOMETHING ABOUT THIS. *JB