2006 Ford F-250 Complaint Log

THIS IS A SUSPENSION PROBLEM THAT I NOTICED ABOUT 9 MONTHS AFTER I BOUGHT THE VEH., (2006 FORD F-250SD). THE PROBLEM IS IN THE SUSPENSION. IT SEEMS TO ONLY HAPPEN WHEN YOU GO OVER AN AREA OF THE ROAD THAT IS ROUGH. IT HAS GOTTEN PROGRESSIVELY WORSE. I WAS DRIVING AT 60 MPH AND WENT OVER A BUMPY AREA ON THE HIGHWAY AND I ALMOST LOST CONTROL OF THE TRUCK. IT PULLED HARD TO THE LEFT AND BEGAN SHAKING HEAVILY. IF I HAD NOT BEEN HOLDING THE WHEEL FIRMLY I WOULD HAVE CROSSED THE DOUBLE YELLOW LINE INTO ONCOMING TRAFFIC. I FOUND A SITE WHERE THERE WERE 11 OTHER COMPLAINTS ON THIS SAME VEH. AND THE SAME PROBLEM. I HAVE OWNED F250'S INCLUDING MY LAST THAT WAS A 2002 AND I NEVER HAD A PROBLEM LIKE THIS. ITS APPARENT THAT THERE IS SOMETHING WRONG WITH THE SUSPENSION SYSTEM THEY USED. IF SOMEONE IS DRIVING THAT HASN'T EXPERIENCED IT THEY MAY LOOSE COMPLETE CONTROL OF THE VEHICLE AND CAUSE A FATALITY. I AM GOING TO TAKE IT TO A FORD DEALER TO LOOK AT, BUT FROM WHAT I READ OF THE OTHER COMPLAINTS SOME PEOPLE HAVE BEEN IN 3-4 TIMES AND STILL HAVE THE SAME PROBLEM. *TR

MY 2006, 5.3 GAS ENGINE, 4 WHEEL DRIVE, F250 SUPER DUTY HAS HAD EXCESSIVE WHEEL HOP, BOUNCING, VIBRATION, AND SOMETIMES, VIOLENT SHAKING OF THE WHOLE FRONT OF THE TRUCK, WHEN GOING OVER EXPANSION JOINTS, BUMPS AND ROAD DEFECTS SINCE IT WAS NEARLY NEW. THIS RESULTS IN THE STEERING WHEEL SHAKING AND MAKES THE TRUCK HARD TO CONTROL. WHEN NEW WITH 300 MILES ON IT IN FEB. 2007, I DROVE IT FROM MA TO FL AND NOTICED THAT SOMETIMES IT SHUDDERED, WHEN GOING OVER A BUMP AT SPEEDS OVER 50. THAT IS, IT DID NOT JUST GIVE ONE HARD JOLT, BUT BOUNCED A FEW TIMES. THE BOUNCING GOT WORSE AS MILEAGE ON THE VEHICLE WENT UP. SOMETIMES THE TRUCK WOULD MOVE LATERALLY AFTER A HARD BUMP, THAT IS, MOVE TO THE EDGE OF THE TRAVELED LANE, OR PARTIALLY INTO ONE OF THE ADJACENT LANES. NOW, WITHIN THE LAST 2 WEEKS, AT ITS EXTREME OF VIBRATIONS AND BOUNCING, THE VIOLENT SHAKING HAS HAPPENED TO ME TWICE, BOTH TIMES WHEN TRAVELING ON A HIGHWAY AT 60-68 MPH, AFTER GOING OVER AN EXPANSION JOINT COMING OFF OR GOING ON TO A BRIDGE. FIRST TIME, ON SEPT 16, 2007, WITH ABOUT 9000 MILES ON THE F250, SHAKING LASTED ABOUT 5 SECONDS, ON I64 IN VIRGINIA BEACH, VA, AND THEN, ON SEPT. 28, 2007, FOR ABOUT 10 SECONDS, OR ABOUT 1000', ON THE NEW JERSEY TURNPIKE. DURING THESE LAST 2 INCIDENTS, I THOUGHT THAT I MIGHT EASILY HAVE LOST CONTROL OF THE VEHICLE AND HAVE EITHER INJURED SOMEONE ELSE OR MYSELF. BOTH OF THE SERIOUS VIOLENT SHAKING EPISODES HAPPENED ON A DRY INTERSTATE HIGHWAY IN DECENT CONDITION WITH OTHER TRAFFIC TRAVELING AT THE SAME SPEED AND MANY, MANY OTHER VEHICLES GOING OVER THE SAME BUMPS. I HAVE CHECKED THE TIRE PRESSURE AND ALL THE TIRES READ ABOUT 50#, THE SAME AS WHEN I GOT THE TRUCK ON JAN. 31, 2007. THERE ARE NO OBVIOUS DEFECTS IN THE TIRES. NOW, IT SHUDDERS WHEN GOING OVER VERY MINOR BUMPS, SOMETIMES EVEN AT BELOW 45 MPH. I'VE MADE IT BACK FROM MY TRIP AND THERE ARE ABOUT 9500 MILES ON THE TRUCK AND I AM TAKING IT TO THE DEALER THIS WEEK. THIS PROBLEM COULD RESULT IN THE LOSS OF LIFE. *JB

2006 F250 FX4 6.0 FRONT END STARTS TO SHACK WHEN HITTING A BUMP TRUCK IS UNCONTROLLABLE TIL SLOWING DOWN TO ABOUT 30MPH. *TR

I PURCHASED A FORD F250 FROM A DEALERSHIP, I BELIEVE AFTER DOING MY RESEARCH THAT THIS MODEL HAS A DEFECT IN IT AND IS TO DANGEROUS TO DRIVE. IF I DRIVE OVER 45 MPH AND I HIT A POTHOLE OR A BUMP IT VIOLENTLY SHAKES TO THE POINT WHERE WE FEEL WE ARE GOING TO TIP OVER. WE HAVE TO COME TO A COMPLETE STOP FOR IT TO STOP SHAKING AND WHEN YOU ARE ON A FREEWAY THAT IS VERY DANGEROUS. FORD DOES NOT SEEM TO CARE ABOUT THIS ISSUE AND HAS NOT BEEN ABLE TO FIX IT. I SPENT A LOT OF MONEY ON THIS VEHICLE AND AM AFRAID TO PUT MY 3 CHILDREN IN THE CAR. DO I HAVE TO WAIT FOR SOMEONE TO DIE FOR FORD TO HANDLE IT. I HAVE FOUND 1000'S OF PEOPLE WITH THE SAME PROBLEM AND WANT TO KNOW IF THERE IS ANYTHING YOU CAN DO TO HELP US FIX THIS. *JB

BLOWN TURBO - JUNE 07 9/4/07 THE MOTOR RPM RAN UP AS IF A CLUTCH WAS SLIPPING AND THE TRUCK WOULD NOT GO FASTER THAN 35 MPH FOR A MINUTE 3 MILES TO HOME AND TRUCK RAN EXTREMELY ROUGH CALLED FOLSOM LAKE FORD- 14,440 MILES. 9/5/07 BRAD SAYS IT APPEARS TO BE A WIRING HARNESS..SOMETHING TO DO WITH A RUB ON THE EXHAUST BACKPRESSURE HARNESS AND HE WILL CALL ME LATER. QTD, LOOKS LIKE AN INJECTOR, #1 AND THEY WILL ORDER IT AND GET IT PUT IN PROBABLY TOMORROW. 9/6/07 BRAD SAYS INJECTOR REPLACED BUT WANT TO KEEP IT OVERNIGHT. BRAD QTD THAT WE HAVE A LOT OF THESE 6.0'S COME IN AND NO ONE REALLY LIKES DEALING WITH THEM AS THEY CAN BE VERY TROUBLESOME. BRAD QTD THAT TECH WAS GONE BUT WANTED TO KEEP IT FOR A COLD START AND POSS WARM TESTING AND WOULD CALL ME IN THE MORNING. 9/7/07 CALL FROM BRAD 9:21 AM LOOKS GOOD, WILL HOT TEST 11:11AM QTD COMPUTER HAS NOW THROWN A CODE SHOWING #1 AND #5 INJECTORS BAD.. PM 2:24 CALL FROM BRAD, QTD NOT SURE YOU'LL BELIEVE THIS BUT WANT YOU TO KNOW B4 YOU SEE THE PAPERWORK, NOW THE FUEL PUMP HAS GONE BAD. HAVE ALREADY CLEARED IT W/ENTERPRISE FOR YOU TO KEEP THE CAR THROUGH MONDAY..7-8 DAYS. I ASKED IF THE PARTS WOULD BE NEW OR RE-MANUFACTURED AND WAS TOLD THESE WERE NEW. 9/10/07 CALL TO BRAD 11:12AM QTD CHECKED AT 9AM AND THERE WAS NO CHANGE. WOULD CHECK AND CALL ME BACK. CALLED AND SPOKE TO BRAD AT 1:06 PM, BRAD QTD SPOKE WITH TECH AND TECH SPENT 4 HOURS THIS AM ON MY TRUCK DON'T HAVE ANY NEW INFO, GOT PARTS FOR ANOTHER TRUCK IN AND HAVE TO SHELF MATT'S TRUCK AND GO BACK TO THE ONE THAT HAS BEEN IN OUR SHOP LONGER. WE HAVE FOUR IN HERE RIGHT NOW WITH THE SAME PROBLEM. I RQSTD A FORD 250 DIESEL 4X4 WHILE MINE IS BEING FIXED, I QTD ..PAID 45K PLUS TO BE ABLE TO HAUL AND TOW, ALSO I CAN SEAT SIX PASSENGERS. BRAD SAID THAT HE WOULD GET HIS MANAGER TO CALL ME. THEY TELL ME THEY HAVE NO IDEA AND CAN'T GIVE ME ANY TENTATIVE TIME FRAME FOR FIXING MY TRUCK. *TR

WHEN HITTING AN EXPANSION JOINT ON THE HIGHWAY THE FRONT END WILL SHAKE VIOLENTLY AND THE TRUCK WILL JUMP UNCONTROLLABLY INTO OTHER LANE. VERY UNSAFE. *TR

I HAVE A NEW 2006 FORD F-250 SD DIESEL 6.0L. THE FIRST YEAR I OWNED IT 7,000 MILES I BLEW A HEAD GASKET. IT TOOK FORD MORE THAN 5 WEEKS TO FIX IT AND 2 DIFFERENT DEALERSHIPS OF HASSLE. 6 MONTHS LATER THE PROBLEM HAS HAPPENED AGAIN. I SPOKE WITH FORD THEY GAVE ME AN APPOINTMENT 1 MONTH AFTER I CALLED TO SET THE APPOINTMENT. AFTER THAT MONTH DEALERSHIP TOOK 4 WEEKS OF MY TIME WITH MY TRUCK AND DIDN'T FIX A THING. TOLD ME THEY WERE TO BUSY TO DEAL WITH ME AND I SHOULD TAKE IT TO ANOTHER DEALERSHIP TO GET FIXED. GOT FORD CUSTOMER RELATIONS INVOLVED AND THEY HAVE DONE NOTHING. I NOW HAVE MY "UNFIXED" TRUCK IN MY DRIVEWAY WITH ANOTHER APPOINTMENT 2 WEEKS AWAY AND THAT DEALERSHIP SAYS IT WILL BE SOME TIME BEFORE THEY CAN GET TO IT. NO CUSTOMER SERVICE PLUS THEY HAVEN'T OFFERED ME ANY MONEY FOR CAR RENTAL FEES NOTHING. PLEASE ADVISE. UPDATED 01/11/08. *LJ A COMPLAINT WAS FILED WITH THE POLICE. UPDATED 12/12/07. *JB

I HAVE A 2006 F250 THAT THE FRONT END SHAKES VIOLENTLY AFTER HITTING A HOLE OR SMALL BUMP IN THE ROAD AT 55 TO 60 MPH,THEN YOU MUST USE BOTH HANDS TO CONTROL VEHICLE AND SLOW DOWN TO UNDER 40 MPH OR LESS TO REGAIN CONTROL. THIS IS AN ACCIDENT WAITING TO HAPPEN. I AM A LARGE MAN 6'2" 240LBS AND MY FEAR IS THAT MY WIFE OR SOMEONE OF A SMALLER STATURE BE DRIVING WHEN THIS HAPPENS AND RESULTS IN A FATALITY. THIS HAS HAPPENED SEVERAL TIMES THROUGHOUT A SIX MONTH PERIOD I OWNED THE TRUCK AND IS CONTINUALLY GETTING WORSE , BY THAT I MEAN EVERY DAY THIS PAST WEEK. *TR

TL* THE CONTACT OWNS A 2006 FORD F250. THE CONTACT STATED THAT THE STEERING WHEEL AND THE FRONT END OF THE VEHICLE WOULD VIBRATE EXCESSIVELY WHEN TRAVELING OVER A ROAD OR SPEED BUMP. THE DEALER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE AIR PRESSURE IN THE TIRES CAUSED THE VEHICLE TO VIBRATE. THE CONTACT RECEIVED A MANUFACTURER'S RECALL NOTICE CONCERNING THE VIBRATION, BUT THE MANUFACTURER WOULD NOT REPAIR THE VEHICLE STATING THAT THE VEHICLE HAD BEEN ALTERED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 39,000. KMJ

TL* THE CONTACT OWNS A 2006 FORD F-250 SD WITH 95,000 MILES. THE CONTACT STATED WHILE DRIVING AT HIGHWAY SPEEDS OF 55 MPH OR FASTER THE VEHICLE WOULD SHAKE VERY VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER BUT THEY WERE UNABLE DIAGNOSE THE FAILURE OR REPAIR THE PROBLEM.

AT AROUND 8000 MILES NOTICE WEAR OF ENDS OF MY FRONT TIRES TOOK IT TO MY FORD DEALER AND FINDOUT TRUCK WAS OUT OF ALIGMENT THEY RECOMEND TO HAVE TIRE ROTATION WICH I DID AS ASOON I GOT HOME THEN AT 12000 MILES NOTICE IT START TO WEAR MY FRONT TIRES AGAIN AND ALSO CHUNKS OF RUBBER COMING OFF THE TREADS TOOK TRUCK BACK TO FORD DEALER AGAIN THEY SAID NOTHING WRONG WITH TRUCK NOW NEED HELP HOW TO SOLVE THIS PROBLEM

2006 F-250 SUPER DUTY FRONT END BOUNCES DANGEROUSLY OUT OF CONTROL. *AK

TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING 70 MPH UNDER NORMAL DRY CONDITIONS, THE VEHICLE HIT A POTHOLE AND SPUN OUT. THE CONTACT HAS SPOKEN TO THE DEALER SEVERAL TIMES ABOUT FAILURE. THE DEALER INSPECTED THE VEHICLE BUT WAS UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 16,000.

I WAS COMING BACK HOME FROM VACTION IN LAS VAGAS AROUND JUST PASS STATE LINE,WHEN MY FORD F-250 HD 2006 WENT INTO 4X4 LOW ALL BY IT SELF.MY SPEED WAS AROUND 75 MILES PER HOUR WHEN THE TRUCK WENT INTO 4X4 LOW BY IT SELF.IF THIER WHOULD HAVE BEEN A CARS BEHIND ME THIS WOULD BEEN A MAJOR CRASH.MY SPEED WENT FROM 75 MPH TO 20 MPH IN ABOUT 10 -20 SECONDS,I HEARD SOMETHING LOUD FROM MY TRANSMISSION AND OR ENGINE.MY TRUCK IS AT THE DEALERSHIP,I GOT A CALL ABOUT MY TRUCK FROM THE DEALERSHIP THE SAID THE TRANSFER CASE WAS BAD ON THE 4X4 CONTROL AND THEY WERE GOING TO LOOK AT THE TRANSMISSION.*AK

2006 FORD F250, SHAKES VIOLENTLY TO THE POINT OF LOSING CONTROL IF I ENCOUNTER ROUGH ROAD ON THE HIGHWAY. SO FAR PROBLEM OCCURS AT SPEEDS OVER 60MPH. *TR

TRUCK HAS A VERTICAL VIBRATION MOST NOTICEABLE BETWEEN 45-50 MPH. TRUCK ALSO HAS STEERING PROBLEM AT HIGH SPEEDS SUCH AS INTERSTATE DRIVING. AN EXPANSION JOINT IN THE HIGHWAY WILL JUST ABOUT CAUSE LOSS OF CONTROL OF THE VEHICLE. FORD DENIES ANY PROBLEM, YET HAS ISSUED TSB 07-05-11 TO ADDRESS THE CONCERN THAT A FEW CUSTOMERS MAY HAVE. APPARENTLY IT IS MORE THAN A FEW CUSTOMERS. THIS TRUCK IS DANGEROUS ON THE INTERSTATE. *TR

OUR FORD F250 4X4 DIESEL TRUCK HAS A STEERING PROBLEM. IT'S LOCKING UP WHEN TURNING LEFT TO RIGHT. WE HAD 2 OCCASIONS WHERE WE JUST MISSED BEING IN AN ACCIDENT. WHEN THE STEERING LOCKS YOU CAN NOT DO ANYTHING. THE VEHICLE CONTINUES IN THE DIRECTION JUST PRIOR TO THE LOCK. THE WHEEL NEEDS TO BE TURNED BACK LEFT TO UNLOCK AND THIS IS NOT ALWAYS POSSIBLE. WE LIVE ON A CURVE ROAD AND IT'S VERY DANGEROUS. WE TOOK IT TO THE DEALER IN FOLSOM CA, THEY REPLACED THE STEERING STABILIZER, WHICH DID NOT SOLVE THE PROBLEM. THE VEHICLE WILL BE TOWED BACK THE 60 MILES TODAY AND WE WILL NOT ACCEPT THIS VEHICLE. *AK

I OWN A 2006 F250 4*4 AND WHILE DRIVING AT SPEEDS IN EXCESS OF 60 MPH THE TRUCK SHAKES VIOLENTLY AND EVEN SWAYS FROM LANE TO LANE, WHEN ENCOUNTERING ANY ROUGH PLACE IN THE ROADWAY. THIS IS A VERY VIOLENT SHAKING AND I HAVE BEEN FORTUNATE ENOUGH TO KEEP THE TRUCK FROM WRECKING. THE SHAKING WILL NOT STOP UNTIL YOU HAVE SLOWN DOWN DRAMATICALLY OR COME TO A STOP. FORD HAS COMMENTED THAT IT COULD BE THE AIR PRESSURE AND HAVE ORDERED A STEERING DAMPER TO TRY TO CORRECT THE PROBLEM. THIS TRUCK HAS DONE THIS SINCE DAY ONE AND WITH THE FACTORY TIRES AND THE NEW TIRES THAT I HAVE ON IT NOW. THIS PROBLEM NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED IN AN ACCIDENT RESULTING FROM THE DEFECT IN DESIGN.

TL*THE CONTACT OWNS A 2006 FORD F-250. WHEN HE ATTEMPTED TO USE THE AUTOMATIC LOCK FOR THE VEHICLE, THE DRIVER SIDE DOOR LOCK REMAINED IN THE UP (OPEN) POSITION. THE CONTACT NOTICED THAT THE CYLINDER INSIDE THE DOOR WAS DISLOCATED. THE DEALER STATED THAT IT APPEARED AS IF SOMEONE TRIED TO BREAK INTO THE VEHICLE. NO ONE HAS ATTEMPTED TO OR HAS BROKEN INTO THE VEHICLE AT HIS HOME OR OFFICE. THE COST TO REPAIR THE VEHICLE WAS $500. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CURRENT MILEAGE WAS 13348 AND THE FAILURE MILEAGE WAS 13148.

TL*THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. WHILE DRIVING 70 MPH, THE STEERING WHEEL SHOOK AND MADE A RATTLING NOISE. THE CONTACT HAD DIFFICULTY CONTROLLING THE STEERING WHEEL. IN ORDER TO STOP THE SHAKING, THE VEHICLE HAD TO BE SLOWED DOWN TO A MINIMUM SPEED OF 50 MPH. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE HAS OCCURRED FOUR TIMES. THE DEALER STATED THAT THE AIR PRESSURE IN THE TIRES CAUSED THE SHAKING. THE CONTACT RECEIVED A LETTER, WHICH STATED THAT HIS MAKE AND MODEL VEHICLE WAS EXPERIENCING ISSUES WITH THE STEERING. THE VEHICLE WILL NOT BE REPAIRED BECAUSE IT IS NOT UNDER WARRANTY. FORD IS AWARE OF THE FAILURE, BUT REFUSES TO ISSUE A RECALL. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 64,000. UPDATED 06/08/09 *BF THE CONSUMER WAS TOLD THE STEERING DAMPENER WAS TOO SMALL FOR THE VEHICLE. UPDATED 06/18/09

2006 F250 WITH 36,000 MILES. FRONT END SHAKES VIOLENTLY AFTER HITTING BUMPS IN ROAD. APPEARS TO BE MORE PRONOUNCED WHEN ENCOUNTERING A SERIES OF BUMPS AND GOING DOWN HILL. THERE IS A LOSS OF EFFECTIVE BRAKING WHEN FRONT END IS SHAKING . CAN NOT UNDERSTAND WHY NO RECALL WHEN THERE ARE SO MANY SIMILAR POSTINGS SUBMITTED. ALSO FRONT DRIVE UNIVERSALS ARE BEING REPLACED AT 45,000 MILES AND VACUUM LINE FOR 4 WHEEL ACTIVATION HAS BURNED OFF THREE TIMES, REPAIRED TWICE MY DEALER AT CUSTOMERS COST. *TR

THE TRUCK SHOWED NO SIGNS OF TROUBLE LEADING UP TO THE EVENT. WHILE DRIVING APPROXIMATELY 50-55 MILES AN HOUR AND HEADING AROUND A RIGHT HAND CORNER IN THE ROAD THE TRUCK HIT AN INDENTATION IN THE ROAD SURFACE WHICH CAUSED THE TRUCK TO SHAKE UNCONTROLLABLY AND DRIFT INTO THE ONCOMING LANE CAUSING THE TRUCKS MIRROR TO HIT A BOX TRUCK AND SMASH INTO THE INTERIOR OF MY TRUCK. WHEN THE TRUCK SLOWED DOWN TO BELOW 35, I REGAINED CONTROL OF THE VEHICLE AND PULLED OFF TO THE RIGHT SHOULDER. THE BOX TRUCK, APPARENTLY NOT REALIZING WHAT HAD HAPPENED, CONTINUED ON WITHOUT STOPPING. THE MIRROR WAS DESTROYED, GLASS WAS COVERING THE INTERIOR OF MY TRUCK, AND I SUFFERED MINOR CUTS ON MY FACE AND ARM. I RETURNED HOME WITH MY TRUCK AT SPEEDS UNDER 40 MPH, BUT STILL COULD FEEL A SHUDDER WHEN THE TRUCK HIT EITHER A RAISED BUMP OR AN INDENTATION IN THE ROAD. THE DEALER REPLACED SEVERAL PARTS IN THE FRONT END OF THE TRUCK, BUT NOT THE MIRROR. I WAS TOLD THAT THE MIRROR WOULD NOT BE COVERED UNDER WARRANTY. THE TRUCK HAS NOT HAD THE PROBLEM SINCE. I AM NOT AWARE IF THE OLD PARTS ARE STILL AVAILABLE. *TR

NO PSI FOR TURBO, AND TURBO BLEW OUT. *AK

TL*THE CONTACT OWNS A 2006 FORD F-250 SD. WHILE DRIVING 55-70 MPH, THE STEERING WHEEL VIBRATED AND THE VEHICLE MOVED FROM LEFT TO RIGHT. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE CONTACT TOOK THE VEHICLE TO THE DEALER ON TWO OCCASIONS AND THEY STATED THAT THE STEERING DAMPER CAUSED THE FAILURE. THE DEALER MADE THE REPLACEMENT. AS OF NOVEMBER 26, 2007, THERE HAD BEEN NO FURTHER OCCURRENCES. THE FAILURE MILEAGE WAS 8,000 AND CURRENT MILEAGE WAS 12,120.

FORD 2006 F250 SD DIESEL, HAS HAD VIOLENT SHAKING OF THE STEERING, HAPPENS ATLEAST TWICE PER TRIP, STARTED AROUND 15000 MILES ON TRUCK, HAVE 44000 MILES NOW, SEEMS TO BE GETTING WORSE, THIS STARTED LITTLE OVER A YEAR AFTER I PURCHASED IT BRAND NEW TIL CURRENT, 9/18/10, WAS TOLD BY THE DEALER THAT IT WAS A TIRE PRESSURE ISSUE, IT IS NOT THAT, IT DID NOTHING FOR THE PROBLEM, THIS VEHICLE IS TRULY UNSAFE TO CARRY ME AND MY FAMILY IN. VERY SCARY. *TR

TL*THE CONTACT OWNS A 2006 FORD F-250 SUPER DUTY. WHILE DRIVING 60 MPH ON A BUMPY ROAD, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE CONTACT LOST CONTROL OF THE STEERING AND BRAKING. THE DEALER STATED THAT THE TIRE PRESSURE WAS INCORRECT AND INFLATED THE TIRES. THE FOLLOWING DAY, THE FAILURE RECURRED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT MILEAGE IS 14,500 AND FAILURE MILEAGE WAS 12,000.

FRONT END BOUNCING OUT OF CONTROL, AFTER HITTING A SLIGHT BUMP, OR POTHOLE AT A SPEED OF SIXTY OR MORE. *TR

EVERY 3000 TO 4000 MILES THE FRONT SUSPENSION WILL BEGIN TO RATTLE AND WOBBLE. LOCAL DEALER HAS INSTALLED AND REPLACED STEERING DAMPENER SHOCK ON 3 OCCASIONS. SERVICE MANAGER STATED, MORE THAN ONCE, THAT FORD WILL ONLY LET THEM DO SO MUCH. *TR

SPEEDOMETER WOULD NO LONGER GO BELOW 26 MPH, EVEN WITH VEHICLE STOPPED AND IGNITION TURNED OFF. DRIVING VEHICLE WOULD INDICATE A SPEED CONSTANTLY 26 MPH FASTER THAN ACTUAL SPEED. BROUGHT TO DEALER WHERE DEALER ORDERED AND LATER REPLACED ENTIRE INSTRUMENT PANEL. SECOND PROBLEM INVOLVED PASSENGER SIDE WIPER ARM FELL OFF WHILE IN OPERATION DRIVING DURING RAIN. DEALER REPLACED WIPER ARM. *JB

TOOK TO DEALERSHIP AT APPROXIAMTELY 10,000 MILES AND THEY PERFORMED TSB'S (TECHNICAL SERVICE BULLETINS). HAVE TAKEN VEHICLE TO 2 DIFFERENT DEALERSHIP DEALERS NOW GOING ON THE 8TH TIME FOR SAME ISSUE. THE TRUCK EXPERIENCES A DANGEROUS "HYPER-SHAKE" AT APPROXIMATELY 50-70 MPH. THE TRUCK SHAKES VIOLENTLY SIDE TO SIDE, AND UP AND DOWN AND DRIFTS OUT OF LANE AND TO CORRECT IT MUST APPLY THE BRAKES. STEERING OF THE VEHICLE IS SIGNIFICANTLY IMPEDED , AND SHAKING CONTINUES UNTIL TRUCK SPEED IS DECREASED TO APPROX. 30 MPH. I HAVE DONE ALL SUGGESTIONS GIVEN TO ME BY THE DEALERSHIPS. REBALANCE TIRES, CHECKED ALIGNMENT AND TIRE PRESSURE. I AM CURRENTLY TAKING THIS VEHICLE TO FORD DEALERSHIP MARCH 23, 2007 FOR THEM TO TRY AND FIX THE HYPER-SHAKE. THIS IS VERY DANGEROUS ISSUE AND IT NEEDS TO BE CORRECTED. THIS VEHICLE IS NOT HIGHWAY SAFE.

VIOLENT SHAKING WHEN HITTING A ROUGH PLACE IN HIGHWAY. SHAKING IS SO BAD THAT YOU HAVE NO CONTROL OF STEERING UNTIL A PANIC BRAKING BRINGS VEHICLE TO UNDER 30 MPH. *JB

MY 2006 F-250 SHAKES VIOLENTLY WHEN HITTING A POT HOLE THIS OCCURS ABOUT ONCE EVERY COUPLE OF WEEKS. I HAVE TO COME TO A COMPLETE STOP FOR THE VEHICLE TO QUIT SHAKING I HAVE ALMOST BEEN REARENDED SEVERAL TIMES AND I HAVE BEEN IN THE LANE ON ONCOMING TRAFFIC WITH MY 2-MONTH OLD IN THE VEHICLE BECAUSE I CAN NOT CONTROL THE VEHICLE WHEN THIS OCCURS. I HAVE HAD SEVERAL CLOSE CALLS AND HAVE BEEN EXTREMELY LUCKY THE CIRCUMSTANCES HAVEN'T BEEN DIFFERENT OTHERWISE THE SITUATION COULD OF BEEN FATAL FOR MY 2-MONTH OLD, MY HUSBAND AND MY SELF. *TR

THE RIGHT REAR BRAKE DRAGS OCCASIONALLY....AND MANY OTHER FORD TRUCK OWNERS ARE HAVING THE SAME PROBLEM.... *TR

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2006 FORD F250 WITH N8700 FAILURE MILES AT 30 MPH ON A MODERATELY SNOWY DAY BOTH WINDSHIELD WIPERS FELL OFF WITHOUT ANY WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE WINDSHIELD WIPERS WERE REPLACED, BUT THE CONTACT WAS CONCERNED THAT THE PROBLEM MIGHT REPEAT ITSELF. THE CURRENT MILEAGE WAS 9000.*AK UPDATED 04/05/07. *JB

I HAVE THREE 2006 FORD F-250 SUPER DUTY'S THAT EXPERIENCE THE SAME PROBLEM. THESE TRUCKS EXPERIENCE A DANGEROUS "HYPER-SHAKE" AT APPROX. 50-65 MPH. TRUCK SHAKES VIOLENTLY SIDE TO SIDE AND UP AND DOWN, STEERING IS GREATLY IMPEDED, AND SHAKING CONTINUES UNTIL TRUCK SPEED IS DOWN TO 40-45 MPH. I HAVE RE-BALANCED TIRES, CHECKED ALIGNMENT, REPLACED STEERING DAMPENERS BUT PROBLEM PERSISTS. *JB

2006 FORD F250 PICKUP. ON 1/14/07, I NOTICED THAT THE RUBBER SEAL AROUND THE WINDSHIELD WAS BEGINNING TO LIFT FROM THE VEHICLE BODY (NEAR THE TOP OF THE WINDSHIELD). I TOOK THE VEHICLE TO MY DEALER WHO HAD A WINDSHIELD PROFESSIONAL INSPECT THE RUBBER. ON 1/23/07, I WAS NOTIFIED BY MY DEALER THAT THE WINDSHIELD PROFESSIONAL GLUED DOWN THE LIFTED PORTION AND THAT IF THERE WERE ANY ADDITIONAL PROBLEMS, IT WOULD NOT BE COVERED BY THE MANUFACTURER'S WARRANTY. NOTHING HAS BEEN ALTERED ON THE VEHICLE TO CAUSE THIS. IT IS A MANUFACTURER DEFECT AND FORD IS CLAIMING THAT IT WAS DAMAGED DURING USAGE. THROUGH FURTHER RESEARCH, I LEARNED THAT FORD CROWN VICTORIA'S HAVE A SIMILAR PROBLEM THAT RESULTED IN A SERVICE BULLETIN. I AM DEMANDING THAT THE ENTIRE WINDSHIELD ASSEMBLY (AND SEAL) BE REPLACED UNDER WARRANTY. *JB

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING 55 MPH OVER A ROAD BUMP, THE FRONT END BEGAN SHAKING UNCONTROLLABLY. THE CONTACT HAD TO USE EFFORT TO REGAIN CONTROL OF THE VEHICLE AND APPLIED THE BRAKES UNTIL THE VEHICLE WAS AT A STOP. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT LATER RECEIVED A FIELD ACTION NOTIFICATION FROM THE MANUFACTURER (LETTER NUMBER: 09L02 ) PERTAINING TO A POSSIBLE 'DEATH WOBBLE' . THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 32,000.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPEWED FROM THE FILLER NECK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CHECK VALVE WAS STICKING AND AS RESULT, THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 56,935 AND THE CURRENT MILEAGE WAS 58,827.

SINCE IT WAS BRAND NEW, MY 2006 FORD F250 BOUNCES SO SEVERELY ON THE HIGHWAY AT SPEEDS OVER 55 MPH WHEN HITTING EXPANSION JOINTS, IT HAS CAUSED LOSS OF CONTROL. THIS ONLY HAPPENS ON CERTAIN SECTIONS OF HIGHWAY. NO INJURIES HAVE OCCURED YET AS I HAVE LEARNED WHICH PARTS OF THE HIGHWAY TO SLOW DOWN ON. BUT, THE VEHICLE IS NOT SAFE TO DRIVE ON STRANGE HIGHWAYS.

I HAVE A 2006 FORD F250 2 WHEEL DRIVE TRUCK WITH 41,500 MILES ON IT. WHILE ON A TRIP, THE LEFT FRONT WHEEL BEARINGS SEIZED UP REQUIRING IT TO BE TOWED TO A REPAIR FACILITY. THE INNER RACE OF THE BEARING WAS GALLED (WELDED) ONTO THE SPINDLE REQUIRING NOT ONLY REPLACEMENT OF THE BEARINGS BUT REPLACEMENT OF THE SPINDLE. THE RIGHT FRONT WHEEL BEARINGS WERE ALSO CHECKED FOR DAMAGE AND FOUND TO BE ALSO DEFECTIVE AND WERE REPLACED. NORMALLY, FRONT BEARINGS LAST IN EXCESS OF 100,000 MILES WITHOUT SERVICE. IF I WERE TO KEEP DRIVING ON THE SEIZED BEARING, I COULD HAVE LOST CONTROL OF THE VEHICLE AND POSSIBLY KILLED SOMEONE. FORD HAS ISSUED A SERVICE BULLETIN #06129 AND NHTSA #10020174 WHICH COVERS "NOISY" FRONT WHEEL BEARINGS. THE FIX IS TO REPLACE THE BEARINGS AND INSTALL MOISTURE AND DUST SHIELDS WHICH DO NOT COME WITH A NEW VEHICLE AT THE CUSTOMER EXPENSE. THE REASON WHY THE BEARINGS FAILED IS BECAUSE WATER INTRUDES INTO THE BEARING AREA AND WASHES AWAY OR DILUTES THE GREASE. I BELIEVE THAT THIS SHOULD BE A SAFETY RECALL SINCE FAILURE COULD RESULT IN INJURY OR DEATH. FORD SHOULD PAY FOR ANY REPAIRS WHETHER FORD DID THEM OR NOT. THEY ARE REFUSING TO PAY FOR MY REPAIR SINCE IT WAS NOT DONE AT A FORD DEALERSHIP. *TR

I WAS DRIVING ON THE FREEWAY AT AROUND 65 MPH, AND I HIT A POTHOLE. AFTER HITTING THE POTHOLE (RATHER SMALL), THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIOLENTLY OUT OF CONTROL AND DID NOT STOP UNTIL I WAS ABLE TO PULL OVER TO THE SIDE OF THE FREEWAY AND STOP THE VEHICLE. THIS HAS HAPPENED A TOTAL OF 3 TIMES SO FAR. IT HAS OCCURRED AT 11,000; 14,000; AND 17,000 MILES. CHECKED TIRE PRESSURE AND BALANCE PERSONALLY AND EVERYTHING WAS FINE. CALLED TO ASK DEALERSHIP ABOUT PROBLEM, THEY SAID TO MAKE AN APPOINTMENT TO BRING IT IN, HAVE NOT DONE SO YET. *NM

MY 06 FORD F -250 EXPERIENCES WHAT SEEMS TO BE NORMAL WHEEL-HOP ON THE HIGHWAY (BETWEEN 50-65 MPH) BUT THE HOP INSTANTLY TURNS INTO A "HYPER-SHAKE" CAUSING COMPLETE LOSS OF CONTROL WITH THE TRUCK BOUNCING OUT OF THE LANE TO WHEREVER IT WISHES TO GO UNTIL THE REAR BRAKES MANAGE TO SLOW IT DOWN ENOUGH TO REGAIN CONTROL. THANK GOD IT HAS NOT KILLED ANYONE YET (INCLUDING ME).IT COULD HAVE VERY EASILY WENT HEAD-ON IF THAT IS WHERE THE ROAD WAS HEADED. *JB

TL*THE CONTACT OWNS A 2006 FORD F250 SUPERCREW. THE CONTACT STATED THAT THE 4X4 HIGH DID NOT ENGAGE, THE ENTIRE FRONT END VIBRATED VIOLENTLY, AND THE 4X4 LOW WAS DIFFICULT TO DISENGAGE. THE VEHICLE WAS TAKEN TO A DEALER FIVE TIMES, AND THE FAILURE HAD NOT BEEN DIAGNOSED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEAGE IS 4,200 AND FAILURE MILEAGE WAS 1,000.*AK

PURCHASED VEHICLE 5 WEEKS AGO. HAVE 5K MILES ON IT. SPEEDOMETER STARTED STICKING AT 30 MPH AND CONTINUED TO VARY. PARKED WITH POWER OFF IT STILL READS 20 MPH. I AM AT WORK OUT OF TOWN (5 1/2 HOURS FROM HOME) HAVE NOT TAKEN TO DEALERSHIP YET. *JB

TRUCK VIOLENTLY SHAKES AFTER HITTING A BUMP OR DIP IN THE ROAD AND DOESN'T STOP UNTIL I SLOW DOWN TO ALMOST A COMPLETE STOP. RECEIVED A LETTER FROM FORD ABOUT THIS PROBLEM BUT THE ONLY SOLUTION THEY OFFER IS TO CHECK TIRE PRESSURE WHICH I DID AND OF COURSE DID NOTHING.

FRONT END BOUNCES DANGEROUSLY WHEN DRIVING OVER UNEVEN ROAD OR POTHOLES. FIRST PROBLEM OCCURRED AT 1100 MILES ON 9-15-06 AND SERVICE DEPT COULD FIND ANYTHING WRONG. HAPPENED AGAIN ON THE SAME MONTH STILL COULD NOT FIND ANYTHING. ON 10-23-06 TOOK HEAD MECHANIC FROM SERVICE DEPT WITH ME ON A TEST DRIVE AND THE PROBLEM HAPPENED 3 TIMES MECHANIC COULD NOT PIN POINT PROBLEM. ON 12-11-06 THEY LOOSENED AND RETORQUED ALL FASTENERS STILL NOT FIXED. THEY HAVE REPLACED DAMPENER AND STEERING SHOCK STILL NO FIX IT. TRUCK BOUNCES DANGEROUSLY AND GOES RIGHT OR LEFT COULD CAUSE MAJOR ACCIDENT. JUST PICKED UP TRUCK AGAIN FROM DEALERSHIP THEY RETORQUED EVERYTHING AGAIN STILL NOT FIXED. *JB

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND GOING OVER A BUMP ON THE ROAD, THE FRONT OF THE VEHICLE WOBBLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A STABILIZATION BAR WAS INSTALLED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000.

FORD 250 BOUNCES DANGEROUSLY WHEN HITTING POTHOLES. *JB

I HAVE OVER 118 PAGES OF REPAIRS DEALING FROM ELECTRICAL, SUSPENSION, ENGINE FAILURE, TURBO, FLUID LEAKAGE, OIL COOLER FAILURE. EJECTORS, GLOW PLUGS AND COUNTING. THEY CONTINUE TO REOCCUR TIME AFTER TIME AND DEALER WILL NOT COVER. I MET ALOT OF CONSUMERS THAT HAS THE SAME VEHICLE AND THEY ALL ARE HAVING THE SAME PROBLEM. I KNOW THAT FORD HAS SUED THE DESIGNER OF THE 6.0 ENGINE AND WON BILLIONS BUT WILL NOT ATTEMPT TO ASSIST THE CONSUMER. THE RIGHT THING TO DO IS, IF YOU KNOW THAT IF THERE'S A PROBLEM WITH A PROBLEM WHY NOT ASSIST THE CONSUMER IN CORRECTING INSTEAD OF DOING A PATCH JOB. THEY WILL NOT ATTEMPT TO DO THE RIGHT THING UNLESS SOMEONE FORCE THEM TO DO SO. THANKS *TR

I HAVE A PROBLEM WITH MY 2006 FORD F-250. MY FRONT END WANTS TO VEER OFF THE ROAD WHEN I HIT POT HOLES IN THE ROAD. I HAVE TRAVELED THE SAME ROADS WITH MY WORK TRUCK, 2006 F-150 AND HAVE LITTLE OR NO PROBLEMS COMPARED TO THE F250. I HAVE TAKEN MY TRUCK TO THE DEALER I PURCHASED THE TRUCK FROM AND HAVE NO SUCCESS GETTING THE PROBLEM RESOLVED.*TR