2000 Ford F-350 Complaint Log

On [XXX], I rented a Class C motorhome from Cruise America at their Duluth, Georgia branch (Reservation #[XXX]). When I picked up the vehicle, the Cruise America employee pointed to a handwritten note taped over the tire pressure warning light on the dashboard that said: “ignore tire sensor.” The note was already in place before I arrived, suggesting that other renters may have used the vehicle in that same unsafe condition. Three days later, while traveling northbound on [XXX] near Memphis, Tennessee, the RV suffered a sudden tire blowout at highway speed. We narrowly avoided a collision while maneuvering to the shoulder. Thankfully, no one was injured, but the incident was extremely dangerous and could easily have resulted in fatalities. Cruise America knowingly rented out a vehicle with an active tire pressure warning covered and concealed, depriving the driver of critical safety information. The company did not repair or document the issue, instead instructing renters to “ignore” the tire warning. This conduct may violate Federal Motor Vehicle Safety Standard No. 138 (49 C.F.R. § 571.138) and 49 U.S.C. § 30122, which prohibit making safety equipment inoperative or misleading drivers about safety system status. While TPMS sensors can fail naturally, covering the warning light constitutes deliberate concealment and undermines the system’s purpose. I am concerned that Cruise America may be circulating other rental vehicles in similar unsafe condition. Please investigate whether Cruise America, Inc. is in compliance with federal vehicle-safety laws governing TPMS functionality and rental-vehicle maintenance standards. Specifically, whether any branch locations are renting vehicles with disabled, covered, or ignored tire-pressure monitoring systems or other concealed safety warnings. Reported to Cruise America Customer Relations (Case #[XXX]). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The first and only notification received was the April 5, 2025 email. The 2000 F350 did experience issues of stalling on the road many times. After several thousand dollars of repairs, the camshaft position sensor was replaced by a commercial diesel mechanic. No warnings of any kind were displayed. The truck stalled on the freeway ramp and other streets. These issues occurred since 2000 when the truck was purchased. The lack of notification and choice of fix caused danger and a lot of repair costs. This is unacceptable.

On 7/2/24, I went to Robinson Brothers Ford in Baton Rouge, LA to address an unrepaired Recall item on a 1994 F350. The service advisor refused to perform the recall work. They stated that the vehicle was too old. This recall is concerning an issue with a switch that can leak break fluid and cause an engine fire.

I scan the truck misfire keep popping up I change four coil packs and all new sparkplugs and the same thing 4cyl misfire again and its paper sucking up thru tail pipe

I had purchesed a set of Dick Cepek Extreme Country LT315/75/R16. The tires have 9/32nd left with approximately 15,000 miles. While driving on the highway the sidewall of the tire peeled off in one strip causing the tire to no longer hold its shape and blow out. Had it been a steer tire the incident could have been much worse. Twenty minutes prior to the failure all tires were inspected and confirmed to be inflated to the proper psi and without damage.

The death wobble. Hitting a bump - no matter the size and without warning - may cause your entire vehicle to wobble/shake uncontrollably and loose ability to steer. You’re only recourse is to let off of the accelerator and TRY to hold the truck in the lane and pray you don’t have to brake or make a turn. It has happened multiple times but the worse was while traveling I-10 in San Antonio, Texas while pulling a horse and trailer.

The fuel tank sender on this vehicle is defective. Every single person I know, including over 100 people in a small facebook Ford group have broken fuel tank senders. Ford never recalled it and sell a new one for $600.

WHILE DRIVING ON THE N.Y THRUWAY. MY MICHELIN MLX TIRES TREAD SEPARATED FOR THE TIRE CAUSING A BLOW OUT AND TEARING OFF THE REAR PASSENGER DUALLY FENDER OF MY F350 . PIECES OF THE FEND AND TIRE FLEW ALL OVER THE N.Y THRUWAY

STOPPED AND PUT IN PARK,SLIPPED OUT OF PARK AND ROLLED. HAS HAPPENED 3 TIMES. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT WHILE INSPECTING THE FRONT WHEELS ON THE VEHICLE, THE CONTACT BECAME AWARE OF A FRACTURE ON ONE OF THE WHEELS. THE CONTACT STATED THAT THE FRACTURE WAS LOCATED ON THE INNER LIP OF THE WHEEL. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. VARSITY FORD (3480 JACKSON AVE ANN ARBOR MI) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 171,700.

THERE IS A SERIOUS ISSUE WITH THE STEERING THAT MY MECHANIC SAYS IS CALLED THE DEATH WOBBLE'. I WAS DRIVING DOWN THE ROAD AND THE STEERING BEGAN TO WOBBLE UNCONTROLLABLY. MY FRONT TIRES ARE NEW, STEERING COMPONENT ALL TIGHT AND INFLATION IS ACCURATE. I PULLED TO THE AIDE OF THE ROAD AND ALMOST CRASHED. THE 'WOBBLE' OCCURS SPORADICALLY AND IS NOT PREDICABLE. IT HAS OCCURRED 6-7 TIMES IN THE TWO YEARS I HAVE OWNED THE TRUCK. I AM EXTREMELY CONCERED AS IT IS MY ONLY TRANSPORTATION. MY MECHANIC IS SAYING IT IS A MANUFACTURER DEFECT AND FORD NEEDS TO ADDRESS.

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH FIRESTONE TIRES, TIRE LINE: TRANS FORCE AT, TIRE SIZE: LT 265/75R16, AND DOT NUMBER: 8XW8TR7. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEENING SERVICE FOR AN OIL CHANGE, THE TECHNICIAN NOTICED THE TREAD WAS SEPARATED FROM THE REAR DRIVER SIDE TIRE. THE TIRE WAS NOT REPLACED AND WAS NOT TAKEN TO A DEALER. THE CONTACT CALLED FIRESTONE COMPLETE AUTO CARE, (1439 S WASHINGTON ST, GRAND FORKS, ND 58201, (701) 203-558) AND WAS INFORMED THAT THERE WAS NO WARRANTY ON THE TIRES. THE CONTACT STATED THAT THERE WAS A DEFECT IN THE TIRE THAT COULD LEAD TO A BLOWOUT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE OF THE VEHICLE WAS 271,374 AND TIRE WAS 42,200.

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH SIX BF GOODRICH COMMERCIAL T/A ALL SEASON TIRES, SIZE: LT235/85/R16 /LRE MPLUS (NA). AFTER APPROXIMATELY 150 MILES OF USE, A BUBBLE WAS PRESENT ON THE SIDEWALL OF THE OUTER REAR DRIVER'S SIDE TIRE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE TIRE FAILURE MILEAGE WAS 150. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN.

The contact owns a 2000 Ford F-350 equipped with Guangzhou 9007 bulbs. The contact stated that upon installing the bulbs, he noticed that the low-beam and the high-beam bulbs provided similar illumination. The contact then received an email from Amazon notifying him of NHTSA Campaign Number: 21E004000 (Exterior Lighting). The contact was instructed to fill out a form on the manufacturer's website to receive replacement bulbs; however, the contact had yet to receive the replacement bulbs. The contact also made multiple attempts to reach the manufacturer by phone, but all the attempts were unsuccessful. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The bulbs were not replaced. The failure mileage was approximately 140,000. The VIN was not available.

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT THE INDEPENDENT FACILITY AND THE SELLER OF THE VEHICLE MADE NO MENTION OF A FAILURE WITH THE FRONT BRAKES AND THE REAR BRAKES, WHICH WERE WARPED BEFORE THE VEHICLE WAS SOLD. IN ADDITION, THE ENGINE COOLING FAN HAD HOLES. THE VEHICLE WAS NOT INSPECTED NOR DIAGNOSED BY A DEALER. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE ENGINE COOLING FAN, AND FRONT AND REAR BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH BF GOODRICH ALL TERRAIN T/A TIRES, SIZE: LT285/75R16. WHILE DRIVING 70 MPH, THERE WAS A VIBRATION IN THE TIRES AND A LOUD NOISE WAS HEARD AS IF SOMETHING HIT THE VEHICLE. THE CONTACT STATED THAT THERE WAS ALSO A LOUD POPPING SOUND. THE CONTACT WAS ABLE TO EXIT THE FREEWAY AND, UPON EXITING, NOTICED THE TIRE TREAD ON THE ROADWAY ALONG WITH DAMAGE TO THE FRONT DRIVER SIDE FENDER AND RUNNING BOARD. THE CONTACT CALLED AAA TO CHANGE THE TIRE. THE VEHICLE WAS THEN DRIVEN TO AN INDEPENDENT TIRE SHOP. THE CAUSE OF THE FAILURE WAS NOT DETERMINED, BUT ALL FOUR TIRES WERE REPLACED. THE VEHICLE AND TIRES WERE NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 123-53467. THE VEHICLE FAILURE MILEAGE WAS 218,589 AND THE APPROXIMATE TIRE FAILURE MILEAGE WAS 213,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH ALCOA WHEELS, 16X6K FRONT (NA). THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WHEEL LOST AIR DUE TO A SPLITTING WHEEL. THE VEHICLE WAS TAKEN TO A LOCAL TIRE SHOP, BUT THEY WERE UNABLE TO REPAIR THE TIRE DUE TO THE RIM FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE CONTACT RESEARCHED ONLINE AND FOUND THAT THE ALCOA COMPANY VOLUNTARILY RECALLED THE WHEELS. THE VIN AND TIRE AND VEHICLE FAILURE MILEAGE WERE UNKNOWN.

MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

MESA A/P2 TIRES, CRACKING AROUND BEAD WITH ONLY 3889 MILES ON SUPPOSEDLY NOT BIG O BRAND MESA NOT FOUND IN MENU

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT LOCATED UNDER THE FUEL FILTER, THE O-RING AND THE DRAIN LINE FAILED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRAIN LINE AND INDICATED THAT THERE WAS TOO MUCH PRESSURE FLOWING INTO THE FUEL FILTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/10/16*LJ UPDATED 11/3/2017*JS

FORD F-350. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE INFLATION PRESSURE PROBLEMS. *SMD THE CONSUMER STATED THE TIRE WAS INFLATED TO 55 PSI TO SOFTEN THE RIDE. LATER, WHILE HAULING TRACTOR THE TREAD ON ONE OF THE TIRES PEELED OFF. THE CONSUMER PUT THE SPARE ON THE TRUCK. THE CONSUMER WAS ADVISED TO RUN THE TIRES AT THE MAXIMUM INFLATION PRESSURE FOR THE BEST WEAR, MAXIMUM LOAD CAPACITY, BEST MILEAGE AND LONGEST LIFE. EACH OF THE TIRES EVENTUALLY FAILED ONE AT A TIME. WHEN THE CONSUMER PURCHASED NEW TIRES, THEY WERE INFLATED 60 PSI FOR THE FRONT AND 50 PSI FOR THE REAR, INSTEAD OF 80 PSI. EVERYTHING WAS FINE FOR A WHILE, UNTIL THE CONSUMER STARTED TO EXPERIENCE ROUGH RIDING AND NOISY TIRES AS A RESULT OF IMPROPER INFLATION. THE RETAILER STATED THE INFLATED THE TIRES ACCORDING TO WHAT WAS PRINTED ON THE DOOR STICKER. THE UNDER INFLATION CAUSED EXCESSIVE SIDEWALL FLEX, REDUCED MILEAGE, SHORTENED LIFE AND SEVERAL TIRE FAILURES. *JB *CN

AS WE WERE RETURNING HOME FROM A ROAD TRIP, WE HEARD A SCREECHING NOISE COMING FROM THE LEFT WHEEL WELL AREA WHEN WE MADE WIDE SWEEPING TURNS AND HIGHWAY CURVES. WE PULLED OVER AND, UPON INSPECTION, SAW OUR ORIGINAL ALLOY WHEEL ON OUR TRUCK WAS CRACKED. ONE OF THE WHEELS WAS DANGEROUSLY CLOSE TO COMING OFF THE HUB. PHOTOS DOCUMENT HOW SEVERE THE CRACKING OF THE WHEELS WAS - THREE OF FOUR WHEELS WERE FOUND TO HAVE CRACKS AND CHUCKS OF METAL MISSING,COMPROMISING THE INTEGRITY OF THE WHEELS AND THE SAFETY OF OUR VEHICLE. WE HAD TO PURCHASE NEW WHEELS AT A COST OF ALMOST $1,300.

TL* THE CONTACT OWNS A 2000 FORD F350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING ASSIST AND THE BRAKES FAILED WITHOUT WARNING. ON ANOTHER OCCASION, THE VEHICLE BECAME RESISTANT TO ACCELERATING ATTEMPTS AS THE CONTACT EXITED A DRIVEWAY AND THEN STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE MECHANIC STATED THAT THE INJECTORS WERE DEFECTIVE AND THE INJECTOR DEVICE MODULE (IDM) HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGE WAS 130,000. THE VIN WAS NOT PROVIDED.

TL* THE CONTACT OWNS A 2000 FORD F-350. WHILE DRIVING 15 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. UPDATED 10/30/14*CN

DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

THIS ISSUE WAS ON A 2000 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO TABS GARAGE IN KING NC AND $1700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 3 INJECTORS DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE WIRES THAT WERE CONNECTED TO THE MASTER CYLINDER AND ONTO THE ELECTRICAL CONNECTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 160,000.

I WAS TRAVELING DOWN THE HIGHWAY AT 60 MILES PER HOUR WHEN I HEARD A LARGE BANG. I STOPPED AND DIDN'T SEE ANYTHING UNTIL I STOPPED FOR GAS. GAS WAS LEAKING OUT THE FILL HOSE AND I LOOKED UNDER THE TRUCK AND THE GAS TANK STRAP HAD BROKE AND THE TANK WAS VERILY HANGING ON. I PURCHASED TWO STRAPS TO HOLD THE TANK IN PLACE UNTIL I COULD GET TO A FORD DEALERSHIP. THIS IS THE SAME PROBLEM THAT FORD RECALLED THE 150 AND 250 MODELS FOR. LUCKILY FOR ME THE TANK DID NOT RUPTURE AND CATCH FIRE. THE 350 NEEDS TO BE RECALLED TO FIX THIS PROBLEM BEFORE SOMEONE IS KILLED. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, HE HEARD A POPPING NOISE COMING FROM THE FRONT END OF THE VEHICLE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE FRONT DRIVER'S AND PASSENGER'S SIDE ALLOY WHEELS WERE FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TR

THIS ISSUE WAS ON A 2000 FORD F350 RESCUE TRUCK ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO GARAGE IN KING NC AND $900.00 LATER AFTER NEW FUEL TANK FUEL FILTER AND FUEL PUMP TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH AND MAKING A RIGHT HAND TURN, HE LOST CONTROL OF THE VEHICLE CAUSING HIM TO CRASH INTO SOMEONE'S MAILBOX. THE CONTACT STATED THAT THE POWER STEERING BECAME EXTREMELY LOOSE AND THE BRAKES ALSO FAILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS LATER TOWED HOME. THE TOW TRUCK DRIVER INFORMED THE CONTACT THAT THE POWER STEERING HOSE LOOKS AS IF IT FRACTURED, WHICH MAY HAVE POSSIBLY CAUSED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 253,000.

MY 2000 F350 SD RIGHT REAR SINGLE WHEEL 4X4 ALUMINUM RIM CRACKED ON SEAM NOT AT BOLT HOLES CALLED FORD WAS TOLD THEY NEVER HEARD OF THIS PROBLEM THAT'S FUNNY CALLED JUNK YARD AND WAS TOLD THIS IS A COMMON PROBLEM I THINK FORD NEEDS TO RECALL THEM DUE TO COULD CASE DEATH IF DRIVING AT BREAKS APART TODAY I TOOK TIRE OFF RIM IT IS CRACKED WHOLE WAY THRU I STILL HAVE RIM TO SHOW OR SEND PICTURE THEY ARE FACTORY FORD RIMS. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT THE FRONT PASSENGER WHEEL WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 224,430 AND THE CURRENT MILEAGE 224,455.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT ATTEMPTED TO OPEN THE REAR DRIVER AND PASSENGER SIDE DOORS BUT NOTICED THAT THE TOP DOOR LATCH WOULD NOT RELEASE. THE BOTTOM LATCH RELEASED WITHOUT FAILURE. THE CONTACT WAS UNABLE TO OPEN THE REAR DOORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THAT THE DOOR ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT HE ATTEMPTED TO ACCELERATE, BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE HAD NOT BEEN DIAGNOSED BY THE DEALER AND NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 182,000.

TL* THE CONTACT OWNS A SET OF YOKOHANA LT TIRES, SIZE: 265 75R 16 (N/A). THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE FRONT PASSENGER SIDE TIRE EXPLODED, CAUSING DAMAGE TO THE HOOD AND FENDER. SEVERAL WEEKS LATER THE REAR PASSENGER SIDE IRE EXPLODED, ALSO CAUSING EXTENSIVE DAMAGE TO THE REAR OF THE VEHICLE. THE TIRES WERE ONLY 3 MONTHS OLD WHEN THE FAILURE OCCURRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND STATED THAT THEY WOULD SEND SOMEONE TO FURTHER INVESTIGATE THE TIRES. THE VEIHCLE FAILURE MILEAGE WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 10,000.THE VIN WAS NOT AVAILABLE.

THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE TO INSPECT THE NOISE AND NOTICED THAT THE FRONT FUEL TANK STRAP WAS CORRODED AND FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THAT AND CONTACTED THE MANUFACTURER BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 11/03/11*LJ UPDATED 12/02/11

I WAS INQUIRING ABOUT THE DELAMINATION OF FORDS FUEL TANKS ON THEIR F-SERIES DIESELS. I OWN A 2000 F350 7.3L DIESEL. LAST WEEK IT BEGAN TO RUN AS IF IT WASN'T GETTING FUEL SO I STOPPED INTO A LOCAL FORD DEALER AND THEIR DIAGNOSES WAS THE FUEL TANK ON MY F350 STARTED TO DELAMINATE AND CLOG THE ENTIRE FUEL SYSTEM. I HAVE OWNED THIS TRUCK SINCE IT WAS NEW AND HAVE DONE ALL THE MAINTENANCE AND UP-KEEP AS REQUIRED I HAVEN'T HAD ANY TROUBLE UNTIL AFTER THE FUEL COMPANIES STARTED TO CHANGE THE DIESEL FUEL. I HAVE OWNED THE TRUCK SINCE IT WAS NEW AND NEVER HAD A PROBLEM UNTIL JUST RECENTLY. THE FUEL TANK PROBLEM WAS DIAGNOSED LAST WEEK BY A FORD DEALER IN MY AREA AND IT WILL COST APPROXIMATELY $3600 TO REPAIR. MY QUESTION IS, "IS THERE GOING TO BE AN INVESTIGATION ON THIS?" I HAVE FOUND A BLOG FROM MANY OTHER CUSTOMERS THAT ARE HAVING THE SAME TROUBLE. SOMEONE ELSE SHOULD HAVE TO PAY FOR THIS NOT THE CONSUMER OR FORD, UNLESS THEY NEW THIS WOULD BE A PROBLEM AND CONTINUED TO PUT METAL TANKS IN INSTEAD OF PLASTIC. I WOULD GREATLY APPRECIATE A REPLY. *TR

TL* THE CONTACT OWNS A 2000 FORD F-350 DIESEL. THE CONTACT NOTICED THERE WAS A EXCESSIVE RUST ON THE FRAME AND THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT HE NEEDED A FRAME, TRUCK BED, ETC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000. UPDATED 12/05/11

AFTER COMPLAINING TO BF GOODRICH ABOUT (4) CRACKING SIDEWALLS AND BEING TOLD THAT THEY WERE SURFACE CRACKS AND IF THE TIRES HELD AIR THEY WOULD DO NOTHING BECAUSE THE TIRES ARE GOOD AT (1) YEAR OLD WITH 20,000 MI. (1 1/2) YEAR LATER THE SIDEWALL AND TIRE TREAD SEPARATED WHILE SITTING IN THE DRIVE WAY. I HAVE NOW REPLACED ALL (4) TIRES WITH A DIFFERENT TIRE BRAND. *TT

BRAKE LINES FAILED AND TRUCK RAN INTO FENCE.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE STALLED ALTHOUGH THE FUEL LEVEL WAS AT CAPACITY. THE CONTACT TOOK HIS VEHICLE TO AN INDEPENDENT MECHANIC AND THE DEALER WHO BOTH STATED THAT HAVING LESS THEN 5% BIO DIESEL WOULD CAUSE THE FAILURE TO OCCUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE CURRENT MILEAGE WAS 200,000.

2000 FORD F350 CREW CAB 4X4 BRAKE LINE WAS CORRODED FROM DIFFERENT METALS USED. HAD HOLE IN LINE AND BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HAVE NO BRAKES. EXTREMELY DANGEROUS!!! *TR

FUEL TANK STRAP HAS BROKEN AGAIN.2ND TIME FOR THE REAR STRAP,FRONT REPLACED 1 TIME. ALSO REPLACED GAS TANK IN 2006 DUE TO LEAK FROM RUSTING AT SEAM,TANK IS STARTING TO LEAK AGAIN. TANK DROPPED TO THE STREET WHEN STRAP GAVE WAY LAST TIME,LUCKILY I WAS GOING SLOW ON A SIDE STREET. SPEAKING WITH OTHER OWNERS OF THESE TRUCKS,F-350 SUPERDUTY 2000 CAB AND CHASSIS MOST ARE HAVING OR HAVE HAD THE SAME ISSUES I AM HAVING. *TR

TL* THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE CLUTCH ARM BROKE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER AND DEALER WERE CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 154,000. UPDATED 08/31/11*LJ UPDATED 2/9/12 *CN

TL* THE CONTACT OWNS A 2000 FORD F350. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE ENGINE STARTED TO EXHIBIT BLACK SMOKE AND HE WAS ABLE TO CONTINUE DRIVING HOME ONCE THE VEHICLE WAS RESTARTED. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT HE WOULD NEED TO REPLACE THE MOTOR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 110,000.

2000 FORD F350, UNIT #1 WAS TRAVELING EASTBOUND IN THE LEFT LANE WHEN THE RIGHT TIRE BLEW OUT. UNIT 1 WENT OFF THE RIGHT SIDE OF THE ROADWAY, STRUCK THE DITCH AND STRUCK A FENCE. BF THE DRIVER AND PASSENGER SUFFERED MINOR INJURIES. (OHIO TRAFFIC CRASH REPORT # 10-0415-89)*JB UPDATED 12/10/10 *BF

TL* THE CONTACT OWNS A 2000 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE CAM SHAFT SENSOR WAS REPLACED IN AUGUST 2009 UNDER RECALL CAMPAIGN NUMBER 07V553000, WHICH WAS FOR ENGINE AND ENGINE COOLING. THE CAM SHAFT SENSOR THAT WAS REPLACED IN AUGUST OF 2009 WAS NOT REPLACED BECAUSE IT FAILED; IT WAS REPLACED BECAUSE THE DEALER STATED THAT THE CONTACT HAD TO GET THE NEW CAM SHAFT SENSOR. THE CONTACT HAD THE ORIGINAL CAM SHAFT SENSOR REPLACED SEPTEMBER 2005 AND WAS NOT HAVING ANY PROBLEMS. THE NEW CAM SHAFT SENSOR HAS FAILED IN JUST OVER A YEAR AND LESS THAN 4000 MILES. THE MANUFACTURER STATED THAT THE CAM SHAFT HAS A 12 MONTH 12000 MILE WARRANTY.THE FAILURE MILEAGE WAS 184329 AND THE CURRENT MILEAGE WAS 188600.