2012 Ford Focus Body & Structure Problems

Back passenger door fails to latch when closed.

The contact owns a 2012 Ford Focus. The contact stated following repair work on the transmission, the contact was advised by the dealer to pick up the vehicle. The dealer informed the contact that the vehicle was not test driven because of extreme rust to the sub frame, and that the vehicle was unsafe to drive. The contact determined that the cost of replacing the sub frame would exceed the value of the vehicle. The vehicle was not repaired. The contact researched online and related the failure to several reported instances of severe corrosion for several years, makes, and models of the vehicle. The manufacturer had been informed of the failure. The failure mileage was approximately 123,000.

The rear driver side door latch will not latch and stay closed. The door swung open while I was driving. it has not been reproduced. it has not been inspected. I believe something is wrong with the door latch, but I do not use this door very much.

The vehicle was being towed by a Class A RV using a manufacturer approved towing system. All connections and safety measures were properly installed and tested just prior to incident. Vehicle has been towed using the same equipment for several years with no incident. The attachment from the frame to the front-end assembly completely separated and the vehicle body went into oncoming traffic. The vehicle in oncoming lane was struck and one individual injured. Upon visual examination, the frame component appears to have failed on both sides at the front-end. The bolts are still in-tack, tight and uncompromised. This is a frame component failure.

There is a warning light showing a code 1450, unable to create fuel vacuum, that at first was thought to be an issue with a current recall for the car that was fixed. But after a routine oil change a fuel leak was found. I was told by the mechanic that it appears to be a fuel tank deformation similar to the 19S22 recall. My Ford focus was not apart of that recall and I was told by Ford to contact you to potentially have my car added. The leak is subnational enough that it could cause an engine fire.

I have taken my car into to Carson City, NV Ford dealer many times. They say they fixed something else and do not have the time to fix the door latches that I made the appointment for . The only one that needs to be done is the back door on the driver's side. The rest were done the first time I took it in. I'm on a six plus month waiting list again to have the latch replaced with the right one! This has gone on way to many years. What happens if the door open and then closes on a kid/person in the back seat? Safety recall notice 20S30 / NHTSA 20V-331

After completing door latch recall there is still an alert the the hatchback is open. And doesn't shut off. The dealer states that I have to pay for replacement since the recall shows complete. Except the instructions did not show anything in regards to this component , in regards to the fuel system, the dealer said I would have to pay for test to determine if the PCM would fix the engine ight after I took in for recall.

FORD RECALL 20530, NHTSA RECALL 16V-643. CAR WAS SERVICED UNDER RECALL BUT HAS EXHIBITED ISSUE WITH DOOR OPENING SINCE RECALL SERVICE. WITHIN THE LAST 6 MONTHS THE CAR WILL GIVE A WARNING THAT THE DOOR IS AJAR WHILE DRIVING. THE ISSUE IS INTERMITTENT BUT HAS HAPPENED ON MULTIPLE OCCASIONS. CONTACTED FORD DIRECTLY AND IT WAS STATED THAT THEY WILL NOT REPAIR CAR UNDER THE RECALL. THE "WARRANTY FOR THE RECALL HAS EXPIRED" ALL REPAIRS EVEN THOUGH THEY ARE DIRECTLY RELATED TO THE RECALL WILL HAVE TO BE REPAIRED "OUT OF WARRANY". THIS IS CLEARLY A SAFETY ISSUE. A CAR DOOR SHOULD NOT OPEN WHEN TRAVELING AT 65MPH

THERE REAR DRIVERS DOOR WON'T SHUT AND I JUST FOUND OUT IT WAS RECALLED.

TOOK MY VEHICLE IN FOR THE RECALL ON THE DOOR LATCHES AND THEY SAID EVERYTHING WAS GOOD AND WHEN L CHECK THE VIN ON THE NHTSA IT STATES THAT RECALL INCOMPLETE. ALSO FORD HAD A RECALL MY FORD FOCUS IN MY 2012 YEAR ABOUT THE EVAP L HAVE HAD CODE P0456 IN RELATION TO P0456 EVAPORATIVE EMISSIONS SYSTEM - SMALL LEAK DETECTED. FORD SUPPOSELY DID A RECALL ON THIS AND SUPPOSELY DID WORK ON MY VEHICLE BEFORE L OWNED IT, NOW IT HAS SAME ISSUE SO L BELIEVE IT WAS NEVER CHANGED OUT? I BELIEVE THAT RECALL WAS BACK IN 2016 OR 2017 OR 2018?

ON 5/26/20, REPLACEMENT DRIVER'S SIDE FRONT DOOR LATCH STOPPED WORKING. THE LATCH WAS REPLACED IN 2017 UNDER THE RECALL. *TR

DOOR LATCHES HAVE FAILED AFTER BEING INSTALLED DO TO RECALL TWICE IN A LITTLE OVER 2 YEARS 3 DOORS IN TOTAL HAVE FAIL TWO RECENTLY FORD IS REFUSING TO FIX SOMEBODY GOING TO GET KILLED BECAUSE OF THIS ISSUE I AM A HEAVY COLLISON TECT WITH CLOSE TO 59 YEARS EXPERIANCE THEY DONE NOTHING TO RESOLVE THIS ISSUE

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING BETWEEN 45 AND 50 MPH, THE FRONT PASSENGER LEANED AGAINST THE INTERIOR PASSENGER SIDE DOOR AND IT OPENED INDEPENDENTLY WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE FRONT PASSENGER SIDE DOOR LOCK FAILED. THE CONTACT DROVE THE VEHICLE HOME USING A CARGO STRAP TO KEEP THE DOOR CLOSED. THE CONTACT CALLED KRAUSE FAMILY FORD OF WOODSTOCK (195 WOODSTOCK PKWY, WOODSTOCK, GA 30188, (877) 808-3640) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V643000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

SPRING CLIP BROKE POST RECALL REPLACEMENT 2012 FORD FOCUS REAR DRIVER DOOR. CAR WAS STATIONARY WHEN FIRST NOTICED ISSUE. DOOR WILL NOT LATCH CLOSED NOR ALLOW OTHER CAR DOORS TO BE LOCKED. POSES SAFETY RISK TO CHILDREN IN BACK SEAT AND PROTECTION RISK TO CAR THEFT.

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING, THE VEHICLE STALLED IN THE MIDDLE OF THE HIGHWAY AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD. WHEN THE VEHICLE WAS POWERED OFF AND RESTARTED, THE VEHICLE DROVE NORMALLY. ON ANOTHER OCCASION, WHILE ATTEMPTING TO DRIVE THE VEHICLE, IT FAILED TO START. THE VEHICLE WAS TAKEN TO ROGEL FORD (LOCATED AT 26167 MS-27, CRYSTAL SPRINGS, MS 39059, (601) 892-3673) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. FURTHERMORE, THE FRONT DRIVER SIDE DOOR FAILED TO CLOSE. THE VEHICLE WAS TAKEN BACK TO ROGEL FORD WHERE THE DOOR WAS REPAIRED, BUT NOT DIAGNOSED. THE CONTACT WAS INFORMED BY THE DEALER THAT THEY ALSO REPROGRAMMED THE POWER TRAIN MODULE. THE CONTACT STATED THAT THE FUEL GAUGE WOULD SHOW FULL WHEN IT WAS SUPPOSED TO BE AT HALF A TANK. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES AND STATED THAT ROGEL FORD REPAIRED THE VEHICLE PER NHTSA CAMPAIGN NUMBER: 18V735000 (FUEL SYSTEM, GASOLINE). NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 159,000.

DRIVER'S SIDE REAR DOOR FAILED TO LATCH. TOOK VEH TO DEALER. THEY ADVISED REAR DOOR LATCH FAILURE REMOVED DOOR PANEL AND REPLACED DOOR LATCH. I ASKED IF THIS WAS A RECALL AND WAS TOLD NO I WOULD HAVE TO PAY FOR IT, THAT THIS VEHICLE WAS NOT ON THE RECALL ISSUED BY NHTSA 16V643000 2012-1015 FORD FOCUS. IF THIS IS CORRECT MAYBE YOU NEED TO EXTEND THE RECALL. SEE ATTACHMENT WITH BILL FOR REPAIRS.

RECALL # 16S30 SIDE DOOR LATCH REPLACEMENT REMEDY WAS NEVER PERFORMED ON VEHICLE IN 2016. I JUST PURCHASED CAR ON OCTOBER 27, 2018 AND THERE IS A PROBLEM WITH THE DOOR CLOSING WHICH LEADS ME TO BELIEVE IT IS BECAUSE THE REMEDY WAS NEVER PERFORMED. THE VEHICLE WAS AT THE DEALERSHIP WHEN I DISCOVERED A PROBLEM WITH THE DOOR.

I WAS DRIVING AND MY REAR LEFT DOOR FLEW OPEN WHEN MAKING A RIGHT TURN OUT OF A PARKING LOT, NOW I SHUT MY RIGHT FRONT DOOR AND IT WON'T LATCH. I'VE NEVER RECEIVED A NOTIFICATION ABOUT A RECALL. THIS SHOULD BE FIXED BEFORE A CHILD FLIES OUT OF A CAR. MY CAR ONLY HAS 55K MILES ON IT. THIS IS PRETTY SAD.

ALL OF A SUDDEN MY DRIVERS DOOR CLOSES, BUT WILL NOT LATCH SHUT AND THIS IS A HUGE SAFETY ISSUE. WORKED YESTERDAY AND TODAY WHEN I WENT TO LEAVE DOOR OPENED AND INTERIOR LIGHTS CAME ON WITH A DASH WARNING THAT DRIVERS DOOR IS OPEN. THIS HAPPENED IN MY DRIVEWAY.

DOOR WILL NOT CLOSE AND LATCH. THEREFORE IT WILL FLY OPEN WHEN DRIVING IF IT IS NOT TIED TO SOMETHING ELSE IN THE CAR. THIS HAPPENED SPONTANEOUSLY WITH AN ACCIDENT, BUT DURING REGULAR USE.