2012 Ford Focus Tires & Wheels Problems

14-Dec-2023, Brought my car into the tire repair store to have flat fixed. Was told the 5 lug nuts would have to be replaced because the original ones were corroded due to their design. This cost me $51.00 on this trip. 20-Aug-2020, Brought my car into the Ford dealership to have tires rotated. Was tolld 12 lug nuts would have be replace becaue the original ones were corroded due to their design. It cost me $82.08 on that trip. These lug nuts can break because of corrision, causing a serious accident.

Was told my lug nuts are swollen and need to be replaced.

The contact owns a 2012 Ford Focus. The contact stated while taking the vehicle to routine service at the dealer, the service tech stated that the vehicle needed a new set of lug nuts. The contact was informed that the lug nuts could not properly be tightened and therefore needed to be replaced. The manufacturer was not contacted. The failure mileage was 63,000.

Lug nuts swelled, unable to remove without damaging, all 20 lugs nuts.

I went to Ramsey Ford Dealer in Rising Sun, Maryland for tire rotation on 7/22/21 with 125,803 mileage. They told me that I needed new lug nuts because the old lug nuts were swollen. I bought 20 lug nuts @ $6.38 each totalling $127.60. I am going for 4 new tires to Walmart Auto tomorrow 9/19/23 and the mileage is 143,619 and I told them that all my lug nuts were swollen because I rotated the tires myself last year and I had to hammer a 19mm socket on each lug nut to remove them. Walmart told me that the lug nuts were going to cost over $5.50 each. The 20 lug nuts are going to cost me over $110. That's if the mechanic does not charge more for hammering them or drilling them off. It is what it is! I figured I would reporr it. I do have a hammer and sockets in my trunck if I get a flat tire. But I have seen on tge internet hundreds of people getting stranded on the highway.

Tread wore away

I WAS WONDERING ABOUT ANY RECALLS OR COMPLAINTS ON THE SUMITOMO TOUR PLUS LSV 215/50R17 TIRES. I PURCHASED A VEHICLE 2 MONTHS AGO THAT HAS A SET OF THESE AND BOTH FRONT TIRES HAVE HAD TO BE REPLACED DUE TO WHAT APPEARS TO BE THE CENTER BELT IN THE TIRE BEING BROKEN. BOTH TIRES WERE VISIBLY WARPED AND YOU CAN SEE WHERE IT SINKS IN THE MIDDLE OF THE TIRE. UNFORTUNATELY THE CARS WARRANTY DOESN'T COVER THE TIRES AND I'M HAVING TO PAY TO REPLACE THEM SO JUST LOOKING FOR ANSWERS OR PROOF OF A FAULT SO I MIGHT CAN HAVE THEM REPLACED

THE CAR USES TWO PART LUGS THAT SWELL AND DEGRADE OVER TIME, AND SOME POINT, CANNOT BE USED TO HOLD ON A WHEEL THAT HAS BEEN REMOVED. THAT CAN BE A HAZARD, FOR EXAMPLE, IF A PERSON NEEDS TO REPLACE A FLAT TIRE ON A HIGHWAY AND THEN CANNOT REATTACH THE LUG NUTS. I RECENTLY HAD TO REPLACE THE LUG NUTS FOR SAFETY REASONS, AND WHILE I COULD FIND ONES THAT FIT THE POST THEY SCREW ON TO, THEY WERE NOR WIDE ENOUGH TO HOLD THE WHEEL COVER.

THE LUG NUTS THAT FORD USES ON MY CAR ARE POORLY DESIGNED, AND WILL SWELL. WHEN THIS HAPPENS, IT IS IMPOSSIBLE TO REMOVE THEM (SUCH AS WHEN YOU HAVE A FLAT TIRE) AND THEY NEED TO BE BROKEN OFF, AND NEW LUG NUTS PUT ON. IF YOU HAVE A FLAT, YOU HAVE TO GET YOUR CAR TOWED. FORD KNOWS THIS IS AN ISSUE AND REFUSES TO DO ANYTHING TO MAKE IT RIGHT, INFECT THEY STILL USE THIS FAULTY PARTS.

2012 FORD FOCUS. CONSUMER WRITES IN REGARDS TO DEFECTIVE LUG NUTS. *LD THE CONSUMER STATED THE LUG NUTS IN THE TIRES HAD SWOLLEN PREVENTING THE TIRES FROM BEING ROTATED*JS

LUGNUTS ON WHEELS ARE ROUNDED AND SWELLING MAKING IT IMPOSSIBLE FOR THE TOOL TO FIT OVER THEM TO REMOVE. THIS IS A SAFETY HAZARD BECAUSE THIS WILL PROLONG THE TIME A PERSON IS ON THE SIDE OF THE ROAD INCREASING THE CHANCE OF HARM.

MY CAR BEGAN MAKING REALLY LOUD HUMMING THAT GOT LOUDER AS I DROVE FASTER. ON OCCASION I WOULD FEEL IT 'SLIP' AT HIGH SPEEDS BUT I KNEW IT WASN'T THE TRANSMISSION. IT TURNED OUT THAT ALL 4 SETS OF THE WHEEL BEARINGS WERE LOCKING UP . BECAUSE THE BEARINGS ARE SUPPOSED TO BE IN A SEALED ENVIRONMENT THEY SHOULDN'T HAVE BEEN EXPOSED TO THE ELEMENTS FOR ONE, AND I HAD TO REPLACE THE ENTIRE WHEEL HUB FOR ALL 4 SINCE THE BEARINGS ALONE ARE NOT SERVICEABLE.

2012 FORD FOCUS HATCHBACK. CONSUMER WRITES IN REGARD TO PROBLEMS WITH WHEEL LUG NUTS. *AS *TR

WHEN GOING ABOUT 55 MPH MY CAR STARTS TO GET VERY LOUD, NOTHING SEEMS TO BE WRONG IT'S AS IF THERE'S A LEAF BLOWER INSIDE THE VEHICLE. AS I SLOW DOWN, USE THE BRAKES, THE SOUND SLOWLY GETS MORE QUIET.

TL* THE CONTACT OWNS A 2012 FORD FOCUS. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED. IN ADDITION, THE FRONT DRIVER'S SIDE WHEEL WAS WOBBLING. FURTHERMORE, THE ENGINE STALLED AND THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE CONTACT HAD TO RESTART THE VEHICLE AND THE CHECK ENGINE INDICATOR TURNED OFF AND ON. THORNHILL FORD LINCOLN (U.S. 119 NORTH 500 FORD FAIRLANE, CHAPMANVILLE, WV 25508, (304) 855-8300) STATED THAT THERE WAS NO WARRANTY COVERAGE; THEREFORE, THE CONTACT WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 18V735000 (FUEL SYSTEM, GASOLINE) AND TOOK THE VEHICLE TO THE SAME DEALER FOR THE RECALL REPAIR. THE FAILURE RECURRED AFTER APPROXIMATELY ONE MONTH. THE DEALER WANTED TO CHARGE FOR ANOTHER DIAGNOSTIC TEST. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 53,000.

THE LUG NUTS ARE SWELLING AND SEPARATING. BECAUSE THEY ARE TWO PART CHROME COVERED. FOR THIS CAR, THE LUGNUTS ARE CUSTOM. IF THEY ARE PLACED BY STANDARD LUG NUTS, THEN THE WHEEL COVER CANNOT STAY ON. THE TWO PART CHROME LUG NUT IS NOT CARRIED AS A STOCK ITEM IN A DEALERSHIP. TIRES CANNOT BE REMOVED BY STANDARD LUG WRENCH, BECAUSE THE LUGNUT IS NOT A STANDARD SIZE. THE LUG NUT MUST BE CUT OFF. THEREFORE IF A TIRE BECOMES FLAT ON THE ROAD, IT MUST BE TOWED INTO A DEALERSHIP AND NOT FIXED AT ANY OTHER PLACE. I WAS TOLD THAT IT COULD TAKE OVER A WEEK TO GET A LUG NUT IN WITH A GREATLY INCREASED PRICE OF OVER $20 INSTEAD OF A STANDARD LUG NUT COST OF $4. RECEIVED THE FOLLOWING FROM THE DEALERSHIP GARY CROSSLEY: DEAR THOMAS, DURING YOUR RECENT VISIT, WE RECOMMENDED THE FOLLOWING IMPORTANT SERVICE(S):' 'TIRES REQUIRE IMMEDIATE REPLACEMENT. AT QUICK LANE AT GARY CROSSLEY FORD, OUR FACTORY-TRAINED TECHNICIANS CAN PROVIDE THIS SERVICE WHILE YOU WAIT. AND THERE'S NO APPOINTMENT NECESSARY ' SIMPLY EXCELLENT SERVICE AT YOUR CONVENIENCE. STOP IN TODAY! SINCERELY, YOUR QUICK LANE SERVICE TEAM

TL* THE CONTACT OWNS A 2012 FORD FOCUS EQUIPPED WITH CONTINENTAL CONTI PRO CONTACT TIRES, SIZE: 215/55R16 (NA). WHILE DRIVING APPROXIMATELY 30 MPH, THE FRONT PASSENGER TIRE BLEW OUT WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT INSPECTED THE OTHER TIRES ON THE VEHICLE AND NOTICED THAT THE FRONT DRIVER SIDE, REAR DRIVER SIDE, AND REAR PASSENGER SIDE TIRES ALL HAD BUBBLES IN THE SIDEWALLS. THE TIRES ON THE VEHICLE WERE THE ORIGINAL TIRES AND THERE WAS A NOTICEABLE VIBRATION WHEN DRIVING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE VEHICLE AND TIRE FAILURE MILEAGE WAS 29,000.

TL* THE CONTACT OWNS A 2012 FORD FOCUS. WHILE DRIVING 35 MPH, THE CONTACT HEARD AN EXPLOSIVE ABNORMAL NOISE COMING FROM THE REAR DRIVER SIDE. THE CONTACT NOTICED BURNT RUBBER AND SMOKE COMING FROM THE TIRE. THE LOW TIRE PRESSURE WARNING LIGHT ILLUMINATED. THE CONTACT THEN NOTICED THAT THE FRONT AND REAR DRIVER SIDE TIRES BLEW OUT AND WERE DEFLATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HBT BOLT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.

TL* THE CONTACT OWNS A 2012 FORD FOCUS EQUIPPED WITH CONTINENTAL CONTIPROCONTACT TIRES, SIZE: 215/50/R17 (NA). WHILE PARKED, THERE WAS AN EXPLOSIVE NOISE COMING FROM THE VEHICLE. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE TIRE BLEW OUT AND DEFLATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE TIRE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS 300.

WHILE TOWING THIS CAR BEHIND MY MOTORCOACH FOUR-TIRES DOWN, PER FORD MANUAL AND CURRENT RV SAFETY PRACTICES, THE FOCUS' PASSENGER-SIDE REAR TIRE HAD A BLOW OUT. THE TIRE CAME COMPLETELY OFF OF THE RIM. ALL FOUR FOCUS TIRES WERE CHECKED TWO DAYS BEFORE AND PRESSURES WERE AT SPEC. WITH NO SIGN OF LEAKS OR APPARENT DAMAGE. THE TIRES ARE MICHELIN DEFENDER TIRES WITH ABOUT 14,500 MILES ON THEM AND PURCHASED IN APRIL OF 2014. THIS BLOW OUT WAS A COMPLETE SURPRISE, FOR THE TIRES WERE IN APPARENTLY VERY GOOD CONDITION, I DID NOT RUN OVER ANY ROAD DEBRIS AND I WAS TRAVELING AT 55 MPH. I HAVE PHOTOS OF THE BLOWN OUT TIRE AND WILL PROVIDE THEM UPON REQUEST. THANK YOU. *TR