2005 Ford Freestar Complaint Log

DRIVING HOME VAN STARTING SHUTTERING VIOLENTLY THEN SHUT OFF WHILE STILL ROLLING LOST ALL POWER, WAS SAFELY ABLE TO GET TO SIDE OF ROAD . TOLD ISSUE COST 1500 TO FIX SEEN FORD SERVICE BULLETIN ON DEFECT OF WATER GETTING TO PCM ON INTERNET. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE SLIDING DOOR LOCK FAILED AND COULD NOT BE UNLOCKED ELECTRONICALLY OR MANUALLY. THE LOCAL MECHANIC STATED THAT THE POWER CONTROL MODULE WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.

RECEIVED 3 VEHICLE SERVICE BULLETINS MFGR CAMPAIGN #: 11S25 . MADE APPOINTMENT FOR 07/08/14 @ 10:00AM WITH DUVAL FORD 32210 AND DROVE MY VAN THERE. DUVAL FORD RENTED ME A HERTZ VEHICLE BECAUSE THEY COULD NOT FINISH THE RECALL REPAIR. ON 07/11/14 DUVAL FORD CALLED ME TO SAY MY VAN IS READY. MILEAGE ON MY VAN IN ON 07/08 WAS 47322, MILEAGE OUT ON 07/11 WAS 47324 . 08/25/14 MILEAGE 47597 CALLED DUVAL FORD MY VAN KEEPS STALLING AND SHUTS OFF IN DRIVE ALSO CHUGS UP ON INCLINES. I HAD AAA TOW IN. DUVAL FORD DID IN PLACE NEXT MORNING START UP, NO ROAD TEST DID SAY 1 CODE IN SYSTEM P21 07 REV LIMITER. I DROVE HOME APPROXIMATELY 15 MILES NO STALLING. 09/05/14 MILEAGE 47598 ? AS WRITTEN ON SERVICE ORDER CALLED DUVAL FORD MY COMPLAINT UPON ACCELERATING VAN SHUDDERS CALLED AAA TOWED IN TO DUVAL FORD ROADTESTED FOUND BAD SHUTTER, NO ACCELERATION, FOUND #3 CYL NOT FIRING #5 MISFIRING, REPLACED COIL PACK, SPARK PLUGS AND WIRES REMOVED UPPER INTAKE TO SERVICE. CHARGE $780.25 09/25/14 MILEAGE 47834 CALLED DUVAL FORD, AAA TOWED IN,CHECK ENGINE LIGHT ON AND NOT DRIVING RIGHT DIAGNOSIS WATER IN THE PCM CONNECTOR RESEALED TOP ENGINE COWL, NUMEROUS TRANSMISSION AND ENGINE CODES ON. 10/21/14 MILEAGE 47968 CALLED DUVAL FORD AAA TOWED IN VAN STALLING AND WON'T MOVE WHEN IN REVERSE GEAR. DIAGNOSIS TRANS CODES IN MEMORY U1039,PO713,P1502 VOLTAGE SPIKES WHEN TRANS UPSHIFTS. ETC.. 01/21/15 MILEAGE48536 CALLED DUVAL FORD AAA TOWED IN VAN STALLING SHUTS OFF WON'T MOVE WHEN IN REVERSE. DIAGNOSIS CANNOT FIND ANY PROBLEM. DRIVER RETURNED VAN TO MY DRIVEWAY. NO WORK SERVICE ORDER. 01/23/15 MILEAGE 48549 STARTED VAN WOULD NOT MOVE WHEN IN REVERSE PLAYED WITH SHIFTER, DID GO IN REVERSE BACKED INTO STREET SHIFTED INTO DRIVE, ENGINE LT ON, SHUDDERS. DROVE 50 FT TURNED AROUND PARKED IT IN DRIVEWAY. SAME ORIGINAL PROBLEM AFTER RECALL FIX. TIME LINE 197 DAYS AND 1225 MILES NO PREVIOUS PROBLEMS. *TR

THIS HAS HAPPENED SEVERAL TIME OVER LAST YEAR OR SO THAT I HAVE OWNED THIS VEHICLE. WHEN DRIVING DOWN HIGHWAY AND IT STARTS TO RAIN CARS SPUTTERS AND SEEMS TO LOOSE POWER. TWICE IT HAS STALLED ON ME GOING 55 MILES AN HOUR ON HIGHWAY AND HAVE HAD TO TRY AND COAST TO SIDE OF ROAD IN TRAFFIC WITH PEOPLE BEEPING WITH LOSS OF STEERING. LUCKILY BOTH TIMES AFTER A FEW MINS THE VEHICLE STARTED AGAIN AND WAS ABLE TO MAKE IT HOME. HAVE CHANGED WIRES AND PLUGS, RUNS FINES IN DRY WEATHER BUT STILL STUTTERS AND TRIES TO STALL WHEN ITS WET OUT OR RAINS! VERY DANGEROUS AND WONT LET WIFE TAKE KIDS OUT WHEN IT RAINS IN FEAR THEY WILL GET STUCK SOMEWHERE. *TR

TRACTION CONTROL WARNING LIGHT INTERMITTANT, WITH AWD MALFUNCTION ON. MECHANIC SAYS CODE 1889. SAID LOTS OF PROBLEMS ON FREESTYLES, FORD 500 AND MERCUTY MODELS WITH AWD. APPARENT SERVICE BULLETINS. LOSS OF POWER, IF SERVICE BULL ISSUED THERE IS A KNOWN PROBLEM. WHY NO RECALL? *JS

AFTER 2 HOURS OF DRIVING, I TRIED TO PASS A CAR ON THE TURNPIKE, THE CAR MADE A LOUD NOISE AND IT LOOKED LIKE IT WENT INTO NEUTRAL. TOOK THE CAR TO THE SHOP, THEY SAY THAT THE TRANSMISSION IS BROKEN, FORD REPLACED THE TORQUE CONVERTER DUE TO THE RECALL ON JANUARY OF 2014, BUT NOW THEY ARE SAYING THAT THE ISSUE IS NOT THE TORQUE CONVERTED, THEY STATE THAT THE TRANSMISSION NEEDS TO BE REBUILT. *JS

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING APPROXIMATELY 30 MPH, THE FRONT PASSENGER SIDE OF THE VEHICLE BEGAN TO JERK AND AN UNFAMILIAR WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY ASSEMBLY WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

HEAVY RAIN ALL DAY AND THE WATER WAS LEAKING ON THE MAIN COMPUTER BOARD. CAUSING THE VAN TO STALL OUT AND RESULTING IN A 100.00 TOW BILL. THE SHOP TOLD ME IT IS LEAKING AND NEEDS TO BE REPLACED AND SEALED. *TR

IN 06/2014 MY VAN TRANSMISSION LIGHT CAME ON THEN WENT OUT. I THOUGHT IT WAS NOTHING AS TIME PROGRESS I NOTICE THAT MY VAN WAS SLOW AND HARD SHIFTING. I TOOK IT TO THE NEAREST TRANSMISSION AUTO SHOP AND THEY TOLD ME IT WAS MY INTERNAL TRANSMISSION FAILING. I PUT IT IN THE SHOP AND THE REPAIR COST 1200.00 TO FIX. IT GOT IT OUT WORKED FINE FOR A FEW DAYS THEN STARTED BACK SLOW AND HARD SHIFTING AGAIN. TOOK IT BACK TO MECHANIC THEY SAID THEY DON'T SEE ANYTHING WRONG WITH IT. I DID THIS SEVERAL AND HAD NO LUCK WITH IT. 08/2014 I STARTED HAVING MORE NOTICEABLE ELECTRICAL PROBLEMS LIKE DASH BOARD LIGHTS COME ON NOW AND THEN RADIO RESETS IT SELF SOMETIMES IT WONT WORK AT NOT EVEN THE DVD PLAYER. THE DOORS WONT LOCK ALARM GOES OFF WHEN IT WANTS TO AND POWER SLIDING WONT CLOSE. SO I ONLY DROVE THE VAN AROUND TIME LIMITING MY TRIPS CONTACTED FORD NO HELP THERE. THEN WINTER COMES IN ALL OF SUDDEN MY VAN WORKS GREAT DASH BOARD LIGHTS WORKING DVD AND RADIO WORKING FINE MOST IMPORTANTLY MY VAN TRANSMISSION WAS SHIFTING PROPERLY BUT THEN ON WARMER DAYS IT STARTS TO ACT UP AGAIN.ON 02/16/20015 MY CHILDREN AND I WAS ON OUR WAY TO GET GROCERIES FOR THE WINTER STORM THAT WAS COMING,THE LOST POWER AND DIED LUCKILY WAS CLOSE TO HOME THAT I COULD PULL OVER START IT AGAIN AND MAKE IT HOME SAFELY. THEN TODAY IT WILL NOT START UP AT ALL. IM A SINGLE MOTHER OF FIVE YOUNG DAUGHTERS AND MY OLDEST DAUGHTER AND I ARE BOTH DISABLED. WE DEPEND ON THIS VEHICLE TO GET BACK AND FORTH TO OUR DOCTORS APPT. IM PLANNING HAVE A MECHANIC CHECK MY PCM AND TO SEE IF ITS WATER DAMAGE. BUT I'VE NOTICE SEVERAL FELLOW FORD OWNERS ARE GOING THROUGH SIMILAR PROBLEMS. I DON'T KNOW WHY FORD NOT WILLING TO OWN UP TO THEIR LIFE THREATENING MISTAKES. *TR

AFTER WET WEATHER THE NIGHT BEFORE, VEHICLE RUNNING ROUGH (TO THE POINT OF NEAR STALL), HESITATING TO BURN FUEL PROPERLY TO GET UP TO SPEED AND NOT SHIFTING PROPERLY. VEHICLE WAS THEN PARKED, RE-STARTED AND ACTED NORMALLY. WITHIN THE PAST WEEK, EACH DAY AFTER RAIN THE CAR REPRODUCES THIS ISSUE AND ONLY AFTER EXPOSURE TO RAIN. YESTERDAY I NOTED GAP IN COWL TO SHEET METAL ABOVE PCM AS WELL AND ALSO NOTED THAT A BODY SEAL NEXT TO THE PCM WAS SOAKED. IT IS CONSISTENT WITH THE INTERNET COMPLAINTS ABOUT PCM BEING EXPOSED/FLOODED WITH WATER. THIS IS A SERIOUS CONCERN AS TO THE DAMAGE IT CAN DO TO THE VEHICLE'S MOST EXPENSIVE COMPONENTS (ENGINE, TRANSMISSION, ETC) AS WELL AS POTENTIALLY PRODUCE AN ACCIDENT ON THE ROAD SHOULD OTHER ANOMALOUS BEHAVIOR SURFACE. IT IS ALSO IMPORTANT TO NOTE THAT AS THIS VEHICLE AGES, MORE OF THE POPULATION OF PRODUCED VEHICLES WOULD BE EXPOSED TO THIS CONCERN AS GASKETS LOSE EFFECTIVENESS DUE TO COMPRESSION SET, DETERIORATION OF SEAL, THE PLASTIC THE SEAL IS ATTACHED TO WARPS, ETC. *TR

IN THE BEGINNING (5/21/14), OUR 2005 FORD FREESTAR VAN DECELERATED TO ABOUT 35 MPH, THEN STALLED 3 TIMES, THEN WOULDN'T GO IN REVERSE OR DRIVE, HARD TO START AFTER SITTING IN RAIN. AT FIRST, WAS TOLD TRANSMISSION BY REPAIR SHOP, WHO HAD REBUILT 6 MOS EARLIER, THEN SAID PCM.. AFTER RESEARCH, FOUND PCM GETS WET, HAD REPLACED & STILL AT FORD DEALER ALMOST 2 MOS LATER..THEY REPLACED TORQUE CONVERTER (RECALL), THROTTLE POSITION SENSOR (6/19/14) & CAM SENSOR (6/12/14) BECAUSE "PCM" TOLD THEM THEY WERE BAD AFTER WE PAID FOR ANOTHER PCM TO BE INSTALLED..DEALER ORDERED SHIELD WHICH WE HAVE TO PAY FOR. THIS OCCURS INTERMITTENTLY, AND, NOTICED AFTER IT RAINS. SERVICE MANAGER NOW SAID THIS MORNING (7/16/14) HE THINKS FUSES IN FUSE BOX BY BATTERY ON DRIVER SIDE (AFTER WE CALLED TO LET HIM KNOW WOULDN'T GO IN REVERSE)..HE CAME TO OUR HOME & COULDN'T GET VAN TO START, AFTER STARTING, WOULDN'T GO INTO REVERSE OR DRIVE, STALLED AGAIN, WOULDN'T START. WE HAVE GIVEN HIM A LOT OF INFORMATION, INCLUDING A YOU TUBE VIDEO EXPLAINING THE PROBLEM & HOW TO FIX, BUT HE DOES NOT BELIEVE US. FORD NEEDS TO RECALL THESE AS THIS IS A MANUFACTURING DEFECT BEFORE SOMEONE IS KILLED OR INJURED WHEN VEHICLE STALLS GOING 70 MPH ON EXPRESSWAY OR MAYBE THEY ALREADY HAVE, THEY JUST WEREN'T AWARE OF THE PROBLEM. IF IT STALLS ON THE EXPRESSWAY OR GOING DOWN A HILL, THE POWER STEERING AND BRAKES GO OUT..FORD ISSUED A TSB IN 2004... DATE REPORTED: DECEMBER 13 2004 NHTSA REFERENCE: #10014086 TSB REFERENCE: #042107 DESCRIPTION: GENERAL (PCM) POWER TRAIN CONTROL MODULE PROGRAMMING PROCEDURES. *TT REPAIR INFORMATION FOR NHTSA #10014086 DATE REPORTED: NOVEMBER 01 2004 NHTSA REFERENCE: #10013369 TSB REFERENCE: #04217 *TR

THIS IS ABOUT A 2005 FORD FREESTAR. WHEN ACCELERATING, SPECIALLY IN RAINY CONDITIONS, THE VEHICLE'S ENGINE MAKES A SCREECHY NOISE AND LOSES POWER. THE SCREECHY NOISE SOMETIMES STOPS AND THE VEHICLE IS ABLE TO CONTINUE MOVING. USUALLY WHEN IT'S WET/RAINY THE ENGINE LOSES POWER AND VIBRATES. IT'S VERY DANGEROUS AND STRESSFUL BECAUSE IT USUALLY HAPPENS WHEN ATTEMPTING TO PASS SLOWER VEHICLES ON THE LEFT LANES AND WHEN THE VEHICLE LOSES POWER WE ATTEMPT TO MOVE TO THE RIGHT LANE'S SHOULDER. LUCKY THAT THIS HAPPENED WHEN TRAFFIC WAS LIGHT AT 6AM. AFTER RESTARTING THE ENGINE I DROVE ON SIDE ROADS TO REACH MY DESTINATION. THIS HAS HAPPENED AT LEAST TWENTY TIMES SINCE 2013. *TR

TL*THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE COWL NEEDED TO BE SEALED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED TWO ADDITIONAL TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS A LOUD NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT HUB, ROTORS, AND WHEEL BEARINGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

I WOULD LIKE TO REPORT THE FAILURE OF A COMPANY AND A VAN. I RECENTLY PURCHASED A 2005 FORD FREESTAR FOR MY FAMILY OF FIVE THAT HAS BEEN THE WORST DECISION OF MY LIFE. A MONTH AFTER I EXPERIENCED WHAT TOO MANY OTHER OWNER HAVE ALSO EXPERIENCED. WATER IN THE PCM, THIS ALMOST RESULTED IN A CRASH AND INJURY TO ME AND MY FAMILY. STALLING OUT WITHOUT WARNING AT ANY SPEED. THIS KNOWN ISSUE HAS GONE ON TOO LONG WITHOUT ANY RESPONSE FROM FORD COMPANY. I AM NOT A BELIEVER IN SOMEONE HAS TO DIE FOR THERE TO BE CHANGE. ALSO DON'T APPRECIATE THE COST OF THIS JOB OVER $1000. I WAS FORTUNATE TO NOT BE ON THE HIGHWAY AND CRASH. ALTHOUGH THEN WE MIGHT GET OUR MONEY BACK. THIS HAS ALSO LED TO OTHER ISSUES THAT HAS BECOME A CHAIN REACTION OF FAILURE. I WILL KEEP MY RECEIPT FOR AS LONG AS I HAVE TO. *TR

LAST COUPLE OF YEARS SINCE THE WARRANTY WENT OUT, THE VEHICLE SEEMS TO BE SLIPPING WHEN ACCELERATING FROM A STOP. DEALERSHIP WON'T DO ANYTHING WITHOUT US PAYING A LARGE SUM OF MONEY TO FIX IT. WE HAVE HAD THE TORQUE CONVERTER REPLACED THREE TIMES. THE LAST TIME WAS BY THE FORD DEALERSHIP DUE TO THE RECALL. I HAVE SEEN MANY SIMILAR ISSUES WITH SAME MAKE, MODEL, AND YEAR ON BLOGS AND FORUMS. WOULD LOVE FOR FORD TO REMEDY THIS ISSUE WITHOUT US HAVING TO SPEND MONEY THAT WE DON'T HAVE. THIS IS A SERIOUS SAFETY ISSUE!!! AT A BUSY INTERSECTION, THE TRANNY SLIPPING COULD EASILY PUT ONE IN HARMS WAY. *JS

AFTER HAVING THE TORQUE CONVERTER RECALL REPAIR DONE, THE VEHICLE STARTED HAVING MINOR TRANSMISSION PROBLEMS (THOUGH I DID NOT RECOGNIZE THEM AS THAT AT THE TIME). IT WOULD BE SLUGGISH IN SHIFTING, FOR EXAMPLE. HOWEVER, EVENTUALLY THIS REACHED THE POINT THAT AT TIMES I COULD NOT PLACE THE TRANSMISSION IN REVERSE. I WOULD BE STUCK UNTIL AFTER GOING BACK AND FORTH THROUGH THE TRANSMISSION, OR TURNING OFF AND RESTARTING THE VEHICLE, IT WOULD EVENTUALLY ENGAGE IN REVERSE. THEN THIS STARTED HAPPENING IN FORWARD GEARS ALSO. I ASSUMED IT WAS PART OF THE SAME TRANSMISSION ISSUES AS IN THE RECALL (NHTSA ENGINEERING ANALYSIS #EA09016), BUT THE DEALER SAID NO, IT WAS WATER IN THE TRANSMISSION AND A SEPARATE ISSUE ALTOGETHER. NO-ONE CAN EXPLAIN WHY THIS SHOULD HAPPEN AT 70,000 MILES. I THINK THIS IS RELATED TO THE ORIGINAL ISSUE OR THE RECALL REPAIR AND SHOULD BE COVERED. IT SEEMS NHTSA HAS TWO OTHER INVESTIGATIONS GOING ON THIS: NHTSA PRELIMINARY EVALUATION #PE09033 AND NHTSA PRELIMINARY EVALUATION #PE10033. I WANT TO ADD THIS TO THE DATA COLLECTION, SINCE I THINK FORD IS RESPONSIBLE. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THERE WAS A SUDDEN LOSS OF ENGINE POWER AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TORQUE CONVERTER NEEDED TO BE REPLACED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 127,000.

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. WHILE DRIVING AT VARIOUS SPEEDS DURING RAINY WEATHER CONDITIONS, ALL OF THE LIGHTS ON THE INSTRUMENT PANEL ILLUMINATED AND THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE DID NOT RESTART. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

TL* THE CONTACT OWNS A 2005 FORD FREESTYLE. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE INDEPENDENTLY DECELERATED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 12V006000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 212,000.

DRIVING AT APPROXIMATELY 35MPH THE VEHICLE STARTED STALLING OUT AND WOULD NOT SHIFT PROPERLY. FORTUNATELY WAS ABLE TO SAFELY COAST TO SIDE OF ROAD. HAD VEHICLE TOWED TO CONWAY FORD IN CONWAY, SC. NEEDED NEW POWER CONTROL MODULAR (PCM) DUE TO WATER LEAKING THROUGH WINDSHIELD COWLING AND SHORTING OUT CONNECTIONS TO PCM. CREATED A POTENTIALLY DANGEROUS SITUATION WITH VEHICLE STALLING OUT WHILE IN MOTION. RESEARCH HAS REVEALED THIS TO BE A VERY COMMON PROBLEM WITH THIS VEHICLE THAT IS A SAFETY HAZARD THAT NEEDS TO BE ADDRESSED BY FORD MOTOR COMPANY WITH A RECALL. *TR

I HAVE HAD AN ISSUE WITH IT DYING AND STALLING OUT AND NOT WANTING TO MOVE.... AFTER 3 TRIPS IN A MONTH TO THE DEALERSHIP THEY FINALLY FOUND THE PROBLEM, IT WAS THE PCM MODULE..... I CALLED FORD MOTOR COMPANY AND INFORMED THEM THAT AFTER DOING RESEARCH ONLINE THAT I HAVE NOTICED THAT THIS IS A MAJOR ISSUE WITH MANY OWNERS..... THEY SAID THAT IF ENOUGH PEOPLE CALL IN AND INFORM IT WILL GET ADDRESSED BY NHTSA...SO IF YOU ARE HAVING THIS PROBLEM OR HAVE HAD IT PLEASE CALL IN. KEEP YOUR RECEIPTS FOR ANY REPAIRS DONE DUE TO THIS AND IF THERE IS A RECALL AND HOPEFULLY IT WILL BE BEFORE SOMEONE DIES DUE TO IT. WE WILL BE REIMBURSED FOR OUR REPAIR COSTS. *TR

I ATTEMPTED TO START VEHICLE AND THE ENGINE WAS DIFFICULT TO TURN OVER. WHEN IT DID START THE RPMS WERE GOING UP AND DOWN . WHEN I TRIED TO PUT CAR IN REVERSE IT WOULD NOT ENGAGE CAUSING VEHICLE TO ROLL FORWARD. ( I WAS PARKED ON A SLIGHT DECLINED DRIVEWAY). AFTER READING ABOUT SIMILAR PROBLEMS I CHECKED THE PCM (POWER CONTROL MODULE. IT WAS FILLED WITH WATER !!! AFTER UNPLUGGING THE PCM AND ALLOWING IT TO DRY OUT I PLUGGED IT BACK IN AND THE PROBLEM WAS CORRECTED. IT APPEARS TO ME THAT THE PCM IS LOCATED IN A BAD LOCATION CAUSING IT TO HAVE PROBLEMS WHEN IT RAINS OR SNOWS. I MADE A TEMPORARY FIX BY PUTTING SILICONE CAULKING AROUND THE COWLING WHERE I BELIEVE THE WATER IS GETTING IN.... *TR

THE LIGHT FOR THE POWERTRAIN MALFUNCTION STARTED FLASHING AFTER WE HAD THE ALTERNATOR CHANGED. DO NOT KNOW IF IT WAS JUST A COINCIDENCE BUT THE SPEEDOMETER ALSO STOPPED WORKING. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT HAD EXPERIENCED DIFFICULTY WITH THE GEARS SHIFTING INTERMITTENTLY AND HAD HEARD A GRINDING NOISE MULTIPLE TIMES. THE CONTACT STATED WHILE TRAVELING 60 MPH, THE VEHICLE HAD JERKED VIOLENTLY AND THE TRANSMISSION WAS SLIPPING MORE THAN ONCE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHO DIAGNOSED AND REPLACED THE TORQUE CONVERVER. THE VEHILCE WAS REPAIRED AND THE FAILURE RECURRED. THE CONTACT WAS INCLUDED IN 12V006000 (POWER TRAIN) BUT HAD BEEN TOLD MORE THAN ONCE BY THE LOCAL DEALER THAT THE PART WAS NOT AVAILABLE FOR THE RECALL REPAIR. THE CONTACT HAD EXPERIENCED THE FAILURE MULTIPLE TIMES WHILE WAITING FOR THE PART FOR THE REPAIR. TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE JERKED VIOLENTLY. THE FAILURE WAS RECURRING. ADDITIONALLY, THE GEAR SHIFTER WOULD OFTEN BECOME RESISTANT WHEN THE CONTACT WAS ATTEMPTING TO SHIFT GEARS AND THE VEHICLE WOULD EXHIBIT AN ABNORMAL GRINDING NOISE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHERE THE TORQUE CONVERTER WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN) BUT WAS CONSTANTLY TOLD THAT THE PART WAS NOT AVAILABLE FOR THE RECALL REPAIR. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

WHILE DRIVING DOWN THE ROAD, THE VAN WILL SUDDENLY DIE. ALL ALARMS, ENGINE LIGHT, ABS, TRACTION CONTROL. WILL GO OFF. SUDENLY THERE IS NO POWER. VAN WILL START RIGHT BACK UP AND DRIVE AGAIN. THIS HAS BEEN GOING ON FOR OVER A YEAR. I HAVE HAD IT AT 7 DIFFERENT MECHANICS, INCLUDING THE FORD DEALERSHIP WHERE I PURCHASED THE VEHICLE. IT HAS HAPPENED AT ALL DIFFERENT SPEEDS, 20-65, ALSO HAPPENS IF STALLED AT A STOP LIGHT OR DRIVE-THRU. ADDITIONALLY, I CAN BE DRIVING AT 25-35MPH AND THE RPM'S WILL SHOOT UP TO 7000 OR FALL ALL THE WAY DOWN LIKE YOU ARE IDLEING. VEHICLE MAKES NOISES LIKE IT IS GOING TO BLOW UP AND THEN WILL BE FINE. *TR

COMING INTO MY PARKING LOT, I LOST POWER STEERING. IT APPEARS THAT I HAVE A LEAK. BUT BEFORE THIS HAPPENED, I HAD SOME ODD SOUNDS HAPPENING AND SOME OTHER MINOR ISSUES WITH THE VEHICLE THAT AT THE TIME SEEMED UNRELATED. THEN I LOST MY STEERING. I BOUGHT THIS VEHICLE USED IN '09, SO I EXPECTED A FEW ISSUES ALONG THE WAY. THIS IS NOT THE FIRST MAJOR ISSUE I HAVE HAD, AS I HAD TO HAVE THE TRANNY RECALL ISSUE REPAIRED ABOUT A YEAR OR TWO AGO. (WHAT IS IT WITH FORD THINKING IT IS MORE COST EFFICIENT TO ALLOW PEOPLE TO GET HARMED THAN TO FIX A PROBLEM?!!! UNFORTUNATELY I HAVE NOT HAD THE INCOME TO BUY A NON-FORD VEHICLE, BUT MARK MY WORDS, WHEN I DO HAVE THE INCOME, I WILL NO LONGER BE A FORD DRIVER.) NOT THE FIRST TIME THAT I HAVE HAD TO GET RECALL WORK DONE EITHER, I NOW HAVE TO GET THE REAR SEAT FIXED YET, BUT CANNOT DRIVE IT TO THE DEALER TO GET IT FIXED BECAUSE I DON'T HAVE POWER STEERING! IRONIC? HHMMMM...I WONDER. MY CAR HAS BEEN SITTING SINCE JAN 6 2014. NO MONEY TO FIX IT UNTIL NOW. THANKS FORD -PLEASE NOTE: SAID WITH SARCASM. *TR

I WAS DRIVING ALONG THE ROAD WITH MY CHILDREN IN THE CAR WHEN MY CAR JUST LOST THE GEAR. THE CAR WAS STILL ON BUT WHEN I PRESSED ON THE GAS PEDAL IT WOULD DO NOTHING BUT STALL. I HAD TO ROLL TO A STOP IN THE MIDDLE OF THE HIGHWAY. I FOUND OUT AFTER THIS PROBLEM THAT MY VAN HAD A RECALL IN JAN 2012 FOR THE TORQUE CONVERTER WHICH NEEDED TO BE REPLACED. I GOT THE VAN IN OCT 2012 AND I HAD NO IDEA THAT WAS ONE OF THE RECALLS ON THIS VEHICLE UNTIL I HAD THIS PROBLEM. I TOOK IT IN TO THE FORD DEALERSHIP AND THEY TOLD ME THAT WOULD NOT SOLVE THE PROBLEM THE BAD TORQUE CONVERTER, BUT WHEN TAKEN TO ANOTHER SHOP THEY SAID THE BAD TORQUE CONVERTER CAUSED THE PROBLEM AND NOW THERE ARE PIECES OF METAL IN THE TRANSMISSION WHICH THEY ARE CALLING INTERNAL TRANSMISSION FAILURE. *TR

MY WIFE HAD JUST LEFT WORK. ON A VERY BUSY STREET THE VAN UP AND DIED. RESTARTED IT AND HAD NO POWER TO GET UP TO SPEED. KEPT SHUTTING DOWN. MANAGED TO GET IN TO A PARKING LOT. HAD IT TOWED TO THE DEALERSHIP. AT FIRST WAS TOLD IT WAS THE TRANSMISSION. NOW, THEY SAY IT IS THE PCM. PCM HAS BEEN ON BACK ORDER FOR SOME TIME. FORD SAID IT WAS SHIPPED ON NOV. 13 2013. CALLED THE DEALERSHIP ON THE FOLLOWING FRIDAY AND NO PART. NO WAS TOLD THAT THERE IS AN EVEN LONGER WAIT TIME FOR THE PCM. HAVING A AFTERMARKET PCM INSTALLED. TWO WEEKS WITHOUT OUR VAN IS LONG ENOUGH. HOPE TO HAVE IT BACK ON FRIDAY THE 22ND OF 2013. HAVE TALKED TO FORD CUSTOMER CARE, THEY KNOW THERE IS A PROBLEM. HAVE READ THAT THE SEAL UNDER THE COWLING LETS GO AND WATER WILL DRIP DOWN ONTO THE PCM CONNECTION AND MESS UP THE PCM. *TR

I HAVE A 2005 FORD FREESTAR THAT I HAVE HAD FOR 2 LONG LONG YEARS. I AM ON MY 3RD TRANSMISSION, I HAVE HAD THE RECALL WORK DONE TO IT FOR THE TORQUE CONVERTER BUT ITS NOT THE ISSUE. ITS THE TRANSMISSION. I DON'T HAVE TIME NOR MONEY TO KEEP PUTTING INTO THIS CAR AND WORK TWO JOBS AS IT IS AND I NEED A CAR. JUST CANT DO IT ANYMORE AND I KNOW A LOT OF OTHERS WHO ARE HAVING TO GO THREW THE SAME THING AND ALSO SO TIRED OF BEING STRANDED ON THE SIDE OF THE ROAD. PLEASE JUST FIX IT ALREADY. I AM GOING TO FILE A LAW SUITE AGAINST THEM SOON. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THERE WAS A LOSS OF POWER STEERING WITHOUT WARNING. THE STEERING WHEEL BECAME EXTREMELY DIFFICULT TO TURN. IN ADDITION, THE POWER STEERING FLUID CONTINUOUSLY LEAKED ONTO THE GROUND EVEN THOUGH THE CONTACT REFILLED THE RESERVOIR CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 131,000.

WHILE CHANGING THE RIGHT FRONT TIRE THE JACK BROKE AND THE CAR DROP TO THE GROUND! THE JACK BENT AND BROKE. *TR

ENGINE, INTERNAL CATALYTIC CONVERTER FAILURE. ON FORD EXTENDED WARRANTY TO 10 YEARS, OR 112,00 MILES; THE REPAIR IS NOT COVERED WITHIN THE WARRANTY . . QUOTED COST TO REPAIR WILL BE $3,300.00, WHEN COMPLETED BY [XXX]-HILLTOP-FORD IN RICHMOND, CALIFORNIA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

MY FREESTAR WAS RECALLED FOR A PROBLEM WITH THE TORQUE CONVERTER,( MY VEHICLE NEVER REALLY HAD GOOD PICK-UP) ANYWAY THE TRANS WENT AND A FORD DEALER IN NY STATE (WATKINS GLEN) REPAIRED IT IT STILL DIDNT HAVE ANY PICK -UP NOW ABOUT 1.5 YEARS LATER IM HAVING SAME PROBLEM MY VANS BEEN SITTING NOW FOR A YEAR COULD THEY HAVE INSTALLED ANOTHER FAULTY TORQUE CONVERTER? WHAT CAN I DO?08

I HAD THE TORQUE CONVERTER RECALL WORK DONE ON MY VAN, SINCE THEN PROBLEMS IN FORWARD MOTION BEGAN TO HAPPEN. I HAVE TAKEN THE VAN TO THE DEALERSHIP TO FIND OUT WHAT WAS WRONG AND EVERY TIME WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM SO IT COULD BE FIXED. THE PROBLEM CONTINUED TO BECOME WORSE TO THE POINT IT BECAME A DANGER TO DRIVE BECAUSE OF LOSS OF FORWARD MOTION. I HAD NO CHOICE BUT TO TAKE IT TO A TRANSMISSION SHOP THAT DUPLICATED THE PROBLEM AND ALSO RECEIVED A CODE . I INSTRUCTED THE TRANSMISSION BE INSPECTED AND FOUND CONTAMINATION OF METALLIC MATERIAL IN THE TRANSMISSION. I CALLED EVERY ONE AT THE DEALERSHIP AND FORD TO FIND OUT WHY THE TRANSMISSION FILTER WAS NOT REPLACED WHEN THE RECALL WORK WAS DONE AND WAS TOLD FORD DID NOT INCLUDE REPLACING THE FILTER EVEN WHEN THE RECALL WAS BECAUSE OF IMPROPERLY HARDENED PART. NO HELP. *TR

USING AN ON RAMP FROM S.R. 87 SOUTH TO HIGHWAY 98 WEST IN NAVARRE FL. AND SUDDENLY LOST THE VEHICLE DRIVE TRAIN. I WAS ABLE TO COAST OUT OF TRAFFIC TO SAFETY TO AWAIT TOWING. *TR

I HAVE HAD TWO INCIDENTS WITH THIS VAN. THE FIRST INCIDENT I WAS DRIVING AND HEARD A CLICKING SOUND AND THEN LOST ALL POWER TO MY VEHICLE. I CALLED A TOW TRUCK AND TOOK IT TO A MECHANIC WHO SAID IT WAS THE TRANSMISSION WHICH HAD SHAVINGS FROM MY TORQUE CONVERTER OF MY VAN. HE STATED THAT HE HAD FIXED TRANSMISSION AND TORQUE CONVERTER IN FORD 2005 FREESTARS VEHICLES. THIS WAS IN MARCH 2012. I HAD IT FIXED WITH AN EXPENSES OF 1, 985, BUT AFTER CHECKING ON FREESTARS IT WAS IN THE PROCESS OF BEING EVALUATED. I COULD NOT WAIT FOR THE RESOLVING OF THIS BY FORD. I FIXED MY VEHICLE AND ASSUMED THE COST. I RECEIVED A RECALL NOTICE FOR THE TORQUE CONVERTER/TRANSMISSION. I ALSO RECEIVED A RECALL FOR THE BACK SEAT. BEFORE I HAD A CHANCE TO TAKE IT IN FOR REPAIRS. ON, JULY 30, 2013 WHILE DRIVING ON THE HIGHWAY TO WORK MY VAN WENT FROM 65 TO 20 WITHIN A MATTER OF SECONDS. I PLACED MY HAZARDS AND LOOKED FOR THE ACCESS ROAD. I THEN DROVE MY VAN INTO THE NEAREST DEALER. I TOLD THE DEALER REP THAT THE SYMBOL INDICATED THAT MY POWER TRAIN WAS HAVING PROBLEMS HE OFFERED TO DO A DIAGNOSTIC FOR $106. I AGREED AND MENTIONED THE RECALLS. WHEN I RECEIVED THE DIAGNOSTIC RESULTS STATING THAT THE FUEL PUMP, THE EG VALVE, AND THE FUEL RAIL PRESSURE SENSOR NEEDED TO BE REPLACED. *TR

THE SITUATION IS VERY DANGER, THE PROBLEM WITH THE PCM ISSUES, THAT SHARE BAD INFORMATION WITH ANY OTHER COMPONENT IN USE, ENGINE, TRANSMISSION, LIGHTS, AC SYSTEM, LOW BATTERY OR NOT TURN ON EVEN WITH NEW BATTERY, AND THE WIRES AND CONNECTORS CLEAN. THE MOST DANGEROUS IS JUST STOP RUNNING IN MIDDLE OF TRAFFIC, OR SOME MECHANIC DID NOT HAVE IDEA ABOUT THE PROBLEM, EVEN THE SARASOTA FORD MECHANICS. A FEW WEEKS A GO I LEFT THE CAR FOR 2 DAYS, PRESENT IN MY OPINION TRANSMISSION MAL-FUNCTION, AFTER THEY CHARGE ME $140, NO PROBLEMS SOLVED, AND THEY SAY THE TECHNICIAN REPORT : NEEDS ENGINE WORK BEFORE TRANSMISSION DIAGNOSTICS. NEEDS CAM SYNCRO ASSY.(FIX WHINNING NOISE) I AGREE OK. NEED A SENSOR ASY ??????? CONNECT A LITTLE METAL WIRE ON TOP ENGINE (THEY CALL BUSH.....???) AFTER THAT ALL THE PROBLEMS STILL HAPPENING ALL THE TIME. IF YOU HAVE ANY ANSWER ABOUT ALL THIS, OR PLACE TO GO AND GET A REAL INSPECTION AND REPORT. FROM NOW AND FOREVER, THANK YOU VERY MUCH. *TR

IN THE MORNING THE VEHICLE BATTERY HAD BEEN DRAINED AND WE HAD IT TOWED TO THE DEALER. THEY REPLACED THE ALTERNATOR. WE PICKED IT UP AND THE CHECK ENGINE LIGHT CAME ON. THEY SAID IT WAS THE MASS AIR FLOW SENSOR AND REPLACED IT. TWO WEEKS WENT BY AND ONE DAY THE VEHICLE WOULDN'T START. WE HAD IT TOWED TO THE DEALER AND THEY SAID IT WAS THE MASS AIR FLOW CONNECTOR AND REPLACED IT. THE NEXT DAY THE VEHICLE WOULDN'T START. WE HAD IT TOWED TO THE DEALER AND THEY SAID NOTHING WAS WRONG. THE ENGINE ALWAYS IDLES VERY ROUGH AND NO ONE CAN CORRECT IT. IT HAS STALLED IN TRAFFIC. I HAVE DONE RESEARCH AND HAVE BEEN MADE AWARE OF A PROBLEM WITH THE PCM MODULE ON THESE VEHICLES. APPARENTLY RAIN GETS IT AND SOAKS THE MODULE CAUSING ALL SORTS OF ELECTRICAL AND TRANSMISSION PROBLEMS. FORD IS AWARE OF THE ISSUE AND HAS ISSUED A SERVICE BULLETIN AND REPAIR KIT FOR THIS PROBLEM, BUT NO RECALL. *TR

WHILE DRIVING THROUGH TOWN AT 30 MILES PER HOUR, ENGINE STALLED, LOST POWER STEERING AND SPEED CONTROL. THE ENGINE LIGHT CAME ON AND THE TRANSAXLE LIGHT WAS BLINKING. THANK GOODNESS I WASN'T ON THE HIGHWAY. *TR I BELIEVE ONE BAD PART HAD BEEN REPLACE WITH ANOTHER AS THE TORQUE CONVERTER PART HAD BEEN REPLACED AND HERE IT WAS DOING THE SAME THING ALL OVER AGAIN LESS THAN 1 YEAR LATER. I FIGURED I HAD NO OPTIONS, WHAT COULD I DO, HAD IT TOWED. I JUST FEEL IF THEY ARE USING INADEQUATE PARTS TO REPLACE BAD PARTS THE DANGER CONTINUES TO APPLY AND THEY SHOULD BE HELD ACCOUNTABLE. *TR

WAS IN A 30 MILE PER HOUR SPEED ZONE CAME TO A CAUTION LIGHT AND HAD TO MAKE A RIGHT HAND TURN ON A VERY DANGEROUS CORNER....MANY TRACTOR TRAILERS USE THIS TURN, WHILE MAKING THE TURN, ENGINE STALLED AND WAS HARD TO CONTROL STEERING WITH NO POWER. MANAGED TO PULL TO SIDE OF THE ROAD WHEN SEVERAL TRACTOR TRAILERS CAME AROUND THE SAME CORNER. HAD I NOT BEEN ABLE TO MOVE OVER I WOULD HAVE BEEN HIT AS THEY WOULD HAVE HAD NO WHERE TO GO, JUST A 2 LANE ROAD. CAR STARTED BUT WHEN I TRIED TO MOVE IT, IT WENT ABOUT 20 FEET AND STALLED AGAIN. HAD TO CALL A TOW COMPANY. TORQUE CONVERTER HAS ALREADY BEEN REPLACED ONCE AT APPROXIMATELY 99,900 MILES. FLASHING LIGHT ON DASH SAYS TO CHECK TRANSAXLE. NOT FIXED AS YET...CODE P0715 CAME UP ON THE TECH MACHINE, TURBINE SPEED SENSOR CHECK FAULT. I HAVE CHECKED FOR THESE CODES AND IT SEEMS THAT FORD SENT THESE VEHICLES OFF THE PRODUCTION LINES WITH THESE PROBLEMS TO BEGIN WITH. I FIND THAT NOTHING EVER GETS DONE UNTIL SOMEONE IS KILLED OR SEVERELY INJURED. IT'S A SAD WORLD WE LIVE IN THAT LIFE HAS TO BE LOST BEFORE MANUFACTURERS ARE MADE TO CORRECT WHAT SHOULD HAVE BEEN FIXED BEFORE LEAVING THE PLANT. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE EXITING THE DRIVEWAY AT UNKNOWN SPEEDS, THE ODOMETER FAILED TO TRACK SPEED AND THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE SPEED SENSOR AND BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE PROBLEM PERSISTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 57,000.

WHILE TRAVELING ON THE HIGHWAY WITH NO WARNING THE VEHICLE LOST ALL ACCELERATION. ONCE ABLE TO GET TO A SAFE AREA TO PULL OVER THE VEHICLE STARTED TO RESPOND. SINCE THIS OCCURRENCE THIS SITUATION HAS HAPPENED INTERMITTENTLY FOR THE PAST YEAR. I HAVE BROUGHT THE VEHICLE TO THE FORD DEALER AND 2 DIFFERENT MECHANICS, ALL OF WHOM HAVE CHANGED MANY DIFFERENT ITEMS RANGING FROM A TUNE UP TO A NEW COIL AND MULTIPLE CAM SHAFT SENSORS. ALL 3 HAVE PERFORMED MANY DIAGNOSTICS BUT TO DATE HAVE BEEN UNABLE TO LOCATE THE PROBLEM WHICH STILL EXISTS BUT WITH MORE REGULARITY. I AM NO LONGER ABLE TO DRIVE THE VEHICLE DUE TO ITS PERFORMANCE AND I AM SCARED TO PUT MY WIFE AND CHILDREN IN THE VEHICLE. WHEN I DID DO SOME RESEARCH ON THE INTERNET I CAME ACROSS HUNDREDS IF NOT THOUSANDS OF THE VERY SAME COMPLAINTS, SOMEONE HAS TO FORCE FORD TO ADDRESS THIS SAFETY ISSUE. MINI VANS ARE MOST COMMONLY USED FOR TRANSPORTING OUR MOST PRECIOUS PASSENGERS, CHILDREN. WILL IT TAKE A CAR FULL OF CHILDREN DYING FOR FORD TO ACKNOWLEDGE THIS PROBLEM EXISTS AND THAT THEY NEED TO DO THE RIGHT THING. *TR

I WAS DRIVING ON A CITY STREET WHEN MY ENGINE LIGHT BEGAN FLASHING/BLINKING. I WAS HAVING TROUBLE WITH VAN MAKING WEIRD SOUNDS AND VIBRATIONS. I IMMEDIATELY PULLED OVER. JUST HAD TRANNY RECALL WORK DONE, SAME LIGHT ON. I CALLED FORD-THEY SAID IT WAS A MISS AND I SHOULD BRING IT IN. I WAS TOO AFRAID TO DRIVE THAT FAR, AND I HAVE NO $ FOR A TOW OR FIX. WAS TOLD BY MECH FRIEND THAT IT COULD BE ANY OF MANY SENSORS AND I'D HAVE TO TRIAL AND ERROR TO FIND IT. THIS IS NOT THE FIRST TIME THIS HAS HAPPENED TO ME, AND IT SEEMS TO BE WORSE WHEN IT HAS RAINED OR IS VERY DAMP OUT. IT VIBRATES, SHAKES, AND SOUNDS LIKE THE ENGINE IS NOT RIGHT. ALSO I HAVE NO GET UP AND GO, IT WANTS TO STALL OUT EVERY TIME I TRY TO ACCELERATE, AND I HAD A NEAR ACCIDENT ONCE. SEEMS TO BE WORSE ON HILLS OR ANY INCLINES. NOT A HAPPY FORD CUSTOMER-AGAIN. THESE PROBLEMS HAVE BEEN ON-GOING FOR THE LAST SIX MONTHS OR SO. ANYTHING OVER 25MPH AND THE VAN "SHIMMIES" REALLY BAD. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 12V006000 (POWER TRAIN). HOWEVER, AFTER THE REPAIR WAS PERFORMED THE VEHICLE WOULD NOT ACCELERATE AND STALLED SPORADICALLY. THE CONTACT STATED THAT PRIOR TO THE RECALL REPAIR HE HAD NOT EXPERIENCED A FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN FOUND THAT THE PCM WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 79,000. *TR

AFTER RAIN ALL NIGHT ON WED.6/4/2013 WENT TO TAKE VAN TO PITTSBURGH STARTED HESITATING AND VIBRATING WHILE ON HIGHWAY COULD NOT SPEED UP AND TRIED TO GET IN SLOW LANE LOT OF TRAFFIC ALMOST COLLISION . TRIED TO GO UP SMALL HILL NO POWER VIBRATING TRYING TO STALL, TURNED OFF WOULDN'T STARTFOR 15 MINUTES VERY SCARY. LOOKED ONLINE BULLETIN FOR PCM GETS WET AND CAUSES THIS,SOMEONE COULD HAVE BEEN KILLED. *TR

I BOUGHT MY 2005 FORD FREESTAR IN 2005. ALMOST IMMEDIATELY AFTER BUYING IT WE HAD INSTANCES OF THE POWER LOCKS NOT WORKING. THE DRIVER DOOR WILL UNLOCK BUT THE REST WILL NOT. WE HAVE EVEN HAD TO CLIMB IN THROUGH THE DRIVER DOOR TO UNLOCK THE BACK DOORS BY HAND THEN TRY TO GET GROCERIES OUT OF THE WAY BACK THROUGH THE MIDDLE DOORS. THIS IS ALSO A HUGE SAFETY CONCERN FOR ME. IF I WERE TO GET INTO AN ACCIDENT AND BE INCAPACITATED AND MY KIDS WERE IN THE CAR, THEY WOULDN'T BE ABLE TO OPEN THOSE DOORS BECAUSE IT KEEPS THEM LOCKED EVEN IF YOU PUSH THE BUTTONS TO OPEN THEM AUTOMATICALLY. I AM SICK OF DEALING WITH THIS ISSUE. THERE ARE SO MANY FORUMS ON LINE WHERE OTHER PEOPLE HAVE THE SAME PROBLEM. THIS NEEDS TO BE FIXED! *TR

I BECAME AWARE OF OTHER CUSTOMER COMPLAINTS ABOUT THE TRANSMISSION/PCM RELATED CONCERNS IN 2011 WHEN EXPERIENCING A VIBRATION WHEN SHIFTING FROM 2ND TO 3RD (IT SEEMED) AND RESEARCHED MY VEHICLE AND POSSIBLE RELATED CONCERNS. I ALSO DISCUSSED WITH A LOCAL DEALER AND I FOLLOWED A DEALERS RECOMMENDATION BY HAVING MY TRANSMISSION FLUID CHANGED AS RECOMMENDED TO FORD SPECS. THE VIBRATION SEEMED TO CALM SOMEWHAT. AROUND THIS SAME TIME I NOTICED MY CRUISE CONTROL WOULD WORK ONLY OFF AND ON AT DIFFERENT SPEEDS AND TIMES. NO CHECK ENGINE LIGHT EVER CAME ON. I SENT MY AN EMAIL TO FORD OF CANADA AT WHICH TIME I WAS ADVISED THAT A TORQUE CONVERTER RECALL WAS COMING AND THAT I SHOULD CONTACT THE DEALER. I WAS ADVISED TO WAIT FOR THE FORMAL RECALL WHICH I RECEIVED AND BOOKED MY RECALL AND IT WAS COMPLETED IN APPROXIMATELY LATE 2012. I ALSO HAD ANOTHER RECALL DONE FOR A SEAT CONCERN JUST IN MAY 2013. WHILE DRIVING TO THE US MAY 19TH 2013 AT 100KM/HR MY VEHICLES CRUISE WAS ACTING SUSPICIOUS (HARD SHIFT UP) AND I DISENGAGED IT FOR THIS REASON. I THEN NOTICED MY VEHICLE WAS AT 3000RPMS SO SEEMED TO BE STUCK IN 3RD GEAR OR SOMETHING. IT THEN FAILED (WAS LIKE I WAS IN NEUTRAL) AND I WAS BARELY ABLE TO GET OFF AT AN EXIT AND HAD TO PUSH MY VEHICLE INTO A SPOT AT A SERVICE STATION. I WAS VERY CONCERNED FOR MY SAFETY AND MY FAMILY AT THIS TIME. I WAS IN TOTAL SHOCK THAT THERE WAS NO REAL WARNING AND IF I KNOW IF I WAS IN THE FAST LANE I HATE TO THINK OF THE END RESULT. I CHECKED THE DIPSTICK FOR THE TRANNY AND THERE SEEMED TO BE ENOUGH FLUID HOWEVER SLIGHT AMOUNTS OF SMOKE CAME FROM THE DIPSTICK RESERVOIR. NO SIGNS OF LEAKING BELOW THE VEHICLE WHATSOEVER. IT WAS TOWED TO A FORD DEALER AND I WAS LEFT WITH NO REAL OPTION OTHER THAN REPLACE THE TRANNY FOR $3200. MY HOME DEALER IN CANADA WAS CLOSED FOR THE HOLIDAY. *TR

TL* THE CONTACT OWNS A 2005 FORD FREESTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE TRANSMISSION AND TORQUE CONVERTER WOULD HAVE TO BE REPLACED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 12V006000 (POWER TRAIN) BUT WAS ADVISED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 66,000. *TR

ENGINE LIGHT CAME ON CAR STALLED SEVERAL TIMES, WOULD NOT SHIFT. YOU PEOPLE KNOW WHAT THE PROBLEM IS FIX IT OR I WILL GO BUY SOMETHING OTHER THAN A FORD. I TOOK IT TO A FORD DEALERSHIP SERVICE AND FOUND OUT THAT WATER GOT INTO THE PMC MODULE AND TERMINALS WERE CORRODED. MECHANIC BLOW DRIED INTERIOR OF PMC BEST HE COULD SILICON TO SEAL THE BEST HE COULD AND TOLD ME IT WAS A TEMPORARY FIX. WATER KEEPS GETTING INTO THE MODULE. WHY DOESN'T FORD STAND BEHIND THEIR MISTAKES AND RESOLVE THE PROBLEM? I LOVE MY FREESTAR BUT WHY SHOULD I PAY FOR THE MANUFACTURE ENGINEERING MISTAKES? *TR