2019 Ford Fusion Complaint Log

Recall. Told to not charge our Ford Fusion Rechargeable Hybrid for fear of a fire! No solution now for 6 months. Told to run gas engine only. Car was not designed to be used this way which is a safety hazard in itself. Filed for gas card 5 months ago, no gas card issued. My spouse is an active nurse and Christian community activist. She relies on this vehicle. If we do not have some action from Ford in another 30 days, we will be forced to file for an Arizona Lemon Law replacement.

The contact owns a 2019 Ford Fusion. The contact stated while parking the vehicle, the contact shifted to drive(D) to reverse(R) and the “System Fault – Service Required” message was displayed. The contact stated that the vehicle failed to drive or reverse as needed. The vehicle was towed to the dealer to be diagnosed and the contact was informed that the shifter cable bushing was missing, and that the vehicle had experienced the failure listed in NHTSA Campaign Number: 22V413000 (Power Train) however, the VIN was not included. The vehicle was repaired. The manufacturer was contacted, and a case was filed but no assistance was provided. The failure mileage was 70,945. The contact stated the dealer replaced the shift cable bushing and transmission shifter cable bushing. Also, installed a protective cap.

The contact owns a 2019 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000(Electrical System) however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure causing the check engine light to illuminate, the vehicle to lose power, and rough starts. The failure mileage was 45,000. The VIN tool confirms parts not available.

This recall has been going on for months. Ford gives me the run around with apparently no solution

Recall 23V-440. Recall from June 2023 still not fixed. No answers from Ford

The electrical system constantly discharges the battery. If the car is not started at least every three days, the battery discharges and must be taken to Ford to have the battery replaced. Ford customer service and the dealer know about this and have taken the position that as a customer I must go start the car because Ford cannot fix the problem, Unknown why they cannot fix it. To start the car every three days is very difficult for me because I am disabled and must climb stairs and walk to the street to manually start the car. Ford suggested using the remote start feature of furnished with the car by Ford. The remote start works but it is limited to remote starting the car two times and then you must go to the car and manually start the car. If I am unable to get to the car in time to start it, the battery goes dead and I cannot use my car in case of an emergency. Ford has been made aware of this, Ford says they agree it is a problem but that Ford Engineers won't remove the two start limit. Ford will not say why there is a two start limit. This could be fixed (limit removed) by just updating the software. Ford does not respond anymore when I ask them about it.

The contact owns a 2019 Ford Fusion. The contact stated while his daughter was driving approximately 40-45 MPH, the check engine warning light illuminated, and the vehicle went into LIMP mode. The contact stated that the vehicle failed to exceed 5 MPH. The contact's daughter pulled into a parking lot. The contact stated that he used an OBD reader to determine that cylinder #2 was misfiring. The vehicle was taken to the Chevrolet dealer where it was purchased, and was diagnosed with coolant intrusion into the engine, causing cylinder #2 to misfire. The contact was informed that the engine needed to be replaced. The vehicle was taken to a Ford dealer, where the diagnostic result was confirmed. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 21N12. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 84,717.

Last year on or about May or June 2023, I received a Safety Recall 23S33 from Ford. I had experienced a similar recall with my 2018 Chrysler Pacifica PHEV. Up until the time a fix was identified, Chrysler offered monthly debit cards of $200 to compensate for additional expense of gasoline that would not have been incurred but for the recall. Later, Chrysler offered reimbursement for the the additional expense of a rental vehicle. The only benefit or compensation for the inconvenience and expense of not being able to charge my 2019 Ford Fusion PHEV is a single $200 debit card sent during the holiday season in late 2023. I have called Ford asking the status of a fix as well as any customer benefit available for this recall for which I was told my Ford there was none. This month will be one full year since the recall and Ford has failed to 1) provide periodic updates on the status of a fix, 2) provided any customer benefit such as debit cards, rental car reimbursement, or buy back benefit. I am extremely concerned that if the NHTSA does not immediately sanction or fine Ford for - at best - poor customer service or - at worst - negligent business practices, the result will be little to no incentive for automobile manufacturers to promptly rectify defective parts in their vehicles or, even worse, little to no incentive to avoid manufacturing vehicles with a foreseeable risk of serious defects. Given almost an entire year since the recall, I strongly advocate that the NHTSA take immediate and meaningful action on behalf of impacted Ford customers to require Ford to provide cash compensation (debit cards), reimbursement (for alternative car rental), or customer friendly buy-back options for those subject to the recall since May 2023.

May 16, 2023-check engine light activated reading code P0302 Cylinder 2 misfire May 27, 2023-warning light appeared reading engine overheating, and the car would not start. May 27, 2023-took it to the dealership and they advised me I had an internal engine coolant leak and that I needed to replace the short block and head gasket. I was quoted $7600! After doing some research I discovered it is an unaddressed recall from Ford and that NHTSA issued Bulletin# 21N12. Letters went out June 20, 2022 for a one-time no cost repair. The program ended five months later on November 30,2022. I never received the letter. I called Ford Customer service and they stated they cannot cover the repairs because I'm past the November 30, 2022 deadline.

I have a 2019 Ford Fusion Titanium that I just recently sold to my son. I purchased the car used from a dealership in January of 2020. In October of 2021the flexplate went out and was replaced under the manufacturer warranty. The part went out again in May of 2023 and since the car had been totaled out due to a hail storm I have been told the manufacturer warranty is no longer valid. I have been able to find that there was a bad batch of replacement parts that may have found its way into several vehicles that have experienced this same problem. When Ford replaced the flexplate it was only the flexplate that was replaced. I was required to replace the flexplate, the front fluid pump assembly and the torque converter when I had to have it fixed again. I believe that if Ford has updated this recall it is due to them knowing that either the parts used in the original repair were defective and they don't know which ones it was; or, they now know that the original fix should have included the front fluid pump assembly as well as the torque converter. I believe that either way I should at least be able to ask for Ford to cover the cost of the parts under this second repair in less than two years on the same issue. The parts that I had put on now are guaranteed for two years, why is that? The labor should be at a discounted rate as well. It is my hope that you will investigate this or look at your database to see how many other customers are experiencing the same issue.

The contact owns a 2019 Ford Fusion. The contact stated that while reversing, the rearview camera image was blue. Additionally, the infotainment system screen was blue. The vehicle was taken to the dealer where it was diagnosed and determined that the APIM had failed and needed to be replaced. The vehicle was being repaired. The manufacturer was notified of the of the failure, but no assistance was provided. The failure mileage was approximately 23,500.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the engine overheated. While starting the vehicle, the vehicle was shaking abnormally. The engine coolant temperature was elevated, and the vehicle stalled. The vehicle was taken to the local dealer, where it was diagnosed and determined that there was coolant intrusion into the engine and that the coolant was leaking into the cylinder. The vehicle was not repaired. The vehicle was taken to another local dealer, Kerry Chevrolet (7500 Alexandria Pike, Alexandria, KY 41001) where it was determined that there was a coolant intrusion into the cylinders. The vehicle was not repaired. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case, but no additional assistance was provided. The failure mileage was approximately 75,000.

The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle hesitated to start. Additionally, the contact stated that the vehicle hesitated to respond while depressing the accelerator pedal. The check engine warning light was illuminated. The contact stated that the failure reoccurred while driving at various speeds and depressing the accelerator pedal. The dealer was contacted and informed the contact that they could not assist as the VIN was not included in a recall. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 92,770.

Pedestrian detection system malfunction. Sync 3 system APIM unit is going out and needs replacing (only at 58k miles, 10k out of warranty). Passenger front seat heater and climate control failed due to seat heater melting wiring harness.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle made abnormal sounds. Additionally, the check engine warning light was illuminated along with several unknown misfire codes. The vehicle was taken to the dealer, who informed the contact that the engine needed to be replaced due to coolant leaking into cylinder #4. The contact related the failure to Technical Service Bulletin: 19-2375 (EcoBoost). The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 104,195.

check engine code for anti knock sensor. Dealer unable to fix after 4 attempts and car spending > 30 days in service in less than 6 months. Car sold to dealer and I hope they don't sell to an unsuspecting buyer.

Coolant Intrusion. Coolant is leaking into the head gasket, causing car to say coolant running hot. Also causes car to lose speed. There was a recall for this same model, a month before my model was built, but clearly the problem was never fixed.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the contact stated that the vehicle was taken to an independent mechanic for routine maintenance where the oil and spark plugs were changed; however, the vehicle was diagnosed and produced code: P0302. The contact was advised to take the vehicle to the dealer. The vehicle was then taken to the dealer where it was diagnosed that the engine needed to be replaced. The technician informed the contact of Customer Satisfaction Program 19B37 and REF: Technical Service Bulletin (TSB) 22-2134. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number. The failure mileage was approximately 90,000.

my transmission is faulty my car is a 2019 Ford Fusion and it has all the same problems as earlier models with recalls that are equipped with the same components as mine my it keeps stalling when I come to a stop which I see numerous complaints of the same thing it there were no warning lights on at the time it occurred I've done research on my own through forums and there are thousands of complaints of the same thing happing to there's there's no way that can be just are luck there has to be something wrong with the way the car is built or made

The contact owns a 2019 Ford Fusion. The contact stated while driving 65 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that coolant was leaking into the engine. The mechanic related the failure to Ford Campaign Number: 21N12. The vehicle was taken to the dealer several times, and the dealer informed the contact that the vehicle could not be repaired under the service campaign as the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 82,100.

The contact owns a 2019 Ford Fusion. The contact stated while driving 25 MPH, the vehicle started overheating with the check engine warning light illuminated. The contact stated that after several minutes, the engine temperature returned to normal, and the vehicle operated normally. On another occasion, while driving 15 MPH, the vehicle would not properly accelerate. The contact became aware that the vehicle was overheating. The contact was able to pull over on the side of the road and turned off the vehicle. The contact checked the coolant level and noticed that there was no coolant in the coolant reservoir. The contact added coolant and the vehicle started operating normally. The vehicle was taken to the dealer and the dealer stated that there was coolant leaking into the engine, and that there were metal shavings inside the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistances was provided. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 79,000.

The contact owns a 2019 Ford Fusion. The contact stated that while the vehicle was idling the contact attempted to accelerate and the vehicle stalled and then inadvertently shifted to reverse. While attempting to correct the failure, the vehicle the failure reoccurred. The instrument panel showed that the vehicle was in reverse. The contact was unable to shift to the intended gear. The contact had the vehicle towed to the dealer who diagnosed that the transmission shift cable bushing failed and needed to be replaced. The vehicle had been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA hotline. The approximate failure mileage was 80,000.

The vehicle had 115,000 miles and was diagnosed with an engine coolant leak which caused the need for the 1.5L Turbo EcoBoost engine to need to be replaced. However, my VIN for some reason unknown to me, was not included in the Engine Coolant Leak recall (21N12). I contacted Ford and was told I would be put in the Customer Satisfaction Program but only to find out the the representative I had spoken with gave me incorrect information and I was not able to be included in that Program. I’ve had to pay for about 2 years now a car payment on a car that has not ran and have been unable to get the car fixed. This needs to be addressed by Ford and taken care of and paid for by Ford in my opinion. I don’t know why my vehicle wasn’t included in this recall but clearly there were many more vehicles with this problem and a lot of customers are probably suffering as I am, still stuck paying for a vehicle that I cannot afford to get the engine replaced in. Shame on FORD!

The contact owns a 2019 Ford Fusion. The contact stated while attempting to start the vehicle, the vehicle misfired and jerked. The contact took the vehicle to the dealer who diagnosed and determined that coolant was leaking into the cylinders causing the misfire. The dealer confirmed that the failure was related to service bulletin with NHTSA ID Number: 10214126 (Engine and Engine Cooling) however, the VIN was not included. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 84,000.

Vehicle stopped accelerating, heard pop in vehicle behind me, all lite dash symbols flash and displayed message, stop vehicle safely now. Next morning, turn on vehicle to place into neutral to load onto tow truck to take to dealer, kept going back to park, while pulling vehicle onto tow truck, cabin filled with smoke, opened trunk, filling with smoke and then call 911 and fire dept extinguished fire. Have fire report, video and photos. Opened case number with Ford, been over a month and they state it is with the office of general council, unable to make contact with that dept. and customer service at Ford states they can not talk to me besides note i call. It is case number CAS-40994553-Q9P8R4

While I drive my steering got stuck and stiffed. Hard to turn the wheels. Luckily when I entered my neighborhood stop the vehicle. Then I got the message from Ford Pass app saying *Electronic power steering control module fault and *collision warning system lost radar signal. If the steering stuck happened in highways while drive possibly life threatening issue

While driving to work on I35 the a red message popped up on the dash saying "Stop Safely Now" and the engine/hybrid motor instantly completely died. Steering and breaking were almost impossible because I am not a strong person and I was nearly rear ended several times. I had no chance to get to the shoulder and was blocking the lane in the middle of traffic till I was able to get someone to tow it to a side street. Completely unacceptable and very dangerous for the car to die completely like this.

The contact owns a 2019 Ford Fusion. The contact stated that while driving approximately 50 MPH, the vehicle was jerking. There was o warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the torque converter needed to be replaced. The contact was made aware that the VIN was not included in NHTSA Campaign Number: 17V427000 (Power Train). The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 78,000.

Unknown, I have had to refill my antifreeze 2 times in one month. Took it to the mechanic and they believe that the problem is with the gasket leading to the engine.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was taken to the dealer, where the contact was informed that coolant was leaking into cylinder #4 and that the engine needed to be replaced. The contact related the failure to Technical Service Bulletin: 19-2208 (Coolant in Cylinders). The manufacturer was made aware of the failure. The failure mileage was 71,353.

My vehicle had a recall opened nearly a year ago. The recall is 23S33 PHEV BATTERY CELL DEGRADATION. I had taken my car into the dealership nearly a dozen times over the course of almost 2 years prior to the recall being announced. I was told not to charge a car that I bought for that specific purpose. Initially a solution was posted of replacing the battery which was then removed. So there very much is a remedy available, they just don't want to pay the cost to provide that remedy. I am attaching a saved image of the recall from ford's website that under remedy specifically states what the remedy is. The longer they wait the less of these vehicles will be on the road due to accidents and such. So the longer they delay the less they have to spend to solve the issue. Meanwhile customers are not only unable to charge a vehicle that we bought for that purpose, but are driving a car Ford has admitted is dangerous. As it's a hybrid electric the battery is still being used everytime we drive the car.

I have 69,400 miles on my car. Last week, out of no where, the engine started shaking and clicking very loud. The repair shop said the flex plate is cracked and it’s a common issue with Ford. I went to the dealership and they even said it happens all the time. This is nearly a $2000 job. Why isn’t there a recall?!

*Upon check engine light, oriellys advised of misfire on p0301- installed following day due to part shipping to store. Day after coil ignition and spark plug replacement, engine light came back on which mechanic said not to worry as long as car isnt shaking. The following day after taking kids to school, the battery died at the school. With only the check engine light on I waited 10 minutes and the car started. On my way home on the highway, the car just stalled in the middle of the highway. There was a brief alarm stating coolant temperature high turn off car. Several dealerships advised soonest availability was December. I needed my car asap. I had it towed to pepboys who did a full diagnostic and provided documentation saying I'd need a new engine. 78250 miles, premium gas, annual premium treatment at oil changes with royal purple, schedule a tuneup with diagnostic, new tires, wash tub monthly cleans. I treat my car better than I do my kids. I called ford and asked about warranty info which they advised the only way to see if warranty covers it is to have a certified dealership diagnostic. After searching for days, I finally got one to do the diagnostic and said there is an issue with the coolant destroying the engine. How was your safety or the safety of others put at risk? *Extremely dangerous with car stalled in middle of highway. Has the problem been reproduced or confirmed by a dealer or independent service center? *yes Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? *Ford Dealership servicer and third party service shop Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Engine light was addressed promptly and coolant error message showed up once ever when the car abruptly stalled in the middle of highspeed traffic Ford refused to help after escalation attempt to have them pay for faulty product or lemon buyback

The engine keeps cracking which leads to the coolant mixing with the oil. Eventually it causes the head gasket to blow.

I routinely take my car to get oil changes and check for any other problems. So 2 days after getting my oil changed at a dealership my car began to overheat which shouldn’t have happened because when I got my oil changed they filled the liquids to proper levels. So I added antifreeze because my reservoir was empty once cooled I opened my reservoir and antifreeze began to come back up to the proper level. After getting it home that same thing happened and haven’t moved it since. Now my car shakes and the overheating light stays on. There is no visible leak and I don’t know where the antifreeze goes. My car is only about 3 years old and I don’t believe this should be happening. I take good care of my car routine check ups and oil changes. After doing some research online I’ve seen so many people with my same car reporting the same issue. I believe this problem has been recalled in older years (2014-2016) unsure of exact years but I believe it wasn’t fixed and now has cause major stress for me because I only have one car. Please look into this because right now I’m out of a car and I don’t know what to do and I am still paying on it and can’t even drive it.

The contact owns a 2019 Ford Fusion. The contact stated while driving approximately 10 MPH and decelerating at a stop light, the vehicle hesitated and stalled. No warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline, but no further assistance was provided. The failure mileage was approximately 28,000.

The contact owns a 2019 Ford Fusion. The contact stated that after refueling the vehicle, the vehicle failed to start up immediately. The contact stated that several attempts were made to restart the vehicle, but the engine failed to turn over. The contact stated that the vehicle started after approximately five minutes with the check engine warning light illuminated. The vehicle was taken to Midas where it was diagnosed that the cannister purge valve needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and the contact was directed to call the NHTSA Hotline. The failure mileage was approximately 56,000.

Last year my car started overheating for no apparent reason checked coolant reservoir and visibly seemed empty but when I removed the cap antifreeze rose fast. Added antifreeze and it stopped overheating. About 3 months ago Because it overheated I had to get the head gasket replaced, timing components replaced, heads repaired, and engine flushed(antifreeze had entered engine), not to mention labor all costing roughly $3,000. Only for it to happen again and now I’m out of $3,000 because the same thing is happen only this time my car is shaking and smoking from the tail pipe badly. In the mean time my fiancé has lost his job due to us not being able to drive the car. After doing god knows how much research to find out this is an ongoing problem with this particular make of car. Because of having to pay for countless repairs and no one seeming to know what’s going on with my car I am now behind on bills and still without a car that is only 4 years old. I haven’t done any long driving to other states beside neighbors states that are about 2-3 hours away but that shouldn’t matter because it’s a new car I shouldn’t have any problems driving it wherever. I purchased this car at a lil over 30k miles my problems started at about 61k miles which is odd since the manufacturer warranty had just expired about 1k miles before that. I believed in ford for the longest and now I am regretting ever buying one. My very first car purchase from a lot and it turns out to be the worst car I’ve ever purchased. I’m sure me typing all of this probably won’t get read or even looked into but this is an experience I wouldn’t dare want anyone else to go through so I’m sure to leave many reviews but I thought you should know. Also because of the over heating my car has cut off at times where my life could have been taken (at lights and intersections) have a good day!

2019 Ford Fusion SE. Car kept stalling and running hot. I took it in and there’s coolant in the cylinders, which means new engine. Haven’t had the car a year and a half. Chevy sent me to Ford, Ford wants my extended warranty to pay for it. If it does, I’ll be capped off and still have to come up with $1000!!

The contact owns a 2019 Ford Focus. The contact stated that the vehicle was taken in for an annual inspection but failed due to the lug nuts. The contact was informed by the technician that the lug nuts needed to be replaced with aftermarket one-piece lug nuts. The vehicle was then taken to the dealer where it was confirmed that the lug nuts needed to be replaced. The vehicle had not yet been repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,000.

My Ford Fussion has a Cracked flex plate. It cracked while I was driving and no service or warning lights turned on.it is currently at dealership waiting for warranty company to approve repairs.

The contact owns a 2019 Ford Fusion. The contact stated while shifting into drive(D), the gear inadvertently shifted back to park(P). The shifter bushing light illuminated. The vehicle was unable to be driven. The vehicle was diagnosed at the residence by an independent mechanic as a shifter cable failure. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle was not included in NHTSA Campaign Number: 22V413000 (Power Train). The approximate failure mileage was 70,000.

2019 Ford Fusion Titanium coolant infusion into cylinder #2. I Took the car to the dealer because the coolant reservoir was always low. I always had to add coolant in a weekly bases but I never notice any leaks. The dealer told me that since there was no check engine lights on it was something normal. I continued to add coolant every now and then. About six(6) months later, the engine stopped. My father came to help and after checking my car told me there was coolant mixing with the motor oil. He asked me if there was a check engine light on or if the car heated up at any moment. No, my car never heated up and there was never a check light on. He towed the car to Tropical Ford, Orlando Fl. The Ford dealer told me I need a new engine and the repair was gonna be $6,261.00 We researched the problem and found the 2014 - 2019 Ford Fusion vehicles equipped with 1.5L or 2.0L Ecoboost engines came with a defect in the engine block and that is why coolant was intruding into the engine cylinders. We found that this is well known issue on this but Ford never told us about it. There are hundreds of complains about this same issue; Coolant infusion into the engine cylinders due to a factory bad block. The Ford Company corrected the factory issue by making a new engine block for the same engine but they refuse to accept responsibility that the original block is in fact, defected. My question to them was; Why would Ford make a new block for the same engine if there was never a factory problem with the original block? The answer is simple. There is a factory problem with the original block and ford knows/knew about it. https://www.carproblemzoo.com/ford/fusion/2019/engine-and-engine-cooling-problems.php https://www.newsom.law/ford-fusion-overheating-lawsuit.html

The electronic parking brake system malfunctioned and is available for inspection upon request. If it was to engage while driving, it can cause an accident risking my life including others on the road. The problem has been confirmed by an independent service center and was also inspected be the independent service center. There were two warning messages prior to the failure and periodically appeared and disappeared. It recurred in the last two days

Not sure what system is causing it but my trunk keeps opening and it’s done it many while I was driving. I understand a lot of other Ford Fusion owners are having the same problem and I urge you to look into the problem as it can cause accidents and deaths.

I bought this vehicle in 2019 and one of the engines cylinders was crack and now I need a new engine and I heard that this a very common problem with this vehicle

A few months ago, I began to notice that my engine would shake a little upon startup but would stop and run normally after a few seconds. This wouldn't happen every time I started my vehicle so I didn't pay much attention to it until my check engine light eventually came on one day after startup. I brought my car to an auto parts shop to have the OBII read and it came up as a misfire in cylinder 4. I contacted my Ford dealer and made an appointment for the following day. Upon taking my car to the dealer, they informed me that my car is leaking coolant into cylinder 4 and that is why it was misfiring. They told me that this was an issue that Ford was aware of but did not have a fix for, aside from replacing the engine. I was told that I could take the car home while they reached out to Ford to see if they were willing to cooperate in taking care of the cost of repair, that the car was safe to drive and was only burning off a tiny bit of coolant when starting. A few weeks went by and one day I was stopped in traffic when my car got another warning on the dash that my engine oil was over temperature. When I was finally able to pull off the road safely, I opened my hood and found that my coolant reservoir was completely empty.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the vehicle while idle. The vehicle then lost motive power. The check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a cracked flywheel. The dealer informed the contact that the flywheel needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000. The VIN was unavailable.

The flywheel apparently broke and messed up the crankshaft as well as the front pump in the transmission. Which in turn caused the transmission to slip out of gear and kill while being operated on a busy interstate requiring a tow home and then to ford service for diagnostics. With repairs totaling in excess of $8000.

The contact owns a 2019 Ford Fusion. The contact stated that while operating the vehicle, there was an abnormal noise coming from under the dashboard. In addition, there was excessive tailpipe smoke along with a strong fuel odor when the vehicle was idled. The vehicle was taken to the local dealer who diagnosed that the engine small block was damaged due to low coolant. As a result, the engine needed to be replaced. The vehicle was not repaired. The contact was informed that the damage was caused due to improper manufacturing of the engine in which two different types of metals were used causing the engine to cool down at different rates. The vehicle was previously serviced under Customer Satisfaction Program: 19B37. The manufacturer was not notified of the failure. The failure mileage was 28,000.