2018 Ford Mustang Complaint Log

While completing a turn at a T-intersection, the vehicle experienced a complete loss of motive power for several seconds, leaving the car stationary in the path of oncoming traffic. The transmission (10R80) failed to engage, a known symptom of internal CDF Drum sleeve failure (TSB 24-2254). This follows a 'Green' inspection by a dealer on March 23rd where an axle seal leak and shifting issues were overlooked. The failure to engage gear during a turn creates an unreasonable risk of a T-bone collision.

I was told by my mechanic I have a head gasket leak. Turns out there is a class action lawsuit for my 2.3 ecoboost motor for this coolant intrusion problem. It is a known problem. It is a safety issue as I’ve heard of some engine fires. My car only has 56000 miles on it but it is a 2018 so just out of the manufacturer warranty. I’ve reached out to Ford but no definitive answer on whether they will help or not they want me to pay them to diagnose it even though I’ve already had it properly diagnosed

A check engine light turned on and the vehicle was taken to a local dealership. The check engine light was for an engine misfire and was diagnosed further. There was an engine failure due to coolant entering the system. Upon further research, I learned this is a common issue for 2016-2020 Ford Mustangs and it is due to a faulty engine design. The dealership is recommending a new engine install with a price tag of over 13,000 despite this being known to happen because of a badly designed engine with these cars.

The vehicle was subjected to the “ecoboom” due to Ford’s lack of care when designing the engine. The car blew the head gasket and now requires an engine rebuild.

The contact owns a 2018 Ford Mustang. The vehicle was taken to the dealer to be repaired under NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION); however, the dealer inspected the rear-view camera, and the camera was found to be functional. However, the contact reported that the camera image was distorted, with a grey raindrop line running across the screen. The dealer was notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 99,858.

Touch screen system has completely stopped turning on (and wont turn on) any time the outside temperature drops below about 70 degrees fahrenheit. Per online research this is a common, known issue and given that this prevents the use of key saftey features such as the backup camera and climate controls I am unsure why this has not yet initiated a safety recall. I have dealt with this for the past 3 winters and can confirm it is 100% in relation to outside temperature. There is no warning lamp/message. The screen will simply not turn on in below 70 degree temperatures. A component to the touch screen must be shielded improperly/not graded for outdoor use.

Recall

Random/multiple misfires and cyl 3 misfire (P0300 and P0303). Mechanic used a borescope and found coolant on the walls; visible coolant intrusion in cylinder 3. Coolant has gotten to low levels. Very rough cold start. Mechanic highly recommends to get the engine replaced.

The contact owns a 2018 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was contacted but the vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the camera was inoperable. The vehicle was not repaired. The failure mileage was unavailable.

When driving the car, the engine temperature light came on, pulled the car over to let it cool down, when cooled, drove home and looked in the engine compartment, found the coolant reservoir empty, filled it with proper coolant, next day the engine light came on, took to O'Reilly auto parts to scan code, problem was Cylinder #3 misfire, changed out spark plug, noticed that coolant reservoir was low again, searched internet for possible causes when found that many people are having the same issue, turns out Ford manufactured the 2.3L engines with a faulty design where the cooling leaks into the cylinders "Coolant intrusion". the fix that Ford has established for this issue is to replace the engine with a "long block" version, but will not issue a recall. We have contacted Ford and explained the issue, but they will not repair. This should not be happening to a car with only 27,000 miles. now we are stuck with a car we can't drive and don't have the extra $5,000 plus dollars to replace the engine!

My 2018 Ford Mustang EcoBoost experienced sudden engine failure at 70,915 miles. The dealership documented misfire codes P0300, P0301, and P0316, which match the known 2.3L EcoBoost coolant-intrusion defect. This defect causes loss of power, rough operation, misfires, and potential stalling, creating a safety risk during driving. Ford Customer Relationship Center instructed me that the dealership must escalate the defect to the Regional Field Service Engineer. However, the dealer refused to do so, leaving the failure unresolved. This appears to be part of a widespread safety-related defect involving 2.3L EcoBoost engines, with risk of sudden loss of power, stalling, and internal engine failure

The contact owns a 2018 Ford Mustang. The contact stated that while driving at an undisclosed speed, the vehicle suddenly came to a stop while attempting to shift to second gear. The contact pulled over to the side of the road. The contact stated that the failure had been recurring while driving in second gear, which required the contact to release the accelerator pedal before the vehicle could shift to second gear. The vehicle was taken to O'Reilly’s, where it was diagnosed with transmission failure. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000.

There is a coolant intrusion on my vehicle, which resulted in either cracking the engine block or head gasket. In turn, this has caused a costly repair on a car with only 56,000 miles on it. Ford is aware of the issues with these engines and the seals on them. It’s a 2018 Ecoboost! It also happened to my mom’s Ecoboost around the same mileage. This isn’t normal and Ford is literally turning a blind eye to a very serious issue which results in total engine failure. On top of that the repair for this issue is costing $12,000 to repair at the dealership. This is absolutely absurd for a company as big as Ford, to build a faulty engine and then not offer any support/recalls to help all of those affected by it, including me.

The vehicle jolts when placed from park or reverse to Drive after being driven 30 or more minutes or driving 10+ miles. I had previously sent it to 3 different dealerships and only one was able to temporarily resolve the issue. They had to adjust the issue through a computer system. However, after 6-12 months, it is happening again. I feel that is a property or safety issue for drivers because, the transmission or shift change makes the vehicle jump forward and if not carefully could possibly hit another vehicle or person that passes through the front side of the vehicle.

Rear camera safety recall. I've contacted the local dealerships of Galpin Ford and Santa Monica Ford to fix and been denied. This recall is over 1-month now, and they say they do not have the parts to fix and cannot help. This is affecting my safety and a financial inconvenience. Please advise, thank you.

The vehicle is subject to NHTSA Safety Recall 25V572 (Manufacturer Recall Number 25S89) regarding the rear-view camera wiring harness. The manufacturer has notified owners of the safety risk but indicates that the remedy parts are currently unavailable and has failed to provide a specific timeline for repair. I have contacted the authorized dealer and the manufacturer requesting a remedy or an interim inspection, as the rear-view camera is currently functioning correctly with no blank screen or distortion. However, the manufacturer and dealer have refused to perform an inspection to verify the system's safety and close the recall status temporarily. Because the manufacturer cannot provide parts and refuses to offer an inspection-based solution, the vehicle remains flagged with an open safety recall indefinitely. This represents an unreasonable delay in the remedy process, rendering the vehicle unusable for its intended purpose while the manufacturer fails to address the safety defect status.

Over the past year, we've had this car into the Ford of Clermont Florida dealer 5 times about a leak. Whenever we have a storm, the back footwell fills with water. Their leak specialist has said he has found the source of the issue multiple times and after each "repair", we still have a leak. They've replaced the rubber around both side windows and they've asked us to have the front windshield replaced. Even with all of this work, we still have a leak. In the longer term, this could compromise the structural integrity of the car. I don't know what else to do beyond bringing the car back again. I am listing [XXX] as the date the "incident occurred" because this is the latest water breach. But, it's been happening over the past year. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While parked all day with the ignition off and lights off, I returned to find the brake lights and third brake light illuminated. The lights stayed on even after moving the brake pedal. I discovered a small broken plastic bumper on the floorboard, which appears to be the brake pedal stop bumper associated with recall 22V011. This failure causes the brake light circuit to remain closed, leaving the brake lamps on continuously, potentially confusing other drivers and draining the battery. No crash occurred.

The contact owns a 2018 Ford Mustang. The contact stated that upon starting the vehicle, there was an abnormal knocking sound coming from the engine compartment. Upon inspecting the vehicle, the contact found oil underneath the engine compartment. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure. The failure mileage was 49,000.

I have a 2018 Mustang GT with the 10R80 transmission. The transmission started giving me problems like slamming and slipping while shifting and sometimes jumping in and out of gear when drinking in the highway.The problem came from an engineering is with the CDF Drum... Ford has updated the CDF Drum and has fixed the problem. Ford never issues a recall to fix this problem with the vehicles produced with this issue but instead just used the updated production parts in the later models leaving the customers like myself to have to either pay out of pocket or rely on a warranty or after market warranty company to have this very expensive issue fixed. Right now as I am writing this, my car is in the transmission shop. Please help me. When I did a Google search of the CDF Drum issue, this is what was quoted: "The 2018 Ford Mustang GT with the 10R80 transmission can experience issues with the CDF (Clutch-Drum-Forward) drum, specifically with its bushing. This problem can lead to slippage, harsh shifting, and potential transmission failure. Ford has addressed this issue with design revisions to the CDF drum, including adding a lip to the bushing to prevent it from moving and causing fluid leaks."

The contact owns a 2018 Ford Mustang. The contact stated that the front driver’s side and front passenger’s side seat belts failed to retract and failed to properly secure the occupants seated in the vehicle. The vehicle was taken to the local dealer who replaced the seat belts, and the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 50,000.

Sync to my phone works off and on. The radio stays on even when the vehicle is shut off, and media button stopped working.

My engine began experiencing misfires at around 40,000 miles. They were on and off. The check engine light would pop up and go away for around a month. Then the vehicle began having a rough start and check engine light would not go away. I sent the vehicle back to the dealer where they determined that my engine was having misfires due to a coolant leak into cylinder one, stemming from a poor engine design. The engine needed to be replaced. The repair was covered under my warranty.

The contact owns a 2018 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V572000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that occasionally the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. In addition, the contact was unable to activate the heater while the screen was black. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

The contact owns a 2018 Ford Mustang. The contact stated that while starting the vehicle, there was a misfire coming from the engine. The contact stated that the vehicle was shaking abnormally, with the check engine warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the head gasket had failed, and the engine needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 66,637.

Clutch pedal is making a creaking sound when pressed and released. This is known on online forums to lead to failure of the welds near the top of the pedal arm where it pivots. This can cause the pedal to come off while driving and is not safe.

Check engine light came on. Took car to dealership where I learned that the car needs a new engine due to coolant leaking into the cylinders. I later learned this is a "known issue" with this engine, yet Ford has refused to fix or do a recall. The engine could fail or catch on fire if not replaced.

The contact owns a 2018 Ford Mustang. The contact stated while attempting to accelerate from a stop, the vehicle jerked until shifting into gear. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the CDF drum and the main control were faulty and needed to be replaced. The vehicle was not repaired. The contact referenced Technical Service Bulletin: 25-2126 as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage 102,000.

The contact owns a 2018 Ford Mustang. The contact stated that while the vehicle was parked, the contact stated that the vehicle failed to shift into reverse properly, with several unknown warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 70,000.

Took Mustang Ecoboost to Ford dealership as result of steady check engine light. Prior to check engine light rough idle at start up that smooths out after 10 to 15 seconds. Dealer identified CYL 3 misfire as well as random misfires. They also observed carbon tracking on plugs. Dealer replaced plugs and performed GDI cleaning service. About three weeks following repair same conditions reappeared rough idle and check engine light. Upon dealer inspection and use of bore scope discovered coolant intrusion in cylinder and recommended long block engine replacement. The second dealer appointment was several days after my warranty expired and mileage was 30,106 miles. Although the dealership was very supportive and understanding Ford would not provide any assistance even after I also pursued relief directly. As a result the long block engine replacement cost is $8,200. After considerable research was able to identify that ecoboost 2.3 engines as well as other small ecoboost engines all had a block defect that has since been corrected. The defect tends to permit, over time, coolant to leak into cylinders. Although a new head gasket may correct the condition, Ford normally recommends long block engine replacement as a long term fix. This condition if not attended to or if coming on suddenly will cause total engine failure. And, as failure can only occur when operating an engine failure under any driving condition is fraught with danger. To my knowledge Ford has not taken any steps to address this issue with the 2.3 liter engine built prior to about February 2020. And, at that time made an engineering change to the engine block addressing the design defect. Additionally, Ford did provide relief to owners of other smaller ecoboost engines having a similar design defect. At the present time there are several class actions suits pending for this 2.3 coolant intrusion issue. One final point should an ecoboost experience CYL or random misfires ensure bore scope is employed.

Backup camera fails frequently. Screen turns blue and error message of backup camera not available is displayed on the screen.

For roughly 4mths beginning in April 2025, my 2018 Ford Mustang Ecoboost has been suffering from a sporadic misfire, with it the system reporting the misfire and the check engine light coming on, the Ford App identifying the misfire occurring. It was initially repaired with replacing all spark plugs, ignition leads. The sporadic misfire would continue to occur, Ford dealership kept the car for 2 days in late July, took everything apart said they were unable to replicate the misfire, cleared the codes (P0303 being the main one that appears consistently) and said to come back if it occurred again. Roughly 2 weeks later the issue occurred again, took the vehicle back to Ford where they kept the car for 2 days, went through the same process and could not replicate the issue. They dug deeper into the issue and found that the coolant would not hold pressure and with the use of a video scope found that the Intake Valve had fractured and was leaking coolant into the engine as well as distributing multiple shards and pieces of metal from the Valve Intake Fracture. Informed me that the only option was to replace with a new engine and turboboost. They reviewed and found that there were no recalls related to this issue for this vehicle. After undertaking my own research, I found this to be a known issue for Ford and that roughly 100k vehicles had been recalled starting with the 2020 vehicles for the same issue. The out of pocket expense is around 14k, and the vehicle is currently waiting on a replacement engine to arrive. Currently Ford are not offering any assistance in the cost of the replacement, been though they have been servicing the car since 2020 and it is regularly maintained per their guidelines of vehicle needs based on the mileage driven.

The contact owns a 2018 Ford Mustang. The contact stated while the vehicle was stationary, the contact attempted to warm up the vehicle; however, when the contact returned to the vehicle, the vehicle was off. The contact attempted to restart the vehicle and the check engine warning light illuminated. The contact restarted the vehicle however, the engine sounded like it was losing power with an abnormal ticking sound coming from the engine. The message to “Shift to Park” was displayed; however, the gear shifter was already in park(P). The vehicle was towed to an independent mechanic, the vehicle was diagnosed with engine failure due to a lack of engine oil. The vehicle was not repaired. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 129,000.

Head gasket failure from research online there seems to be a flaw in the engine block that leads to coolant leaking in between cylinder walls causing premature head gasket failure.

Car has issues with SYNC software and Radio Module and the display screen goes black while reverse parking or using the navigation system. Car is with the dealership and they are not able to do diagnosis as ford sync system has issues.

I own a 2018 Ford Mustang EcoBoost with a Gasoline Direct Injection (GDI) engine. At around 100,000 miles, the engine developed severe carbon buildup, resulting in cylinder scoring and catastrophic engine failure. Despite following Ford’s recommended maintenance schedule (including a 100,000-mile GDI cleaning service performed by the dealership), my car now has one cylinder with only 70 psi compression (confirmed by borescope and mechanical test). Other cylinders measure 135–160 psi. I have learned Ford is aware of this issue and has made design changes in later models (adding extra fuel pumps/dual injection systems) to address it, but no recall or owner warning has been issued for earlier EcoBoost Mustangs. My research and discussions with BG Products and independent experts show this is a common flaw with GDI-only systems, and Ford has failed to inform owners or provide a lasting solution. The dealership and Ford have offered limited goodwill, but the engine is beyond repair and requires a full replacement. I believe Ford’s failure to warn owners about this well-known defect constitutes a safety and reliability risk. I am requesting NHTSA to investigate this widespread issue and require Ford to take responsibility for affected vehicles.

The contact owns a 2018 Ford Mustang. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle with a misfire in cylinder #1, and coolant leaking into the engine. The mechanic referred the contact to the dealer. The vehicle was taken to the dealer who confirmed the diagnosis and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 49,000.

2018 Ford Mustang Echo boost. Engine light came on code P0420 which is the Catalytic Converter and we already new this when bringing it into Ford dealership. We informed the check in Advisor the Transmission feels like it's slipping or jerks when in 2nd Geer which slows down the vehicle. Took it to Ford and was first informed the Transmission was good nothing wrong with it just need to change my Catalytic Converter because that was the code. We changed the Catalytic Converter but when driving still was experiencing the same thing we originally brought it in for which is the Jerking and slowing down upon accelaration. Took it back to Ford they re checked it and said the CDF Drum is failing and to repair it would cost $4000. I don't have $4000 and my vehicle is out of warranty because of the mileage.

Car jerking,Rpm needle jumps alot,feel like im going to run into someone or something, not getting gas mileage like before.

The contact owns a 2018 Ford Mustang. The contact stated that while starting the vehicle, the "Exhaust Mode Not Available" message was displayed. Upon inspection, the contact discovered that the active exhaust on the rear passenger side had rubbed against the subframe, causing valve fuse 34 to blow. The contact replaced fuse 34 but was unable to disconnect the active exhaust, and the wiring had detached. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was opened. The failure mileage was approximately 68,000.

Ford selling vehicles with malfunctioning engines. This malfunction is allowing coolant to mix in with the oil causing misfires, which leads to the car consuming all of its coolant which can cause the engine to catch on fire. Ford has known about this issue for years and are not trying to put a recall on the engine. They’re making customers pay out of pocket to fix the engine. the dealer determined that the failure was a result of coolant intrusion into cylinder #2 #3. Due to the failure, the engine needed to be replaced. There’s been reports of the vehicle engine completely shutting down while people are driving on the roads. There’s been reporting of the car overheating and catching on fire. The vast majority of consumers who bought the 2.3 liter engines from years 2013-2019 are experiencing these problems. While driving on the highway, the vehicles engine misfired causing lost of power. Luckily I was able to move to the side.

Passenger door unlatches and opens on its own at highway speed.

Engine block failure at 47k miles. Car was driven at 1/4 throttle or less when detonation occurred creating a hole in the engine block. This is so prevalent that it is colloquially termed “ecoboom.” Cost of repair is nearly $9,500

My car engine made a huge boom at only 40,000 miles while on the interstate and I lost all power and almost got ran over by other vehicle because of this. The engine had blown up under normal driving conditions

The contact owns a 2018 Ford Mustang. The contact received notification of NHTSA Campaign Number: 25V572000 (Back Over Prevention). The contact stated that on several occasions while in reverse (R), the rear-view camera screen displayed a cloudy image. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 44,000.

Gas tank does not fill properly. Gas back feeds up the tube and all over the car. To fill gas tank it takes about 30min pumping a few cents at a time.

Like many many Ford Mustangs 2015 and newer, the AC Evaporator has failed and is leaking. This can cause condensation on the windshield and visibility issues with fogging / defrosting. Ford refuses to replace the defective evaporator. Ford dealer Coughlin Ford, Newark, Ohio diagnosed the defect and provided an estimate of $2,679.88 to replace the evaporator.

On multiple occasions now, the passenger side door has randomly opened, which sets off the door ajar warning, and I have to pull over and close the door. In addition, again randomly, the passenger side door locks will unlock, then relock, usually several times in rapid succession. Both situations seem to occur only when the vehicle is in drive, and not while in park. The vehicle is available for inspection; Fortunately, no one was sitting in the passenger seat when these instances occured; The problem has not yet been diagnosed by a dealer or service center; It has not been inspected by anyone; There were no warning lamps or messages prior to the failure, only after the door popped open. I am making this report prior to having it inspected by the dealership because it seems to be a very common problem with other Mustang owners as evidenced by this site, as well as on Mustang forums.

The contact owns a 2018 Ford Mustang. While the contact's wife was driving at an undisclosed speed, there was a grinding sound coming from the vehicle and the vehicle jerked abnormally. In addition, the contact stated that the TPMS warning light was illuminated. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The contact was provided with the cost of a diagnostic test fee. The vehicle was taken to an independent mechanic where it was diagnosed with valve body failure. The contact was informed that the valve body needed to be replaced. The vehicle was not repaired. The contact was informed of Technical Service Bulletin: 21-2115. The manufacturer was made aware of the failure and a case was filed. The contact was also informed of Technical Service Bulletin: 10R80; however, the contact was informed that the repair was not covered under the program. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 44,113.

transmission solenoid malfunction (p0757). car came to an abrupt stop in the middle of a speeding boulevard for no external reason at all. there was no prior impact or damage. i almost got rear-ended and t-boned ten times. considering the amount of complaints on this ford transmission 10R80, i firmly believe this transmission needs to be recalled and our repair/damage expenses reimbursed. Thank you.