2020 Ford Ranger Powertrain & Transmission Problems

Truck shifts from 1st to 3rd, hard shifting in 4th through 10th gears.

My 10 speed 10r80 transmission is failing and dangerous. Besides slipping bucking and delaying shifting it now revs up without moving. I've almost been hit more than 6 times. My ford dealer changed the fluid road tested and normal all that I'm complaining about is normal.

2020 Ford Ranger with transmission and engine (EGR cooler) issues resulting in hard shifting and surges makes it dangerous to drive. Happened on vehicle that was properly cared for and maintained. Issues present on truck that has less than 70k miles.

all of these issues: Shuddering at the point of acceleration Inability to reach desired speed Gear lockout Failure to start Shifter “lockout” or being “stuck in park” Hesitation from a stopped position Sluggish performance, including during towing “Check engine” light “Juddering,” which involves shaking of the vehicle during normal operation Loss of power or failure to engage

Purchased used in 2024 with 44,000 miles. Transmission issues began at 79,000 miles. Hard shifting, slipping and then lurching when it goes in gear. Diagnosed after transmission service ($600) as a factory defect in the 10 speed transmission. Ford has issued Service Bulletins defining and outlining the issue but has offered no assistance in rectifying and repairing. Since so many vehicles are affected there should be a recall. I understand that in Canada a class action lawsuit has been initiated.

Automatic transmission Available for request Accelerating and stoping proves to be a safety issue on the roadways Confirmed by anyone that drives the vehicle Not inspected, out of warranty and can not afford replacement No lamps

I bought the 4x4 Ford Ranger specifically to be towed behind my motor home and followed the directions on how to set up the Flat-tow feature that allows the Ranger to be towed behind my motorhome. I had traveled to a number of Good Same Rallys without any trouble with the Ranger. I use it also as my main vehicle at home to go to store, church etc. On my last trip to Branson, MO while coming home there was a noise that sounded like my brakes on the Ranger were locked up. I took my foot off the gas pedal and it stopped, I proceeded on home when it did this several times. Each time it would stop. I got home disconnected the Ranger and it started fine, I drove it almost 200 miles when I began to notice a jerking from the transmission and took it to my dealer. They proceeded to check it out and told me that the transmission and universal were bad and needed to be replaced at a 17k price. According to the computer readout my battery had failed 2 times. HOW CAN A BATTERY FAIL TWO TIME??? Apparently this caused my flat tow in nuetral tow to go into normal range and at that time made my truck act like it was in normal range, towing a dead truck. THIS COULD HAVE CAUSED ME TO HAVE A BAD ACCIDENT, END UP IN A DITCH. The shop checked and the batter was low but ok. The computer on board did this to my truck and lied on the readout. Three (3) other Rangers had this happen to them and one blew up. I am sure other Ranger owners have had this happen to them too. This can cause a serious accident. I have filed a complaint to our attorney General in my state.

Internal component failure of the 10R80 transmission. While driving one evening on a highway the vehicle while in cruise began bucking, surging and reduced gears. The vehicle began spraying transmission fluid on vehicles behind me and what was once a 10 speed transmission became a 7 speed transmission. Prior to failure there was zero indication of an issue. Nearly getting into an accident I had to make my way to the side of the road where there wasn’t much of a flat shoulder. Not only could my sudden decline in speed have caused an accident but the transmission fluid spraying on vehicles behind me could have reduced others visibility. Dealership near the incident area has confirmed internal failure which is extremely common for these transmissions. Vehicle is currently awaiting a replacement transmission.

Rough shift and jerkings around 35 to 40 mph

When accelerating from a stop, there is a lag in the engine shifting into gear, it causes the RPM's to climb before eventually shifting gears and once it does that the whole vehicle jolts forwards. There is also a noticeable lag when the vehicle is shifting from 1st and second, as well as a jolt when it does shift but not as much of a jolt as the initial 1st to 2nd. Once the vehicle is up to 3/4th gear, it does not appear to have the same issue shifting. This poses a safety issue in numerous situations. One example being, when stopped at an intersection and trying to make a left hand turn, I have to be extremely cautious that I have plenty of space as to account for the potential lag and not being able to accelerate quickly.

On the freeway cruise control at 75 mph, truck started down shifting in to 7th gear, then back up and continued to do this several times until i reached my destination. Took it out of cruise control and still did it. It did it again about 3 days later. I took it to ford dealership, they test drove it and it wouldn't do it for them.

The contact owns a 2020 Ford Ranger. The contact stated that while the vehicle was in reverse(R), the vehicle jerked before the transmission responded as needed. The contact stated that the vehicle returned to normal functionality afterwards. No warning lights were illuminated. The vehicle was taken to the dealer where it was diagnosed that the gear shifter assembly needed to be replaced. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 50 MPH, there was an abnormal humming sound coming from the vehicle before the transmission unexpectedly downshifted. The contact stated that unknown warning lights were intermittently illuminated. The vehicle was taken to a dealer and was diagnosed with an internal leak in the transmission which caused the failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired after the latest failure. The manufacturer was contacted and opened a case. The contact related the failure to Ford Campaign Number: 242046. The failure mileage was approximately 77,000.

Transmission issues since purchasing used. Has been in once for Transmission reprogramming. Less than 6 months later, Transmission now bucks when foot removed from accelerator and shifts out of gear while driving. Returning to Lincoln dealer 6/6 for additional service.

I bought my 2020 Ford Ranger preowned with around 64k miles on it. After having owned it for about 6 months or so, I started to notice lots of problems with the transmission. After first noticing it, the problems persisted for a couple more months until I finally decided to address it. The problems were very characteristic of transmission slippage, and they got progressively worse week by week, which it what ultimately prompted me to address it. When accelerating and shifting through the lower gears (15-30 MPHs, approximately), the shift would be delayed and lag a couple seconds. This would often cause stalling in the acceleration, particularly when going from a stop to a start, such as through traffic lights. There were also very rough and aggressive shifts at higher gears when driving on the highway. It would feel like rough jolts that would rock the truck a little. Also transitioning the truck into reverse often caused serious jolts as the transmission shifted very aggressively. Eventually, I took my truck into an AMCO transmission shop for inspection. They confirmed that my transmission was damaged and needed replaced. This was at about 86k miles. I took the truck into a Ford dealership to get a second opinion and they also confirmed my transmission needed replaced. I went ahead and had the transmission replaced at that point. The replacement was done with the truck at 86k miles. The Ford dealership replaced the 10R80 transmission with a re-manufactured 10R80. It has now been about 8k miles and 9 months since the transmission was replaced, and the re-manufactured transmission is starting to experience similar problems. Mostly with a lag when shifting in lower gears and hard jolts when placing it in reverse. The problems are not as bad as the original transmission before I had it replaced, but some still remain. There were no warning lamps or messages with this problem. Ford's 10R80 transmission is notorious for failing and being a safety problem to the public.

Transmission has rough and erratic shifts at lower speeds. Bucking and bouncing of the vehicle occurs do to the shifting.

Repeated problems with the 10 SPD automatic transmission in my 2020 Ford Ranger. Transmission skips between gears, shakes, jerks, feels like I’m driving over rumble strips. You name it, the transmission is doing it. Took it to the Ford dealership last year and they “cannot reproduce the issue”. That’s because it doesn’t happen all the time. I guess I need to take a technician on a road trip with me to identify the issue. Fast forward to now…warranty is gone and problem still persists. Only 28,000 on the truck. Waiting on a recall to replace the transmission. I mean, these issues are all over the internet. Super common issue. The transmissions are obviously faulty and Ford refuses to resolve the issue. I am beyond irritated at this point

The contact owns a 2020 Ford Ranger. The contact stated that while driving at undisclosed speeds, there was an abnormal squeaking and humming sound coming from the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who determined that the failure was due to the carrier bearings and there was no grease or scratches. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 64,000.

The contact owns a 2020 Ford Ranger. The contact stated while attempting to accelerate from a complete stop, the vehicle failed to respond. The contact shifted into neutral(N), and then shifted back into drive(D). The contact stated that the vehicle responded, then jerked forward and backward. The contact stated that the failure recurred several times while driving from a complete stop; however, on the latest failure, the vehicle failed to respond and stalled. The vehicle was pushed to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 109,000.

The contact owns a 2020 Ford Ranger. The contact stated that on several occasions while driving between 40-45 MPH, the vehicle began jerking and the transmission was skipping. Additionally, the vehicle lost power and was consuming an excessive amount of fuel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 55,900.

Vehicle has hard jerking when increasing speeds. Vehicle takes several seconds to gain power from being stopped at red light and shifts very hard. Sometimes feels like gear slips into neutral and loses power after accelerating slowing. Takes several seconds to recognize being in reverse and jerks hard when it gets going. Started at around 37,000 miles and getting worse at 45,000. Been told several times it's normal, but it very obviously is not and feels very unstable and unsafe.