There are 6 owner-reported tires & wheels complaints for the 2020 Ford Transitin NHTSA's database. These are unverified consumer reports and may not reflect confirmed defects.
The contact owns a 2020 Ford Transit equipped with Hankook Tires, Tire Line: Dynapro HT, Tire size: 205/75/16, DOT Number: (NA). The contact stated that while pulling into a gas station there was a thumping noise coming from the trailer. The contact inspected the trailer and observed that the front driver’s tire was flat. A mobile mechanic was called to the location and replaced the flat tire with the spare tire. The vehicle was then taken to a tire shop where it was determined that the front driver’s tire was worn down to the metal and experience a blowout. The tire was replaced. The contact stated that on the same day while driving 62 MPH, the tire pressure warning light illuminated, indicating that the tire was deflating quickly. The vehicle was pulled over to the side of the road and the contact became aware that the front passenger’s tire was flat. The vehicle was taken to tire shop and the front tires were replaced. The manufacturer was notified of the failure. The vehicle and tire failure mileages were approximately 20,250.
I have encountered an issue multiple times now on multiple Ford Transit vans. The "lug wrench" included with the vehicle as part of the spare tire tool kit does not allow me to remove the lug nuts. I am a Fleet customer and I own many Ford Transit AWD vans. When they are brand new, the spare tire lug wrench barely reaches the lug nut as it is not a very deep socket. After a couple of tire rotations I believe the lug studs possibly stretch slightly and the lug wrench tool no longer reaches the lug nut. This issue has caused my drivers to be stranded multiple times. I believe it is an oversight by Ford and it should be addressed. Thank you
Tire was a Continental 235/65 R16 C 121/119R Van Light Truck M.S Radial Tubeless - Name of Tire was Con Vancontact A/S - On October 07 2023 [XXX] was driving on IH35 North South of Waco TX at around 70 MPG and the tire had a blowout/explosion doing multiple damage to the vehicle before it could be brought to a full stop INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6
While driving on the freeway at about 75 mph, the rear passenger tire exploded causing our driver to almost lose control of the vehicle before coming to a stop on the side of the road. No lamps or warnings were given. No inspections have been completed but I have retained the tire if needed.
TL* THE CONTACT RENTED A 2020 FORD TRANSIT CARGO VAN EQUIPPED WITH CONTINENTAL TIRES, TIRE LINE: VANCONTACT A/S N/A, TIRE SIZE: 235/65/R16 N/A, DOT NUMBER: 16Y04DR83. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 70 MPH, A POPPING SOUND WAS HEARD BEFORE THE VAN BECAME UNSTABLE AND BEGAN TO SHAKE AND VIBRATE. AFTER STOPPING TO INSPECT THE VEHICLE, IT WAS DISCOVERED THAT THE PASSENGER'S SIDE REAR TIRE HAD SUSTAINED SEVERE SIDE WALL DAMAGE AND TREAD SEPARATION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. ENTERPRISE TRUCK RENTAL LOCATED AT 249 FOREST PKWY, FOREST PARK, GA 30297 WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 400. THE VIN WAS NOT AVAILABLE.
AT 565 MILES I WAS DRIVING DOWN THE HIGHWAY AND ONE OF MY VALVE STEMS STARTED RAPIDLY LEAKING AIR. AT 11,400 MILES, ANOTHER VALVE STEM STARTED LEAKING RAPIDLY AFTER STOPPING FOR GAS ON A TRIP. ALUMINUM WHEELS, NEVER TOUCHED ANYTHING WITH THEM. WHEN WILL THE REMAINING ONES FAIL?
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
Data synced from NHTSA on Apr 26, 2026