2021 Genesis GV80 Lighting Problems

Component: Exterior Lighting / Headlamps Vehicle: 2021 Genesis GV80 VIN: [XXX] Mileage at Failure: 77,000 Complaint: The front left headlamp on my 2021 Genesis GV80 failed completely after visible moisture and condensation accumulated inside the lamp housing for approximately one week. There was no impact, damage, or tampering. The Genesis service center inspected the vehicle and confirmed the failure was caused by moisture intrusion consistent with Genesis Technical Service Bulletin 23‑BD‑002G (“Information for Lamp Condensation”). This condition is also documented with NHTSA under XXX The failure resulted in a complete loss of headlamp function, creating a significant safety hazard while driving at night. Genesis Customer Care initially informed me that if the dealer confirmed the failure was consistent with the TSB, the repair would be covered under goodwill. After the dealer confirmed the defect, Genesis corporate declined to cover the repair due to the vehicle being out of warranty, despite the failure being caused by a known manufacturer defect affecting visibility and safety. I am filing this complaint because the defect is safety‑related, documented by the manufacturer, and resulted in the loss of primary forward lighting. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The passage side headlight has moistures in it. They said run the engine for 30 minutes so it will dissolve and it didn't. And now the headlights not working and its $2,000 to get it replace.

Condensation has appeared in the driver side headlight. It has caused the headlight and blinker to stop working. In addition, several warning lights have appeared on the dash indicating the following operations are no longer working.... Driver Attention Warning System, Forward Safety System, Lane Change Assist system, Lane Departure Warning System and High Beam Assist. While the driving assist systems may be optional functions, the lack of headlight and blinker are, in my opinion, safety issues. Certainly, the car would not pass a safety inspection in the state of Virginia and, as a result, I would not be able to register the vehicle. Genesis has known of the headlight condensation problem for years and has issued several TSB's, yet they continue to build cars with a known safety issue. In my opinion, a safety recall should be implemented and Genesis should be required to repair the problem at their expense.

2021 gv80. Drivers side headlight failed while on vacation. Had newly formed condensation in headlight and must have shorted it had to drive back home with no turning signal and no headlight. Had the shop look at it when I got home and confirmed the unit was bad. Dealer is charging around 2,500-3,000.00 for headlight replacement

Seal on headlight and turn signal failed during a rainy day letting Condensation into assembly and burned out unit. Dealer verified the issue and wants $4200 for the part plus labour and taxes. Many complaints online about same problem. 0

The component that failed is the driver side headlamp and blinker. It collected condensation from a manufacturer defect that Genesis will not take accountability for. They over tightened the screws which caused hairline cracks in the assembly, which then causes condensation in the housing. The condensation cause the headlight and blinker to stop working altogether. This is a major safety issue and put me at risk of danger from cars not knowing where I am turning, or not being able to see me at all without a headlight. No, it doesn't need confirmed. It is not hard to tell when a headlight is out. There is literally no light.

There are cracks on the driver side headlamp due to design flaw. My light went completely off causing the front headlamp to turn off and disable certain things that are crucial forndriving. the dealer will not replace the headlamp saying it is external factors. Other have the same issue. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Left LED Headlamps & intergral camera sensor assembly has failed due to moisture penetration behind the lenses. In addition to no left headlamps or left front turn signal, we have lost the emergency braking, forward collision warning, the lane departure warning and the lane keeping assistance features. Service advisor has advised on 01/08/24 that this is a common problem & parts are not readily available.