2006 Honda Civic Brakes Problems

The contact owns a 2006 Honda Civic. The contact stated while driving approximately 40-45 MPH, the vehicle experienced shaking with all four tires bouncing. Additionally, the vehicle made abnormal noises and both of the rear tires kept losing air. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 07V399000 (Service Brakes, Hydraulic) associated with the VIN. The failure mileage was approximately 114,000.

13 December, 2021 VIN: [XXX] Background: 30 June, 2015 - Took Our 2006 Honda Civic 4 door sedan (LX) in for service (odometer reading 75,801) in order to address coolant leaks. The OEM dealership indicated there was a recall on this specific engine and Honda USA replaced the short block and gaskets ( exhibit H0CS10872 – replacement engine ID number D67141432M ) to correct this problem. Issue: 10 December, 2021 - While driving home (8 miles on local errands) the engine began making a rattling noise. No warranting indicators appeared on the dashboard alerts. Parked the in garage, inspected the garage floor for fluid leaks – there were none. Immediately arranged to take can in for service. 12 December, 2021 - Left residence to take the car in for an inspection and / or service. Without warranting the engine failed, lost steering and braking. Had car towed for inspection. 13 December, 2021 – Car inspected (odometer reading 117,366) finding engine sized. It should be noted that since the short block replacement the car has only been driven 41,565 miles in 5 years. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

ENGINE BLOCK IS LEAKING COOLANT. RIGHT REAR TIRE IS WEARING OFF.

MY ABS SYSTEM CAUSED ME TO CRASH. I WAS GOING 20 MPH IN SNOWY CONDITIONS (I HAVE SNOW TIRES). WHEN I PRESSED THE BRAKES THE ABS SYSTEM ENGAGED BUT AFTER 20 FEET OR SO MY CAR HAD NOT SLOWED AT ALL. FINALLY I PULLED THE EMERGENCY BRAKE AND THE CAR BEGAN TO SLOW, BUT IT WAS TOO LATE AND I HIT THE CAR IN FRONT OF ME. I'VE SLIDE THROUGH SEVERAL INTERSECTIONS IN THE PAST BECAUSE WHEN THE ABS COMES ON IN THE SNOW THERE IS VIRTUALLY NO BRAKING AT ALL. I KNOW IT'S THE ABS SYSTEM THAT IS THE PROBLEM BECUASE IN ALL OF THESE INSTANCES I CAN ACCELERATE WITH NO PROBLEM, BUT WHEN I TRY TO BRAKE THE CAR WONT STOP. I FINALLY TOOK THE FUSE OUT OF THE ABS AND DROVE THROUGH THE SAME INTERSECTIONS AND MY CAR STOPS IMMEDIATELY WITH NO PROBLEM. I EVEN TRIED SLAMMING ON MY BRAKES ON THE SNOW COVERED ROAD WITH MY ABS FUSE REMOVED AND THE CAR STOPS IN LIKE 5 FEET, BUT WITH THE ABS FUSE INSTALLED IT TAKES ABOUT 30 FEET. WHY IS ABS REQUIRED IF IT'S SO DANGEROUS IN THE SNOW/ICE? WHY IS THERE NO BUTTON TO TURN IT OFF.

THE BRAKE LINE OF OUR 2006 CIVIC DEVELOPED A MAJOR LEAK AS A RESULT OF CORROSION OR ABRASION, LEADING TO A LOSS OF BRAKE FLUID AND SEVERELY DIMINISHED BRAKING. *TR

I ON A 2006 HONDA CIVIC EX. YESTERDAY I CAME TO A STOP LIGHT AND APPLIED THE BRAKES AND AS I DID SO THE CAR STOPPED AND THEN THE ENGINE BEGAN TO RACE AND ROAR. I APPLIED THE BRAKES HARDER AS THE CAR BEGAN TO TRY TO JUMP FORWARD INTO THE INTERSECTION THE ENGINE RACED EVEN MORE AND THE BRAKES WERE NOT HOLDING THE CAR BACK SO I QUICKLY PUT THE CAR IN PARK AND TURNED OFF THE ENGINE. I WAITED ABOUT 30 SECONDS AND THEN STARTED THE CAR AGAIN AND KEPT MY FOOT ON THE BRAKE. THE CARE ENGINE WAS NORMAL THIS TIME AND THE ENGINE DID NOT RACE SO I DROVE HOME. THE NEXT DAY I TOOK MY CAR TO THE HONDA DEALERSHIP AND THEY PUT IT ON THE COMPUTER AND DID NOT FIND ANYTHING WRONG, BUT WHEN THEY DID A VISUAL CHECK OF THE GAS PEDAL, THEY FOUND THAT THE GAS PEDAL HAD COME LOOSE FROM THE FLOOR MOUNTING. THEY TIGHTEN THIS PART AND CHARGED ME FOR LABOR AND THE TIME ON THE COMPUTER (WHICH CAME TO $104.). THEY SAID THERE WAS A RECALL ON THIS PART FOR SOME OF THE 2006 HONDA CIVICS, BUT THAT MINE WAS NOT THE RIGHT VIN NUMBER FOR THIS RECALL. WHEN I LOOK ON YOU WEBSITE IT TYPE IN MY VIN NUMBER AND MAKE AND MODEL, IT SAYS IT IS ON RECALL AND THAT THEY HAVE A MODIFICATION KIT FOR THE GAS PEDAL THAT THEY SEND TO THE DEALERSHIP TO REPAIR THE CAR FOR FREE THAT IS SUPPOSED TO PREVENT THIS FROM HAPPENING AGAIN. I FEEL THAT THEY SHOULD HAVE ORDER THE REPAIR KIT FOR MY GAS PEDAL AND TOLD ME THAT THEY WOULD SERVICE MY CAR FOR FREE. MY LIFE OR SOMEONE ELSE'S COULD HAVE BEEN AT RISK WITH THIS INCIDENT AND POSSIBLY WITHOUT THIS MODIFICATION KIT, IT CAN HAPPEN AGAIN IN THE FUTURE. I WOULD LIKE TO KNOW HOW TO GET MY CAR INCLUDED IN THIS RECALL AND FREE INSTALLATION OF THE MODIFICATION KIT AS IT SHOULD NOT BE EXCLUDED SINCE I OBVIOUSLY SUFFER THE SAME RISK AS THOSE OTHER 2006 HONDA CIVICS WITH THE APPROVED VIN NUMBERS. I WOULD ALSO LIKE A REFUND ON THE $104. *TR

TL* THE CONTACT OWNS A 2006 HONDA CIVIC. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 07V399000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT STATED THAT THE DEALER DECLINED TO REPAIR THE VEHICLE UNDER THE RECALL DUE TO THE WHEEL BEARING BEING PAINTED. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD EXCESSIVELY WEAR DOWN TIRES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 99,838.

TWO DAYS AGO I WAS PULLING INTO A PARKING SPACE IN A GROCERY STORE PARKING LOT. I WAS SLOWING THE CAR DOWN USING THE BRAKES. AS I TURNED INTO THE PARKING SPACE I APPLIED PRESSURE ON THE BRAKES, THE BRAKES BECAME SOFT AND SUDDENLY THE ENGINES RPMS INCREASED AND BEGAN JUMPING BETWEEN 3000 RPMS TO 4000 RPMS. THE CAR BEGAN TO MOVE FORWARD EVEN THOUGH I HAD THE BRAKES FULLY DEPRESSED AND I WAS IN DANGER OF HITTING OTHER CARS OR PEOPLE. I IMMEDIATELY PUT THE CAR IN NEUTRAL AND THE RPMS JUMPED EVEN HIGHER. I TURNED THE ENGINE OFF AND AFTER A FEW SECONDS THE ENGINE STOPPED. I RE-STARTED IT AND DROVE TO THE HONDA DEALERSHIP. THEY HAVE HAD THE CAR FOR TWO DAYS AND CAN NOT FIND THE PROBLEM (OR SO THEY SAY). THIS IS THE SECOND TIME IN 8 WEEKS THIS HAS HAPPENED IN THIS CAR (SEE COMPLAINT NUMBER 10435619). THIS WAS NOT PEDAL ERROR. MY FOOT WAS ONLY ON THE BRAKE. AFTER DOING A GOOGLE SEARCH I SEE HUNDREDS OF SIMILAR COMPLAINTS. HONDA IS NOT ADMITTING THAT THERE IS A PROBLEM WITH THE SOFTWARE IN THEIR CARS BUT THERE IS. PLEASE LOOK INTO THIS BEFORE TOO MANY PEOPLE GET KILLED. I COULD HAVE EASILY RUN OVER THE 2-3 PEOPLE WALKING IN FRONT OF ME IF I HADN'T BEEN THROUGH THIS BEFORE AND KNEW TO PUT THE CAR IN NEUTRAL RIGHT AWAY. BOTH TIMES WHEN I PUT MY FOOT ON THE BRAKE I FELT THE BRAKES SOFTEN AND THE ENGINE SUDDENLY REVVED. IT APPEARS TO ME THAT THERE IS SOME GLITCH IN THEIR SOFTWARE THAT TELLS THE ENGINE TO DOWNSHIFT WHEN BRAKING. INSTEAD OF DOWNSHIFTING THE ENGINE ACCELERATES. SOMETHING IS CLEARLY WRONG WITH THIS CAR. UNFORTUNATELY THE CHECK ENGINE LIGHT DOES NOT COME ON SO HONDA CAN NOT FIND THE ERROR. CLEARLY IF YOU DO A GOOGLE SEARCH THERE IS A SERIOUS PROBLEM OUT THERE WITH THESE HONDAS. *TR

HAVING TAKEN MY CAR IN FOR A ROUTINE MAINTENANCE AT 91,000 MILES I WAS TOLD THAT THE BRAKE LIGHT SWITCH WAS ONLY WORKING ON AN INTERMEDIATE BASIS. I WAS ALSO TOLD THAT A PRODUCT RECALL WAS IN PLACE FOR SAME YEAR MAKE - DIFFERENT MODEL. I'M HAVING THIS CORRECTED AT MY EXPENSE BUT FELT IT NECESSARY TO ALERT YOU FOLKS TO A POSSIBLE DEFECT IN OTHER CARS OF SAME MAKE AND MODEL YEAR. *TR

TL* THE CONTACT OWNS A 2006 HONDA CIVIC. THE CONTACT STATED THAT THE FRONT BRAKE PADS AND ROTORS WERE WORN PREMATURELY. THE ROTORS WERE TOO SMALL FOR THE PADS AND THERE WAS A CONSTANT NOISE COMING FROM THE BRAKES. THE BRAKE PADS AND ROTORS WERE REPLACED AT LEAST THREE TIMES. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2006 HONDA CIVIC. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH AND THE VEHICLE BEGAN TO VIBRATE. ALSO, A LOUD TICKING NOISE EMITTED FROM THE REAR OF THE VEHICLE. IN MARCH OF 2010, THE VEHICLE WAS INSPECTED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V399000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK: WHEEL SPEED SENSOR); HOWEVER THE TECHNICIAN WAS UNABLE TO DETECT A MALFUNCTION. THE DEALER REFUSED TO ACCEPT RESPONSIBILITY FOR THE MOST RECENT FAILURE OF THE REAR DRIVER SIDE WHEEL BEARING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

OUR 2006 HONDA CIVIC EX AUTOMATIC HAD THE BATTERY DIE ON US WHILE THE KEY WAS STILL IN THE IGNITION AND APPARENTLY THIS COMBO IS A SURE FIRE WAY OF DESTROYING THE ABS MODULATOR WHICH HONDA CHARGES $900 TO REPAIR. THIS IS A WIDE SPREAD HONDA PROBLEM WHICH WAS REVEALED ONCE I STARTED SEARCHING FOR WHAT THE LIGHTS ON OUR DASH MEANT. MORE PEOPLE WITH THE SAME PROBLEM CAN BE FOUND HERE. HTTP://WWW.8THCIVIC.COM/FORUMS/CANADA-EAST/83944-ABS-LIGHT-E-BRAKE.HTML HTTP://WWW.ANSWERBAG.COM/Q_VIEW/1057973 HTTP://WWW.8THCIVIC.COM/FORUMS/MECHANICAL-PROBLEMS-TECHNICAL-CHAT/231978-ABS-BRAKE-LIGHTS-AFTER-HUB-BEARING-REPLACEMENT.HTML. *TR

I AM UNCERTAIN THIS IS THE PROPER FORUM FOR MY COMPLAINT BUT IT HAS TO DO WITH THE BRAKING SYSTEM ON MY 2006 HONDA CIVIC. I GO THROUGH FRONT BRAKE PADS IN LESS THAN 15K MILES AND MY REAR BRAKES HAVE HARDLY BEEN TOUCHED. SOON, AT JUST OVER 40K I WILL BE REPLACING PADS A 3RD TIME AND ROTORS TOO. ON MY PRIOR CAR, A 1991 HONDA ACCORD THAT I PUT 325K MILES ON, I REPLACED PADS ABOUT EVERY 40K MILES. THIS IS A BIGGER HEAVIER CAR YET THE BRAKES LASTED LONGER AND AS I GROW OLDER I THINK MY DRIVING HAS BECOME MORE PATIENT AND LESS AGGRESSIVE SO I WOULD EXPECT MY BRAKES TO LAST THE SAME OR LONGER ON A SMALLER LIGHTER CAR. I THINK MY CURRENT CIVIC BRAKING SYSTEM IS OVER ZEALOUS AND BURNING THROUGH BRAKE PADS TOO FAST. IF AS SUGGESTED BY THIS ARTICLE (HTTP://LOSANGELES.BIZJOURNALS.COM/LOSANGELES/STORIES/2010/03/15/DAILY7.HTML?ED=2010-03-16&ANA=E_DU_PAP) THE VSA MODULATOR IS 'UNDER PERFORMING' IN BRAKING SITUATIONS, ISN'T IT JUST AS LIKELY THE SAME DESIGN COULD BE 'OVER PERFORMING' AS WELL? MY MIDAS MECHANIC SURE THINKS SO BUT SAID I WOULD NEVER BE ABLE TO PROVE IT ON MY OWN. I THOUGHT IT WAS WORTH BRINGING TO YOUR ATTENTION. MY FRONT BRAKES OVER DO IT AND MY BACK BRAKES MIGHT AS WELL NOT BE THERE AT ALL. BETTER TO BRAKE TOO MUCH INSTEAD OF TOO LITTLE BUT I THINK THIS FLAW IS RELATED. *TR

VEHICLE BROUGHT TO REPAIR SHOP FOR BURNING SMELL. IT WAS FOUND THAT FRONT BRAKES WERE LOCKED. BLEEDERS WERE OPENED WHICH RELEASED THE FRONT BRAKE APPLICATION. ONLY THE BUILT UP PRESSURE IN THE CALIPER WAS RELEASED, HYDRAULIC SYSTEM WAS NOT DRAINED, OR BLED. THE BRAKE FLUID IS FULL, THERE ARE NO SIGNS OF FLUID CONTAMINATION. NOW, VEHICLE HAS A HARD BRAKE PEDAL BUT ABSOLUTELY NO BRAKE APPLICATION. NO BRAKE FLUID ESCAPES WHEN OPENING BLEEDERS, WITH HELPER PRESSING BRAKE PEDAL. I THOUGHT, EVEN IN THE EVENT OF COMPLETE ABS FAILURE, THE BASIC HYDRAULIC SYSTEM WOULD STILL BE FUNCTIONING. *TR UPDATED 4/13/10 *CN THE PROBLEM WAS CREATED BY AN IMPROPER ADJUSTMENT OF THE BRAKE POSITION SWITCH (BRAKE LIGHT SWITCH). UPDATED 05/13/10.*JB

1. LEFT MY LIGHTS ON AND NEEDED A JUMP START ON MY 2006 HONDA CIVIC HYBRID NAVI. 2. AFTER RECEIVING THE JUMP START, THE VEHICLES BRAKE LIGHT, ABS LIGHT AND BRAKE SYSTEM LIGHTS WERE ALL ILLUMINATED ON MY DASH BOARD. IN ADDITION, THE VEHICLES AUTO ENGINE STOP FEATURE WAS NO LONGER OPERATIVE, 3. MY HONDA DEALERSHIP DIAGNOSED THE PROBLEM AS A FAILURE OF THE ABS MODULE. AS SUCH, THE VEHICLE'S ABS WAS NON FUNCTIONAL, ALTHOUGH THE AUTOMOBILE CONTINUED TO RUN. SINCE MY VEHICLE HAD 103,000 MILES IT WAS NOT COVERED UNDER WARRANTY. THE INITIAL ESTIMATED REPAIR COST WAS $1500. I SUSPECTED THAT THE CAUSE OF THE ABS WAS THE JUMP START. I DID SOME ONLINE RESEARCH AND CONFIRMED A NUMBER OF OTHER SIMILAR REPORTS OF THE SAME PROBLEM, SAME CONDITION (AFTER A JUMP START) AND SAME EXPENSIVE REPAIR HAVE BEEN REPORTED. THERE IS NO WARNING ABOUT JUMP STARTING IN THE VEHICLES ENGINE COMPARTMENT, ALTHOUGH THERE ARE MANY OTHER WARNINGS. THERE IS NO PROTECTIVE COVER ON THE VEHICLES NEGATIVE BATTERY TERMINAL (WHICH MAY BE THE CAUSE OF THE PROBLEM). AND THERE IS NO WARNING IN THE VEHICLES USERS MANUAL. I CONTACTED AMERICAN HONDA MOTOR CORPORATION TO REPORT THE PROBLEM, ONLY TO BE TOLD THAT MY VEHICLE WAS OUT OF WARRANTY DUE TO ITS MILEAGE. I CONTINUED TO REACH OUT TO SENIOR MANAGEMENT OF AMERICAN HONDA MOTOR CORP TO REPORT THE PROBLEM AND ASK FOR THEIR ASSISTANCE AS "A GOODWILL GESTURE" AND AGAIN RECEIVED THE SAME "OUT OF WARRANTY" REPLY. ON DECEMBER 21, I SENT CERTIFIED LETTERS TO AMERICAN HONDA MOTOR CORPS CEO OUTLINING THE ISSUE AND THE FACT THAT THEY HAVE A DOCUMENTATION AND WARNING LABEL FAILURE, WHICH CAN PUT THE DRIVER AT EXTREME RISK OF INJURY SINCE THE ABS CIRCUIT BECOMES NON OPERATIONAL. ON DECEMBER 28TH I RECEIVED A PHONE CALL FROM AMERICAN HONDA IN WHICH THEY CONFIRMED THAT HAVE RECEIVED OTHER COMPLAINTS ON THIS IDENTICAL ISSUE, BUT THEY DENIED MY REQUEST FOR ASSISTANCE SINCE THE VEHICLE WAS NO LONGER COVERED BY THEIR WARRANTY. *TR

WAS TRAVELING APPROX. 20 MPH APPROACHING A STOP SIGN, APPLIED THE BRAKE. BRAKE FADED, CAR SUDDENLY WAS ACCELERATED. PUT CAR IN NEUTRAL, IT ACCELERATED FOR APPROX. 2 SECONDS AND THEN WENT INTO IDLE. *TR

TL*THE CONTACT OWNS A 2006 HONDA CIVIC HYBRID. WHILE DRIVING 5 MPH OUT OF THE DRIVEWAY, THE VEHICLE STRUCK A BUMP AND IT SUDDENLY ACCELERATED ON ITS OWN. THE CONTACT LOST CONTROL OF THE VEHICLE AND IT SPUN AROUND. BOTH THE BRAKES AND EMERGENCY BRAKE FAILED. THE VEHICLE CAME TO A STOP WHEN IT STRUCK A MUDDY EMBANKMENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THERE WERE NO INJURIES. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

I HAVE A 2006 HONDA CIVIC. THE BRAKE PADS WERE REPLACED IN AUGUST 2008 AND THE HONDA SERVICE DEPT SAID THEY SHOWED UNUSUAL WEAR AND DO I USE THE BRAKES ON HILLY TERRAIN? WHICH I DON'T!. THE BRAKES NEVER FEEL FULLY DISENGAGED. I JUST READ A COMMENT ON A WEBSITE THAT SAID THE SAME THING FOR ANOTHER CAR. ALSO THE SUN VISORS SPONTANEOUSLY CRACK. I HAD THE DRIVER SIDE REPLACED AND THE PASSENGER ONE IS NEEDING REPLACEMENT. HONDA SEEMS TO BE IGNORING PEOPLE'S PROBLEMS WITH THESE BRAKE ISSUES AND VISORS. PLEASE HELP NUDGE HONDA TO RECALL THE BRAKE SYSTEMS ON THESE CARS! THANK YOU SO MUCH. *TR

FRONT BRAKES REPLACED DUE TO UNEVEN WEAR. INNER PADS WERE 95% WORN & OUTER PADS WERE 50% WORN. THEY REFUSED TO PRO-RATE THE REPAIR DUE TO IT BEING A WEAR ITEM EVEN THOUGH THIS IS A KNOWN DESIGN DEFECT. OLD PARTS ARE AVAILABLE FOR INSPECTION. *TR

PROBLEM: INTERMITTENT LOSS OF FULL BRAKING ABILITY. DETAILED DESCRIPTION: WHEN LEAVING WORK, MY DRIVING ROUTINE IS VERY SIMILAR DAY-TO-DAY. OF THE ESTIMATED 370 TIMES I HAVE LEFT WORK WHILE DRIVING THIS VEHICLE, I HAVE HAD BRAKE FAILURE ON 5 TO 10 OCCASIONS. THE SCENARIO IS THIS: 1.START ENGINE, BACK OUT OF PARKING SPOT, AND APPLY BRAKES IN ORDER TO SHIFT FROM R TO D. 2.DRIVE 100 FEET THROUGH PARKING LOT AND APPLY BRAKES A SECOND TIME WHILE WAITING TO ENTER THE MAIN ROAD. 3.DRIVE ONE-QUARTER MILE AND APPLY BRAKES A THIRD TIME AT THE FIRST TRAFFIC LIGHT. IT IS THIS THIRD APPLICATION OF BRAKES THAT SOMETIME RESULTS IN BRAKE FAILURE. THE BRAKE PEDAL WILL GO ALL THE WAY TO THE FLOOR, AND BRAKING CAPABILITY IS ABOUT 30% OF WHAT IT SHOULD BE. IF I PUMP THE BRAKES, THE FAILURE WILL DISAPPEAR AND NORMAL BRAKING RETURNS. THIS RESULTED IN A REAR END ACCIDENT, WHEN I COULD NOT STOP AND HIT THE STOPPED VEHICLE IN FRONT OF ME. VEHICLE HAD 36,801 MILES ON THE ODOMETER AT THE TIME OF ACCIDENT, AND NO BRAKE REPAIRS HAD EVER BEEN ATTEMPTED ON THE VEHICLE. *TR