2017 Honda Pilot Complaint Log

Over the past couple of months the the vehicle has been "throwing" misfiring cylinder errors, particularly cylinder 4 (P0304) and every once in a while cylinder 1 (P0301), and a catalytic converter bank 2 error (P0430). Last week, I filled up with premium fuel and added a catalytic cleaner. This eliminated the P0430 error and reduced the frequency of the P0304 error. Yesterday ([XXX]) we were driving from Casper, WY to Gillette, WY for a volleyball tournament. About 35 miles into the trip, we were travelling at a speed of 72 mph when the tires squealed, accompanied by metal clanging and extreme vibration in the engine; the car nearly came to a complete stop. I was able to maintain control of the vehicle and pull off to the side of the road. I looked down at the console display and noticed that the check engine light was blinking. I connected an OBDII scanner and observed a P0304 error. I then tried to pull forward slowly and the car barely moved and the engine clanging and vibration persisted. At that point I turned off the engine and called a tow truck; I also called my son to pick up my daughter and take her to her volleyball tournament. While waiting for the two truck, I attempted to start the car so I could run the OBDII scanner again. The car would not start. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The issue appears to involve the vehicle’s electrical control system responsible for power management and system activation while the vehicle is off, possibly including the Smart Power Control Module and related components. It may be arranged for the vehicle to be inspected. The vehicle behaved as though it had been remote started, initiating engine cranking without any user input while turned off. If this occurs while parked in a garage or enclosed space, it could lead to dangerous carbon monoxide buildup and pose a serious risk to occupants. Unintended engine activation also presents a risk to nearby people or property. The unintended engine cranking event occurred once and was directly witnessed while I was seated inside the vehicle observing other electrical oddities. The issue has not been reproducible on demand. However, related symptoms including the alarm activating on its own and unexplained electrical activity while the vehicle is off have occurred multiple times. The vehicle has not yet been inspected for this issue by a dealership, manufacturer, or third party. No police or insurance reports have been filed. I plan to take it to the dealership tomorrow (4/4/2026). There were no warning lights or messages before or during the event. Prior symptoms include intermittent alarm activation, display flashing, clicking fuses, and electrical activity while off, beginning before the engine cranking incident.

The contact owns a 2017 Honda Pilot. The contact stated that while stopped at a traffic light, the vehicle unexpectedly lunged forward with the check engine warning light illuminated, and the “Emission System” error message was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed with fuel pump failure. The contact was informed that the fuel pump needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.

The contact owns a 2017 Honda Pilot. The contact stated that while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle decelerated to 25 MPH unintendedly. While driving at a reduced speed, the vehicle was immediately driven to the local dealer who diagnosed that the camshaft had failed and needed to be replaced. The camshaft, camshaft thrust cover, and camshaft sensor were replaced, and the vehicle was repaired. The manufacturer was notified of the failure and informed the contact that VIN was not eligible for the extended warranty coverage for the failure. The failure mileage was 94,000.

While driving on the interstate I was trying to pass a vehicle and the vehicle all systems but the brake system issue. Check engine, emissions, power steering, hill start assist, traction assist. The vehicle would not accelerate. When I got on the shoulder the engine was struggling to stay on and had a loud knocking sound. Had the vehicle towed to nearest exit and had someone come pick me up with a trailer to take back home 5 hours away. The engine knocking got louder if you press on the gas.

So our family of four, two adults and two kids driving down buford dr in GA on March 29 2026 apparently at 11am found ourselves in a dangerous situation. The oil light on our honda pilot came on and the vehicle shut off in the middle of a 3 lane extremely busy road. This is not safe and I am a experience automotive technician for more then 20 years of experience and have not yet found a rod bearing to go bad at 167k with full oil and no oil leaks this is unacceptable for honda to only recall only some year models knowing the used the same j32 in most of there vehicles

it is unfortunately the camshaft end play issue that we see with these engines from time to time. Honda identified that the surface roughness of the camshaft thrust cover on these engines was manufactured out of specification. This poor surface finish creates excessive friction and wear, allowing the camshaft to develop excess fore-and-aft movement (end play). As the camshaft shifts physically out of its correct alignment, it begins to scrape against the thrust cover or cause the reluctor wheel to physically strike and damage the Camshaft Position (CMP) sensor. So you have to replace the camshaft, the camshaft sensor, the thrust plate, and timing cover plate. In this picture you can see where the reluctor wheel has been scraping on the cam sensor. This was sent to me not only by one mechanic but multiple. Honda needs to replace this and a recall needs to be made!!!

Car is dangerous. I have been the only owner of this car. Over the years and again today the car loses acceleration when attempting to pass someone on the highway at speeds of 65 MPH +. The car just doesn't accelerate and leave you pushing gas and nothing happens. I have had issues where I have had to move over 2 lanes on busy highway to pull over due to lack of anything happening when I press the gas. Today, it actually didn't throw any codes, but acceleration returned after about 25 stressful seconds. It's bad enough this car has to have the idle engine depressed everytime you start it or the car will die and not restart at a traffic light. There are way too many safety issue with this car. I will keep reporting as time allows. I have done all the routine maintenance on this car as well. I try to keep my cars 10 years, but this one has been an issue since early on.

It has happened on multiple occasions where I’m driving at 70mph, and my engine cuts out and I can no longer accelerate on the highway. My rpm’s drop to 0. I have to pull over until it comes back on again. It’s putting my safety, my children’s safety at risk, other drivers on the road at risk when all of the sudden my car will not accelerate.. has not been inspected by manufacturer. No other symptoms, no lights come on.

The contact owns a 2017 Honda Pilot. The contact stated that while driving at slower speeds, the transmission unexpectedly shifted to neutral(N) while the accelerator pedal was depressed. Several unknown warning lights were illuminated. Prior to the failure, the vehicle was taken to a local dealer for a fuel injector replacement. The vehicle was taken to a local dealer, where it was diagnosed and determined that the fuel pump and catalytic converter needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign: 23V858000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.

I was driving, and my engine died in the middle of Highway 40 about 5 miles outside of [XXX] . It was extremely dangerous, and Colorado State troopers and Colorado Division of Transportation workers had to stop traffic. The car could not be put into neutral, and towing to a safe location was very difficult and dangerous. The car has less than 76K, and there was absolutely no warning before the car died. No engine lights, no noise. Just died. I have read about rod bearing failures and believe my car is part of this problem. I have had frequent service, and my mechanic has said there was oil in the car, and the engine just seized. The mechanic believes it is a crankshaft rod bearing issue. I could have been hit and was traveling alone in an area that often does not have cell phone service available. This needs to be addressed, and engines should be recalled without delay. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, the vehicle lost engine power on three separate occasions (3/6/26, 3/10/26, 3/20/26) and had to coast to a stop on the road. One of the codes that appeared was P0087; the Honda dealership replaced the fuel pump kit (part # 06161-RLV-305) due to the fuel rail pressure being too low, but the vehicle continued to stall upon replacement after being picked up from the dealership. When it was brought back to them, they could not find a problem or replicate the stalling. This is a safety risk because the car is stalling for an unknown reason and will not start back up for 10-15 minutes. This is a safety risk to the driver and others because stalling could cause an accident or fatalities if the driver is unable to safely pull over. Fuel pumps are a known problem in 2017 Pilots and this vehicle was not included in the recall (SB 24-010). I paid $1694 for the repair from the Honda dealership and the problem is still occurring. There were no warning lights prior to the failure. Honda should reimburse me for this cost, but they denied responsibility for the cost despite Service Bulletin 24-010. These vehicles are unsafe and should not be on the road at all.

I was taking my kids to school and then suddenly a knocking sound started and then a boom. I found out that at 134,000 miles my engine threw a rod and punched a hole in my block. My [XXX] old was freaking out because there was smoke coming from the engine and her sisters said the car was going to catch fire. The [XXX] old was stuck in her seatbelt and couldn't get out. Then as I was calling a tow truck my [XXX] old almost walked out into traffic because she wanted to see what I was looking at. After getting another family member to get my kids to school I was able to get to a repair shop where I was informed that Honda had a safety recall for rod issues and was advised to see if my car was covered. I check and it looked like only the all wheel drive cars were covered but mine was front wheel drive so it didn't fall under the recall. I want to issue a formal complaint to expand the recall on Honda Pilots for rod issues because mine obviously had an issue with the rod and should have been recalled. American honda refuses to give any good will because I didn't get my oil changes with them, even though it is an hour drive to get to the closest dealership. Engines shouldn't throw rods at 134,000 miles. A car is a big investment and it died after 9 years. I had all my maintenance done as scheduled, this never should have happened. Currently my car is at Carson Honda in Carson City NV. Also, another issue. I would get transmission system warnings. I did take it to the honda dealer because I was told there was an injector issue and they looked at the car, reset the code and said there was nothing more they could do. I don't know if the two were connected in any way but wanted to throw that out there. They need to be investigated for crappy parts and scamming customers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

ECHOING EXACLY WHAT OTHER PILOT OWNERS ARE COMMENTING. ENGINE COMPLETELY GAVE OUT ON THE HIGHWAY.

knocking noise from engine, oil light, blinking CEL, no acceleration, vehicle stalled. Brought to mechanic, from noise he said it sounds like a rod knocking and advised to contact Honda because on known issues.

I was stopped at a traffic light, and my vehicle would not re-start when the traffic light turned green. It stalled because the Auto Idle Stop/Start (AIS) function did not work as intended. The dashboard cluster lights were all on (or many of them, at least). I had to collect myself, put the car in park, and wait a couple of minutes to try to restart the vehicle, all while I had a line of vehicles behind me honking. This isn't the first instance. It has happened several times before, and I am familiar with what the Honda service reps say when I have taken the vehicle in for repair, so I'll cut through the nonsense they have told me. I recently replaced my battery with a quality name brand battery, so it's not an issue with the battery. I have had the PGM-FI Idle Stop Software Update recall service performed twice, one in response to a March 2023 recall notice, and again from a May 2024 recall notice. There is something seriously and obviously wrong with this AIS feature. I have looked on many forums and this is a frequently recurring problem. This shouldn't happen simply because I (or my family member) forget to hit the AIS-disengage button. There should be a permanent fix for this feature if it frequently fails.

Transmission issues began to occur shortly after purchase in 2017. The Honda dealership finally did a software update after several complaint. This temporarily fixed the issue. The car shifts low gears harshly and with hesitation. The transmission system failure/problem light came on and the car lost power. The car makes a squeaking noise between 23-30mph. Most recently we were traveling on an interstate at 75mph and had to slow down quickly (~55mph) once we began to accelerate the car went limp. This incident happened twice within a weeks time. This put the occupants in the car in danger because the car would not accelerate. It did finally begin to accelerate.

Collision Mitigation Braking System camera failure indictions appeared in the dashboard control center. I took the vehicle to the Honda dealership who stated there is not an active recall and that this was not a covered expense. Out of caution because I have read of the system failues causing brake lock-up related to over 40 vehicular crashes and almost twice that number of injuries, I decided to immediately obtain this $2,000 repair. I contact Honda of America to start a claim for a goodwill reimbursement and they told me only (and repeatedly) that the vehicle was too old, out of warranty and that they WOULD NOT consider reimbursement of the repair to this integrated and vital safety system. The National Highway Traffic Safety Administration (NHTSA) has documented 2,976 complaints involving unintended automatic braking in Honda vehicles, with 47 crashes and 93 injuries reported. These issues involve Honda vehicles equipped with camera-based collision mitigation braking systems similar to the one used in the 2017 Pilot. Because this failure involves a core safety system component, and because there is: -documented evidence of system-wide safety investigations -thousands of consumer complaints -shared safety technology across the Honda lineup I requested reimbursement from Honda America. They made ZERO effort to acknowledge this safety system fault and clearly stated they would not reimburse me NOR would the customer service representative provide me with any guidance on how to further pursue the matter. NHTSA complaints involving the 2017 Honda Pilot reference failures involving the Collision Mitigation Braking System, Lane Keeping Assist System, and Adaptive Cruise Control warnings, all systems dependent on the same forward-facing camera architecture. Front multipurpose camera replacement was the final repair needed and NOT reimbursed.

The car had a piston rod failure and is available for inspection at the Springfield Honda dealership. The car was traveling at 63 mph when the check engine light started flashing along with 6 system errors including the power steering. I had to make an emergency stop on the side of the road. The dealership has confirmed and recommended an engine replacement. They have a video recorded of the sound and error codes. The only person to have inspected the car is the dealership. We were told that it wouldnt be covered because our VIN didnt fall with in the affected vehicles for the piston rod recall. The car was driving normal and had no service lights on prior to the check engine light coming on during the incident.

I own a 2017 Honda Pilot. The vehicle has been stalling and losing power while driving. The loss of power creates a serious safety risk, especially in traffic and at highway speeds, as the vehicle hesitates and struggles to accelerate. The High-Pressure Fuel Pump was replaced at my expense after the vehicle began stalling and losing power. Despite this repair, the problem has persisted. I am now being told by Honda that the Low-Pressure Fuel Pump also needs to be replaced. I have already paid for significant repairs, including replacement of the High-Pressure Fuel Pump, water pump, timing belt, and related components. My vehicle’s VIN is not included in any fuel pump recall, although similar vehicles appear to have had related recalls. I did receive a warranty extension for the torque converter, but I have received no notification or warranty support regarding the Low-Pressure Fuel Pump. The stalling and loss of power place me and other drivers at risk, particularly in intersections and during highway driving. The issue has been diagnosed by a Honda dealer/service center. The failed components are available for inspection upon request. No consistent warning lamps appeared prior to failure. I am concerned this may be a broader safety defect affecting vehicles outside the current recall population.

Alarm randomly goes off when parked and locked without doors being open. Unplugged hood latch sensor and it stopped but security system is not armed (absence of blinking light).

Internal engine damage was determined by a Folsom Honda Dealer in California. The damage is originating from the primary rod bearings; Replacement of the short block is necessary. Folsom Honda also stated the vehicle will need Cams and Heads of the engine replace. Needless to say, this a major engine failure. The vehicle only has 140K miles mainly freeway. Dealer estimated it will cost from 11K to 15K to repair the problem. We aware of Savannah Messenger V. American Honda Motor Co. Inc Lawsuit. We need help from you guys on this….. please advice Francisco Talavera [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

This vehicle is facing the common "rod knock" issue known with the 2016-2022 Honda Pilots Diagnosis by Honda pending but symptoms present

The rods on my engine seized while I was driving on [XXX] in South Dakota. The car came to rest on [XXX] . The vehicle died on the most-traveled road in Brookings. right off the exit ramp. We had to wait 20 minutes for a patrol officer to park behind us, and we then waited another 20 minutes for the tow truck to take us to a nearby parking lot. The problem was confirmed by an independent service center. There were no warning lamps or symptoms prior to the engine seizing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I was driving back from my daughter's tournament in [XXX] and while driving, I heard a loud Crack. It sounded like It came from the top of the car. When we got home I hit the button for the moonroof slide and noticed that the moorroof had cracked. There was no one in front of us and no debris when the loud Crack occurred. Luckily there was no glass shards that fell on the kids. I looked online and saw many other customers had this same scenario happen and glass fell on their children. Customers are also saying that this is due to cold/heat exposure. The Problem cannot be reproduced as it involves glass. And there are no warning lights for this issue. I am reporting the incident today to my dealer and insurance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Honda Pilot. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate while depressing the accelerator pedal. There were several unknown warning lights illuminated. The contact referenced NHTSA Campaign Number: 23V858000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 143,000.

Engine was making a loud grinding noise and when my fiance got home from work it completely died out and will not turn over

The contact owns a 2017 Honda Pilot. The contact stated that while driving between with the RPM between 2,000 and 2,500, the vehicle bucked. There was no warning light illuminated. The vehicle was taken to the dealer, where a transmission triple flush was performed; however, the failure recurred within 1-2 months. The vehicle was taken to an independent mechanic, where the transmission was serviced several times; however, the failure reoccurred. Transmission fluid was added to the vehicle; however, the failure persisted. The dealer was notified of the failure and advised the contact that another diagnostic test was needed. The vehicle was not repaired. The contact related the failure to TSB: 16-091 (Judder from the Torque Converter Lock-Up Clutch); however, the model year was not included. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 120,000.

The contact owns a 2017 Honda Pilot. The contact stated that while his wife was driving approximately 65 MPH on the freeway, the vehicle stalled due to battery failure. There were no warning lights illuminated. The vehicle was towed to an independent mechanic, where the battery was replaced. After restarting the vehicle, the contact heard an abnormal knocking sound consistent with a rod knock. Additionally, the trunk handle paint had chipped and was rusted. The local dealer was contacted and referred the contact to the manufacturer for assistance. The manufacturer was contacted and confirmed that there were no recalls associated with the VIN. The failure mileage was approximately 51,000.

On Feb. 03, 2026 around 5:30 pm, driving 290 west going 65 mph. No cars on either side of me and the next closest car 6 lengths of me, my car slammed on the brakes and alarmed. The sudden braking lasted 1-2 seconds.

I am submitting a safety complaint regarding a 2017 Honda Pilot experiencing a connecting rod bearing failure. Which has left my vehicle disabled. While driving on I-270 North, the vehicle suddenly made a loud “pop” noise and immediately lost power, creating a dangerous situation on a busy highway. Shortly afterward, the engine developed a very loud knocking noise, consistent with internal engine failure. The vehicle does not need to reproduce the concern, as multiple technicians were able to immediately hear the knocking upon inspection. The issue is constant and clearly present. There were no warning lights, no check engine light, and no prior indications of failure before the incident occurred. This sudden failure without warning presents a serious safety risk, especially at highway speeds. The vehicle has been regularly inspected and serviced, including services performed in dealership settings. The vehicle is currently available for inspection if needed. I am aware that similar model years have been affected by connecting rod bearing issues, and I believe this vehicle should be included or further investigated due to the sudden and dangerous nature of the failure.

Component/System Failed: Engine – Excessive oil consumption (piston rings / internal engine components). The vehicle is available for inspection upon request. Description of the Problem: The engine is experiencing excessive oil consumption. During a monitored oil consumption test, approximately 0.9 quarts of oil were consumed over about 1,006 miles, which equals a consumption rate of approximately 1 quart per 1,118 miles. This rate is abnormally high and indicates an internal engine defect, likely related to piston rings and/or sealant failure. Safety Risk: Excessive oil consumption creates a significant safety risk. If the oil level drops too low between oil changes, it can lead to engine failure, sudden loss of power while driving, engine seizure, or stalling. This could place the driver and others at risk, especially at highway speeds or in traffic. There was no visible oil leak. The oil is being burned internally. Inspection / Confirmation: The issue has been monitored through an oil consumption test. Dealer diagnosis indicates internal engine repair is required (piston and seal-related repair). Estimated repair cost is approximately $6,000. Warning Lamps or Prior Symptoms: No external oil leak was present. Oil level dropped significantly between checks. (If applicable, add: “Oil warning light did/did not illuminate.” If unsure, write: UNKNOWN.) Manufacturer / Other Inspections: Vehicle has been inspected by dealership service department. (If Honda corporate has been contacted, add that here.) Additional Information: The repair cost is excessive for a defect involving internal engine components and appears to be a known oil consumption issue.

Transmission and torque converter, were effected on my car. Safety concerns were witness when wife was driving on freeway with our 4 kids and car was jerking and not going like it’s was suppose to. We drove to slow lane were we proceeded to destination slowly . Problem was detected when transmission light came on when my wife and sister in law were driving on freeway. America Honda didnt want to look into it due to it being out of there warranty-of 150,000. So we took it to a transmission shop. We’re he diagnosed the code for the torque converter. The warning light came on at 166,000 miles. Thats when we’re actually aware of the issue. We never received a letter or call from America Honda warranty regarding this issue.

On [XXX], approximately 17 hours after purchasing this vehicle from a licensed dealer, the transmission began violently jerking, shuddering, and hesitating without warning while traveling at highway speed in Alabama. The sudden loss of smooth vehicle control created an immediate risk of collision with other vehicles. Diagnostic evaluation at O'Reilly Auto Parts confirmed fault code P0741 — Torque Converter Clutch Circuit Performance or Stuck OFF. A subsequent Honda dealership evaluation confirmed this as a PERMANENT DTC, meaning the fault existed across multiple drive cycles prior to purchase and prior to the failure event. I am aware that Honda previously acknowledged this transmission defect in 2016-2017 Honda Pilots and extended the warranty to 150,000 miles. This vehicle failed at 152,848 miles.... just 2,848 miles beyond that threshold. Honda USA denied goodwill assistance based solely on mileage. A permanent fault code cannot be cleared by battery disconnect. The defect was pre-existing at time of sale. The dealer listed the vehicle as having "No Issues." The dangerous transmission behavior at highway speed represents a serious ongoing public safety risk for any owner of an affected vehicle. I am requesting formal investigation and recall consideration for this known defect. Two independent repair facilities have confirmed transmission replacement is required. Estimated repair cost: $5,374 to $7,000. We have parked this dangerous vehicle until we can find a way to INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle started to Make loud clinking sound coming from engine. Went to dealership for diagnostic and high pressure fuel pump failed. Was quote 2000 .

My Honda Pilot has been diagnosed with engine failure by Royalty Auto in Kingsland, GA despite having been cared for quite well. This failure occurred well before reaching the expected life of the vehicle, yet outside the warranty window and having NO symptoms before the sudden failure. After doing some research on Pilot owner online forums, as well as, the NHTSA website, it seems similar complaints have been well reported and a recall has been issued for some vehicles in the same year and model under NHTSA campaign number 23V75100. This relates to Honda manufacturer recall XG1 and Honda recall GG0.

The contact owns a 2017 Honda Pilot. The contact stated that while driving at an undisclosed speed, several unknown warning lights were illuminated. The vehicle was pending an appointment with the dealer. The contact used a handheld scanner and retrieved seventeen different undisclosed diagnostic trouble codes. The contact stated that the warning lights were intermittently illuminated. The manufacturer was not made aware of the failure. The failure mileage was approximately 115,000.

While driving my 2017 Honda Pilot Elite, the vehicle has experienced four separate incidents of sudden and complete loss of power, including while traveling at highway speeds and during rush-hour traffic. The engine shuts off without warning, causing the vehicle to stop in traffic. In multiple incidents, the vehicle would not restart for several minutes. These incidents occurred on U.S. 19 and Interstate 275 in heavy traffic, creating an immediate risk of collision. In one incident, the vehicle died while traveling at highway speeds. In another, it shut off at a red light and blocked traffic during rush hour. The vehicle has been taken to an authorized Honda dealership multiple times. Diagnostic testing initially found no issues. Later visits attributed the problem to the battery, despite the battery being recently replaced and the condition recurring after replacement. The symptoms exactly match Honda Pilot start/stop engine failure recalls affecting nearby model years. However, because my model year is not included, the dealership refused to repair the vehicle in accordance with the recall, even when I offered to pay for the repair. I believe this represents a safety-related defect involving sudden engine shutdown while driving. The vehicle is unreliable and unsafe to operate. Furthermore, given the repeated failure of this vehicle, the dealership’s inability to permanently repair the condition after multiple attempts, and the ongoing safety risk, I am concerned this matter may meet the criteria for a nonconformity under Florida’s Motor Vehicle Warranty Enforcement Act. I am hopeful Honda will resolve this matter cooperatively and without the need for further regulatory or legal action.

I received a letter from Honda regarding a warranty extension on the torque converter of my 2017 Honda Pilot. When I took the vehicle into the dealership, their senior technician confirmed the mechanical issues happening with the vehicle are aligned with the description of the concerns outlined in the warranty extension. The only element of the extension condition that was not happening was a code popping up on the screen. When I asked what conditions would need to take place for the code to pop up, they stated the torque converter would seize up while driving and cause the vehicle to be a hazard to those in the vehicle. When I explained this to Honda, they continued to deny the repair since the code did not populate. I am asking the NHTSA to look into this matter as I assume the purpose of the warranty extension was to repair an issue that could cause serious injury to the inhabitants of the vehicle, and not to rely on an electronic error code to pop up. Thank You

Car bought at 103,000 miles engine failed at 109,700 verified thru Honda Dearler with metal shavings in number six (6) cylinder. Started ... with check engine display and started missing.

Turned car on and it was making a very loud sound coming from what sounded like the engine. Very loud when accelerating or stepping on the gas. Driving at lower speed was also loud. Unknown if it was safe to drive. Took to mechanic and was told it was the high pressure fuel pump. There were no warning lights or warnings.

The vehicle constantly says “ keyless start system problem” I’ve only had the car for a year, it also says “ break system problem and won’t let me start the car often”

Subject: Engine Knocking Noise – 2017 Honda Pilot Hello, I’m reaching out because my 2017 Honda Pilot has recently developed a noticeable knocking noise coming from the engine area, especially during acceleration and low‑speed driving. I’m aware that some 2016 Honda Pilot models have experienced sudden engine seizure, stalling, or failure with little warning. I also learned that the 2016–2020 Acura MDX, which uses the same engine, was issued an engine‑related recall. This makes me particularly concerned that the noise may be an early sign of a serious issue. I’d appreciate having the vehicle evaluated as soon as possible. Please let me know your earliest available appointment and whether it’s safe to continue driving in the meantime. Thank you, Honda Pilot owner

My 2017 Honda Pilot (3.5L V6) is experiencing severe, rhythmic engine knocking and loss of power. The vehicle has no active warning lights or check engine codes. I am aware of the active NHTSA investigation PE25008 regarding connecting rod bearing seizure in this model year. The engine failure creates a significant safety risk, including potential stalling at highway speeds and the risk of engine fire. I am requesting that this vehicle be included in any forthcoming recall for the 3.5L V6 engine crankshaft/bearing defect.

With no warning, the engine has completely stopped while I was driving. The engine will not turn over at all after that moment. All maintenance was maintained on the vehicle, including regular oil changes. There were no lights, signals, or even engine sounds leading into it stopping. It appears that there are others who have had the same issue with this engine.

Was driving down highway I40 near Nashville and the engine started making a noise. I was able to drive to my Mothers house. My Dad looked at it and stated it sounded like a rod knocking. So we went to take it to the dealer because after some research we found a recall for rod bearing failure. My vehicle was not on the recall list. We then proceeded to take the car to the dealer to check if there was a safety bulletin at the dealership when the engine locked up. My Dad came to rescue us and towed the car back to his and my mom’s house.

Vehicle: 2017 Honda Pilot Elite VIN: [XXX] Mileage at failure: 107,593 The 9-speed automatic transmission failed at approximately 107,593 miles. The repair cost 6,229.91 at an independent shop and included a full transaxle overhaul, replacement of the torque converter, transmission oil pump, and main control valve body. The vehicle previously had fuel injectors replaced under warranty at approximately 87,000 miles. I have opened a Honda goodwill reimbursement case (Case #16225384). I am filing this complaint to document the premature failure of critical powertrain components and support review for Honda goodwill assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am submitting additional documentation related to NHTSA complaint #11723932 for my 2017 Honda Pilot. I have obtained a transmission inspection report confirming that the failure was caused by a defective torque converter, resulting in internal transmission damage including the valve body and transmission oil pump. The report also indicates that the failure was not related to maintenance and represents a defect in the component. This required a full transmission overhaul at approximately 107,593 miles. I am providing this update to ensure the complaint accurately reflects the cause of the failure. I have contacted Honda several times and they are not willingvto look into my case. I had to get my fuel injector replaced at 87,000 miles when it was under warranty then the transmission goes 20k miles later.

Emissions System Problem- UNKNOWN reason

Engine connecting rod bearing failure diagnosed at the dealership. At 30mph, engine lost power and clunking noise was heard, coasted into a parking lot and had the vehicle towed to the Baierl Honda Wexford PA Dealership quoted total engine replacement at $9,978.93 +labor, + tax.