2020 Honda Pilot Electrical System Problems

Infotainment center making popping and cracking sounds during every drive. System will completely shut down and not work at all. No access to navigation, phone or infotainment center at all. Audio will completely cut out during music and phone calls.

While driving, we eill hear a popping noice coming from the dash speakers - almost sounds like fine grains if sand hitting windshield - at which time the media display, i.e. navigation /radio control display/etc. will turn black and briefly display "Network Connection Lost, MOST Net Off" message before the display goes completely black. This has only been noticed AFTER a recall service was performed.

CAR WILL RANDOMLY LOSE ALL POWER AS IF THE BATTERY IS DEAD AND THEN FLICKER AND COME BACK ON. NO WARNING LIGHTS OR CHECK ENGINE LIGHTS ARE ON. NOTHING HAS BEEN INSPECTED YET BUT THIS SAME PROBLEM WAS A PREVIOUS RECALL ON THIS MAKE AND MODEL

Driving on the highway dash goes completely black. Can’t see speed. Cruise control shuts down. Have to pull off the highway shut the engine down and wait for a couple minutes then restart. I have had all recalls repaired at the dealership where purchased but this happens weekly. At 50,000 miles I noticed rough and abrupt transmission shifting and clunking with a lag in acceleration. This continues despite multiple transmission flushes. The problem continues to worsen and current mileage is at 71000

My wife drives this vehicle daily with our 3 children all of sudden these warning lights come up: Trailer stability assist problem Road departure mitigation system problem Power steering system problem Emission system problem Vehicle stability assist problem Hill start assist problem The last time this happen was 1/28/2026 Took it to the dealer 1/31/2026 showed the association the video he said he has not heard of this but mostly caused by the battery. They looked at the battery all is well. If it happens again to bring it in he said. This was the 3rd time this happens the warning lights will go off. Took it to auto zone and they could not find the caused. This is dangerous to happen and unacceptable. Based on social media multiple people have this issue and causinga safety concern. What would it take for HONDA TO FIX THIS. PLEASE MAKE A RECALL!!

The infotainment center goes out, the screen reads "Network Communication Lost" "MOST Net off". This occurs while using the rearview camera, causing a safety issue. This is a known Honda issue, bulletin 20-049, 20-058, A19-030B. Replacement of FAKRA connectors, MOST bus wiring harness (parts 39817-TJB-ACO housing or 39165-TG7 cords) or the entire floor harness.. Vehicle has 79,000 miles.

The auto shut off has been not working properly and the vehicle wont restart after it shuts off. My wife was at a traffic light, and the vehicle shut off. When the light turned green, it did not restart. As a result of this she about got taken out by a semi that was coming in behind her. This could have been a deadly accident as it is raining and wet. She was stuck at the light on a busy highway for 3 minutes before the vehicle would restart.

Lane departure front facing projection camera suddenly went out disabling multiple safety features of the car. The part number for the car is 36160-TG8-A83. This car only has ~86,000 miles and this is unacceptable. This failure disables the Lane keep assist, lane departure, auto high/low beam, adaptive cruise control, auto braking safety features and causes the brake light system light to come on. Apparently, this is a common issue and should be investigated. The parts are on back order nationally and good luck finding a used one.

While stopped at red light the auto off feature engaged and the car stalled out when restarting. This has happened multiple times since buying the vehicle

All safety features on the dashboard have lit up all are constantly on. Honda America states no open recall, I see many forums for Honda owners having this issue that also impacts safety

The LKAS camera stopped working and it won’t allow any of the connected systems to operate including ACC, emergency brake assist, cruise control, etc.

Car intermittently won’t start due to insufficient battery charge. Jump starting will start the car. Dealership testing of battery and charging system determined no issues. However, issue reoccurs. Suspect charging doesn’t occur until battery reaches a minimum voltage level which is currently set too low. Safety issue in that car starting is unreliable.

The idle engine turn back on feature has not turned on several times. It has happened a couple of times upon turning it back on after a complete turn off in a parking lot. Also, it has happened in traffic at a stop light on busy roads where I was sitting there dead stopped in the road unable to get the car started. Another time, it did not turn back on as I was pulling out of my neighborhood and we almost got hit because of it. The battery seems to be involved and seems to have to recharge for a few minutes and then it will turn back on. I've called 911 to help me get out of the road, have taken out the battery and put it back, and had it checked at the dealership. I have to remember to use the button that turns off the idle engine turn off feature or it will happen. It doesn't have any pattern or reason to it.

The contact owns a 2020 Honda Pilot. The contact stated while driving at an undisclosed speed, the vehicle started to lose automotive power, and failed to return to normal operation. The contact stated that several unknown warning lights were illuminated. The vehicle remained at the residence. A dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 70,000.

Since purchasing the vehicle there was a leak under the driver's side console after heavy rains. After multiple trips to the dealer they directed us to replace the windshield. We did so (under protest). The leak still existed. The dealership determined that there was a gap at the A pillar. We worry that this is related to the Sturcture recall about missing welds. Honda will not admit to any issue.

What component or system failed or malfunctioned, and is it available for inspection upon request? When calling the dealer they believe it is the “Smart Control unit.” How was your safety or the safety of others put at risk? My vehicle will not start most of the time…leaving me stranded when I have to go anywhere and I have to get out to take the battery terminal off and back on just to try to reset it long enough for it to try to start. Has the problem been reproduced or confirmed by a dealer or independent service center? No, from my understanding of reading other people having the same problem Honda knows it is a common issue and has not done anything about it. The dealer wants paid to do an inspection. I do not have the money they are asking for. I know inspections aren’t very expensive but most people (myself included) can’t afford even a simple inspection. Just to pay for the car takes all I have. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? At first I noticed my car alarm would go off randomly and originally thought my doors weren’t being shut all the way however after making sure all doors were in fact shut it still went off. I was at work that night and had to keep going out to turn my alarm off…the next morning I go in to start my car and leave and it had trouble starting saying “keyless start system problem” after finally getting it started I drove to the gas station to get gas and turned off the engine as I was walking away I heard cracking noises and my car making the ding noise it makes when you turn it on ACC mode. When I came back to the car all the lights on the dash, radio screen, headlights, tail lights, and mirror lights (the ones that light up when a car is close) were flashing like crazy and still heard the crackling noise.

All the associated warnings are on dash, diagnosed at local Honda dealership with code u 3006-16. Advised multi camera failure and requested $1600 to repair. Immediate after I am now getting a transmission warning problem on dash.

The infotainment screen is turning off and says “Network Communication Lost. MOST Net Off”. This means the infotainment screen goes black, often for long periods before it cycles back on, making it difficult to use Navigation and the screen for reverse camera.

•What component or system failed or malfunctioned, and is it available for inspection upon request? The “smart” control module, part# 38320-TG7-L112-M1 was removed and inspected; obvious incomplete conformation coverage was discovered along with significant dendritic growth on an uncovered IC. Proper cleaning of the board alleviated the issue – for the time being at any rate. I am including pictures of the board and growth that clearly show this defect and its related consequences, but I can provide the part for inspection if it’s feasible timewise and if I haven’t sold the vehicle by that point. •How was your safety or the safety of others put at risk? The vehicle was rendered completely and utterly inoperable by this condition and additionally necessitated the removal of the battery to keep the car alarm from triggering randomly. If this condition manifests itself at the wrong time it could easily create a dangerous situation for myself, my family and others. •Has the problem been reproduced or confirmed by a dealer or independent service center? The diagnosis, research, documentation and associated repair were performed by an independent service technician. •Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? This problem was reported to Honda USA in late March of 2025; no acceptable recourse was provided or offered. •Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. On Friday March 21st at approx. 6PM, the car alarm was triggered with no interaction whatsoever after the vehicle had sat for several hours. After disconnecting the battery for over an hour the problem immediately returned upon reconnection along with flashing dash & interior lights and clicking relays and/or components.

2020 Honda Pilot Touring was purchased in CT at Honda of Stamford, May of 2023. I started having issues in July pertaining to extreme dust coming into the cabin causing my children and myself asthma conditions to worsen. I took the car to the dealer and they blew out something connected with the system. I than started having issues with the radio system and large popping sounds coming from it. The dealer didn't check this for me. The car also brakes on it's own while driving without warning and nothing is in front of me. The dealer didn't check this. On [XXX] the dashboard lite up with a lot of error messages and the car brake light was on. The car would only go 20mph on the highway. The car was stuck in Greenwich, CT at my son school for 2 days until I got it towed to the dealer. On Feb24th the car was towed to the dealer. I was told the brake switch went out and needed replacement. I was charged 200.00. I picked the car up on Feb25th @1pm and the dealer claimed the repair was done. On [XXX]. I was traveling on the highway in Norwalk, CT and the dashboard lite up with the same errors and he brakes did the same thing and the car was hard to steering. I took it back to the dealer and was told 3 other things was wrong with the car. Code-C0040-62 Brake lamp switch failure stuck. U3000-49 Multi purpose camerawave radar internal electronic failure. B2A60-97. Tech reset camera and the system still gave failure codes. The dealer confirmed the issues, but refused to give me a replacement. I had a DMV investigation and the out was to refund me for the conveyance fee the dealer lied about on the contract. I was also refunded for vin etching the dealer lied about on the contract and refunded for Honda Care. I was in the car with my children when the brake issue happened both times and it was scary. The car was never inspected before it was sold to me. I also never received several documents from the dealership required by CT state law. I left the car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)