2017 Hyundai Tucson Powertrain & Transmission Problems

Car engine seized and lost ALL power going 60mph down the highway at night with my child in the back seat. I have poured quarts and quarts of oil in this vehicle because it burns oil at an alarming rate until it eventually runs dry and the engine seizes. This is extremely dangerous and luckily my child and I were able to drift to the side of the road without harm and injury. Very discouraging that there are thousands of these cars and engines on the road that can literally seize up at any minute. Maintenance was performed and kept up with. The Oil pressure light had been flashing when the vehicle turned but was flashing even when oil had just been changed. These engines are dangerous and have people in a financial hard spot. I still owe $16k on a car I can no longer drive and that Hyundai is saying due to owner maintenance will not get an engine replacement. The Facebook group Hyundai Oil Consumption test has thousands of people dealing with the same exact issue on these cars and engines.

severe oil consumption. the vehicle eats the oil at an alarming rate. having to fill the oil tank very often and the engine light has been on. it is affecting acceleration at 30mph where the engine warning light will flash. It also completely dies while driving. very unsafe and needs to be resolved.

While driving on the interstate at highway speed, my 2017 Hyundai Tucson lost power without any warning lights or prior symptoms. The vehicle experienced an immediate loss of propulsion while I was traveling in traffic, creating a dangerous situation because surrounding vehicles were also moving at highway speed & I had to quicky maneuver the vehicle to the shoulder with no power. The vehicle had approximately 73,861 miles at the time of the failure. After the incident, the vehicle was taken to a Hyundai dealership and diagnosed with a burned exhaust valve requiring replacement of the cylinder head & valve. The estimated cost of repair provided by the dealership was approximately 7550. The vehicle had no prior warning lights or symptoms before the sudden loss of power. A sudden engine failure resulting in loss of propulsion at highway speed presents a serious safety risk to both the driver and surrounding traffic. This was an extremely dangerous failure.

I recently purchased vehicle and when checking recalls from my local Hyundai dealership I was advised that there was two previous attempts to have engine replaced due to knocking and it was denied this recalls is the 209 I escalated to Hyundai corporate and after taking to a Hyundai dealership and paying for a diagnostic test they advised car doesn't have oil pressure and the oil pump needed replaced and Hyundai corporate denied repairs saying this didn't pertain to recall 209 because my engine is a 1.6 liter and it was ok only to the 2.0 engines, I would like to report this and ask for help please.

I've taken the vehicle to several mechanics for engine-idling when turning, going up-hill. I've purchased new plugs, lines, engine cleaners, no-one can figure it out. The oil now has engine shavings even though the oil was recently changed. The car broke down today

- Kept regular 5K-6K oil changes since 2022 when I purchased the vehicle -Took the vehicle to a Hyundai dealership, multiple times, to ask about the engine stalling at a stop or slow turn, and/or jerking. -July '25 new oil change and flushed engine -October'25- no engine or oil lights. Engine seized and needs to be replaced. - VIN didn't populate recall but the symptoms are the same

Issue was first noticed in October 2025 - there are roughly 70k miles on the vehicle. It is a 2017 vehicle, and has regular service (oil, inspection). There was a class action lawsuit for this issue (wylie v hyundai), which was settled prior to the purchase of the vehicle. Vehicle stutters when shifting into and out of first gear. A local mechanic and hyundai both confirmed that it was a transmission defect. The Hyundai dealership initially thought it was an actuator issue, but has since said that it is a faulty gear assembly. it has a DCT (dual clutch transmission). Vehicle suddenly stops and is erratic when driving. Coming out of a stop risks the vehicle shuddering; going through an intersection or turning cross traffic is extremely dangerous as the vehicle could stop momentarily and cause a collision. Vehicle is unable to maintain flow of traffic. The problem appears to be widespread - there are various forums we found where others have this same issue. There were no warnings on the dashboard prior to the issue. When issue appeared a check engine light was displayed.

My Hyundai’s replacement engine, installed under a recall a little over a year ago, is now failing again. Hyundai’s service department was the only shop to ever work on the engine. There is visible silicone drooping from the area where the head and block were torqued down — a defect hidden beneath the engine cover that isn’t removed during normal maintenance. Hyundai Corporate acknowledged silicone use would be “shoddy work,” yet refuses further review, stating they’ve “never had a customer dispute something within 18 months later.” If Hyundai engines arrive sealed and shops don’t handle insulation, silicone should not be present. This may indicate poor workmanship or improper installation on recalled engines. I request NHTSA review this as a recurring safety and workmanship issue on Hyundai recall replacements.

My 2017 Hyundai Tucson Limited 1.6L Turbo (with 7-speed EcoShift DCT) has ongoing transmission problems. The vehicle hesitates, jolts, and sometimes fails to accelerate from a stop, which creates a serious safety risk when entering traffic or crossing intersections. The problem has been reproduced and confirmed by the Hyundai dealership in Fairfield, CT. They diagnosed the transmission and recommended a complete replacement at a cost of over $7,000. This issue matches the defect described in NHTSA Recall 16V628000 and Hyundai Service Campaign T1B, which involved the same 7-speed EcoShift DCT in 2016–2017 Tucson models. However, my VIN was not included even though I am experiencing the exact same safety defect. No warning lamps appeared before the hesitation/judder began. The safety risk is significant because the vehicle can fail to accelerate as expected in traffic, increasing the chance of a crash.

Excessive oil consumption, Full synthetic Oil last less than 2000 miles. Transmission takes some time to respond when start driving from a stop. Car shake a bit.

excessive OIL CONSUMPTION no leaks its buring oil

This unresolved issue has created serious safety risks. On two separate occasions, my vehicle lost power while crossing the Leo Frigo Bridge in Green Bay—an extremely dangerous scenario for both my family and other drivers. Most recently, within just ~40 miles of picking up the vehicle from service, the issue recurred. The service department reported finding oil on the ignition coils—symptoms consistent with known and documented warranty concerns such as: Valve cover gasket leaks Spark plug tube seal failure High-pressure fuel pump gasket leaks The vehicle has been brought multiple times to a certified Hyundai dealership for recurring problems including power loss, poor engine performance, and excessive oil consumption. Despite these repeated service visits, the underlying issue has not been properly addressed. I have now been informed that I am responsible for diagnostic charges—even though the vehicle is covered under the TXXM Engine Warranty Extension / Powertrain Limited Warranty due to known oil consumption-related defects.

The vehicle has a transmission (powertrain) malfunction that first appeared in July 2025, a few weeks after I purchased the vehicle and after the warranty had expired. At the time the issue began, the vehicle had well under 80,000 miles. The transmission slips, fails to properly engage, and cannot provide sufficient power, particularly when accelerating or driving uphill. The vehicle struggles to move forward and behaves unpredictably during normal driving conditions. This defect has put my safety and the safety of others at risk. On one occasion, the transmission failed while I was driving and I became stuck in the middle of an intersection, unable to accelerate, creating a serious traffic hazard. The issue has been reproduced consistently and has persisted despite repeated transmission fluid services. Multiple mechanics have inspected the vehicle and have indicated that the problem is not due to lack of maintenance, but instead is likely caused by the transmission not being properly filled with transmission fluid at the time of manufacture. Despite servicing, the problem continues, indicating an internal or manufacturing-related defect. I have also been in contact with multiple owners of the same make and model vehicle who report the same transmission failure, suggesting this is a widespread issue rather than an isolated incident.

While driving, the vehicle started knocking and jerking, lost power and began to run roughly. The check engine light initially flashed and then turned solid before the vehicle shut off. The next day, I took the vehicle to the dealership for a diagnostic after experiencing problems with knocking when the check engine light illuminated. The codes were P302 and 304 indicating misfiring. The diagnostic tech wrote the problem up as having oil in the cylinder and suggesting engine/turbo replacement for approximately $15,000.00. The engine has less than 100,000 miles. I asked about the 10/100. After inquiring about the recalls for GDI engines in the 2017 Tucson for rods causing engine fires due to oil leaking into the cylinders, the service agent stated that it was only the 2.0 and not the 1.6 with recalls. I said sir it is the same issue: high oil consumption, sputtering and knocking, check engine light indicating misfire. Now the oil is accumulating in the cylinders. He stated that because I am the secondary owner neither the dealership nor Hyundai will correct the problem. However, if I was the original owner the powertrain warranty would cover the repair. The problem with the 2017 GDI, DCT in the Tucson is a safety issue for all owners. Escalated the issue to Hyundai Motor America, agent Kyrillos, who said that he would contact the dealership to check for prior authorization with the dealership to see if they would cover it under the recall. After numerous calls (on my behalf) and finally speaking with Kyrillos, I was advised that the dealership denied the repair. I requested supervisor contact and have not had any further communication from the company. I did send a follow up email asking when I could expect to hear from them.

Car is burning oil. Oil change done at 3k and no oil in vehicle at all. Transmission shakes violently on start up and first movement and slips shifting gears. No response sometimes when pressing gas pedal to go

The transmission failed, and it's only at 70k. This was only diagnosed AFTER being told that my dual clutch was faulty. I had that replaced, only to be told that my actuator was faulty and NOT the clutch, after haviing paid for the replacement. Now, the vehicle will barely move with rpms through the roof. So not only was Ithe vehicle misdiagnosed TWICE, the cost of repairs was sky high! This could have been avoided. I contacted the dealerships, at they advised that they did everything as hyundai instructed them. Well, hyundai was wrong, and now my vehicle doesn't even work.

The transmission in my vehicle failed while driving and the car completely shut off while driving. Less than 4 months after replacing the transmission with a brand new transmission, the engine failed while driving on the highway. The engine started sputtering, then it started smoking, then the car stalled.

There is an intermittent problem with the transmission. It’s impossible to predict when the transmission will slip. When navigating traffic, it has happened multiple times trying to pull out across oncoming traffic, and the transmission begins slipping so badly in a couple of instances nearly causing a side impact. There are no recalls related to this, but the dealership confirms it is common… the fact that it is intermittent makes it worse. You get used to the transmission performing as it should… Next thing you know it slips when you can’t afford for it to slip..

I am writing to report a serious issue with my 2017 Hyundai Tucson SEL 2.0 that poses potential safety risks. The vehicle is consuming more than 4 quarts of oil every 1,000 miles, which is far beyond normal and acceptable levels. The car has approximately 166,000 miles on it and has been regularly maintained, including timely oil changes. Despite proper maintenance, this excessive oil consumption leads to frequent low-oil warnings, risking sudden engine failure if not continuously monitored. This creates an unsafe driving condition, particularly on highways or during long trips, as the engine could seize without warning. Additionally, I am aware that many other owners of Hyundai vehicles with similar engines have reported comparable issues. This suggests a widespread defect in the engine design or manufacturing process. I am requesting the NHTSA to investigate this matter further to determine if a recall, warranty extension, or other corrective action is necessary to address this issue. Hyundai should be held accountable for resolving this problem, especially since it compromises the safety and reliability of the vehicle. Vehicle Information: Year: 2017 Make: Hyundai Model: Tucson SEL Engine: 2.0L VIN: [Your Vehicle Identification Number here] Thank you for your attention to this matter. I hope for a prompt investigation and resolution to ensure the safety of all Hyundai Tucson owners.

Greetings, I have had issues with the Hyundai Tucson 2017 I own for many months. Issues include among others an abnormal knocking noise from the engine, reduced engine power and/or hesitation, burning smell, oil leaking, and smoke coming out of the engine, misfires, and other issues. It happened many times on the highway and almost caused accidents and the last time it happened, the vehicle was towed, and recently the smoke coming from the engine forced me to pull over. I reported the issue to the dealer but they didn't recall or address the issue. The car has been maintained properly over time and now I fear for my life. It is totally unfair that about 100k of this brand have been recalled for the same issue, in my case it is just after I finished to pay in full the vehicle. I seek your support to have it addressed for safety