2016 Hyundai Veloster Complaint Log

The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at 35 MPH, the vehicle shuddered and stalled. The vehicle was restarted. The contact shifted to reverse and pulled into a parking lot. The message that the transmission had overheated was displayed. The contact used a scanner and diagnosed the vehicle with clutch actuator failure. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 86,494.

I was driving on 8 east freeway when all of a sudden my car lost complete power. Engine light flashing, and couldn't pick up any speed. The truck in back of me almost hit me cause my car wouldn't go. Prior to this incident, my car was and has been working perfectly. . My mom had it towed back home and got a mechanic to check the code and it gave a P1326 code which is exact code for a previous recall on these cars. I contacted Hyundai Corporate and the rep told me to take it into a Hyundai dealership to get repaired but to mention that campaign 966 was performed on the car already. Which was to prevent the p1326 recall from happening. And clearly it didn't.

I was instructed by Hyundai USA to tow my Veloster to West Palm Beach Hyundai dealership specifically for the rod bearing diagnostic after I reported huge amount of smoke coming from the engine, engine oil leak, failed thermostat, and failed water pump, all while I was driving to work. I have repeatedly asked for Hyundai USA to send me a copy of the technician's notes, oil pressure test results, and bearing clearance measurements, part of Hyundai's TSB 21-GI-009H. Hyundai USA continues to refuse to release to me the technical rod bearing diagnostic report completed on my 2016 Veloster. Since rod bearing failure is a safety recall issue (stalling), I am listing your help to explicitly request the Service Manager's diagnostic report and photos of the rod bearing clearance test. I can't get to work with my Veloster because it is unsafe to drive and has been at the dealership since January 17, 2026. My safety is at risk.

On March 2024, I had my veloster towed to a certified Hyundai service dealer because it suddenly began losing power, the oil light came on, the engine light flickered, and it began making a whining noise, and then the engine died and wouldn’t crank again. It took them weeks to diagnose it, and they told me the turbo was out in it, and quoted me an absurd amount to replace it. I had the turbo replaced, as well as some gaskets, the coils and spark plugs. It ran fine after that until June 2025 when the oil and check engine light came on and the engine died again while we were coming home from a vacation, 2 hours south of where we live in a tiny town that had no dealership or rental company within 100 miles. We found a small mechanic who said it needed a lower fuel pump. He put one in it and we got back on the road, but it still wasn’t running as well as it should. It don’t have quite as much power, but no dash lights came on. When I got home I took it to another local certified Hyundai service dealer, who said it needed new coils and spark plugs again, so they replaced them. Again it ran fine for a while until the day after thanksgiving this year, 11/25, when the oil light came on again at the end of my road. I took it to another local certified auto parts store who read the codes and found no suggested fix. No certified dealers were open that day, so I took it to Pep Boys where the engine light came on when I pulled in, and who said they thought it needed new timing solenoids, and put them in it. When they finished, they drove it and told me they felt like the turbo was going out and advised I take it to the dealer again. I had it towed to a certified Hyundai service dealer on Monday 12/01/25. They diagnosed it as needing a new turbo (again), a lower oil pan, and an oil switch. Quoted $3550. Over a week later today they told me that after putting it all in and tiring it on that the oil light came back on. They have now diagnosed it as needing an oil pump.

While driving my 2016 Hyundai Veloster (VIN: [XXX] ) on the highway, the vehicle suddenly lost acceleration. I went from 60 mph down to 20 mph with no throttle response, and the car only continued moving briefly from momentum. I was forced to stop in unsafe highway conditions and had the vehicle towed home. Prior to this complete failure, the car had recurring transmission/drive issues: it would start, but when placed in reverse it moved backward, and when shifted into drive it still only moved backward. Despite repeated repair attempts, the problems persisted. A certified mechanic later inspected the vehicle and confirmed severe internal engine damage, including metallic noises, blue smoke, oil leakage from worn piston rings, and complete compression loss. The mechanic concluded the vehicle requires deep engine repair or replacement. These failures are consistent with widespread reports of Hyundai Veloster engine defects, which pose serious safety risks to drivers. My vehicle is now inoperable despite responsible maintenance and repeated attempts to fix the issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

King Hyundai hung up/refused free Recall 198 inspection despite confirmed defect (rod bearing/crank damage). VIN [XXX] . Case #1824300. Safety risk—stall/fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

When changing vehicle oil it has been noticed that there is contaminants appearing to be metal bits/glittery could possibly be rod bearing material. Also have noticed fluctuating idle

TRAUMATIC CRITICAL FAILURE At [XXX] (XXX), in p/u spot, put car in P, got out, reached in to grab wallet when car lunged into R, as if being driven. Ran over & drug me until it hit another car to stop it. serious pain in L ribs (previously broken & healed 5 yrs prior), felt like sternum re-broken from accident prior year, broken & healed. Back pain. Onlookers horrified & called 911. Taken by ambulance to Baptist Medical Center3300 [XXX] . I told ER Dr about injuries. CT Scan performed, broken ribs, sternum broken & displaced & fracture in spine. MRI completed yr prior after accident & only break was sternum. I have CT Scan & MRI results. Two wks later, in severe pain w ribs, wondered if I had pneumonia (I'm 62),, went to Urgent Care [XXX] took x-rays & called ambulance to pick me up, went to [XXX] [XXX] . Treated for rib & back pain & had a pleural effusion, most likely related to accident. Lost so much income, finally drove & about a mth later, at window at Jack in the Box, put car in P as I waited, after about 1 min, car started going fast into R, wouldn't stop, I had to turn car off. Fixed at Firestone. Broken shifter cable. About month later, still issues, Car threw itself into D when trying to go in R while driving. I assumed car wouldn't go in R. Took to Firestone next day. They said nothing wrong, went in all gears fine other serious car issues from day 1, currently at [XXX] Hyundai [XXX] Issues w car from day one, issues w SM at dealership that did work-alternator, starter, battery, tried to commit fraud, kept car hostage for wk, wouldn't give paperwork when asked for recall 198 Car engine knocking loud, kept running when turned off, consuming massive amts oil, began stalling, causing accident, further issues & my putting $ into car INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Greetings, I went in for an oil change and was notified that my car airbags did not work and/or have not worked for an indeterminant time. The dealership ordered a part which still has not arrived. It’s been nearly 3 weeks, and I am unable to collect my car unless I pay $2,000. I’ve been paying out of pocket for a rental during that time, and as a college student have missed some classes. Currently, my car is still at the dealership unable to be driven safely. They say the seat sensor went bad and disabled my entire airbag system. There’s no telling how long my family and I have been at great risk of injury or death driving this car. I’m afraid to pay or pickup the vehicle as I’m unsure if it’s safe. I have been denied warranty coverage from corporate Hyundai and from the dealership. Im not sure how to proceed.

The contact owns a 2016 Hyundai Veloster. While the contact’s wife was driving at an undisclosed speed, the vehicle suddenly lost power, with the check engine warning light illuminated. The contact stated that the vehicle then stalled at a stoplight. The vehicle was restarted and immediately driven to the local dealer, who diagnosed the vehicle and determined that the engine compression was abnormal and advised the contact that the engine needed to be replaced. The vehicle was not repaired. The contact stated that while at the dealer, the service and diagnostic guidelines were not followed regarding the NHTSA Action Number: EA21003 (ENGINE), and the coverage was denied. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 125,367.

The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment, and the vehicle failed to exceed 40 MPH, prompting the contact to discontinue driving the vehicle. The check engine and low oil pressure warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed that the connecting rod bearings failure had resulted in the engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000(Engine), but the VIN was not included. The manufacturer was notified of the failure but no assistance was provided. The failure mileage was 99,000.

I am going to answer each point one by one for clarity. 1.) Mass oil consumption from bad piston rings, and yes it is available. 2.) I was driving after work one night and my oil pressure light was blinking red. Needed to immedelty pull to the side and have someone get me oil to top off. This was when I first found out about this issue. 3.) Yes as it is a constant problem and I've had two different mechanics look and confirm that my engine is essentially toast. 4.) No, not yet as I am not willing to pay an absurd amount of money for a dealer inspection unless they truely mean well with it. 5.) Other than the red oil pressure light I mentioned eariler, no. This was Augest 12th. Bought the car from the dealer April 18th.

The contact owns a 2016 Hyundai Veloster. The contact stated that after completing a routine oil change, the contact discovered that while starting the vehicle, there was an abnormal knocking sound coming from the vehicle. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 20V746000 (Engine). The contact had an independent mechanic inspect the vehicle, who determined that the failure was related to the engine. The local dealer was contacted, and it was diagnosed that the engine needed to be replaced. There was corrosion around the engine. The vehicle was not repaired. The manufacturer was contacted, and requested the maintenance records, but declined to assist due to maintenance neglect. The contact stated that the maintenance records were not accessible due to not being the original owner. The failure mileage was approximately 150,000.

As I was driving to work one day my 2016 Veloster suddenly lost power on the expressway at expressway speeds. Now that in itself is very dangerous seeing as how there were big rigs around me. Luckily I managed to make it off of the expressway traveling slower than I turtle.i was almost rear ended on various occasions. I parked right away and left to work. I came back later that day and cranked her over and it started,but now with the check engine light blinking. So I attempted to drive it a little and it worked but now I've come to find out that it is in protect mode.I took it to my local Hyundai dealership (Hyundai of pharr) in pharr Texas and was told that Hyundai would not honor their extended warranty because whatever is wrong with it is not covered according to them. So a while back there was a class action lawsuit in California against the Hyundai Corporation of which I was a part of. When it was time for settlement I had a choice of monetary gain or and overly extended warranty on my 2016 Veloster that covered engine and transmission for I believe was 10 more years. So I chose the warranty but Hyundai still won't cover it. I guess I have to wait for my car to catch on fire before they submit the warranty and even then they will blame something else. So here I am,telling my story.

The climate control knob and AC system failed due to an apparent wiring defect. This is a known issue affecting hundreds or thousands of Hyundai Veloster owners. The failure causes loss of climate control and creates a safety issue due to a lack of defrosting and cabin airflow, as well as electrical fires. I have spent thousands of dollars trying to get this fixed, and mechanics are turning me away.

The contact owns a 2016 Hyundai Veloster. The contact stated that while the vehicle was parked, the sunroof glass shattered. The contact was unaware of what caused the glass to shatter. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 90,900.

The contact owns a 2016 Hyundai Veloster. The contact stated that while driving 65 MPH, the vehicle hesitated to respond while depressing the accelerator pedal, failed to exceed 45 MPH and made an abnormal knocking sound. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic who referred the contact to the dealer. The vehicle was taken to a dealer where a BCT (Bearing Clearance Test) was performed, and the knock sensors were replaced; however, the failure recurred immediately while leaving dealer's parking lot. The vehicle was taken to two other independent mechanics, where the contact was informed that the engine needed to be replaced due to damage to the engine rod bearings. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V746000(Engine); however, the VIN was not included in the recall. The manufacturer was notified of the failure and the contact was referred to the dealer for assistance. The failure mileage was approximately 79,700.

While driving home one late night, the engine completely locked up while driving causing the vehicle to come to a halt and left me stranded in the road. Got it off the road and eventually towed home where it was later inspected and found the engine bone dry of oil. There were no signs or indications there were any issues with oil leaking, etc. After much research, it's a commonly known issue with other Hyundai makes and models and even some of the same as mine in other years. This engine only has 100,000 miles on it. It just barely broke that mark before completely leaving me stranded. It's still an unresolved issue as no one wants to repair my car.

I am the second owner of a 2016 Hyundai Veloster Base, purchased used at approximately 19,976 miles. Since then, the vehicle has experienced multiple major powertrain-related failures. At 49,196 miles, the first catalytic converter failed and was replaced. Later, both the engine and second catalytic converter were replaced by Kearny Mesa Hyundai, a certified Hyundai dealership in San Diego, CA. When I brought the vehicle to Kearny Mesa Hyundai, there were no warning lights or active diagnostic trouble codes. However, the dealership’s service documentation stated that a P0420 code (catalyst system efficiency below threshold) was present — a code that was not active when I dropped off the vehicle, raising concerns about diagnostic accuracy or documentation. Now, at 61,982 miles, I brought the vehicle to Hyundai Ontario due to delayed shifting and hesitation when accelerating. The dealership diagnosed internal transmission failure and quoted approximately $5,000 for repairs. There were no warning lights or codes detected, meaning this diagnosis is based solely on driving symptoms. The failure of two catalytic converters, the engine, and now the transmission — all within approximately 42,000 miles of ownership — raises serious concerns about the long-term reliability of this vehicle and possible manufacturing defects. The transmission symptoms pose a serious safety risk, especially when merging or accelerating into traffic. I am requesting that this vehicle be investigated for potential systemic issues affecting its powertrain components.

The car is sluggish and loses power when it is taking off. It is like it is in slow mode. The other issue is that it uses lots of oil. I even had the dealership to repair the valve cover gasket. It should not use oil at the rate.

The car stall when I'm driving

The reason I am submitting this form is because my 2016 Veloster Turbo has an open recall out for premature wear in the bottom end (bearings and rods) and my car has been experiencing the same problems. I have had the highest rated shop in my area to look at the wear directly and it is clear this is the problem with the engine. Despite this all attempts to contact dealers and the manufacture have resulted in those parties claiming my unit was not affected during the recall and therefore there is nothing they can do to help me. It is clear my engine is experiencing the exact problems detailed in the recall and I have treated this engine as well I can as I had knowledge of these problems, even still my engine is only a couple hundred miles away from blowing up completely and not running. When this car was bought I added a catch can to specifically help with the premature wear on the engine as well as never revving the engine to over 5,0000 rpms. As well to both of the previously mentioned conditions I have consistently changed the oil every 3,000 miles or before with the best oil and oil filter money can buy. Despite all of this and treating the car as well as I possibly could I still experienced significant terminal damage to my engine and I haven't even hit 99,000 miles yet. This whole experience has been awful and near impossible even for me someone who is very well equipped to handle car problems and I can't imagine how a regular family with basic car knowledge could ever navigate and handle this situation accordingly. All I am looking for is some type of help in any way to move forward my car is still running and driving but if I continue to drive it, it will most definitely blow up leaving me stranded. Thank you for your time.

The component that failed is acceleration. He came from work at the Frywed when he reduced the speed from 65 to 30 and no longer accelerated .. if an independent service had no warning or failure at that time they were detected

The engine has a known issue with the port holes being too small to allow adequate oil flow, this has been addressed in the non turbo engines. Our veloster had the same malfunction engine failure in which hyundai is not covering and the dealership is doing a goodwill coverage of only 70% expense of engine only. When the engine throws a rod due to the malfunction it damages the turbo most times and they are requiring a full payment for that issue. Main focus is the engine when replaced has larger holes/ports and the engine can perform adequately. So as a consumer and owner we want to advise on this unbalance of coverage of the extended warranty. Especially since the turbo engine is identical just adding the turbo which it's performing at a higher rate.

The contact owns a 2016 Hyundai Veloster. The contact stated while driving approximately 70 MPH, the vehicle lost motive power. The contact stated there was no warning light illuminated. The vehicle was taken to a Midas where it was diagnosed and determined that the fuel pressure regulator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 119,000. The VIN was unavailable.

The contact owns a 2016 Hyundai Veloster. The contact stated that the vehicle stalled while driving at an undisclosed speed. No warning light illuminated. The contact also noticed black smoke coming from the vehicle The vehicle was taken to an independent mechanic where it was diagnosed that the rod bearings failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer but was not diagnosed or repaired. The manufacturer was made aware of the failure and a case was opened The approximate failure mileage was 115,000.

My vehicle has been burning through oil for 2 years now. It started with me having to get oil changes every 3 months, then 2, then 1, now I am forced to go get oil top offs every 2-3 weeks or the check oil light comes on and car drives very rough. I have been reaching out and opening cases with Hyundai and working with my local dealer for a year now and still nothing is being resolved. I need my engine replaced and they refuse, wanting me to jump through hoops and doing various tests only to tell me that even after I pay thousands for the tests, there’s no guarantee they can replace the engine. This is a known issue when you search online and thousands of people’s Hyundais are being affected. This vehicle is less than 10 years old it should not be having these issues. Hyundai is at fault for creating faulty vehicles and they are refusing to do anything about it.

I have a 2016 Hyundai Veloster turbo and my AC started making a weird noise coming from my AC controller, I opened and my climate control resistor was burned and smelling and I’m worried about my car getting on fire and I seen this is a common problem in velosters

The contact owns a 2016 Hyundai Veloster. The contact stated while driving on the highway at 65 MPH, the vehicle started to jerk, and the oil warning light was illuminated. The contact pulled over to the side of the highway to inspect the vehicle and the contact became aware that the oil level was low. The contact waited for several minutes before restarting the vehicle and continued driving to the residence. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was informed that the catalytic convertor had caused the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage 132,000.

As I was driving on the highway I started losing power and a warning of transmission over heating appeared on screen. I let the car sit and cool down and when I started it up again the same issue persisted, I had the car towed home. My vehicle is available for inspection upon request. My safety was put at risk since I was driving and highway speed and car just slowed down during rush hour traffic. The vehicle has not been expected at this time.

Shortly after finishing major repairs at my local dealer, I started to expirience, what I believe, now, to be a "low-end engine knock". Engine knock can usually occur due to oil starvation, where the connecting rod bearings are worn and debris enters the engine. So, I brought my car back to the dealer to ask them what this strange noise was I was hearing; I asked them if it could be the brand new clutch, or their equipment they left in the engine bay for me. They gave me an answer and it was to not drive the car anymore. One employee of the dealer even suggested "wrapping it around a telephone pole"... They told me what the repairs would cost and I had not qualified for a warranty extention so I left. I acquired a definitive diagnostic elsewhere and was shown the gravity of the situation. My oil filter had caught pieces of the engine and it was dubbed an engine knock. This incident took me completely by surprise. I regularly changed my oil and never saw my levels get so low that they would be considered empty. I have only owned the car for 5 years and it being only 8 years old, I was hoping to enjoy the driving expirience for years to come. That sensation has been replaced with apprehension and possible engine fire... how do I afford to buy a new car every 5 years if I can't drive the one I have now??

On May 13, 2024 my car had it's motor replaced. This was done at no charge by Hyundai of Wesley Chapel (Not where I bought it). The motor was replaced because of a recall (Product Improvement Campaign 966/ Knock Sensor Detection System). On July 28, 2024 my car engine ( the new one they had given me 10 weeks earlier) overheated and broke down. We had the car towed back to Hyundai of Wesley Chapel. They were unable to determine the cause of the engine breaking down, other than that is was leaking coolant. Hyundai is asking me to pay for a diagnostic test, estimated at between $3,000 and $4,000 to determine the cause. We do not want to do that and don't believe we should be held responsible for this cost. We have not been provided with a loaner car. This is a big inconvenience that we need resolved.

The "touch screen" in the car has warped from heat and no longer responds to touch. Many features and settings for the car are no longer available. Not sure if it's a safety issue; it would depend on the car model and which settings are managed through the touch screen. Since I can't access the settings, I don't know what features or settings are now inaccessible, so I'm reporting the affected equipment as a precaution.

The contact owns a 2016 Hyundai Veloster. The contact stated while driving from a complete stop, the check engine warning light was illuminated. The vehicle was taken to AutoZone, where diagnostic test codes indicated a timing chain failure and other diagnostic test codes were retrieved. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed due to low engine oil, and the engine needed to be replaced. The dealer informed the contact that 2 quarts of oil was added to the vehicle. The vehicle was then taken to an independent mechanic, where the contact was informed that the engine was overfilled with oil. The mechanic diagnosed the vehicle and determined that the failure was related to the knock sensor. The vehicle was then taken to another dealer, Great Lakes Hyundai of Dublin (2441 Billingsley Rd, Columbus, OH 43235), where it was diagnosed. The dealer informed the contact that no engine failure was found; however, the catalytic convertor needed to be replaced. The vehicle was not repaired. The contact stated while her husband was driving at an undisclosed speed, the vehicle lost motive power, went into LIMP Mode, and failed to exceed 5 MPH. The contact stated that the failure recurred while driving 35-40 MPH. The contact was able to drive to the residence. The contact stated that the vehicle had become undrivable. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they relied on the dealer’ assessment. The failure mileage was approximately 96,000.

Rod knocking noise engine.

Code: P0087 show up when I scanned it. I was driving on freeway and my car lose power suddenly. This could potentially cause accident because it’s was heavy traffic time.

After noticing a significant shortage of oil, I took my 2016 HYUNDAI Veloster Turbo to get an oil change. There continued to be persistent low oil in my vehicle even after an oil change. I put things under my car to make sure there was no leak and the vehicle maintenance advisor informed me there is no external leak present when getting the oil change. I drove a week and my oil dipstick was already showing significantly low oil in the engine. After contacting Hyundai about this issue, they said I would need to go through the same process with them and they would not be held responsible for billing. This comes at a time where Technical Service Bulletin #23-EM-007H was recently released in December 2023 applying to 4-Cylinder Gasoline Engines. I’m concerned about the safety of myself and others due to the probability of a fire, however I have already paid out of pocket for maintenance that had diagnosed the issue.

There is a recall for 2016 Velosters that is for the engine rods failing. The 2015 to 2016 Hyundai Veloster has been recalled for connecting-rod bearings in the engine that could wear out prematurely and damage the engine1. The 2016 Hyundai Veloster has had several engine-related issues, including excessive oil consumption, going into limp mode, hesitating at acceleration, knocking sound in the engine, poor acceleration, stalling, failure in the timing chain tensioner, rough idling, and oil leaks. Which is exactly what is happening to my car currently. Told me I was not eligible. But I'm not understanding why.

Knocking on engine. All service necessary for the vehicle has been up to date. Hyundai Dealer has said to wait for a recall. Rod bearing recall has happened and my vehicle was never recalled.

The contact owns a 2016 Hyundai Veloster. The contact stated that while his son was driving at an undisclosed speed, he heard an abnormal knocking sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the connecting rod bearings. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 20V746000 (Engine) but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 130,000.

The contact owns a 2016 Hyundai Veloster. The contact stated while driving at approximately 30 MPH, there was an abnormal sound coming from the engine compartment. The contact stated no warning light was illuminated. The contact was able to drive the vehicle to the residence. The contact stated that while driving onto the driveway at the residence, the vehicle was vibrating violently and then stalled. The contact turned off and later attempted to restart the vehicle however, the vehicle started momentarily and then stalled. The contact stated there was cloud of smoke coming from the exhaust. The contact stated that prior to the engine failure, he became aware that the vehicle was consuming approximately 1 quart of engine oil every two weeks. The vehicle was not taken to a dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was not informed of the failure. The failure mileage was approximately 129,000.

Cylinder one lost compression. My mechanic pulled the engine apart and found the valve broke, a piece of the valve broke off. Compression test was only at 30 lb. in cylinder one. cylinder two had 120 lb., cylinder three had 130 lb., cylinder 4 had 149 lb. This Car had oil changes done every 3k to 4k miles with full synthetic. Never raced and always driven properly. 121k miles and the engine was basically done. Having the entire engine rebuilt for 5k$ now. I was having to add about a quart of oil every 500 miles before the valve broke.

02/??/22 immediately after purchase, the vehicle’s alternator died and had to be replaced. 12/06/22 catalytic converter blew with no warning while driving. Car was towed to mechanic. 12/07/22 repairs were approved, costing $1,748.66. Shop informed us this repair was due to a recall (campaign 22-01-023H-2) From 12/22 through 07-23 I opened many cases with Hyundai, who closed cases without explanation. During this time I am required to refill vehicle’s oil every month to stop engine knocking and prevent break down. 06/23 I was finally able to set an appointment to start the first step of the recall. 07/10/23 I arrived for my appointment to start oil monitoring, but was told to reschedule and come back later. 07/19/23 I arrived for my rescheduled appointment. Dealer made me pay for oil that was used and instructed me to return in 1,000 miles. After 1,000 miles I returned and left my car at the dealer for a few days. When I returned Hyundai staff told me the recall was “only for the original owner.” I was also told the recall was “already fixed” and there was “nothing wrong” with the car. I self advocated, stating again that the oil was depleting rapidly and what I had gone through. Staff told me to “drive the car until it breaks down, then Hyundai will cover the costs of repair.” I mentioned how that is unsafe, but was sent away. 11/24/23 vehicle completely broke down out of state in a dark and unfamiliar area at nighttime. Vehicle was towed, requiring engine repairs. 11/27/23 I opened a case with Hyundai regarding these issues. A few weeks later I was told the case was closed since they “had to believe the dealer and not the client.” 02/05/24 alternator died, vehicle required a tow to the mechanic. 02/06/24 repairs were approved for almost $1,000. I do not feel safe driving this vehicle as it is unreliable, breaks down without warning lights- which only appear after break down, and the manufacturer refuses to take accountability for these issues.

How do I get help with a complaint against Hyundai for non compliance . This is my 2nd engine fire!!

On 11/21/2023, I took my vehicle to Musser's Automotive in Tipp City, Ohio & I was informed of an Internal Oil Consumption & recommendation for warranty coverage.

The contact owns a 2016 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the engine made knocking sounds. Additionally, the vehicle hesitated to accelerate while driving. The TPMS warning light was illuminated. The vehicle was taken to the dealer, where Service Campaign 993 (Inspect & Anti-Theft Software Upgrade) was performed, and the engine was replaced. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 73,200.

After previous complaint I filed, my engine continued to decline. Began burning a quart of oil approximately every 240 miles and has now almost completely lost power. It will not go above 25 miles per hour. I can not drive it anywhere except within two miles of my house where the speed limit is 25mph. EXCEEDINGLY DANGEROUS! It will die while driving and crank right back up but then die again. As contained in my previous complaint - Check engine light has been flashing since last December, Oil light comes on approximately every 240 miles. Other model years of this car have been recalled due to oil issues - but not this one. Yes the engine has been inspected and everyone agrees the engine is bad but Hyundai refuses to do anything about it due to the car not being included in the previous recall years. PLEASE inspect it. Anytime you want. It's not like I can drive it anywhere. I would drive it straight to a junk yard, but am still paying on it. You should know, if you don't already, that Hyundai is regularly giving owners of cars that have been included in the recall, the runaround on repairing anything. There are multiple facebook groups with literally THOUSANDS of people complaining about the same or similar issues with their Hyundai vehicles and nothing is being done. The MOST disreputable company I have ever dealt with - from the dealer all the way up to corporate. READ SOME OF THESE STORIES TO GET A TRUE UNDERSTANDING OF THE PROBLEM... [XXX] [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Unknown Regular oil changes, cranked my car up one morning and it started knocking, I have been in a rental for 2 weeks now and paying out pocket as a single mother in grad school. The dealers excuse of not diagnosing the car sooner, is that their schedule is busy after arguing with the extended warranty company about my coverage. I booked their next soonest appointment to be told we'll see if we can get it looked at that day. I believe they're hiding the fact that my bricks falls under recall 198 and do not want to admit it.

When my car 2016 Hyundai Veloster reached almost 95000 mileage the oil starts to dissipate much faster so started to do oil change much often. Recently and my care already at 97000 mileage. We are driving going up a hill and it started to make some noise kind of like a motorcycle noise and I know there is something wrong but no light warnings or anything. I was trying to push it to get to a safer side of the road because I have my 86 year old mother with me but the car did nor make it and heard something snap really loud and the car just stopped and saw a little bit of smoke. Had to stop immediately on the side of the road and it was a bad spot against the rail and that blocked the 2 doors on the right side. the car only have 3 doors so now my mother is stuck and had to figure out how to have her crawl out to get out the driver side of the vehicle. If the car was on fire that would have been really dangerous. Took it to the mechanic and my insurance inspector already saw the car and determined that there was some kind of rod that came off and that the engine is blown an that it is with a hole. it is beyond repair or if I do it will cost $5000-$6000. I bought it on 2018 with only 5000 miles on it. I kept up with yearly maintenance. I think it is insane that it will break that fast and we are traumatize with the danger. I am not ready financially for this.

The contact owns a 2016 Hyundai Veloster. The contact stated while driving 40 MPH, the engine started knocking. The contact stated that several days later the knocking sound became louder, and the vehicle became inoperable. The vehicle was towed back to the residence. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and confirmed that the vehicle was not included in a recall. The failure mileage was approximately 109,852.