2021 Jeep Cherokee Complaint Log

PTU overheated, message is "4WD unavailable" or "reduced functionality". PTU replaced by Jeep, new PTU has overheated and will not go out of 4WD low unless car is turned off, PTU cools off for 20 minutes, will then go out of 4WD low. Dealer has confirmed the problem. Not sure what next steps are but I thought you should be aware of this recurring issue since the 2021 PTU is very similar to the earlier model PTU's that have been recalled.

The contact owns a 2021 Jeep Cherokee. While driving at an undisclosed speed, the vehicle abruptly lost automotive power, and the vehicle coasted to the side of the roadway. The contact stated the power transfer unit had failed, causing the transmission to become inoperable. The vehicle was towed to a dealer and was diagnosed with PTU failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 88,000.

I purchased this 2021 Jeep Cherokee, and it has developed a life-threatening defect where it performs an uncommanded braking while driving at speed. Without any warning the car slams on the brakes creating an immediate risk of a Rear end collision. Diagnostic scans show multiple critical failures: PO128 (the initial warning of a computer communication issues). Dealership (Echo Park) refuses to fix with the proper OEM part and denies my warranty, (I called it in on day 15 on my Warranty, 01/28/26) I let them know the fans were loud, RPMs fluctuating, tailpipe full of black soot and making a loud sputtering, this is burning up my fuel fast. My appt was on 02/10/26 They said there was nothing wrong with it. A couple weeks go by and then the check engine light turned on (after my Warranty) i took it back on 03/19/26, They visually verified the code, said I had to pay out of pocket to fix it with an aftermarket part not the OEM part. They set up an appt for 03/25/26. UO128 (lost communication with brake control module) and C008E-00(ECU internal performance). These codes are directly linked to the NHTSA safety investigation PE22- 009. When I took the vehicle to Allways [XXX] on March 23, 2026, the Service Department refused to perform a safety inspection without an upfront payment, despite the vehicle having exposed wiring in the steering column and part of an active federal safety probe. As a small business owner (Maid To Sparkle) grandmother who transports a [XXX] daily, I am now stranded with a vehicle that is unsafe to drive due to a documented a manufacturer defect. While at the dealership I was simultaneously on the phone with Jeep Customer Care. Despite the vehicle being under federal safety investigation for the exact ghost breaking I am experiencing both the dealer and corporate representative denied assistance and refused a safety inspection without an upfront fee This shows a coordinated refusal to address a documented safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Seatbelt failure in a 2021 Jeep Cherokee at approximately 80,000 miles. The seatbelt is not functioning properly and does not operate as intended, creating a safety concern. The issue was diagnosed by the dealership, who confirmed the seatbelt failure and stated repairs are needed. I was quoted 522 for the repair, and only partial goodwill assistance has been offered. Despite this being a critical safety component, I have not been provided a loaner or rental vehicle while the repair is expected to take 5–10 days. This leaves me without safe transportation. I am concerned about the safety risk of a failed seatbelt and the lack of full support for a safety-related defect

The 948TE 9-speed automatic transmission failed at approximately 75,000 miles on my 2021 Jeep Cherokee V6 80th Anniversary Edition. The Engine light eliminated while traveling down the highway. No noise or indication of engine or transmission trouble, Decided to head directly to the dealership. When I approached my first light off the exit (still no sign of trouble) the vehicle rolled backwards. Applying breaks to avoid collisions with vehicles behind, I tried accelerating with little to no power from the transmission. The vehicle is currently at an authorized Jeep dealership and available for inspection. This condition created a safety risk because the vehicle hesitated entering traffic and rolled backward while stopped, increasing the risk of collisions. An engine warning light illuminated while driving prior to complete drivability failure. Symptoms included delayed engagement and slipping from a stop, which worsened rapidly after the warning light appeared. The failure has been diagnosed and confirmed by an authorized Jeep dealership, which determined the transmission requires full replacement. The vehicle has been inspected by the dealership service department. No crash occurred, so no police or insurance inspection was involved. Jeep dealership would not offer any goodwill assistance despite being just outside the threshold for drivetrain warranty.

The 2021 Jeep Cherokee sporadically and infrequently engages the parking brake and hazard flashers. In order to disengage it, the car must be put in park and turned off then on, sometimes repeatedly. It has happened multiple times when the car is at a stop and in drive (at a stoplight, etc.) Recently it started happening while driving. The parking brake engaged and the car slammed to a stop nearly causing the car behind me to rear-end me. The dealership's service department has not been able to duplicate the problem or find any codes indicating a problem. They confirmed the software is up to date.

The contact owns a 2021 Jeep Cherokee. The contact stated that while driving at an undisclosed speed, the radio went black, with the message "Re-insert USB" displayed. The contact was unable to use the radio. Additionally, the rear-view camera, the AC/HEAT settings, and other safety features were inoperable and unavailable. The vehicle was taken to a dealer where it was diagnosed and determined that the radio needed to be replaced. The vehicle was not repaired because the parts were no longer being manufactured. The manufacturer was notified of the failure and informed the contact that the parts were no longer being manufactured. The failure mileage was approximately 92,000.

Car accident on 1/24 hit tree head on around 35 mph with NO airbags deploying. Suffered from concussion and whiplash, and potential of more serious injury. Insurance will be inspecting vehicle in the next week to determine total loss. No warning lamps, messages or other issues to the car prior to the accident

the light came on that says cannot move vehicle, it just stopped. The Power Transfer Unit went out--I cannot get a part since it is backordered over 1200 people right now are having issues with the part of the vehicle

PTU Failure. Known issue. 2017-2019 recalled but the part is still and issue and can lock up transmission. Recall needs to be extended to cover later years

I took my vehicle to dealer shortly after purchase due to jerking forward during stops. A software update was performed and did not have any issues until recently. The past few weeks it began to hesitate upon acceleration and jerked forward harshly into first gear. Today there is a very noticeable prolonged hesitation during acceleration and an odd revving noice coming from TPU. This should be a major recall given the frequency and severity of the issue which could lead to a crash.

The contact owned a 2021 Jeep Cherokee. The contact stated that there was an abnormal sweet/alcohol smell in the vehicle. There were no warning lights illuminated. The vehicle was taken to an independent while in the process of performing a stress test drive. There was a popping sound from the ignition, and it stopped on the interstate. Upon opening the hood, he noticed smoke and flames, and the vehicle fully ignited and caught fire. The fire department was on the scene to extinguish the fire and determined that the cable installation or hose installation failure of equipment/leak resulted in an electrical fire. There was no reported crash, air bag deployment, or police report filed. The local dealer was contacted, who referred to the manufacturer and the NHTSA hotline. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 64,000. The vehicle was deemed a total loss by the insurance company.

The contact owns a 2021 Jeep Cherokee. The contact stated that while his wife was driving at an undisclosed speed, the vehicle lost motive power. Several unknown warning lights were illuminated. The contact stated that the hazard lights failed to operate. The contact's wife coasted the vehicle to the side of the road. The vehicle was towed to the dealer, who determined that the battery had failed. The dealer replaced the battery. The contact stated that the battery warning light was not illuminated before the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 49,000.

The interior screen has become pixelated with different colors. This effects my back up camera which is a big safety hazard. All of the climate control, radio and general info are also on this screen. I have not had it diagnosed at the dealership because they charge 160.00 to just hook up to diagnostics.

I was driving on the interstate at approximately 70 mph when I attempted to accelerate to pass another vehicle. There was no response. At first, I thought I might have hit a patch of ice, but I quickly confirmed that wasn’t the case. I tried to accelerate again, and once more nothing happened—other than the engine revving. No warning lights appeared to indicate a problem. I coasted to the next exit and was able to safely park the Jeep. I then had the vehicle towed to a local Chrysler dealership. As it turns out, the Jeep had suffered a catastrophic failure of the PTU (Power Transfer Unit), which I understand has been a known issue for Jeep for several years. The dealership received a replacement PTU, but they quickly determined that the replacement unit was also defective.

The contact owns a 2021 Jeep Cherokee. The contact stated that while driving 50 MPH on the highway, the vehicle lost 4WD functionality. The message “Service 4WD” was displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the 4WD actuator had failed and the transmission needed to be replaced. The vehicle was not repaired due the part to repair the vehicle not being available. The manufacturer was not notified of the failure. The approximate failure mileage was 44,600.

While driving on the highway a message popped up that the 4 wheel drive system was unavailable. Then the orange error message displayed the svc 4wd. Then it went off. I called the dealership and was told to get it checked sometime, but since it went off there was no rush. I told him to check it when I brought it in for an oil change. Apparently they did not check it for error codes. No error messages or lights when I went to work. Came out to go home and the battery was dead. Called the dealership for a jump. They came and jump started me. When I put the car into reverse, it wouldn't go. I called the dealership again and they came back and said I'd need to get my Jeep towed to them. My Jeep was towed on Wednesday, October 29. It took the dealership a week to look at my car and find out that the PTU had metal chunks and slime in it.

My jeep initially shutoff while driving on the interstate at 70 mph last December. I took it the dealership and they kept it for 2 months and replaced several parts. I got it back and it shutoff the next day, but started after l let it sit for an hour. Then it went for weeks with no issues, then it started happening again, so I took it to a different dealership. They also repaired different issues. I got it back and it shutoff again on the interstate at 70 mph in rush hour traffic. Both times were scary and unsafe situations. The jeep has been at the dealership now over a month with no diagnosis. It has been at 2 dealerships for a total of 4 months. I've researched this and found out that there are a lot of people having the same problem with this jeep and similar types. I'm wondering why is this not a safety recall issue, because both of my situations could of ended badly if I had panicked. Please have this situation addressed or reviewed before it causes bodily harm! The manufacturer/dealership doesn't seem to take this seriously!!

Their was no incident

The vehicle was sold by DriveTime (Highland, Indiana) on August 29, 2025, with a known safety recall (Y18 – Transmission Oil Cooler Hose, NHTSA 21V-310) that had not been properly repaired. Jeep dealership documentation dated October 17, 2025, shows the recall was only “inspected” but no repair was completed. Within 30 days of purchase, the check engine light began turning on and off intermittently, and an AutoZone diagnostic (Code P0934 – Hydraulic Pressure Sensor Circuit Low) confirmed a powertrain failure related to the transmission system. The defect affects hydraulic pressure and gear shifting, creating an unsafe driving condition that risks transmission failure while in motion. The issue has been confirmed by both AutoZone and the Jeep dealership but not repaired. Dealer and warranty administrator SilverRock have refused to provide repairs or a loaner vehicle. Both entities were notified that the vehicle is used by a disabled driver and child, and this refusal poses serious safety and accessibility risks. Despite multiple warnings, both companies continue to deny responsibility, violating federal recall obligations under 49 U.S.C. §§ 30118–30120 and creating an ongoing risk of engine/transmission failure while driving. Related complaints are active with the Indiana Attorney General (Case #11811118) and the Federal Trade Commission.

About a month ago I noticed the gas pump clicking off quickly, way before the tank is full. I have been unable to fully fill my tank since. No accidents have occurred to cause a problem but my engine light is on and after getting it read it says it's an EVAC issue. When placing the nozzle in the tank a large amount of air noise is heard.

PTU failure

SVC 4WD

The car is reporting service 4WD, they are saying the PTU is bad. Took it into the dealership today.

PTU power transfer case. Service PTU light came on. We had the jeep dealership read the code and informed us that we needed to replace the PTU power transfer case. They said that it can be dangerous if completely going out because it can cause sudden loss of power. Afaulty power transfer unit (PTU) is dangerous in a Jeep because it can cause a sudden loss of drive power, increase the risk of a crash, or lead to a rollaway incident when the vehicle is parked. Jeep has issued multiple recalls for PTU-related issues, particularly for some Cherokee models, due to potential manufacturing defects that can lead to transmission failure however the year of my jeep is not included but it is the same issue that is currently recalled. I was also told that the PTU is on backorder because of the recall. It is on backorder for longer than 45 days. Why isn’t my Jeep included in the recall?

The service 4wd light is on. The dealership said it is a PTU problem. They want $2500 for a new PTU and of course add more money for labor. This seems to be a manufacturer problem not a car owner problem. It should be a recall item as it has been for 2017-2019 Jeep Cherokees. The dealer should fix this at no cost to the auto owners.

Our Jeep has had multiple accounts of shifting hard, hesitation while shifting, making a hard sound when putting in reverse and now it is having trouble starting up. When we charged the recently purchased (brand new) battery, the vehicle will start up but when placing in reverse it shifts so hard that it sounds like the bottom is dropping out. Now a lot of lights are shining on my panel; the check engine light, the forward collision light, the parking break light, the regular brake notification, the traction control light.....all shining up like Christmas lights. This is an ongoing issue and I feel a recall needs to be done. My car is over the warranty time frame and for a 2021 model that was purchased brand new I should NOT have to be replacing a transmission already and paying out of pocket expenses.

Incident occur on 25 August, 2025: While driving I experienced a violent jerk and sudden loss of power. The vehicle continued to drive with attenuated power, jerking motion during gear shifts, and loud clucking sounds coming from powertrain. There were no injuries or accidents as result of malfunction. The vehicle was later taken to dealership for diagnosis. The dealership determined root cause as a Power Transfer Unit (PTU) failure. PTUs for this vehicle are on backorder or not available from manufacturer. This vehicle is 2021 Jeep Cherokee Trailhawk 4x4 edition with a 3.2L V6 engine and automatic transmission.

The padding (foam) underneath the cover of the car seat is cracked/broken. It is available whenever for inspection. By the foam being damaged, it is no longer safe to use according to multiple reliable sources. EvenFlo is claiming for it to be just as safe after reporting the damage. I have sent photos of the damage to EvenFlo and they claim that they will not replace it due to being bought from a 3rd party retailer (brand new) and also claim it’s still perfectly safe to use. It was also inspected by the hospital prior to bringing my daughter home (there was no damage).

My vehicle was driving fine and I pulled up to a stop light. When I stepped on gas to drive after the light switched, the car would not move and made a loud noise. The brake automatically kicked in and car would not move. This could have been very dangerous as someone could have slammed into the back of my car which could have caused serious damage to me or my children. There was absolutely no warning of anything wrong with my car. I had to have my vehicle towed to a garage. The PTU in my jeep went with absolutely no warning. This part is on back order apparently because there are so many issues with this part on jeeps. Prior year jeeps have this item as a recall which leads me to believe that this is a Jeep problem that should have been fixed already. So now I am without my vehicle for a month.

When taking off out of my driveway the car hesitated to send power from the engine to the wheels resulting in a delayed start. Unknown which component caused the issue but based on my previous 2014 trailhawks PTU 2 x failure it appears to be the suspect. This placed my me and my family at a risk of a side collision as vehicles drive down our road at high speeds. If we cannot pull out in time, a collision is likely to occur causing serious injury or death. Vehicle I available for inspection upon request but has not been inspected by a dealer, independent shop, of police for this problem and there were no indicator lights that came on.

I have had a service 4wd light on for months. The Power Transfer Case part has been on backorder from jeep for over 4 months and I have been left with out a vehicle this entire time with no updates or information about when the parts will be available.

On May 13th 2025 the 4WD service light came on. We took it to the Dodge Jeep Ram dealership that owns the used car dealership we bought it from. After the mechanic checked everything, they said it was drivable but they needed to order a car part (PTU). Once that car part arrived at the dealership they would have us bring the car back in and they would fix it. On July 8th of 2025, stil no news on when the part would be delivered to the dealership, the car started making weird noises and was not drivable on the road. AAA towed it back to the dealership where they confirmed the Power Transfer Unit stopped altogether (PTU). From there they said they will keep the car until the part comes in, the car part was estimated August 8th. It is now September 11th and they still have not received the part to fix the car. I have contacted Jeep Customer Service, a Law Firm, etc as there is no recall open on this vehicle and it seems to be an issue as our dealership said there were 10 other Jeeps waiting for this part.

July 3 purchased used Jeep 2021 18,500 miles from a Lincoln Dealer July 5-7 notified dealer something wrong with engine July 10 drop off at Lincoln dealer was told Jeep would be taken to there Jeep Dealer in Titusville for service July 16 we find out Jeep has been delivered, July 21 was told the Jeep needs new engine, ordered was placed, as of today Aug 26 no ETA I filed a case with Jeep Care, they state no ETA maybe October. No warnings when I did the test drive, within an hour of driving and got home engine made terrible sounds etc reported it right away

UNKNOWN purchased a used 2021 Jeep on July 3, 2025 received the CARFAX showing it passed all tests however, after I drove off the lot the engine sounded funny, took it back on July 10, they send the car to a Jeep dealer who stated it needed a new engine I also stated the AC smells funny, which they never addressed I finally got my jeep back end of Septemeber with new engine never heard a word from the Dealer even after 2 attempts to speak with them to get a full refund

The check 4wd light on, the PTU needs replaced

The power transfer unit failed and lost power lots of grinding noises and could even roll when in park. What worries me more as I read about this is how many seems to be failing

Driving a 2021 Jeep Cherokee Trailhawk on the interstate with cruise control engaged. All of a sudden the vehicle decelerates/downshifts and the display screen flashes "4WD System Unavailable Service Required" and "4WD Neutral Warning". Trying to cross traffic to get to the shoulder of road and almost hit due to deceleration. Press gas pedal and nothing. Traction control light flashes on. Coast cross traffic to shoulder side of the road. Shut off Jeep. Check for loss of fluids and/or parts. Check brakes. Nothing. No smoke. No burning smell. Turn vehicle on. Vehicle automatically engages parking brake. Shift off parking brake and shift vehicle into drive and it makes a grinding noise like its trying to shift into 4WD. Snow mode pops on as well as the FWD Collision light and traction control. Jeep ran just fine until this point and no prior incidents, no bad/hard shifting. NOTHING.

Upon exiting a major interstate highway, I slowed down and attempted to merge onto a divided highway. The vehicle (2021 Jeep Cherokee Trailhawk) did not respond, as their was little or no power. Cars behind me, took actions to avoid me. After coasting to the shoulder of the divided highway, I placed the vehicle in park and then back into drive. I experienced a grinding, oscillating noise and a dashboard warning message stating to service 4WD system. I repeated this procedure and was able to advance the vehicle at a slow/steady pace to a local Chrysler, Dodge, Jeep dealership, not far from the malfunction. Dealership has confirmed a major PTU failure, one of the "worst" they have seen. I was also informed that the stated wait on replacement parts is 45 days.

Car completely died while operating. No Power. Dead in middle of the road. Unable to signal other cars. Jeep dealership ran code and replaced battery. Did not check PTU as requested. Car is now acting up similar to PTU issues. Exact same experiences as outlined in the recall for 2017 to 2020. 2021 should be included for this recall and reviewed or repaired as this is a known issue in jeep cheerokes. This is a serious issue due to the fact that they shut down immediately leaving you in the middle of the road with zero ability to notify anyone you are stopped. No warning signs were present.

The contact owns a 2021 Jeep Cherokee. The contact stated while attempting to drive from a complete stop, the vehicle stalled. The contact stated that the vehicle was able to restart after several attempts. The check engine warning light was illuminated. The contact stated that while driving approximately 5 MPH and making a turn on the same day, the failure recurred, nearly causing the contact to crash into a vehicle and to be rear-ended by another vehicle. The contact stated that the failure had recurred on another occasion. The dealer was notified of the failure and advised the contact to take the vehicle to their location for a diagnostic test. Additionally, the dealer informed the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 51,000.

2021 78784 MILES WONT DRIVE 4 WHEEL LIGHT ON DEALER STATES NEES NEW PTU SAYS THERES MAJOR PROBLEMS WITH THE PTU BUT WILL NOT COVER UNDER WARRANTY. $ 4, 000 TO REPAIR 99 COMPLIANTS HERE ALONE

PTU failure Service 4WD Light came on in April 2025 problem confirmed by independent service center has not been inspected by manufacture, police, insurance or others

I was driving on the highway with no overpass, no foreign objects flying, not behind anyone, and my sunroof shattered and exploded all over me with no explanation.

PTU went out at 42,900 miles 2 weeks ago traveling on I81, was very foggy and all of a sudden my rpm went crazy and check engine and service 4 wd light came on pulled to side of highway and car was reving itself on and off and when shifting to drive or reverse car would not move and emergency brake was engaging on it’s own. Called Triple A and had to have towed on truck to dealer . Just bought vehicle 3 months prior . Dealer tested and told me PTU went out in vehicle not sure when part will be available could be months . We were sitting on berm of highway for an hour in foggy conditions and semi trucks flying by was very scary.

Failed rear driveline failed rear differential and failed DTCM. Jeep is still sluggish upon shifting to acceleration. Clunk from park to drive and cold start to warm up normal to drop to normal rpm then rev up to 2.0 while sitting still. I have suspicions that the PTU could be having issues after all the above was replaced

"Service 4wd" message came on after startup one day.

2/16/2025 Light for 4WD came on when the temperature was 11 degrees. 4WD System Unavailable Service Required 2/19/25 & 2/25/25 Taken into the dealer and stated that Debris in the PTU causing Actuator to stick - will need to be replace PTU - if approved will need to locate part. Car difficult to put into park

Vehicle hesitates to go into gear and upon takeoff resulting in slamming into first gear. This causes significant stress on the transmission and PTU causing premature failure. Additionally, loss of power to the wheels upon take off could result in a vehicle collision when turning into on coming traffic.

The contact owns a 2021 Jeep Cherokee. The contact stated that while his wife was driving 75 MPH on I-15 and accelerating, the transmission seized, and the vehicle skidded to the side of the roadway. The contact stated that the engine was running but the vehicle failed to move. There were no warning lights illuminated. The vehicle was towed to the local dealer, where codes were retrieved for the power transfer unit (PTU); but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 99,000.