2022 Jeep Gladiator Fuel System Problems

I suspect there is a design flaw with the gas tank. Everytime I put gas in the vehicle, and I go to multiple gas stations, the automatic shut off on the gas pump will stop pumping gas when the tank is full but the aperture to my gas tank regurgitates a great deal of gas onto the ground. Even when pumping at the slowest speed, I manage to spill 4 plus ounces of gas onto my car and the ground. This happens every time, and I doubt I am the only person this happens to. I have never had this issue with my other automobiles. This occurs every time I get gas.

When filling gas tank and letting the pump stop on it’s own, Tank gets full, pump clicks off, fuel pushes back out of the fuel filler and I end up with fuel spill on my car and the ground. I worry that fuel spilling and any source of ignition equals a posible fire hazard. Jeep dealership replaced the fuel filler neck but the issue continues. After one repair attempted , I took the car back to dealership two other times for the same concern. 2nd time they say unable to replicate and the 3rd time did not perform any repairs. I have multiple videos of this issue happening when filling up the tank of my jeep. Vehicle has 27385 miles has done this since new, just doesn’t do it all the time.

I've been on the waiting list for 9 months and they said it would take about 30 more months for me to get the part fixxed.

Drove the vehicle approx 18 miles to work in the morning. The vehicle sat parked, locked and secured in a corporate office lot visible from office. Left for the day and as I started to drive began to smell gasoline. Looked for a gas trail and didn’t see it. Continued to drive and occasionally would smell gas. When I arrived at home, looked in the engine bay and it was dry. Looked underneath and saw that the passenger side undercarriage was dripping with gas. So much the fumes filled the garage and began to move into the house. Parked the vehicle on the street and contacted local dealership. Dealership via phone said only appt is approx more than 2 weeks out and couldn’t give an answer what would happen if the vehicle was brought in and or towed in. I explained the safety aspects of an active fuel leak and they still couldn’t find a way to make an appointment. The next morning a small plate sized leak of fuel as on the asphalt directly under passenger side (where fuel tank is). Vehicle hesitated when starting, when it finally did I looked for active fuel spilling and could not locate. I began to drive to dealership. At one one point when I stopped for a long red light the smell of fuel was overwhelming. Arrived at dealership where you could and smell gas. Went into office and again was told that with out an appointment that was over two weeks out nothing could be done. Again explained the safety aspect of an active fuel leak and was blankly looked at and then told the only appt is more than 2 weeks out. Finally asked for supervisor and they said that it could be left but wouldn’t be seen for 4-5 days. They rented me a vehicle and boldly stated that “if” the cause of the defect wasn’t done by aftermarket parts or vandalism then they would contact jeep to see if the vehicle could be repaired under warranty. This was stated several times. The vehicle is 2 years old and has approx 19000 miles on it. No aftermarket fuel or engine parts have been installed and there was no

The contact owns a 2022 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 23V263000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available

The contact owns a 2022 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 23V263000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

We have 2 2022 Jeep vehicles with the EcoDiesel engines in them (a Gladiator and Wrangler) that we purchased in 2022. I am filing a case for each of them on this site. In April 2023 there was a recall of the fuel pump on the 3.0 EcoDiesel and to date the problem has not been rectified for either of my vehicles. We have made notification to the dealership that we want to get this done but they say they do not have the parts in stock to do it. The dealership said they only get 1 fuel pump a month to replace and we are waiting and have been waiting for about a year since we notified the dealership for this safety issue to be rectified. I am filing this complaint as directed by the NHTSA website because I feel this issue has not been handled in a timely fashion and I believe that it is irresponsible of Jeep to not rectify this in a much quicker fashion. Each time we call the dealership we are told they do not know when it will be rectified.

The contact owns a 2022 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 23V263000 (Fuel System, Diesel) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.