There are 12 stored owner reports matching the electrical system leading-label group for the 2002 Kia Optima in our NHTSA-sourced dataset. These are unverified consumer reports and may not reflect confirmed defects.
This group counts stored reports whose component label starts with one of this site's matching prefixes, ignoring case. Each matching report counts once within the group. Components mentioned later in the label or only in the narrative are not searched. How component counts work
Loaded 12 of 12 matching reports.
Open the full vehicle complaint log (all categories)locked the car as most people do, then went to unlock the car heard it unlock but the door would not open. I could hear the door sound like it was locking/unlocking like it was stuck. I tried to climb through the passenger side to open the door from the inside and it will not open. The door appears to be "unlocked" but it is not and will not open creating a hazard if in an accident there is no way to get to safety. In researching online this is a common problem and there is a part in the lock mechanism that gets stuck so the door does not unlock and cannot open. It appears it has been reported several times on the year of my car and other years but nothing has been done. There is no warning that this will happen, you just lock the doors and then it doesn't unlock.
MY 16 YEAR OLD JUST PURCHASED A 2002 KIA OPTIMA SEDAN ON SATURDAY 8/20/2016 FROM A USED CAR DEALERSHIP. VERY FIRST CAR, HIS OWN EARNED SAVINGS. UPON FINALIZING THE PAPERWORK, WE LITERALLY WALKED OUT THE DOOR & IMMEDIATELY WERE UNABLE TO UNLOCK HIS DRIVER'S DOOR WITH THE KEY FOB. THE CAR WAS STATIONARY, NOT RUNNING, PARKED IN ALL INSTANCES IN REGARDS TO THIS COMPLAINT. COINCIDENTALLY, IT WORKED PERFECT FOR OUR TEST DRIVE. I DO ALSO HAVE SIGNED DOCUMENTATION STATING THE CAR LOT DOES NOTHING TO THE CAR ELECTRONICALLY, MECHANICALLY OR OTHERWISE AS WELL IF NEEDED. I WAS HOPEFUL IT WAS THE KEY FOB BATTERY, BUT IT'S BEEN REPLACED & STILL NOT WORKING. WE'VE HAD THE SAME ISSUE WITH ALL THE LOCKS SINCE & NO SUCCESS TO UNLOCK WHEN NEEDED. HE USES THE DRIVER'S SIDE THE VAST MAJORITY OF THE TIME, BUT ALL WITHOUT WARNING WILL NOT LOCK OR UNLOCK WITH NO RHYME OR REASON. HE'S HAD TO CRAWL OVER FROM THE PASSENGER SIDE TO GET IN EVERY TIME. MY NIGHTMARE AS ANY PARENTS IS GOD FORBID A FIRE START OR HE ACCIDENTALLY GOES INTO A BODY OF WATER & IS TRAPPED. I REALIZE IT'S AN OLDER CAR BOUGHT USED, BUT I SEE THERE ARE DOZENS OF COMPLAINTS ABOUT THE LOCKS, NOT JUST ON YOUR SITE. EVEN A CLASS ACTION LAWSUIT THAT WAS MYSTERIOUSLY "VOLUNTARILY DISMISSED" BY THE PLAINTIFF IN 2015. CASE NO. [XXX] FROM WHAT I CAN SEE. WHERE IS THE RECALL? WHAT DOES IT TAKE TO HAVE ONE ISSUED? WE DON'T HAVE THE FINANCIAL CAPABILITY TO PAY FOR A MANUFACTURER DEFECT THAT IS ALREADY BEEN UNCOVERED YET AMAZINGLY NO ONE IS REQUIRED TO REPAIR? NOR DO I FEEL WE SHOULD HAVE TO. ANOTHER POINT TO NOTE IS EVERY SINGLE VIN # I'VE SEEN COMPLAINTS ON THIS SITE, ARE IN VERY CLOSE NUMERICAL SUCCESSION WITH OURS. I HAVE TO SAY IT SEEMS VERY UNLIKELY IT'S SHEER COINCIDENCE. I UNDERSTAND COMPANIES NEED TO GUARD THEIR "BOTTOM LINE" BUT WHAT COST? I SINCERELY APPRECIATE YOUR TIME & FEEDBACK. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. AFTER STARTING THE VEHICLE, FLAMES STARTED TO EMIT FROM UNDERNEATH THE HOOD DUE TO THE WIRING NEAR THE STARTER. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 220,000.
WHEN YOU TURN MY CAR ON IT DOES NOT WANT TO TURN OFF. WHEN YOU ARE DRIVING THE CAR IT SUDDENLY SHUTS OFF AND STOPS. I HAVE READ SIMILAR REPORTS OF THE SAME THING HAPPENING AND UNDER THE RECALLS IT LISTS THIS AS A COMPLICATION. I HAVE CALLED KIA AND WAS TOLD THAT MY VIN NUMBER DOESN'T HAVE A RECALL ON IT AND WAS TOLD THAT ANY REPAIRS WOULD BE OUT OF POCKET. I HAVE ALREADY HAD TO REPLACE THE TOP HALF OF MY MOTOR COSTING ME 3500 OUT OF POCKET FOR WELL KNOW PROBLEMS AND RECALLS THAT WERE NOT INCLUDED IN THIS CARS VIN NUMBER I DO NOT THINK A CAR SHOULD HAVE THIS MANY ISSUES AND OR REPAIRS IN THE LAST YEAR ALONE I HAVE PUT 2 GRAND INTO THIS CAR I AM VERY UNHAPPY ABOUT THIS SITUATION EVERYTHING THAT HAS BEEN RECALLED ALREADY I HAVE HAD TO FIX IT OUT OF MY POCKET BECAUSE THIS MODEL OF CAR IS NOT INCLUDED IN THE RECALLS I DON'T FEEL LIKE THIS CAR IS SAFE TO DRIVE AND I HAVE 2 SMALL CHILDREN WHO RIDE IN THE CAR I CAN NOT RISK MY CHILDREN'S LIVES AND HAVE THIS CAR SHUTTING OFF IN THE MIDDLE OF THE ROAD. I NEED SOMETHING DONE ABOUT ALL THE PROBLEMS GOING ON IN THIS CAR DUE TO MANUFACTURING DEFAULTS. *TR
TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER 03V067000 (ELECTRICAL SYSTEM:STARTER ASSEMBLY). THE MANUFACTURER INFORMED THE CONTACT THAT THE REPAIRS WERE MADE PRIOR TO THE CONTACT OWNING THE VEHICLE. WHILE THE VEHICLE WAS PARKED THE CONTACT WAS UNABLE TO TURN THE VEHICLE OFF. THE CONTACT HAD TO DISCONNECT THE BATTERY IN ORDER TO TURN THE VEHICLE OFF. THE VEHICLE WOULD ALSO STALL WHILE DRIVING. THE VEHICLE ALSO FAILED TO START INTEMITTENTLY; HOWEVER, THE FAILURES BECAME PROGRESSIVELY WORSE OVER TIME AND FAILED TO START. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIANS WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE ACTUATOR DOOR LOCKS FOR THE FRONT DRIVER AND PASSENGER DOORS FAILED. THE CONTACT STATED THAT THE WINDOW WAS USED IN ORDER TO ENTER THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE THE FRONT PASSENGER ACTUATOR WAS REPAIRED PREVIOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.
TL*THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT RESEARCHED HER INSURANCE AGENCY'S WEBSITE AND NOTICED A RECALL FOR THE CRANK POSITION SENSOR. THE KIA DEALER STATED THAT NHTSA CAMPAIGN ID NUMBER 03V067000 (ELECTRICAL SYSTEM:STARTER ASSEMBLY) DOES NOT APPLY TO HER VIN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE AUTOMATICALLY STOPPED. SHE TOOK THE VEHICLE TO ANOTHER DEALER AND THE VEHICLE WAS REPAIRED AT THE CONTACTS EXPENSE. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 74,000 AND CURRENT MILEAGE WAS 77,000. UPDATED 02-14-08 *BF UPDATED 02/14/08 *TR
WHILE DRIVING ON ROUTE I10 IN HOUSTON, TX CAR STALLED/WOULD NOT START. TOWED CAR TO GAS STATION AND HAD IT JUMPED. DID NOT HELP. TOWED TO A MECHANIC SHOP, WHERE I WAS TOLD THAT IT WAS THE CRANKSHAFT POSITION SENSOR THAT NEEDED TO BE REPAIRED. THIS PART WAS FOUND TO BE DEFECTIVE IN KIA OPTIMAS IN 2001 AND 2002. WHILE RESEARCHING THE PART ONLINE I FOUND THAT THE NHTSA RECALLED THE 2001 AND 2002 OPTIMAS BECAUSE, AND I QUOTE FORM THE NHTSA WEBSITE" 2001-02 W/V6: TWO SEAERATE RECALLS FOR IMPROPERLY MANUFACTURED CRANKSHAFT POSITION SENSORS COULD RESULT IN ENGINE STALLING WHILE DRIVING. DEALERS WILL REPLACE AFFECTED PARTS. *AK I CALLED THE KIA DEALERSHIP WHICH SAID THAT MY VIN NUMBER WAS NOT AFFECTED IN THE RECALL. I FIND IT A BIT IRONIC, AND I AM NOW FILING THIS COMPLAINT THAT MY VEHICLE SHOULD BE INCLUDED.
ST: 8TH OF 2004 THE BATTERY STARTED TO DIE,\. DEALER TOLD CALLER TO SHUT THE ALARM SYSTEM OFF WHEN NOT DRIVING. VEHICLE BATTERY WAS CHECKED BY KIA, AND REPORTED NO PROBLEMS WITH BATTERY. HOWEVER, BATTERY HAD TO BE CHARGED NUMEROUS TIMES IN DRIVEWAY. ON MAY 2005 THE LOCKS BEGAN TO GO ON AND OFF, AND ALL LIGHTS CAME ON THE DASH. TOOK THE CAR TO DEALER, WHO CHECKED THE BATTERY, BUT DEALER REPORTED THE CAR NEEDED A NEW BATTERY. 05/05/05 AS CONTACT WAS DRIVING ON A MAIN ROAD AND ALL SENSOR LIGHTS CAME ON, AND LOCKS CAME ON AND OFF, AND CAR SHUT OFF. AFTER RESTARTING VEHICLE WAS TAKEN TO DEALER AGAIN FOR REPAIR.*AK
WHILE DRIVING MY 2002 KIA OPTIMA, MY STEREO,HEADLIGHTS,DASHLIGHTS WOULD CUT OUT WHILE DRIVING. I TOOK IT IN TO A KIA DEALERSHIP, THE INSTRUCTED ME TO GET A NEW BATTERY. I DID, AND THAT DID NOT FIX THE PROBLEM. ON SATURDAY, JANUARY 1RST,2005 I WAS DRIVING DOWN THE FREEWAY DOING ABOUT 60 MPH, MY CAR LOST ALL POWER AND STALLED IN THE MIDDLE OF THE FREEWAY. I COULD NOT WARN OTHER DRIVERS BEHIND ME BECAUSE MY HAZARD LIGHTS WOULD NOT TURN ON, I HAD NO ELECTRICAL POWER TO MY CAR. IT ALMOST CAUSED PEOPLE BEHIND ME TO SLAM INTO ME. SINCE THE DEALERSHIP WAS CLOSED ON SUNDAY, I TOOK THE RISK OF GOING TO THE STORE, AND ONCE AGAIN I LOST ALL POWER TO MY CAR HITTING A NEAR BY GARBAGE CAN AND DENTING THE FRONT LEFT SIDE OF MY CAR. I TOOK IT INTO KIA OF TACOMA, THEY TOLD ME TO GET A TUNE UP. NOT LIKING THAT ANSWER, I HAD IT TOWED TO KIA OF PUYALLUP..THEY ARE UNABLE TO FIND THE PROBLEM AND WANT ME TO COME PICK THE CAR UP AND DRIVE IT AROUND AGAIN. AFTER RESEARCHING THIS ON THE INTERNET, I FOUND THERE ARE MANY OTHER PEOPLE THAT THIS IS HAPPENING TOO, AND THERE HAS NOT YET BEEN A RECAL ON THIS CAR. THIS CAR IS A DANGER TO MY LIFE, AND OTHERS AROUND ME. SOMETHING NEEDS TO BE DONE ABOUT THIS RIGHT AWAY BEFORE IT COSTS SOMEBODY THEIR LIFE.*AK
WHILE DRIVING, A BURNING SMELL WAS DETECTED, THEN THE AIR BAG LIGHT CAME ON. AFTER PULLING INTO A SERVICE STATION THE VEHICLE WOULD NOT START. IT WAS DISCOVERED THE ALTERNATOR, COMPUTER AND AIR BAG MODULE WAS DEFECTIVE. AFTER THE REPAIR THE AIR BAG LIGHT REMAINED ON. *JB
WIRING TO THE DRIVERS' SIDE BODY LIGHTS BLOWS THE FUSE. FUSES LAST ONLY A FEW DAYS. *JB
Complaints are unverified consumer reports submitted to NHTSA. A high complaint count may reflect vehicle popularity, not defect severity. Data sourced from NHTSA public records.
NHTSA source checks for this vehicle year
Checks are recorded separately for each dataset, not for the whole page. Dates use UTC. A missing check date does not mean no records exist.
Vehicle import recorded: Apr 28, 2026. This is the stored import date, not confirmation that every source was successfully refreshed.