2002 Kia Optima Suspension Problems

The contact owns a 2002 Kia Optima. The contact stated that after he replaced all four tires, the vehicle was taken to an independent mechanic for an alignment; however, the mechanic was unable to perform an alignment due to the subframe corrosion. The vehicle was not repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Campaign Number: 09V183000 (Suspension) however, the VIN was not included in the recall. The failure mileage was approximately 111,000.

OVER A WEEKS TIME,I NOTICED MY STEERING WHEEL WAS TURNED LIKE MAYBE I NEEDED AN ALIGNMENT AND IT STARTED PULLING TO THE LEFT SO BAD THAT I HAD TO FORCE THE STEERING WHEEL TO THE RIGHT SO I WOULDN'T WRECK INTO THE MEDIAN ON THE INTERSTATE. I COULD ONLY GO ABOUT 45 OR 50 MPH OR IT WOULD START SHAKING THE ENTIRE CAR AND WAS ABSOLUTELY IMPOSSIBLE TO CONTROL IT ON THE ROAD. HAD IT LOOKED AT AND AT THE BOTTOM CONTROL ARM THAT BOLTS TO THE SUBFRAME HAD RUSTED OUT AND THE RIGHT SIDE WAS ON THE VERGE OF DOING THE SAME! THE FL AND FR TIRES, THAT I HAD GOTTEN BRAND NEW 5 MONTHS AGO, WERE WORE DOWN TO THE WIRE!!! I'M SURPRISED I HAD THE CHANCE TO GET IT HOME AND GET IT LOOKED AT BEFORE IT RUSTED ALL THE WAY THROUGH! I WAS SO BLESSED I DIDNT HAVE A HORRIBLE ACCIDENT.

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE DRIVING 50 MPH, THE FRONT DRIVER SIDE LOWER SUBFRAME DETACHED DUE TO CORROSION INSIDE THE SUBFRAME. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

I JUST GOT MY 2002 KIA OPTIMA AND IT JUST RECENTLY STARTED HAVING ISSUES. I WAS DRIVING DOWN THE ROAD AND MY CAR STARTED TO SLIGHTLY WANDER TO THE LEFT, I THOUGHT OK.. IT NEEDS AN ALIGNMENT. SO THEN IT STARTED JERKING TO THE RIGHT, SO BAD I GOT PULLED OFF TO THE SIDE OF THE ROAD AND COULDN'T CONTROL IT. I PARKED MY CAR IN A PARKING LOT TIL MY BF COULD COME LOOK AT IT, AND I HAD HIM DRIVE IT HOME AND THE SAME THING HAPPENED TO HIM. HE LOOKED AT EVERY POSSIBILITY AT WHAT IT COULD BE AS HE IS A MECHANIC AND SAID LOWER CONTROL ARM. IT HAS BEEN SITTING IN MY YARD FOR A WEEK. IT IS NOT SAFE TO DRIVE. I FOUND OUT IT HAD A RECALL BACK IN 2009, SO I CALLED MY LOCAL KIA DEALER AND THEY SAID IT WAS PART OF THE RECALL BUT IT HAS BEEN FIXED- I'M WONDERING HOW IT WAS FIXED IF IT IS DOING THE SAME EXACT THING EVERYONE'S COMPLAINTS I HAVE SEEN IS DOING/ I AM AT A HALT NOT KNOWING WHAT TO DO WITH MY CAR, I HAVE SMALL CHILDREN AND REFUSE TO DRIVE THIS CAR. PLEASE HELP

WE OWN A 2002 KIA OPTIMA- FOUND OUT THERE WAS A RECALL- THE RECALL WAS CORRISION TO THE SUBFRAME THAT COULD LEAD TO PROBLEMS WITH THE CONTROL ARM. I WAS TOLD THAT THE CAR WAS INSPECTED IN 2010 AND THE RECALL WAS TAKEN CARE OF AT THAT TIME. WE BOUGHT THE CAR FROM A PRIVATE OWNER IN 2014. 2015 WENT TO GET NEW TIRES ON THE CAR AND DISCOUNT TIRE TOLD US THAT THEY COULDN'T DO AN ALIGNMENT BECAUSE THERE IS AN ISSUE WITH THE CONTROL ARM. WE FOUND OUT TO REPAIR THE CONTROL ARE IT WOULD BE OVER $500. WHEN I CALLED THE KIA HOTLINE TO INQUIRE ABOUT THE RECALL, I WAS TOLD THAT WE WOULD NEED TO TAKE THE CAR TO A KIA DEALERSHIP TO HAVE THE CAR REVIEWED BY THEIR SERVICE MEN TO SEE IF THERE IS ANY ISSUES WITH THE SUBFRAME AND CONTROL ARM. I'M CONCERNED MY CONCERN IS NOT GOING TO GET ADRESSED. 7/11/2016 JP

DRIVING UP THE ROAD ,PUT ON BRAKES ,AXLE AND SUBFRAME BROKE CAUSING MY CAR TO SLIDE AND STOP IN MIDDLE OF ROAD.THANK GOD NO ONE HIT US.

DRIVING DOWN THE ROAD, STEPPED ON BRAKES AND FRONT FRAME BROKE INTO TWO PIECES, IN THE MIDDLE OF THE ROAD, NEARLY CAUSED A PILE UP ON THE ROAD. *JS

MY TIRE HAD STARTED BENDING INWARD AT THE TOP, AND OUTWARD AT THE BOTTOM. MY CAR STARTED GOING OUT OF ALIGNMENT. I TOOK IT TO A SHOP, AND THEY FOUND OUT MY SUB FRAME WAS RUSTED AND WORN OUT. THEY ALSO FOUND OUT THAT THE SUB FRAME HAD BEEN RECALLED IN 2009, BUT APPARENTLY NOT ON MY EXACT VEHICLE. *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE FAILED TO DRIVE IN A STRAIGHT LINE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V183000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 95,000.

WE HAVE HAD ONGOING PROBLEMS WITH A 2002 KIA OPTIMA, INCLUDING TIRE WEAR, BRAKE PROBLEMS, ELECTRICAL ISSUES, EXCESSIVE BATTERY WEAR. THIS WEEK WE WERE NOTIFIED BY OUR AUTO SHOP THAT THERE IS EXCESSIVE RUST ON THE SUBFRAME AND THAT A RECALL EXISTS FOR THIS CONDITION. WHEN I CONTACTED BOTH OUR LOCAL DEALER AND KIA CORPORATE, I WAS TOLD THAT THIS PARTICULAR VIN IS NOT INCLUDED IN THE RECALL, ALTHOUGH THE RECALL CLEARLY STATES THAT IT DOES MEET THE PARAMETERS. UPON FURTHER RESEARCH, IT APPEARS THAT MANY OTHERS HAVE EXPERIENCED THE SAME PROBLEMS AND BEEN GIVEN THE SAME INFORMATION. CURRENTLY, WE ARE LEFT WITH A CAR THAT IS A DANGER TO DRIVE AND ENORMOUS PERSONAL EXPENSE TO RESOLVE. *TR

CAR WAS MAKING STRANGE NOISE. TOOK TO MECHANIC TO HAVE CHECK. IT WAS DISCOVERED THAT THE SUBFRAME IS COMPLETELY RUSTED THROUGH ON PASSENGER SIDE AT FRAME MOUNTS AND ALMOST RUSTED THROUGH ON DRIVERS SIDE. MECHANIC DETERMINED THAT DUE TO THE SEVERITY OF PROBLEM VEHICLE IS UNSAFE TO DRIVE AND WILL NOT ALLOW BACK ON ROAD UNTIL NECESSARY REPAIRS ARE MADE. I CONTACTED KIA AND WAS TOLD THAT THIS PARTICULAR YEAR VEHICLE WAS IN A RECALL DUE TO THIS PROBLEM. HOWEVER, THIS PARTICULAR VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS ORIGINALLY PURCHASED IN THE STATE OF WEST VA, AS STATED IN THE RECALL. VEHICLE IS STILL PARKED AT MECHANICS GARAGE AND I WOULD GREATLY APPRECIATE COMMUNICATION REGARDING THIS MATTER. I WAS TOLD BY KIA REPRESENTATIVE THAT I WOULD NEED TO CONTACT YOUR ORGANIZATION. *TR

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR ROUTINE SERVICE WHEN HE WAS ADVISED THAT THE SUB FRAME WAS CORRODED. THE MANUFACTURER WAS CONTACTED BUT DENIED ANY ASSISTANCE WITH THE REPAIRS BECAUSE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V183000 (SUSPENSION: FRONT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,148.

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE CONTACT HEARD A LOUD NOISE NEAR THE FRONT DRIVER SIDE TIRE AS THE VEHICLE DROPPED TO THE GROUND. THE VEHICLE WAS TOWED TO A MECHANIC FOR INSPECTION WHERE THEY ADVISED THAT THAT THE BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT HE STILL HEARD A NOISE AFTER THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THERE WAS NOTHING THAT COULD BE DONE. THE FAILURE MILEAGE WAS 85,000. UPDATED 08-03-12 *BF UPDATED 09/07/2012 *JS

TL* THE CONTACT OWNS A 2002 KIA OPTIMA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE VEERED TO THE RIGHT IN A JERKING MOTION. THE FAILURE OCCURRED WHENEVER THE BRAKES WERE DEPRESSED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE PASSENGER'S SIDE TIRE WAS POSITIONED OUTWARDLY. ALSO, BOTH FRONT TIRES HAD PREMATURELY WORN DUE TO THE DEFECT. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 09V183000 (SUSPENSION). THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

TL*THE CONTACT OWNS A 2002 KIA OPTIMA. WHILE THE VEHICLE WAS BEING SERVICED, THE CONTACT WAS INFORMED THAT THE FRONT SUBFRAME HAD CORRODED. THE CONTACT CALLED THE MANUFACTURER AND REFERENCED RECALL 09V183000 (SUSPENSION: FRONT) BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 109,834.

I HAVE A 2002 KIA OPTIMA THAT THE VIN IS NOT ONE OF THE VEHICLES THAT IS COVERED BY YOUR RECALL NHTSA CAMPAIGN ID NUMBER: 09V183000 WHICH STATES "INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING...". YOU HAVE IT LISTED AS STATES WITH DIFFICULT WINTERS AND THE USE OF ROAD SALT. I LIVE IN LOUISVILLE, KY. NOT ONE OF THE NAMED STATES. BUT. I GUARANTEE YOU THAT THIS SAME CORROSION CAN BE CAUSED BY THE WATER COMING FROM THE AIR CONDITIONER RUNNING DIRECTLY ONTO THESE PARTS. THE BACK SIDE OF SUBFRAME HAS RUST HOLES IN IT. THIS RECALL NEEDS TO BE EXPANDED TO ANY AND ALL KIA OPTIMAS THAT HAVE THE AC WATER RUNNING THERE DUE TO MANUFACTURE DESIGN. I HAVE PICTURES THAT I CAN SEND TO YOU SHOWING THIS CORROSION. I TRIED TO GET IT ALIGNED AT A KIA STORE AND THEY SAID "LOWER CONTROL ARM BRACKET ON PASS SIDE IS RUSTED AND BROKEN. PASS SIDE WHEEL IS PUSHED BACK AND TIRES ON FRONT ARE ANGLED." HOW WAS THE 36,538 VEHICLES DETERMINED ? WAS IT FROM THE STATE THAT THE CAR WAS SOLD IN ? *TR

MY SON WAS DRIVING OUR 2002 KIA OPTIMA AND WHEEL ASSEMBLY FELL OFF. THE WHOLE FRAME RUSTED FROM INSIDE OUT CAUSING THE LOWER CONTROL ARM TO FALL OFF. *TR