2016 Kia Optima Body & Structure Problems

I am submitting a defect complaint regarding the paint on my vehicle, which has been progressively deteriorating. The issue begins as small bubbles in the paint, which eventually lead to peeling and complete paint loss in affected areas. This condition is currently present on the trunk, roof, and rear sides of the vehicle, and early signs are now appearing on the hood. This defect is more than cosmetic. As the paint peels, it exposes the underlying metal panels to environmental elements, increasing the risk of corrosion and rust. Over time, this can compromise the structural integrity of the vehicle. Additionally, significant peeling—particularly on surfaces like the roof or hood—can create glare or release debris, posing a potential safety hazard and distraction to both myself and surrounding drivers. I initially brought this issue to a Kia dealership, where the manager advised me to contact Kia Customer Affairs. Upon doing so, I was informed that the issue falls outside the warranty timeframe. However, after speaking with other Kia owners experiencing similar problems—especially with the same paint color—it appears this may be a widespread manufacturing defect rather than normal wear and tear. Furthermore, a professional paint specialist evaluated the condition and indicated that the bubbling and peeling are consistent with poor paint adhesion or a defective clear coat/mid-coat application during manufacturing.

paint peeling, chipping, and bubbling.

The antenna fin flew off while I was driving on the highway.

My paint has begun bubbling up and feeling out of nowhere. I’ve always taken good care of my car yet spots are beginning to pop up along the passanger side. The paint continues to peel more as time goes on. I’ve found many complaints online of people saying they’ve had the same issue with their kia in the Snow White Pearl color I have, but there’s no recall and kia refuses to pay for it.

While driving on the highway, the roof antenna assembly flew off our car. Inspection of the area shows that the screws that were supposed to hold the antenna on had all become sheared off. It looks like there is a recall for this exact issue covering 2016 Kia Optimas produced through June 1, 2016 (SA272), but our Optima was produced on June 23, 2016 and is therefore not covered according to Kia.

I was told that my engine had a recall on it so I had an upcoming appointment with Kia in like 2 weeks for them to check my engine but the car didn’t make it. I was driving my car on interstate 20 my car had began to have a bad chemical smell and started smoking so I pulled over on the interstate and my car was in flames. Me and my daughter was in the car we could have lost our lives thank God we were able to make it out just in time. The fire department came and made a report on the incident. It wasn’t any engine light on at the time. I have contacted Kia about the tragedy that has happened but nothing has been resolved yet.

I bought this car with just under 48k miles September 2023, it had a very small chip on the bumper that I assumed was from a rock. After driving this car for a while, I noticed that chip got bigger and eventually other parts of my bumper and hood started bubbling and chipping as well.90% of my bumper is now lacking paint and it’s starting to chip on my hood more. I’ve only driven it an additional 12k miles since I’ve bought it. Auto body shops are saying it’s delaminating and it’s common in this color.

2 of my windows drop when i go over a speed bump....i have already gotten the motors replaced for the windows (front driver, and back driver sides)....i don't even use the POWER up/down FOR the back windows AT ALL because i am the only one that drives my car (wondering why this is happening for this)....when i took my vehicle for these windows to be replaced, even my mechanic says there should be a recall on these windows and that this should not be happening....NOW my back passenger window is doing the same thing and again i don't even let the BACK WINDOWS down...someone can break in my car by just literally SLIDING the window down (OMG!!!!!!!!)....there are no warning lamps for this..i noticed this happening when KIA fixed one of my recalls

Three of the four windows stoped rolling up at the same time. One or two days apart to each other, the 4th one I’m not going to rolling down, it may stop working too.

The contact owns a 2016 Kia Optima. The contact stated that while driving in a heavy rainstorm, the vehicle experienced water intrusion causing the sub frame undercarriage to become damaged and unsecured. The vehicle was not yet repaired. The local dealer was notified of the failure, but no assistance was offered. The manufacturer was not yet contacted. The failure mileage was 14,000.

Window regulator replacement

Pearl White paint on hood is flaking/delaminating.

My car has now been broke into twice because of the "kia boys" I have now had to replace two windows, and clean my car out from glass.

The trunk latch stopped working won’t lock

White paint is chipping away excessively

I have a 2016 Kia Optima Pearl White and the paint on the hood just started peeling! It looks awful. What should I do to get this problem fixed?

The paint is peeling or delaminating from the car. It is happening in many places. The paint is Snow White Pearl. The car now has about 110,000 miles. The paint warranted for only for 36 months. But it is obvious that this is a quality issue and latent defect. The paint shop says he has seen this a lot with Kias. The paint is not sticking to the primer. I keep hoping there will be a recall on the paint. Even the dealer says it is a problem but Kia corp will not pay to fix the cars with this issue.

All the window regulators continue to turn but the windows stay down and won't go up. Leading cause, the gear that connects to the motor and window regulator wires is plastic and erdes over time causing it to shred itself. Now my windows will not go up.

THE ANTENNA COVER ON MY CAR FLEW OFF ON THE HIGHWAY. I'VE NOTICED AS I WASH(HANDWASH ONLY) WHEN I WIPE AROUND THE ANTENNA IT MOVES. THOUGHT THIS WAS ODD, BUT ASSUMED IT WAS NORMAL. I WAS DRIVING BACK TO WORK ON THE HIGHWAY(03/17/21) THE LEGAL SPEED LIMIT(65MPH)WHEN A TRACTOR-TRAILER PASSED ME CAUSING A WIND GUSH. I HEARD SOMETHING HIT THE HOOD OF MY CAR. WHEN I ARRIVED AT WORK, I SAW THAT THE ANTENNA COVER WAS COMPLETELY GONE. NOTICED THE PLASTIC AROUND THE MOUNTING SCREWS WERE ALL BROKEN OFF PARTIALLY OR COMPLETELY. I WENT ON THE INTERNET TO FIND A REPLACEMENT ANTENNA. I FOUND A GROUP CHAT WITH MANY KIA OWNERS COMPLAINING OF THE EXACT ISSUE. ONE OWNER POSTED A TSB(SA272) FOR 2016 KIA OPTIMA BEING RECALLED FOR DEFECTS IN THE ANTENNA FIN ASSEMBLY FOR SCREWS LOOSENING OR BREAKING. THE BULLETIN STATED THAT OWNERS OF SAID KIA OPTIMA COULD BRING THE VEHICLE TO A KIA DEALERSHIP AND THE ANTENNA WOULD BE REPLACE FREE OF CHARGE BY KIA MOTORS FOR PARTS AND LABOR. I CALLED TWO KIA DEALERSHIP AND LATER KIA CUSTOMER SERVICE. THE CSR SAID THAT SHE DID NOT PULL UP A RECALL ON MY VEHICLE. I GAVE HER THE TSB NUMBER. A POSTER SAID HIS KIA DEALERSHIP REPLACED HIS 2016 KIA OPTIMA BROKEN ANTENNA WITHOUT CHARGE. THE CSR SAID THAT YOUR ORGANIZATION WOULD HAVE TO INITIATE/ORDER THE RECALL AND LIST MY MODEL OF THE 2016 KIA OPTIMA IN ORDER FOR THEM TO REPLACE THE DEFECTIVE ANTENNA AT NO COST. I HAVE THE EXPENSIVE MODEL, THE 2016 KIA OPTIMA(SXL TURBO) W/TECHNOLGY PACKAGE WHY WASN'T MY 2016 MODEL NOT LISTED WITH THE OTHER 2016 KIA OPTIMA? THE DEALERSHIP SAYS IT COSTS OVER $500 TO REPLACE THE ANTENNA. SAID THE ENTIRE ASSEMBLY HAS TO BE REPLACED. A CHEAP PLASTIC ANTENNA COVER FOR $600? YOUR QUICK REPLY AND SOLUTION TO RESOLVE THIS SERIOUS ISSUE WITH KIA ANTENNA WOULD BE GREATLY APPRECIATED. THANK YOU [XXX] CELL : [XXX] WORK: [XXX](MON-THU) EMAIL : [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I BOUGHT MY 2016 PEARL WHITE KIA OPTIMA IN MAY OF 2016. RECENTLY, I NOTICED THE PAINT CHIPPING AND PEELING OFF MY HOOD. IT STARTED OUT THE SIZE OF A PEA BUT NOW IS BIGGER THAN A QUARTER AND CONTINUES TO GET BIGGER BY THE DAY. I NOW HAVE ANOTHER SPOT THAT IS CHIPPING ON THE HOOD DUE FROM HEAVY RAIN THIS PAST WEEK. THE PAINT IS ALSO PEELING OR CHIPPING ON THE ROOF RIGHT ABOVE WHERE THE FRONT WINDSHIELD MEETS. I EXPECT NICKS AND CHIPS FROM DEBRIS WHEN HIT WHILE DRIVING OR PARKED, BUT NOT PAINT PEELING OFF AND CHIPPING WHILE IT SITS IN MY DRIVEWAY WITH NO THREAT OF DAMAGE.