2018 Kia Optima Engine Problems

Consuming fuel to the amount of roughly 1/2 quart per 150 miles. Vehicle has been inspected by mechanic and the oil pan, oil filter, and PCV valve has been replaced and engine oil UV dye added and cycled with no leaks found. The risk is that if not rigorously checked often, the engine will malfunction because the car runs out of oil. I have had my mechanic checking this car since I purchased it in January 2026. We have had to replace the oil pan and do two full oil changes with three separate quarts of oil being added in between all of that to keep it topped up. My mechanic agrees that the engine is consuming oil at an extremely high rate. My mechanic and a mechanic at the dealership where I purchased it are the only one who has inspected the car for this issue so far. The mechanic at the dealership is who recommended we replace the oil pan to see if that fixed the leak, which my personal mechanic did. Yes the critical engine failure lamp illuminates on the dashboard when the oil ran out the first time while I was driving it. This was how I discovered that there was an oil leak. This specific incident occurred three weeks after I purchased the car which I bought in mid-January of 2026.

While driving my 2018 Kia Optima S, the car suddenly jerked, lost power, and stalled in traffic. Multiple warning lights came on at the same time including the oil light, battery light, and check engine light. I had no acceleration and the brakes became very hard to press. The vehicle had to be towed for safety reasons. The Kia dealership inspected the vehicle and confirmed internal engine failure due to “cylinder failure” and stated the engine needs complete replacement. This failure occurred without any external leaks and without warning other than the sudden loss of power. The dealer stated the issue is not covered, even though it is clearly an internal engine malfunction. This is a major safety hazard because the stall happened while I was in active traffic. A sudden loss of power and braking ability puts me and others at risk of an accident. The problem has been confirmed by the Kia dealership through diagnostic testing. The vehicle is still available for inspection. Warning lamps appeared only at the moment of failure, giving no advance warning. This appears to be related to the ongoing engine defects in Kia vehicles involving oil starvation, loss of compression, cylinder scoring, and internal engine failure. Cylinder failure and sudden stalling should be investigated as part of the known safety-related engine defects affecting this model.

Car keeps stalling while driving

My engine is under the Kia class action lawsuit for the KDS with the rod bearing clearance issues. I have done all my oil changes with paper work available. I got the update to the ECU several years ago as needed to be covered. Now my engine has failed and I took to the dealer to check but they said I didn't have a specific code and that they can't do any testing to verify it would be under the warranty. I called Kia Customer Care and have talked to them several times. They have told me there wasn't a need for the code and that the dealer could do other testing. The dealer stated that they can't do the BCT test due to a cylinder not having compression. I told Kia this is all related to the bearing going out and they said they can't do anything if the dealer said it's not under warranty. So I have now been going in circles with kia and dealer since 11/18/25. I sent kia another email on 12/15/25 and another on 12/18/25 due to not receiving a response. It's now 12/23/25 and still no response. They have a service bulletin that I seen online that was for dealers if any issues with testing they had other options but still nothing has been done.

I’ve had my car for 6 months and it constantly burns oil I’ve had 4 oil changes because it Is completely disappearing but my mechanics can not find any leaks. Then I changed all my spark plugs and two were completely burnt and they were changed a month ago and now one of them went again and this time is completely covered in oil

Engine seized and stopped working. While I could not find any recall information based on the VIN, it is a 2018 Kia which was subject to the Kia Engine Settlement (In re: Hyundai and Kia Engine Litigation , No. 8:17‑cv‑00838‑JLS‑JDE and Flaherty v. Hyundai Motor Company, et al. , No. 18‑cv‑02223 (C.D. Cal.)). Was never notified of such settlement as the VIN would have triggered this notification by Kia but they obviously did not list this in the recall.

Car would convulse and shake very wildly metal parts spread around engine. It has very rough idle. 4th cylinder went out and car only has about 99060 miles. The valve went out. My safety was very bad as car was not driving safely and shaking like a person having a seizeure each time it would stop. Vehicle has been inspected by a Kia dealer. This problem I had seems to get an issue many other people with Kia Optima have.

Car suddenly stopped working; it was struggling to stay on. Mechanic stated cylinder is not functioning at full force.

My 2018 Kia Optima has a cracked oil pan, which caused an excessive oil leak —up to 5 quarts in a matter of hours. This eventually led to my engine going out.

My 2018 Kia Optima went into limp mode while exiting the freeway. I had it scanned and received a P1326 code, which is directly tied to the known engine knock sensor / bearing wear issue in Kia models. The engine light came on and the car lost power suddenly. This created a very unsafe situation. I contacted Kia, and they confirmed that my VIN is not included in the engine recall (KSDS campaign), even though my symptoms exactly match the covered vehicles. I am now stuck with an undriveable car and no recall coverage, even though I’m facing the same failure risk. I believe this VIN should be included, and that this is a clear safety issue. I am requesting the NHTSA to investigate and push Kia to expand coverage to include more affected vehicles.

Kia is aware of the engine oil consumption causing misfires, failed emissions test, blowing a rod and engine lock up. THEIR SOLUTION WAS A CLASS ACTION LAWSUIT THAT STATE ONCE THE CAR IS LOCKED UP OR ROD HAS BLOWN THROUGH THE ENGINE THEN THEY WILL FIX IT. I HAVE HAD TO ADD OIL AT LEAST 3 TIMES EVERY 3000 MILES AND CONTINUE TO REPLACE THE OIL FILTER AS WELL. THE SPARK PLUGS HAVE BEEN REPLACED MUTLIPLE TIMES ALSO TO HELP WITH THIS ISSUE. KIA ADVISED THAT MY VEHICLE DID NOT FALL UNDER THIS RECALL EVEN THOUGH MY VEHICHLE IS HAVING THE SAME ISSUES AS THE RECALL STATES. THIS IS A KNOWN ISSUE WITH THIS MAKE AND MODEL AND THEY SHOULD NOT BE ABLE TO GET AWAY WITH SELLING DEFECTIVE VEHICLES AND NOT REPAIRING THE ISSUES THEY KNEW THEY HAD PRIOR TO SELLING THE VEHICLES. SOMETHING NEEDS TO BE DONE.

The 2.4L Theta II engine in my 2018 Kia Optima is failing, exhibiting excessive oil consumption, with oil loss documented at over 1 quart per 1,000 miles, leading to secondary failures in the catalytic converter, clogged with oil carbon and breaking into pieces that may damage the cylinder walls, and the spark plugs, which are fouled with carbon, causing misfires. The engine and related components remain intact and un-repaired, pending Kia’s required 3,000-mile consumption test. Safety of drivers have been put at significant risk. The excessive oil consumption and potential engine seizure threaten sudden loss of power, especially on freeways where car fails to accelerate to city and highway speeds, increasing the chance of a collision. The clogged catalytic converter poses a fire hazard, (reported by NHTSA investigations into Theta II) where oil leaks or debris can ignite on hot surfaces. Risk is heightened during the mandated 3,000-mile test as well. Problem has been confirmed by both a dealer and an independent service center as recent at 1 July, '25, documenting oil loss and new engine recommendation. Symptoms began with noticeable oil loss during oil changes, starting at least 1 quart per interval on May 10, 2023 (mileage 43,374), with the loss increasing over time. Misfires and RPM loss during acceleration first appeared after the oil valve gasket replacement in late May 2025, and freeway pickup issues became apparent around mid-June 2025. The full engine failure was confirmed by Spitzer on July 01, 2025.

My 2018 Kia Optima LX began using excessive oil (>3 quarts/1000 miles) just over 100K miles. I researched and found that the Theta II engine in my car is known for this. When I took my car to dealership (Stokes Hodges Kia, North Augusta, SC), with the check engine light on, they told me me plugs were fouled (they were just replaced 1 yr prior), cylinder 3 misfiring, and that I needed to pay a few thousand dollars to have repaired. When I asked them to guarantee the soaking process they recommended, they responded that they couldn't, that it "only worked 80% of the time." I have the KSDS download since 2019 and asked them to follow the guidelines of their TSB ENG 222 for the class action lawsuit and start a 1000 mile oil consumption test. they refused, basically telling me the only way to get a new engine from Kia, since my car is over 100K miles, is to drive it until the engine seizes. I expressed my fear for personal safety, but they wouldn't help me. I am original owner and have all services, etc documented. I called Kia customer affairs, then was told only local dealership could help. they stuck me in a loop between them without helping. Please help me.

Engine failed despite maintenance and repairs. The car is part of the active class action for Kia Engine Defects. The KSDS software was never installed as we were never notified about the recall by kia. As a result, Kia denied coverage under the engine defect class action settlement. We need this vehicle repaired or compensation for replacement

Subject: Urgent Request for Engine Replacement – 2018 Kia Optima Dear Kia Consumer Affairs, I am writing to formally report a recurring and increasingly dangerous engine issue with my 2018 Kia Optima, and to request immediate assistance, including consideration for an engine replacement due to ongoing safety and reliability concerns. Since June 2024, I have routinely visited the Kia dealership on a near-monthly basis for service due to persistent problems with excessive oil consumption and spark plug failures. Each visit has resulted in service-related expenses, despite my efforts to maintain the vehicle in accordance with manufacturer recommendations. Unfortunately, the issue has not been resolved and continues to worsen. Most recently, on [XXX], I experienced a critical incident. While driving, the engine began shaking aggressively, the check engine light illuminated, and smoke was detected coming from the engine compartment. Out of concern for my safety, I immediately pulled over and had the vehicle dropped off at a nearby garage for emergency inspection. This incident, combined with the repeated monthly service visits and associated costs, clearly indicates a systemic issue that may be linked to known engine defects in similar Kia models. I urge Kia to review my case for warranty coverage, recall eligibility, or goodwill engine replacement assistance. I have attached supporting documentation including service records, receipts, and oil consumption logs. Please advise on the next steps for resolving this matter. Thank you for your attention. I look forward to your prompt response. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Got an oil change, and they advised that it was low on oil. (I had just replaced it recently) I took it to the dealer and they advised a part was bad, that they replaced. I was driving and the check engine light and oil light came on . I had to tow car. Dealer said the engine was burning oil, and that the engine is covered, but I would have to drive it until it got worse.

This vehicle has an active recall: SC218 / DTC P1326 – ECU UPDATE / ENGINE REPAIR. I brought it to Martin Kia in Newark, Delaware, but they refused to perform the recall stating that since the vehicle is owned by a used car dealer, the recall is not applicable. They also provided a written statement saying that the extended warranty does not apply because I am a dealer, and that they will not perform any recall work until the vehicle is owned by a “customer.” However, federal law requires all safety recalls to be completed free of charge, regardless of the vehicle’s current ownership status or whether it is owned by a dealership. This is a safety issue and refusal to perform recall work puts future drivers at risk. I have attached the letter they gave me for your reference. I kindly request your urgent review of this case and enforcement action to ensure the dealership complies with federal recall obligations.

I am the current legal owner of a 2018 Kia Optima Hybrid (VIN: [XXX] ), which has an open safety recall under campaign number SC218Y3 (DTC P1326 – Knock Sensor Detection System / ECU Update / Possible Engine Repair). I attempted to schedule the recall repair with Martin Kia in Newark, Delaware. However, the service department refused to perform the recall service on the basis that I purchased the vehicle from an auction and do not have prior service records. This denial is a clear violation of federal recall regulations. As stated by NHTSA, all safety recall repairs must be completed free of charge regardless of ownership history or how the vehicle was purchased. I am now left with a potentially dangerous vehicle that Kia refuses to service, despite an active recall on file. This situation is unacceptable and puts me, as well as other road users, at risk. I respectfully request that NHTSA investigate Kia’s non-compliance and ensure they are held accountable for refusing to fulfill their legal obligations regarding this recall. I am willing to provide proof of ownership and any supporting documentation. Thank you Best regards My Contact Info: [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The engine of my 2018 Kia Optima is burning oil. When it started, I had 72,000 miles, and it's burning one quart of oil every thousand miles. There is no oil leak. I will take it back to Kia on October 2, 2025. The mechanic reported that it has an internal engine issue.

Vehicle engine shut down without warning while driving on the interstate on April 27,2025. I had the vehicle towed and come to find out a "campaign" was issued for the vehicles engine in July of 2018. I purchased the car used in March of 2021 and was not aware of the "campaign" in which the vehicles engine was defective and could possibly cause a fire. I have reached out to KIA to see if they could help me in resolving the issue with the engine, but have yet to hear back from them.