2020 Kia Optima Complaint Log

The contact owns a 2020 Kia Optima. The contact stated that while driving at an undisclosed speed, and while the vehicle was parked, there was a loud banging sound coming from the engine compartment. There was no warning light illuminated. The RPM failed to operate as intended while driving. The vehicle was taken to an independent mechanic, where it was diagnosed, and determined that there were metal shavings inside the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The mechanic referred the contact to a dealer for additional assistance. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 69,751.

My vehicle burns oil too quickly. I schedule my regular oil change based on the feedback from the auto repair shop. During my last oil change he said I practically had no oil left, but it has been less than 5,000 miles since my previous oil change. The tech informed me he's seen this happen a lot within Kia's including the optima that I currently drive. Fast forward a few months i noticed my oil light illuminate for a moment and immediately turn off. I still want to get it checked out just in case so i brought it back to the same shop. They informed me my oil was very low even though, but I still have another 1,500 miles before my next due oil change. He looked around and confirmed there were no leaks or damage that would affect the consumption rate. He highly recommended me look to see if there were any recalls on my specific model of vehicle that would warrant both an explanation and reason for replacement. In the meantime he topped off my oil and i was all good to go.

My engine has failed. This is the second car I’ve had from Kia that the rod barring has failed.

The rod barring failed in my engine. I broke down in the middle of the parkway with my daughter. This is my third Kia optima that has had this issue but the dealership is stating there is not a recall on this model. The check engine light did not come on except when the car lost all power.

It either has issues shifting gears like its stuck or the transmission may be slipping, it's had this issue since I bought the car. However I wasn't aware until my uncle drove the car and said something might be wrong.. I have no idea what's causing it. It shudders when I make turn or speed up to pass. Not all of the time but at least twice per my normal trip

The contact owns a 2020 Kia Optima. The contact stated that while the vehicle was at a full stop, the red oil warning light illuminated; however, after driving off, the warning light disappeared. The vehicle was driven to an independent mechanic where it was diagnosed with an oil pump failure caused by low oil pressure while the vehicle was stationary, and the RPM was low. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 167,000.

My car burns oil. I had to have my spark.plugs and engine coils replaced. I was driving and my check engine light came on. Also, my car was sputtering like you wouldnt believe. When i had the spark plugs and ignition coils replaced, the spark plugs were covered in oil. Last year, I got an oil change and within a few weeks the oil was empty. A neighbor told me my car was burning oil. I also took it to an independent mechanic and he said that was an issue with the kia optima.

Stable track control failed to work, the driver seatbelt did not tighten & stayed loose, & air bags did not deploy upon hitting the ditch & small trees resulting after hitting ice/water upon coming to a stop sign at a “T” cross road.

The contact owns a 2020 Kia Optima. The contact stated that the vehicle was sputtering and vibrating abnormally while starting. There were no warning lights illuminated. The failure was intermittent but became a recurring failure. The vehicle was towed to an independent mechanic out of fear of the vehicle stalling on the highway. Prior to the engine failure, the contact became aware that there were oil spots where the vehicle was parked. The vehicle was diagnosed, and the mechanic sealed two holes in the oil pan and replaced the spark plugs that were fouled by engine oil. The vehicle was repaired; however, the failure reoccurred. The contact stated that the check engine warning light was illuminated. The vehicle was taken back to the same mechanic who diagnosed the vehicle and determined that the spark plugs were covered in oil again. The contact was advised to take the vehicle to a dealer to check for engine failure. The vehicle was taken to the dealer, and an oil consumption test was performed; however, the vehicle failed the oil consumption test. The dealer had not yet diagnosed the vehicle, but suggested that the engine needed to be disassembled to check for engine wear. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 91,185.

While driving, the vehicle experienced a sudden loss of engine power and entered limp mode. The check engine light began flashing and the vehicle had very limited acceleration, creating a safety concern when driving in traffic. The vehicle was towed to a Kia dealership for diagnosis. The dealer retrieved diagnostic trouble code P1326 (Knock Sensor Detection System – range/performance). During inspection, the dealer found metal contamination in the engine oil and oil control valves and advised that the engine has internal damage and requires replacement.

Took to Kia for engine burning excessive oil. They determined the cylinder wall was scorched due to piston ring. The warranty people say it’s normal wear and tear and won’t honor the warranty. It’s still sitting in their engine bay because they want me to pay for the diagnostic which I don’t have. $4000 roughly for that but it needs a new engine. The warranty should be covering this! NEVER PAY FOR AN EXTENDED WARRANTY!!! They will not help you

Vechile is burning oil and knock sensor came on which indicated rod bearing. While driving the car lost power the check engine came on was abl to pull over and turned off the car. Did not drive it was tow home.

Immediately after getting Kia's latest recall "Voluntary Emissions Service Campaign" software update, my transmission began to Hard-Shift between neutral and 1st gear, and when slowing down, from a gear to a neutral position with the transmission. The car has lunged a few times when going from neutral to 1st gear position--concerning. This is most noticeable when car is cold, but is still always noticeable. Stop-and-go traffic it's also most noticeable. I have notified local dealership by phone message and email but have not heard back in 2 weeks.

I got the car was running good week or 2 later I see the oil light flash after my oil change I go back top it off repeat the cycle almost weekly burning losts of oil then I get a code p1326 for a knock sensor same day car go into limp mode no power rpm won’t go over 2 car won’t go over 60-65 I park it go outside to take it to the dealership next day it ain’t start I haven’t had the car 4 months only have 138,000 miles

Out of the blue I get a code for a misfire on cylinder one. Got in to head to work as normal and it was stalling and shaking so bad that I am scared to drive it. The next day the check engine light was on when I started it to seek out the issue. Car was manufactured in September 2019 but is the 2020 model year. I was told by a license mechanic this is related to an internal Kia engine issue. I contacted 800 333 4KIA to see if this was a known issue that they had a solution to. Of course I was told to self repair that my VIN is not covered under the recall. Can you tell me how Kia assumes that engine issues with the 2019s model year would have been fixed before the 2020 models were assembled? Sounds like my dream car is now my nightmare. 3rd White Kia Optima but I am likely leaving the Kia family if this requires a new engine.

It is an oil burner and engine failed and went into limp mode less than 5 years when drove off dealership brand new.

Metal contamination found on VVT solenoid of 2020 kia optima 2.4L GDI engine. Firestone Autocare Confirmed metal debris in oiling system. Vehicle exhibits symptoms identical to prior theta II bearing recall SC172/SC200/SC227 but not covered under recall range.

My car has been burning oil rapidly. I’ve contacted kia over this issue and I have had several times where I have had to continually add oil. There is no leak. This is a known issue with kia motors across mechanics nationwide and there should be a recall issued. This has been at several shops and over the last few years. This motor should NOT be consuming 4 quarts of oil within 1000 miles after an oil change.

I have kept up on regular oil changes and maintenance on my Kia which I bought new 5 years ago. My issues started when my car's orange check engine light came on, I experienced loss of power such as difficulty accelerating even at low speeds, especially up hill. As soon as I was able I checked my oil which and there was nothing on the dipstick. I put in 3 quarts of oil. I brought it into my usual dealership for service and let them know about the oil issue and issues with power when driving. They failed to address the root cause of the issue, they performed an oil change, engine light turned off, and they started an oil consumption test. But when I drove off the lot the issue with the power continued, and the check engine light came on again. I took my Kia to another dealership to address the car's power issue and the first oil consumption test was not completed because it was unsafe to drive. When I brought my car in, the check engine light was not on, even though there were significant power issues. The dealership was able to confirm my concern, including loss of power and evidence of oil overconsumption. They replaced my turbocharger under warranty. I then underwent a 2nd oil consumption test that indicated overconsumption at a level of 1.5 quarts per 1000 miles. Then they performed a combustion chamber cleaning per Kia guidelines and a 3rd oil consumption test. They 3rd oil consumption results indicated overconsumption at a level of 0.75 quarts per 1000 miles. Although the dealership acknowledged this is still overconsumption, it was not to a level that required Kia to replace my motor. Meanwhile, after all these tests my car is close to out of warranty, at 98.6k miles. I called Kia customer care and their "resolution" to my case was the deny me a new engine and they would not provide me anything in writing. My car's overconsumption of oil and other signs of engine failure match the complaints found in class action settlements related to other Kia models.

The turbo system on the car burns oil at a rapid rate. Had to pay $4000 to replace and still continues to give me problems and check engine light. Violates lemon law. Had replaced in September but was giving me problems well before and finally took it to the dealer for repair

Car burns oil at significant rate which ruins the engine

Without warning my car went into “Limp Mode” while driving on the highway almost causing a collision as I was forced to pull off the road on the highway. Flashing engine light car would not accelerate and was shaking dramatically. Was forced to wait for a tow on a busy highway. P1326 code. Rod knock. A known issue for the Theta II engine. Many recalls have been made for this exact engine for these exact problems but for some reason the 2020 Kia Optima is not included even though it is the same engine covered by lifetime warranty from the 2019 models due to these recalls and know issues. There’s plenty of recorded cases all over the web and is a wide concern for many affected Kia drivers. Kia does not offer the same KRDS update to 2020 Kia drivers as they do to earlier models even with the same engine failure issues so we don’t even get the benefit of possible early detection. Car is well maintained and inspected at a local American tire depot and I am still forced to deal with unwarranted engine failure on a known defective engine solely because KIA will not offer help for affected customers. The 2020 KIA Optima equipped with the Theta II 2.4L engine is not safe and is a known defective product. Action and accountability are needed.

I’ve been told by multiple Kia dealerships that my Kia needs a new engine however I am barely outside of their class action lawsuit so they are not willing to settle with me. They recently within the last two months came out with two recalls that did not fix the issue.

I own a 2020 Kia Optima. My vehicle has experienced repeated low-pressure fuel pump failures, causing hard starting, loss of power, and stalling risk. These issues first appeared in July 2023 and have recurred despite multiple repairs. The dealership has replaced the upper portion of the fuel pump three times (July 10, 2023; March 1, 2025; June 9, 2025) for the same issue, but the problem persists. Most recently, in August 2025, the vehicle again exhibited difficulty starting and loss of power. Diagnostic code P123300 was found, indicating the pump is not generating enough pressure. The dealership confirmed the entire fuel pump assembly needs replacement. This is a serious safety concern because the vehicle has gone into limp mode three times while driving — twice previously on the freeway, and again on [XXX]. On that date, I experienced sudden loss of power while driving, but I had a scheduled oil change on July 29, 2025 so I waited until then to bring the car in. At that visit, the dealership claimed the problem was only an old code P0456 and that my car needed a software update. However, the very next day, my vehicle went into limp mode yet again, creating another hazardous driving situation. My check engine light has repeatedly illuminated, and each failure matches the conditions described in Kia’s extended warranty program (WTY028) for low-pressure fuel pump failures on my model year. The warranty extension letter (WTY028) for my vehicle states that “repairs related to low-pressure fuel pump failure” are covered for 15 years/150,000 miles. It does not state that only the upper portion of the pump is covered. However, my dealership (Sands Kia Surprise) insists that Kia will only cover the upper portion, even though my issue requires replacement of the entire fuel pump assembly to correct the failure. This repeated failure creates a dangerous driving condition and appears to be part of a larger defect affecting this model’s fuel delivery system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Burning oil, not wanting to accelerate properly on the freeway, kia has engine in previous years having the same issue, and these 2020 and they are not trying to fix them.

I took my vehicle to the dealership in Chantilly, VA on May 17, 2025. On July 24, 2025, I discovered that my vehicle had no oil, despite being approximately 4,000 miles away from my next scheduled oil change. I have video documentation confirming that there was no oil in the vehicle. The car was towed back to the dealership; however, no corrective action was taken. The dealership offered to perform a test, which I declined, as this issue did not exist before servicing my vehicle at their location. Additionally, no explanation or guidance regarding the oil was provided to me. I was only advised to pay for another oil change, or a 205 dollars to diagnose the car. Subsequently, I took the vehicle to Fairfax Auto Shop, where a dye test was conducted to check for oil leaks. While no leaks were found, they advised that the vehicle has an oil consumption issue. They recommended that I monitor and top off the oil every 1,000 miles and return for oil changes every 2–3 months.

Engine knocking and stalling on interstate

2020 Kia Optima LX 2.4, LESS THAN 100,000 miles on car. Car started over consuming oil 2 quarts/1,000 miles. Cranked engine yesterday to go to work and serious knocking sounds, engine is rattling severely. Losing revving power, undriveable. Smoke coming out of exhaust that smells like rotten eggs. Will be taking this to get codes run but I believe this is due to Theta II engine failure issue reported in similar cars with the same engine. KIA NEEDS TO COVER THE 2020 OPTIMA UNDER LIFETIME WARRANTY PROTECTION otherwise this is a $10,000 cost to replace engine.

Car consumes a lot of oil. Approximately 5 quarts per week-faulty engine parts allowing oil to seep into the combustion chamber. The oil is then ignited along with the fuel, creating blue-tinted exhaust smoke. It is burning out spark plugs which is then wearing them out and almost caused car accident when car started sputtering and would not barely go once pressing gas. Has been inspected by KIA dealership. Was told engine needs to be replaced-warranty expired and nothing can be done. Car only 2 years old when this problem started and they will not replace.

by the time i’m due for an oil change the car has no oil. there is no leak and no smoke to show car is burning oil

When the vehicle was about 3 years old and at 60,000 miles, the fuel injector went out. Kia took weeks to approve the replacement under warranty. Since then the engine light came on and said cylinder 3 has leak and fouls the plug. We've had it repaired 3 times. The mechanic said it would be too costly to repair and the engine should be replaced.

Engine failure do to excessive oil consumption. I do have records. Not able to file now. Please contact if needed Thank you

engine's knock sensor

UNKNOWN, Engine excessively burns oil and is now seized. Kia used the same engine in this car as they did in the 2016-19 Models which were recalled for engine failure, however mine was not included. 2.4 Theda Engine.

After complaining about clutch judder resulting in getting anti-judder logic software update, followed a month later by transmission serviced, transmission suddenly failed while driving in heavy traffic on the freeway. After repairs, judder keeps happening at low speeds on the freeway or slow speeds under load.

I was driving down the interstate and all of a sudden the blinking lights of the check engine light came on and automatically I went from 75 mph down to 63 mph and when I looked up what it was, it was the knock detection system of the 2020 Kia Optima. I could not accelerate beyond 63 mph and I fear that the engine might stall on me so I went to O’Reillys and have them check it and it says it’s the P1326 Code

Accelerating at a normal rate to get on the highway and the check engine light starts flashing out of nowhere and car goes into limp mode. Made it to local shop and they informed me it was a P1326 code and that a knock sensor would have to be replaced, but that Kia has recalled the older models for this same reason.

The contact owns a 2020 Kia Optima. The contact stated that while attempting to make a right turn, there was an abnormal sound coming from the rear driver’s side window. The contact discovered that the glass had shattered. The contact stated that the Police Department advised her to contact the dealer where the vehicle was purchased, not the Insurance Company. The contact was informed that the failure was caused by a manufacturing defect. A police report was filed. The vehicle was not taken to the dealer or an independent mechanic to be inspected or repaired. diagnoses. The manufacturer was not notified of the failure. The approximate failure mileage was 58,009.

Hi, thank you for taking the time to look over my complaint. On Saturday march 22 while driving down the highway going about 75 mph, my car died. The check engine light was flashing and so was the oil light. I pulled over to the shoulder and when I tried cranking the car it sounded like a rumming noise and the car would not stay on. I had the vehicle towed to Texas Star Auto Shop. On monday march 24th i spoke with the mechanic and he said there is an internal engine problem . Since I am a 2nd owner and the car has 105,736 miles kia will not honor their extended warranty and I am left to pay out of pocket for repairs est cost 10,000+. I am now without a reliable transportation. This has left me annoyed and unhappy with the assistance from Kia.

My engine is burning lg amounts of oil. There has been a lawsuit regarding the same issues with Kia engines (specifically up to 2019 Optimas). The Theta 2 engine lawsuit is regarding excessive oil consumption/burning, knock sensor issues, and deeper engine issues. This has been an ongoing issue for me and is ultimately affecting my engine. Kia will not cover the defects or repair expenses despite knowing the concerns with prior Kia Optima engines.

Dealing with sudden excessive oil consumption at 130,000 miles. Had an oil change about 2,000 miles ago and oil sensor has been going off after 1,500-2,000 miles driven. Mechanic put 3 more quarts in and a week and a half later oil sensor is going off again indicating low oil. Mechanic confined this has been a frequent problem with this engine and insists piston rings are faulty & will eventually need engine replacement.

Vehicle Check engine light started flashing on and off, Code thrown is a P1326 and vehicle went into limp mode, shutting down power essentially going down the highway. Oil burning is excessive, and replacement of oil is at 1-2 quarts every 2 weeks. Engine is not running smoothly. No warning signs of oil burn present until oil pressure light flickers on when taking a curve or sitting on a major incline. Kia Dealership is aware of an issue with the P1326 codes and bearing wear, however, year of vehicle seems to not be included in the original lawsuit and recall/safety notice from all indications. Engine was manufactured and is the same as the 2019 engine that is included. Engine seizure is potential at highway speeds which could cause major harm or death during travel without warning.

The contact owns a 2020 Kia Optima. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, and the vehicle was connected to a diagnostic machine. The DTC indicated a glow relay failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 118,000.

Same issue as the 2011-2019 recalled vehicles. (P1326)

Code P1326 and oil pressure light keeps flashing

I got a CEL (code P1326), three different times. Each time has been after a hard rain or a car wash. I have had to pay to have the knock sensor replaced each time, twice by a mechanic and once by a Kia dealership. There’s a recall for this issue on model years older than my 2020. I was told that Kia is aware but that there aren’t enough people having the issue to warrant them to investigate.

Oil pan developed stress crack below and along both sides of the oil pan drain plug All components are in place and there are no signs of road damage or damage do to obstacles being hit Leak started slowly and progressively became worse Returned car to have plug checked but no report back of any problem and it was documented on service order

The engine in my 2020 Kia Optima S (2.4L GDI Theta II) has been experiencing excessive oil consumption, engine knocking, and loss of power, consistent with known issues in earlier model years of this engine. This component is still in my vehicle and is available for inspection upon request. The issue puts my safety at risk due to unpredictable power loss while driving and the potential for engine seizure or fire, especially during high-speed travel. I’ve had to top off oil multiple times between regular oil changes, and the vehicle showed signs of low oil without any dashboard warning. No KSDS (Knock Sensor Detection System) software was ever installed on the vehicle. I have not yet had a full diagnosis from the dealer, but I have opened a case with Kia Consumer Affairs, who informed me that I do not qualify for recall repair based on the vehicle’s manufacture date — despite the engine matching those in previous lawsuits and recalls. The vehicle has not yet been inspected by the dealer, manufacturer, police, or insurance representatives. However, I can provide receipts for oil purchases and logs documenting how often I’ve had to refill the oil. I am also filing a claim with my third-party powertrain warranty provider. Symptoms first appeared at approximately 85000 miles Engine knocking/ticking noise Oil light flashing briefly or low oil found without warning Needing to add 1–2 quarts of oil between oil changes Rough acceleration or loss of power This issue is widespread, has been previously acknowledged in other model years, and should be formally investigated in the 2020 Optima as well. I am concerned for the long-term safety and reliability of this vehicle

Oil consumption has rapidly been increasing causing the loss of several quarts of oil. Inspection by service center confirmed this is a known Kia issue and recommended a flush to help combat some of the issue. Service center did note that this issue would not fix the problem, but put off needing to replace the engine. Oil light was not flashing on the dash unless coming to a quick stop, but then would disappear. The value of these cars has resulted in quite a bit of negative equity for folks due to the theft issue. Now add on a fear of blowing an engine cause your vehicle is burning through oil like no tomorrow.

I was driving on the high way and the car loose power completely have to do change oil every two weeks and can’t find a solution