2025 Kia Sorento Engine Problems

I am reporting a loss of propulsion event in a 2025 Kia Sorento S AWD. The vehicle experienced a sudden loss of drive power when pressing the accelerator. The engine did not respond normally and the vehicle entered a reduced power (limp mode) condition. Stopping in the middle of major intersections, [XXX] and then [XXX] and [XXX] at 4:30 pm. This vehicle is subject to Recall 25V548 involving engine connecting rod bolts, which warns of possible engine damage and loss of propulsion. The dealership (Gettel Kia of Bradenton, FL) stated they were unable to duplicate the issue. The recall language states that engine damage or loss of propulsion may occur and could create a safety hazard. This event occurred at approximately moving from a stop position to ? mph on [XXX]] with approximately 1,936 miles on the vehicle. As I drove it home it would disengage and reengage. I am concerned about the safety of continued operation given the recall notice and the propulsion failure experienced. VIN: [XXX] Please advise. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle has an ongoing acceleration problem that feels like the engine and transmission are not communicating correctly. There are times when the vehicle will not accelerate even though the RPMs increase. Instead of picking up speed, it feels like the engine is pulling the vehicle back. This creates hesitation and uncertainty about whether the car will respond when I press the accelerator. This happens most noticeably at lower speeds (around 30–40 mph, often near 30 mph), where the RPMs may rise on their own even if I am maintaining steady pressure on the gas pedal. It also occurs when I need to accelerate quickly — such as merging onto the freeway or joining the flow of traffic — and the vehicle feels like it resists gaining speed. Even when I press the pedal gradually and correctly, the vehicle struggles to accelerate and the engine revs without the car moving forward as it should. I reported this to the dealership. They ran diagnostics and told me no issues were detected. They also stated they cannot take action unless they can re-create the problem themselves. Because this does not happen every time, recreating it on command is very unlikely, leaving me without a solution. This is a safety concern because hesitation or failure to accelerate properly during merging or crossing traffic increases the risk of collisions. The problem remains unresolved.

The inverter radiator is punctured during typical road use by road debris. This results in a total loss of circulating coolant in the inverter/electric motor cooling system. This renders the car undrivable, with a concern for electric motor overheating, given that the hydrid mode and electric power can not be turned off. This is available for inspection. It is unclear whether the electric motor will shut down when overheated, but seizing of the motor or fire seems possible. Reproducibility: There are many examples online of this occurring during normal road use of Kia electric and hybrid vehicles. There is a warning 'Check drive motor cooling system' in this model. This appeared during driving and reamined on while the coolant was depleted. Refilling coolant turned the light off but with coolant being actively sprayed out of the pin hole in the radiator at all times (the pump does not turn off when the engine is cold) resulting in rapid coolant loss.

My Sorento has a transmission issue or something similar. It slips, it dies down and sometimes when I come to a stop and try to move, it won’t move. I have to put it back in park and then put it in drive. I have had several near miss accidents due to all these issues. It has been repaired twice but it has never fixed the issue and the dealer claims there is nothing wrong.