2022 Lincoln Aviator Electrical System Problems

high voltage alert and vehicle shuts down and unable to drive and car locks up Should be recall# 23s53 and NHTSA campaign # 23v-626 It has not been repaired yet and this is very frustrating has happened 4-5 times Last incident happened on 11/7/2025 inside of a car wash & had to get towed

Emergency escape issue Like many modern cars the aviator was designed with electric opening doors. Of the four doors, only the front driver side door has a manual override in case of emergency. That means if a major accident was to occur on that ONE door and disable the vehicle the other 3 doors do not have a way to exit. Why would the nhtsa allow a vehicle on a road that at a minimum doesn't have a override for left side and right side or more than one door?

My Aviator was parked with trunk open to load groceries from shopping cart. Must have stepped under bumper such that it triggered the kick sensor to close the tailgate. The problem is, it did NOT detect spouse’s body, did NOT stop the tailgate from closing & as a result, hit him on the head. He jolted out of the way & the tailgate continued to close all the way. This is serious safety issue!

1- ABS/Braking Issue The ABS system appears to be malfunctioning. On multiple occasions, typically once or twice a week, when I apply the brakes, the tires lock up and cause the vehicle to skid. This happens most often when descending hills or backing up on a sloped driveway. The wheels lock and slide until I release the brake pedal, posing a serious safety concern. 2- Severe Water Leak Interior Roof Area There is a significant water leak from the interior roof, specifically from the top center area near the rearview mirror, every time it rains. I’ve taken the vehicle to the dealer multiple times. They confirmed that all drain tubes are clear, all seals are functioning properly, and no water appears to be entering from the sliding moonroof. However, the issue persists. Water pours down like a waterfall through the vent (as shown in the attached photo), soaking the center console and creating an unsafe driving condition. I have also recorded videos showing the water intrusion. Living in Guam, where it rains frequently, this has become a major problem. 3- Malfunctioning Interior Ceiling Light The ceiling light on the driver's side (center dome light) turns on randomly and often remains on until manually switched off. The dealer has inspected this issue but reported no faults found. Despite this, the problem continues to occur intermittently. 4- Rear Camera Display Issue When shifting into reverse, the monitor occasionally turns completely blue, and the backup camera does not function. The blue screen remains until the vehicle is turned off and restarted. This happens sporadically and disrupts safe maneuvering.

Door ajar notification continues to illuminate when all doors are secure. First incident happened on 1/25/2022. Was sent in for repair and returned on 2/2/2022. Issue happened again while driving on the interstate on 3/10/2022, and is back in for repair. This notification causes domes lights to continue to illuminate which is a danger at night, and will not allow for doors to lock.

Lincoln Aviators 2020-2024 using the Sync 3 Radio screen. Have a issue not switching to dimmed/night mode during night time driving. This is a major safety issue because when driving a night you have a super bright display inches from your eyes creating a blinding issue at night. This issue has been reported by many folks, a simple Google search will reveal this. Unless NHTSA steps if to doing something 10s of thousands Lincoln Aviators 2020-2024 are on the road with blinded drivers. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)