2018 Lincoln Navigator Steering Problems

Vehicle: 2018 Lincoln Navigator VIN: [XXX] Component: Steering Mileage: 103899 Complaint Narrative: I recently purchased a 2018 Lincoln Navigator and took delivery on December 10, 2025. Within days of delivery, I observed a metallic contact noise originating from beneath the steering column. The noise occurs consistently when the vehicle is turned off, within one to three seconds after ignition off, and intermittently while driving during steering input, particularly while making turns. The sound is best described as metal on metal contact, not an electronic relay or normal operational noise. The condition appears load dependent and reproducible. The steering response remains functional at this time, and no warning indicators are present. However, because the noise occurs during active steering, I am concerned about possible mechanical interference, wear, or binding within the steering column or related steering components, which could worsen over time and affect steering control. The vehicle has a prior manufacturer buyback history from 2021, and I am documenting this concern to ensure that any steering-related condition is evaluated and tracked as a potential safety issue. I have scheduled a service appointment for diagnostic evaluation. This complaint is submitted to document a steering system concern identified immediately after purchase and delivery, involving noise during active steering operation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The back up camera will randomly black out. The steering wheel motor is broke and the steering wheel does not adjust. Needed a new air conditioner motor, timing chain, had a transmission leak, wheel axel leak. This is a safety hazard and caused a huge financial strain.

The contact owns a 2018 Lincoln Navigator. The contact stated that while operating the vehicle, there was a clunking noise coming from the steering column while turning the steering wheel in either direction. The vehicle was taken to the local dealer who diagnosed that the steering rack was faulty and needed to be replaced. The steering rack was replaced the vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 70,000.

Dealership Responsible: Ted Britt Ford of Chantilly Dealership Address: 4175 Auto Park Cir, Chantilly, VA 20151 Complaint Details: I purchased a 2018 Lincoln Navigator L Black Label, and since then, I have experienced multiple serious mechanical failures due to an improperly performed cam phaser repair by Ted Britt Ford of Chantilly in 2020. The dealership’s service department performed a faulty installation, which resulted in: •Missing and broken screws in the cam phaser system •Jerking, rattling, and acceleration issues •Significant engine damage requiring a complete short block replacement As a result of this in negligent repair, In 2024 I had to replace the cam phaser again, along with replacing the short block of the engine due to the extensive damage caused by the dealership’s poor workmanship. In addition to this issue, I have faced multiple other failures, including: •Valve body replacement •Wastegate failure •Rear heat stopped working •Steering column failure These problems have caused frequent breakdowns and safety concerns, making the vehicle unreliable. The constant need for repairs raises serious questions about the quality of Lincoln’s engineering and service network. This issue is not an isolated incident, and I strongly urge NHTSA to investigate potential defects in the 2018 Lincoln Navigator and to hold dealerships accountable for performing unsafe and defective repairs. Requested Action: I request an investigation into the faulty cam phaser repair process and whether similar issues are being reported by other 2018 Lincoln Navigator owners. This could indicate a larger systemic defect or a trend of poor-quality repairs in Ford/Lincoln service centers

STARTED VEHICLE AND WENT TO ADJUST STEERING WHEEL I PUSHED THE DOWN BUTTON TO LOWER AND STEERING WHEEL DROPPED. STEERING WHEEL IS NO LONGER ABLE TO ADJUST UP OR DOWN ONLY FORWARD AND BACKWARD. WHEN PUSHING THE UP/DOWN BUTTON A GRINDING SOUND OCCURS. WHEN DRIVING STEERING WHEEL FEELS LOOSE AND WILL PULL TO THE RIGHT.