2003 Mercedes-Benz C-Class Powertrain & Transmission Problems

"CHECK COOLANT LEVEL" LEVEL WARNING SIGN WAS ON. APPARENTLY, THERE IS LEAKING OF COOLANT SOME WHERE. IT WAS AT THE WATER PUMP, WHICH WAS REPLACED ON JUNE 20, 2019. IT HAPPENS AGAIN NOW, ABOUT 9 MONTHS LATER.

AT 178,000 MILES THE TIMING CHAIN TENSIONER FAILED WHILE THE CAR DRIVING APPROXIMATELY 25 MPH AND ALLOWED THE TIMING CHAIN TO SKIP SEVERAL TEETH LEAVING THE CAR STRANDED AND POTENTIALLY CAUSING THOUSANDS OF DOLLARS WORTH OF DAMAGE TO THE ENGINE INTERNALS. THE CAR WAS DEALER SERVICED SINCE NEW AND ALWAYS HAD MAINTENANCE ON TIME. THERE IS THOUSANDS OF PEOPLE ONLINE THAT HAVE HAD THE EXACT SAME ISSUE AND MERCEDES BENZ USA REFUSES TO DO ANYTHING ABOUT IT YET THEY ACKNOWLEDGE THEY MADE THEM WRONG BECAUSE THEY HAVE UPDATED THE CHAINS AND TENSIONERS.

2003 MERCEDES C320. CONSUMER WRITES IN REGARDS TO A SAFETY RECALL TRANSFER CASE *TGW THE CONSUMER WAS INFORMED THAT DUE TO THE MILEAGE ON THE VEHICLE, THEY WOULD NOT BE WILLING TO ASSIST WITH ABSORBING SOME OF THE COST FOR THE REPLACEMENT PART. *JB

MY MERCEDES-BENZ C-240 (2003 MODEL), HAVING LESS THAN 18500 MILES, SUDDENLY LOST POWER AFTER SOME 2-HOUR WORTH OF FREE-WAY DRIVING. AROUND NOON ON FRIDAY, 8/26/05, I WAS DRIVING SOUTH -BOUND ON I-15 PAST VICTORVILLE (CA), ABOUT 9 MILES PAST THE EXIT FOR ROUTE 18, WHEN MY C-240 SUDDENLY LOST POWER. AS I DEPRESSED THE ACCELERATOR, I FELT NO POWER AND THE RPM WAS DECREASING. IT FELT LIKE THE ENTIRE ENGINE-TRANSMISSION SYSTEM WAS SHUTTING DOWN. THERE WAS NO PRIOR WARNING. I MADE RIGHT TURN SIGNAL LETTING OTHER VEHICLES KNOW I WAS COMING OFF THE FREE-WAY. I MANAGED TO PULL OFF TO THE RIGHT SHOULDER SAFELY AND CAME TO FULL STOP ON THE GRAVEL. AT THAT TIME, MY DIGITAL ODOMETER READ "1 MALFUNCTION". USING MY CELL PHONE, I IMMEDIATELY CALLED THE MERCEDES HOTLINE. THE ROADSIDE ASSISTANCE REPRESENTATIVE, KRISTIN, ADVISED ME NOT TO DRIVE THE VEHICLE, EVEN AFTER THE "1 MALFUNCTION" SIGN BECAME "NO MALFUNCTION" A LITTLE LATER. MY VEHICLE WAS TOWED TO A MERCEDES-BENZ DEALER IN RIVERSIDE, SOME 50 MILES AWAY. AT THE DEALERS SERVICE DEPT, AFTER A BASIC CHECK INVOLVING COMPUTER AND ELECTRONICS, SOME FAULTY IDENTIFICATIONS WERE MADE, BUT IT WAS DETERMINED TO BE SAFE AND DRIVABLE. I DROVE MY VEHICLE HOME, PLANNING TO HAVE A MAJOR CHECK UP LATER. *JB

ROUGH IDLE; RATTLING NOISE IN ENGINE AREA, HARSH SHIFTING, NO THROTTLE RESPONSE, HESITATES WHEN ACCELERATING WITH A CLICKING SOUND, WINDOW CONTROS SCRATCH WINDOW TINT

THIS IS A 2003 C230 KOMPRESSOR; MANUAL TRANSMISSION. CHECK ENGINE LIGHT CAME ON; IN FOR SERVICE 4 TIMES; CYLINDER HEAD NEEDS TO BE REPLACED/ VALVES NOT SEATED PROPERLY. NOW MB SAYS THEY CAN'T FIND PARTS.*AK

2003 C230 HAS TRANSMISSION THAT JERKS, AND REQUIRES EXCESSIVE EFFORT TO GET VEHICLE TO MOVE WHEN IN REVERSE, ALSO HAS WEAK RIM DESIGN, AND BEND EASILY, HIT POT HOLE ON HIGHWAY AND BENT FRONT RIM. *AK

I BOUGHT MY MERCEDES C230 KOMPRESSOR 9 DAYS AGO. IT HAS ONLY 380 MILES ON IT. 2 DAYS IN A ROW WHEN THE CAR IS PLACED INTO DRIVE THE ENTIRE VEHICLE SHAKES VIOLENTLY. MERCEDES IS GOING TO ATTEMPT TO FIX THE PROBLEM. SS. *AK