2004 Mercedes-Benz E-Class Complaint Log

I am submitting this complaint regarding a suspected safety-related defect involving the fuel system of my Mercedes-Benz vehicle. I have experienced a persistent gasoline odor originating from the vehicle. The presence of fuel odor is not a normal operating condition and reasonably indicates a potential failure involving the fuel tank, fuel lines, or related fuel system components. Fuel vapors present a known fire and explosion hazard and constitute a safety risk to vehicle occupants, surrounding vehicles, and property. This condition was not present prior to the issue and has persisted despite inspection. I reported this concern to Mercedes-Benz USA and referenced that fuel odor and fuel tank-related defects have been documented in other Mercedes-Benz vehicles. During my communication with Mercedes-Benz USA, I was informed that an extended or long-term warranty related to the fuel tank or fuel system had existed but was no longer applicable because the coverage period had expired. I was not made aware of this extended warranty at the time it was active and therefore had no opportunity to seek inspection or repair while coverage was in effect. Mercedes-Benz USA has acknowledged my complaint but has declined to provide corrective action beyond internal review. Given the safety implications of fuel system defects and the potential impact of inadequate disclosure of extended safety-related warranty coverage, I am requesting that NHTSA document this complaint and evaluate whether this condition represents a broader defect trend and whether recall or further investigation is warranted. This complaint is submitted to ensure the issue is formally recorded as a potential fuel system safety defect.

SBC braking system stated as covered under 25 year/unlimited miles warranty. SBC system failed on 2/1/25. Vehicle towed to local dealer service facility on 2/3/25. Tow was authorized at no charge by MB Roadside Assistance at no charge plus $100.00 credit toward diagnostic. Was told by phone on 2/3/25 that upon confirmation that SBC did in fact fail, the SBC replacement would be performed at no charge due to warranty through 2028. As of 2/10/25 service facility did confirm that the SBC system had failed. Currently, MB USA has a HOLD pending for authorization of repairs, with no reason given as to why as of 2/13/25.

To Whom It May Concern, I took my 2004 Mercedes-Benz into the Stevens Creek location located in San Jose, CA 95129 to have the sliding roof bonding recall fixed on December 24, 2024. I have attached the repair invoice to this complaint. It has now been almost two full months and I am still being blocked from updating my vehicle registration because my vehicle needs to complete an Official Brake and Light Adjustment Certification. However, the recall vin lookup page (https://vinrcl.safercar.gov/vin/) has been showing my recall as incomplete for almost two full months now. The mechanic that performs the Brake and Light inspection says the vehicle will fail the test until the recall vin lookup page displays a 0 for my vehicle. Once again, this issue is preventing me from updating my vehicle registration until the recall vin lookup page shows the successful completion of the vehicle recall performed on December 24, 2024 at Mercedes-Benz of Stevens Creek. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The sunroof has a recall due to the fact that it has a bad seal, which could fly off due to this issue. I know the seal is bad because the whole roof leaked a few years ago and fried all the electronic; e.g. lights, sunroof controls, trunk light controls, side door controls. I went to the dealership and they said they would not fix it because they could not open the sunroof to see the manufacturer date on it.

The contact owns a 2004 Mercedes-Benz E320. The contact received notification of NHTSA Campaign Number: 19V918000 (Visibility); however, the contact was informed by the dealer that the sunroof glass was manufactured in a year outside of the year stated in the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that the sunroof glass was not covered under the recall. The contact had not experienced a failure. Parts distribution disconnect.

Vehicle started smoking and caught fire while I was driving. Pulled over and vehicle erupted in flames. It took firefighters 2 hours to put out that fire.

Mercedes Benz has a KNOWN safety problem with this model and has not put it under recall yet and it needs to be. The wire casing in the wiring harness for the headlights crumbles and leaves exposed wires that touch, short, and draw causing dim headlights. Due to being cited for dim headlights the night before, I called MBUSA on December 27 2023 and they initially REFUSED to take a case from me.

The driver's side mirror auto-dim function failed (as theorized by simple research where others have this issue) December 2023 and leaked a liquid behind the glass causing blurriness, double vision, and extremely dim reflection. This makes it difficult to safely judge other traffic using the mirror and seems very dangerous while driving. It also seems to present a risk of misjudging any other objects on the road which are reliant on this mirror. The equivalent replacement mirror glass alone is prohibitively expensive and Mercedes-Benz USA was contacted twice for help and refused to provide help or replacement. Neither the manufacturer nor another entity has inspected it yet. The mirror is available for inspection upon request. The passenger side view mirror is not auto-dimming so there is no issue.

The contact owns a 2004 Mercedes-Benz E320. The contact stated that the headliner had detached from the sunroof causing rainwater to enter the interior of the vehicle. The contact received notification of NHTSA Campaign Number: 22V954000 (Visibility). The vehicle was taken to the dealer where the recall repair was documented as completed. The vehicle was not repaired. The contact stated that the recall repair was not completed, and the failure persisted. The contact stated that the sunroof was manually closed by the dealer and advised the contact to never open the sunroof. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 118,000.

The contact owns a 2004 Mercedes-Benz E320 equipped with Arroyo Tires, Tire Line: Grand Sport ZR A/S, Tire Size: 225/55/R16, DOT Number: (N/A). The contact stated while driving at an undisclosed speed, he heard an unusual sound coming from the rear tires. The contact parked the vehicle and became aware that the rear tires tread had separated, and the steel belts were visible. The tires were not replaced. The dealer was not made aware of the failure. The contact stated that the tires were replacement tires purchased at Pep Boys. The manufacturer was not made aware of the failure. The vehicle failure mileage was approximately 250,000. The tire failure mileage was approximately 35,000.

October 26, 2022 my 2004 Mercedes model E320 W211 VIN # [XXX] dash pop out warning " Brake Wearing visit workshop" October 27, 2022 I had the brake pads and wear sensors both replaced and test drive verified car running normal for 30 minutes then dash pop out RED warning "Brake malfunction stop vehicle" plus transmission shifter stick to parking port can not be shift to other position, so can not drive and car being forced to stop on the road, I managed to press the lock off so can shift out of parking but there has no brake function when driving, I called MB USA and being advised that my car qualified to 25 years extended warranty for SBC hydraulic pump repair, 2005070007 2005110001 but when I tow my car to Mercedes dealer they said it only repair the Recall: 2020040011 - Sliding Roof Bonding - Phase 2, but the SBC Hydraulic pump may be at additional service charges, Please help investigate why Mercedes USA said it is under 25 years extended warranty while dealer said it might not qualify? car can not drive because of the SBC hydraulic pump problem and defected the driving safety? Best Regards/[XXX] email: [XXX] tel: [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2004 Mercedes-Benz E500. The contact stated while driving 55 MPH, there was an abnormally strong fuel odor inside the vehicle. The contact stated that upon making a stop, he noticed fuel leaking onto the driver's side rear wheel. The vehicle was taken to an independent mechanic where it was diagnosed that the failure was associated with an unknown recall for the fuel tank. The dealer was notified of the failure and informed the contact that the vehicle was out of warranty. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 71,000.

Total brake failure Had to cross the over to the other side of the road to turn around. Was almost hit by an oncoming big rig truck . I've looked it up and this is a common occurrence on these vehicles,! They have a SBC unit that has caused numerous incidents exactly like mine . Someone could easily be killed because of this defect. I've read that they extended the warranty for 25 years . But I haven't been notified. They notified me about a recall of the sun roof but not this!!

Extreme Gas Odor after filling gas tank and during time of driving.

the car has smelled like gas from the minute i received it. the previous owner told me that mercedes had quoted 5 grand to fix it so i would only put half a tank in at a time. turns out there was a warranty on it but has since expired. why wasn't it fixed for free when the previous owner brought it? this is very dangerous and can cause an explosion. the warranty should have been fixed rather than quoted and seems very greedy to not disclose that information but instead giving a quote. i have lung and heart problems and this is a definite safety issue that needs to be corrected regardless of the age of the car also brought it to dealership scared and they told me too bad it's been too long. how is a gas leak an ok thing to dismiss?????? i have been trying to get this fixed for years and this is my 2nd attempt for a recall with no response at all

My car seat belts not fastened and car door warning devices stop working. I took it to the Mercedes service department and told and showed them the safety system was not warning me when my door was not properly closed or when I removed the seat belt while driving. They told me that they needed to replace my instrument cluster in order to fix the issue. They charged me almost $2300.00 to change the panel. When I went to pick the vehicle up. And I drove off and took my seat belt off to see if the repair was done and no warning light came on. I than while driving through a parking lot open my door and no warning happened. Now the dealership is telling me that their is nothing they can do to address this dangerous safety issue and that I have no recourse to get what I paid for. Because Mercedes Benz Corp will not allow them to code the new instrument cluster. I was driving one day and did not realize the door was ajar until I hit a bump and heard the rattling. I have spoken with other Mercedes Benz owners of my model and found they've had this problem, but it is just too expensive to repair. I have been dealing with this now since December of 2021 and now no one from the dealership is returning any calls or offered a answer to this issue. I have spoken with the Service Director last on February 7 2022. And he has not reached out to me since.

The glue around front windshield has deteriorated and has caused major damage to my interior lights, electrical essemblys , interior damage to seats , dash board and flooring. Including the trunk seal is also deteriorated and causing the battery to stop working and has made my car non drivable.

The contact owns a 2004 Mercedes-Benz E55. The contact stated that upon placing fuel into the gas tank, a strong gasoline odor began to emit from the vehicle. Upon inspection, the contact removed the rear seat and saw that fuel had leaked from the fuel pumps. The contact reached out to the manufacturer through the manufacturer’s website and his request to repair the vehicle was denied. The contact wrote a letter to the manufacturer and the manufacturer denied the repair a second time. The contact stated that the same failure occurred back in 2008 and that the vehicle was repaired under a manufacturer’s recall. The vehicle was not repaired. The failure mileage was approximately 111,000.

The TRUNK will not open. It is supposed to open by pressing the button on the key fob or taking the thin key out of the key fob and manually open the truck with the keyed lock. Neither method works. There is absolutely no way to open the trunk otherwise (i.e. inside button or lever). When the key fob button and the thin key do not work there is absolutely no way to open the truck. There is no way to access the lock from the trunk lid rear and there is no way to access the trunk from behind the back seat cushions. It is a very bad situation and dangerous.

The contact owns a 2004 Mercedes-Benz E500. The contact stated while driving at various speeds, the brake malfunction warning light was illuminated on the instrument panel. The vehicle was taken to an independent mechanic where it was diagnosed with the SBC hydraulic unit needing to be replaced. The vehicle was not repaired. The contact was relating the failure to NHTSA campaign number: 04V296000 (Service brakes, Hydraulic). The manufacturer had been informed of the failure and referred the contact to the local dealer. The failure mileage was approximately 199,700.

The vehicle will flood after being exposed to rain which has caused all sorts of electrical issues. I have read online where several others have filed lawsuits regarding E class Mercedes for similar issues. The car’s interior will take on water and since there’s several electrical components running along the floor board of the car they will become damaged and cause the car’s computers and electrical system to go crazy. I picked up my car from having the oil changed at a local service shop a few days after it was repaired and I was driving back home after the service pick up and the car completely lost power. I got out of the car and opened the trunk in which I had to do so by using the key inside of the key fob. When I opened the trunk, I noticed that there was a little bit of water in the trunk which led me to open the back door and to my surprise there was standing water behind the driver seat. I checked the driver floor and it was soaked as well. I had the car towed back to the shop where I had the oil changed and the owner did not have the available equipment to test the car. I dried the car out over the next several days and drove to a local Mercedes dealership where they told me to do a full diagnostic on the car it would cost upwards of $19k. Are you kidding me? Now I know from reading others stories that this isn’t an unknown issue. So, what do I do now…file an insurance claim? I guess that would be the next step but they’ll turn around and get the money right back out of me by raising my policy rates. This is terrible. My car is a 2004 E320 with just under 65k miles on it.

VEHICLE HAS A RECALL ON REPLACEMENT OF FUEL TANK. MERCEDES BENZ DEALER DID NOT WANT TO HONOR THE RECALL. WHEN I FILL CAR UP WITH GAS IT LEAKS OUT OF THE TANK AND ON THE GROUND. MERCEDES-BENZ DEALER SAID I MISSED THE TIME FOR THE RECALL. I WENT TO THE DEALERSHIP BEFORE THE RECALL ENDED IN 2019 SPOKE WITH THE SERVICE ADVISOR AT THE MCKINNEY MERCEDES-BENZ DEALERSHIP AND I INFORMED HIM THE CAR WAS NOT DRIVABLE DUE TO THE BRAKING SYSTEM FAILURE CALL THE SPC HYDRAULIC PUMP. TURNS OUT THAT IS ALSO A RECALL THAT IS WIDELY KNOWN.AT THAT TIME THE CAR WAS NOT DRIVABLE AND THEN THE PANDEMIC HIT SO THERE WAS NO NEED TO TAKE IT UP THERE AT THE TIME DUE TO COVID. MERCEDES BENZ SHOULD HONOR THIS SINCE THIS IS A SAFETY ISSUE THAT COULD LEAD TO A DEADLY SITUATION IF NOT ADDRESSED. THEY HAVE BEEN DECEPTIVE BY MARKING THIS IS AN EXTENDED WARRANTY ISSUE AND NOT A SAFETY RECALL ISSUE. THEY PRETTY MUCH TOLD ME SINCE I DON'T HAVE MY CAR WORKED ON AT THE DEALERSHIP, THEY DON'T WANT TO HELP ME IN THIS SITUATION. THEY MENTIONED HAD THE CAR BEEN SERVICED AT THE DEALERSHIP AND NOT AT THE INDEPENDENT SHOO THAT I USED I MAY HAVE HAD A BETTER CHANCE AT THEM COVERING THE CHARGES FOR THIS TANK REPLACEMENT.

RECEIVED THE CAR FROM MY DAD AS A GIFT STONG SMELL OF GAS COMING FROM INSIDE ONLY RELIABLE TRANSPORTATION FOR OUR NEWBORN BABY NOW DONT KNOW WHAT TO DO... LOOKED ALL OVER THE INTERNET AND FOR RECALLS AND SEEN A FEW.. BUT THEN I SEE ALOT OF PEOPLE SAYING NOTHING HAPPENS... JUST SAYING WITH SOMETHING THAT HAD A PREVIOUS RECALL ON AND IF SOMETHING WOULD TO GO WRONG WITH ANYONE'S FAMILY THAT IS A HELL OF A LAWSUIT....

I FILLED THE GAS TANK FULL AND ON PULLING IN THE GARAGE COULD SMELL A STRONG SMELL OF GASOLINE... WENT TO GET MY OIL CHANGE THE NEXT DAY AND THE GENTLEMAN MENTIONED HE COULD SMELL GAS COMING FROM MY CAR AT VALVOLINE OIL CHANGE.... VERY STRONG SMELL IN THE INTERIOR OF THE CAR AS WELL AS WHEN WALKING AROUND THE OUTSIDE OF THE CAR YOU COULD SMELL A STRONG SMELL OF GAS... THE GENTLEMAN FROM VALVOLINE LOOKED UNDER THE CAR AND SAID THERE'S SOME TYPE OF COVER THAT GOES UNDERNEATH THE GAS TANK ITSELF AND PUT HIS FINGER INTO IT AND COULD TOUCH GASOLINE ON HIS HAND... I JUST WENT ONTO THE INTERNET AND READ MANY MANY COMPLAINTS OF THE SAME THING WITH THIS TYPE OF CAR LAWSUITS HAVE BEEN FILED... IN THOSE COMPLAINTS THE PEOPLE THAT BROUGHT THEIR CAR TO DEALERSHIP SAID THAT IT WAS VERY EXPENSIVE TO REMEDY AND THAT THERE SHOULD HAVE BEEN A RECALL... AFTER DRIVING A LITTLE BIT AND REDUCING THE AMOUNT OF GASOLINE IN THE TANK THE SMELL HAS SUBSIDED SOMEWHAT... THOSE COMPLAINTS ALSO MENTION THAT IT CAN BE VERY DANGEROUS WITH THIS TYPE OF LEAK

ON 12/16/2020 WHILE DRIVING THE BRAKES ON MY VEHICLE FAILED. A RED WARNING TRIANGLE APPEARED ON THE VEHICLE MESSAGE BOARD STATING THE CARS BRAKING ABILITY WAS SEVERELY REDUCED AND TO STOP DRIVING IMMEDIATELY. I WAS ABLE TO DRIFT TO THE SIDE OF THE ROAD WITHOUT INCIDENT AND HAD THE VEHICLE TOWED TO MY MECHANIC. THE MECHANIC COULD FIND NO MECHANICAL REASON FOR THE BRAKE FAILURE. THE RED WARNING LIGHT WAS GONE AND THE BRAKES WERE FUNCTIONING NORMALLY. ONLINE RESEARCH REVEALED AN EXTENDED WARRANTY/RECALL FOR THE YEAR, MAKE AND MODEL OF THE CAR RELATED TO BRAKE FAILURE. MERCEDES WILL REPLACE THE SENSORTRONIC BRAKE CONTROL MODULE (SBC) FREE PROVIDED THE CORRECT CODES ARE EVIDENT WHEN THEY DIAGNOSE THE CAR.(SAFETY RECALL #2005110001 I BELIEVE) MY MECHANIC SAID THAT THERE ARE NO CODES SHOWING FOR THE BRAKES AND THE BRAKES ARE NOW FUNCTIONING. MY ONLINE RESEARCH HAS SHOWN THAT THIS CAN BE AN INTERMITTENT PROBLEM AND THE DEALERSHIPS ARE RELUCTANT OR WILL NOT REPLACE THE SBC IF THERE ARE NO CODES. AFTER CONTACTING MERCEDES THE CAR IS BEING TOWED TO THE DEALERSHIP AS I TYPE THIS. I AM HOPEFUL THAT MERCEDES WILL DO THE CORRECT THING AND REPLACE THEIR ADMITTEDLY FLAWED BRAKE MODULE BUT IT ISN'T LOOKING GOOD AS THEY SAID IF THE CORRECT CODES DO NOT APPEAR THEY WILL NOT REPLACE. THE INSANE IDEA THAT I AM EXPECTED TO CONTINUE TO DRIVE THE VEHICLE UNTIL THE BRAKES FAIL AGAIN IN ORDER TO GET THEM REPLACED IS UNACCEPTABLE. I'M IN A NO WIN SITUATION.

The rear passenger side inside door handle will not open the door. This is an unacceptable safety hazard.

STRONG GASOLINE ODOR IN THE BACK OF THE CAR AFTER FILLING UP THE TANK. DEALERSHIP CONFIRMED THAT THE TANK NEEDS TO BE REPLACED. THIS ISSUE WAS COVERED AT SOME POINT BUT WAS NEVER DONE TO THIS SPECIFIC CAR VRTC-DCD-3206. I PURCHASED THE CAR A FEW WEEKS AGO AND WAS TOLD BY MB THAT THE PREVIOUS OWNER REFUSED TO DO THE FIX/SERVICE. THE PROBLEM IS STILL THERE THE CABIN HAS AN INCREDIBLY STRONG ODOR OF GASOLINE. IF THE FIX WAS OFFERED AT SOME POINT AND WAS NEVER DONE, WHY CANT THEY PERFORM IT NOW? QUOTE FOR FIX ATTACHED

GAS LEAK, THERE A STRONG GAS SMELL

SENSOR TONIC BRAKE SYSTEM LIGHT IN INTERMITTENTLY

I INHERITED THIS VEHICLE FROM MY FATHER AND WHEN I FUEL UP THE SMELL OF GAS IS OVERPOWERING. I CHANGED HOSES AND GASKETS IN 2018 AND WAS OK UNTIL 3 MONTHS AGO. NOW IT ALWAYS SMELLS LIKE GAS TO THE POINT OF LIGHT-HEADED AND VOMITING. CALLED MERCEDES THERE WAS AN ACTIVE RECALL THAT EXPIRED IN 2019 BUT I HAD NEVER RECEIVED NOTICES AND SPOKE TO MY MOTHER THAT ALSO NEVER RECEIVED. MERCEDES ADMITTED THEY HAD INCORRECT ADDRESS SO THEY WERE SENDING TO A DECEASED PERSON TO WRONG ADDRESS. BUT SINCE IT IS EXPIRED, THERE IS NOTHING I CAN DO FOR A FAULTY FUEL TANK THAT IS EXTREMELY DANGEROUS

TL* THE CONTACT OWNS A 2004 MERCEDES BENZ E500. THE CONTACT STATED THAT AFTER RELEASING THE DRIVER'S SEAT, THE SEAT BELT WARNING LIGHT ILLUMINATED WITH AN AUDIBLE CHIME. THE CONTACT ALSO STATED THAT REAR PASSENGER'S SEAT BELT FAILED LATCH SECURELY IN THE BUCKLE. ADDITIONALLY, THE CENTER SEAT BELT TONGUE CEASED IN THE BUCKLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V534000 (SEAT BELTS). THE FAILURE MILEAGE WAS 166,000.

SMELL OF STRONG GAS ODOR. RECALL EXPIRED LESS THEN ONE YEAR AGO SO MERCEDES WONT FIX IT. WHY IS THERE A CUT OFF DATE TO A POTENTIALLY DANGEROUS SITUATION? *TR

BAFFLE INSIDE FUEL TANK BROKE AFTER NORMAL USE, CREATING RATTLING NOISE, CANNOT BE REPAIRED AND REPLACEMENT OF TANK REQUIRES LENGTHY VEHICLE DISASSEMBLY. *TR

When the vehicle is has a full tank of gas, there are heavy fumes of gasoline in the interior of the car. It appears to be the fuel pumps that are underneath the rear seats, leaking fuel on top, next to the the wiring. It is a hazard for fumes and possibly a fire

BACK AIR BAG BEHIND DRIVER LOST AIR WHILE DRIVING. TOOK IN TO REPAIR THEY THOUGHT IT WAS AIR LINE. THEY REPAIRED BUT SAME THING HAPPENED LEAVING REPAIR SHOP AT AN INTERSECTION. ALL THE LIGHT TURNED ON TO STOP DRIVING JUST LIKE BEFORE. I TOWED BACK TO SHOP.THEY SAID THE WHOLE SYSTEM NEEDED TO ALL BE REPLACED.MY ONLY REASON TO FILE THIS IS THE FEAR I HAD OF GETTING HURT OR HURTING OTHER BY MY VEHICLE JUST BEING UNDRIVABLE WHILE IN MOTION ON MAJOR INTSECTION.THIS PROBLEM OCCURED BEFORE BUT ALWAYS WHEN LEAVING MY HOME SO ID JUST WAIT FOR THE AIR SUSPENSION SELF CORRECT. WHICH IT HAD BEFORE.I WAS ONLY GOING 15MPG OR SO WHEN IT GAVE OUT I WAS APPROCHING MY RIGHT HAND TURN. WE ARE AVAILABLE TO HELP WITH MORE DETAILS AND DOCUMENTATION IF NEEDED.

TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ E 320. THE CONTACT CALLED ON BEHALF OF HIS WIFE. THE CONTACT STATED WHILE THE VEHICLE WAS AT STAND STILL, THE DRIVER WAS UNABLE TO START THE VEHICLE. A MESSAGE ON THE INSTRUMENT PANEL SHOWED BRAKE MALFUNCTION STOP VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE BATTERY WAS DRAINED. THE VEHICLE WAS JUMP STARTED AND DRIVEN TO THE RESIDENCE. THE CONTACT CALLED AN INDEPENDENT MECHANIC WHO PROVIDED A DIAGNOSIS OVER THE PHONE. THE CONTACT WAS INFORMED THAT THE SENSOTRONIC BRAKE CONTROL (SBC) NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 05V133000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE VIN WAS NOT INCLUDED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 127,000.

2004 MERCEDES E320 HAS A STRONG GAS SMELL. TOOK VEHICLE TO DEALER AND FOUND OUT THAT "1/3 THE FUEL TANK HAS A COVER ON TOP OF IT-SANDWICHED BETWEEN THE TOP OF THE TANK AND THE FLOOR OF THE VEHICLE THE TANK IS LEAKING WHERE THE COVER MEETS THE 2/3 TANK WHEN YOU PULL THE BACK SEAT OUT YOU CAN SEE THE TANK TOP-FUEL IS SEEPING OUT STAINING THE SIDE OF THE TANK" I WAS TOLD THERE WAS A 15 YEAR EXTENDED WARRANTY DUE TO THIS ISSUE AND I WAS ADVISED IT EXPIRED. I WAS NEVER NOTIFIED OF THE EXTENDED WARRANTY AND I HAVE OWNED THE CAR FOR 12 YEARS. I REACHED OUT THE MERCEDES HEADQUARTERS AND THEY ADVISE ITS NOTHING THEY COULD DO. THIS IS A BIG SAFETY ISSUE BECAUSE THE CAR CAN CATCH ON FIRE. SHOULDN'T THIS HAVE BEEN A RECALL? DOES SOMEONE HAVE TO DIE BEFORE IT IS. MERCEDES STILL STATED NOTHING THEY COULD DO. THE TANK WILL COST $2300 AND THEY ADVISE NO AFTERMARKET AVAILABLE. THIS IS UNFAIR TO THE CONSUMER BY ALL MEANS. MERCEDES KNOWING KNEW THERE WAS A ISSUE AND NO RECALL HAS BEEN DONE

VERY STRONG FUEL ODOR WHEN HALF TANK OR MORE OF GAS. CANNOT PARK IN GARAGE OR WILL SMELL ENTIRE GARAGE WITH FUEL ODOR. ALSO HAD THIS PROBLEM WITH MY PREVIOUS CAR WHICH WAS A 2004 MERCEDES E500.

DRIVER IS EXPERIENCING A HEAVY ODOR OF GASOLINE AFTER FILL UP. VEHICLE IS NOT OVERFILLED/TOPPED OFF. VEHICLE WAS SITTING INSIDE GARAGE WHEN OWNER NOTICED A HEAVY FUEL ODOR AND NOTIFIED FIRE DEPARTMENT TO INVESTIGATE. PER RECOMMENDATIONS OF FIRE DEPARTMENT, KEEP VEHICLE OUT OF GARAGE UNTIL ISSUE COULD BE INSPECTED BY A QUALIFIED MECHANIC. MECHANIC INSPECTED FUEL SYSTEM AND FOUND FUEL LEAK UNDER REAR SEATS NEAR FUEL PUMP/SENDING UNIT. MERCEDES BENZ REFUSES REPAIR ISSUE SAYING IT IS NOT A SAFETY ISSUE. GASOLINE FUMES/VAPORS ARE ESPECIALLY HEAVY INSIDE A SINGLE CAR GARAGE, AND IF A IGNITION SOURCE IS INTRODUCED IT COULD BECOME FATAL.

TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ E320. THE CONTACT STATED THAT A BLUE LIGHT ILLUMINATED, WHICH MEANT THAT THE BRAKES NEEDED TO BE SERVICED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE BRAKES WERE SERVICED. A FEW MONTHS LATER, WHILE TRAVELING 30 MPH, THE BRAKES FAILED WITHOUT WARNING. THE CONTACT CONTINUOUSLY PUMPED THE BRAKE PEDAL UNTIL THE VEHICLE STOPPED. THE CONTACT HAD THE VEHICLE TOWED BACK TO THE INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH A SBC HYDRAULIC PUMP FAILURE. THE CONTACT TOOK THE VEHICLE TO MERCEDES-BENZ OF BEVERLY HILLS (9250 BEVERLY BLVD, BEVERLY HILLS, CA 90210, (310) 659-2980) WHERE THE VEHICLE WAS ULTIMATELY DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 106,000.

TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ E500. WHILE THE VEHICLE WAS BEING REFUELED, THE CONTACT BECAME AWARE OF A FUEL LEAK. THE CONTACT STATED THAT THERE WAS AN ABNORMAL ODOR DETECTED OUTSIDE OF THE VEHICLE. THE CONTACT STATED THAT THE THE INSTRUMENT CLUSTER WAS RED AND THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF GOLDENS BRIDGE 321 NY-22, GOLDENS BRIDGE, NY 10526, (914) 232-8122 TO BE DIAGNOSED. A FUEL LEAK WAS CONFIRMED HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED OR INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000.

FUEL SMELL AFTER FILLING WITH GAS. *TR

SMELL STRONG ODOR OF GASOLINE AFTER FILLING GAS TANK OVER PAST SEVERAL MONTHS

STRONG GAS SMELL INSIDE AND OUTSIDE. CHECK ENGINE CAME ON AND GAVE ME A CODE P0456. PLESSE ADVISE!

THE PROBLEM WITH MY VEHICLE IS THAT WITH ITS CURRENT TCM( TRANSMISSION CONTROL MODULE) IN A 722.9 TRANSMISSION, THE CONDUCTOR PLATE THAT HOLDS THE SENSORS IN PLACE BECOME DEFECTIVE AND CREATES A PROBLEM IN WHICH THE TRANSMISSION GETS STUCK IN 2ND GEAR. THIS CAUSES A MAJOR PROBLEM DRIVING ON ROAD WAYS THAT ARE +45MPH BECAUSE THE VEHICLE CANNOT DRIVE OVER 25MPH FURTHER CAUSING MORE PROBLEMS THAT MAY ACTUALLY FREEZE UP THE ENGINE CAUSING THE CAR TO STOP. IF THE CAR IS STOPPED AND BEGINS TO GO AGAIN, THE RMP'S CAN GO VERY HIGH WITHOUT ANY POWER OR MOTION IN THE VEHICLE. THIS HAS HAPPENED TO 2 OF MY PERSONAL FRIENDS ALREADY WITH THE 722.9 TRANSMISSION. IN PARTICULAR THE CONDUCTOR PLATE OR VALVE BODY WAS CORRUPTED AND CAUSED THE VEHICLE TO FAIL. I AM REPORTING THIS BECAUSE THE PART CAN FAIL ANYTIME DURING OPERATION OF THE VEHICLE AND IS A SAFETY ISSUE TO THE DRIVER AND OTHERS AROUND WHEN THIS MAY OCCUR. MANY OTHER OWNERS (I'VE READ ONLINE) WITH THIS 722.9 TRANSMISSION CONDUCTOR PLATE FAULT IS ALSO FRUSTRATED BY THE FACT THAT NOT ONLY MERCEDES-BENZ DOESN'T ALLOW FOR A CONSUMER TO BUY THE PART BUT MANY WARRANTIES ARE VOIDED WITH THIS FAULT. MY VEHICLE (MERCEDES-BENZ E500 2004) ALSO IS ONLY AT 56,000 MILES ON THE SPEEDOMETER. CONSIDERING THE MILEAGE, THIS IS A PROBLEM THAT SEEMS TO BE PREMATURE DUE TO THE FACT THAT THE VEHICLE HAS BEEN SERVICED BY A MERCEDES-BENZ DEALER BUT HAS NO SERVICE FOR THE VERY COMMONLY FAULTED PART.

TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ E320. THE CONTACT STATED THAT A FUEL ODOR WAS PERCEIVED INSIDE AND OUTSIDE THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE AMERICAN SERVICE CENTER DEALER (703-284-2500, LOCATED AT 624 S GLEBE RD, ARLINGTON, VA 22204) WHERE IT WAS DIAGNOSED THAT A CANISTER VALVE AND PURGE VALVE SHUT OFF AND CAUSED FUEL TO LEAK IN THE REAR OF THE VEHICLE. TECHNICIAN ADVISED THAT THE VALVES AND THE FUEL PUMP NEEDED TO BE REPLACED. THE CONTACT WAS TOLD THAT THERE WAS NO RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT REFERENCED NHTSA ACTION NUMBER: EA13003 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 140,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 MERCEDES-BENZ E320. WHEN THE FUEL TANK WAS FULL, A STRONG ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE AND IN THE GARAGE. MERCEDES-BENZ OF FAIRFIELD (165 COMMERCE DRIVE, FAIRFIELD, CT 06825) STATED THAT THE FUEL TANK SEAL MAY BE FAULTY. THE CONTACT PURCHASED A FUEL TANK SEAL AND HAD IT INSTALLED BY AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 82,000.

FOR SEVERAL MONTHS THERE HAS BEEN A STRONG ODOR OF GASOLINE AFTER FUELING THE VEHICLE. THE ODOR HAS BECOME STEADILY WORSE AND WE TOOK THE VEHICLE TO THE DEALERSHIP FOR ASSISTANCE. WE WERE TOLD THAT THE FUEL TANK WAS CRACKED AND HAD TO BE REPLACED. WHEN I INQUIRED HOW THIS COULD HAVE OCCURRED, I WAS TOLD IT COULD BE DUE TO IMPACT OR TRAUMA (WHICH IS IMPOSSIBLE AS THE VEHICLE WAS NOT INVOLVED IN ANY INCIDENT). WAS INFORMED THAT IT WOULD COST $2,300.00 TO REPAIR VEHICLE. CALLED MB-USA AND ASKED FOR ASSISTANCE. WAS INFORMED THAT THERE WAS NOT A RECALL ON THE FUEL TANK AND I WOULD HAVE TO PAY THE COST. AS THE VEHICLE WAS UNSAFE, I HAD THE WORK PERFORMED AND RECEIVED A 10% "GOODWILL" DISCOUNT. PICKED UP VEHICLE AND DROVE A SHORT DISTANCE AND CONTINUED TO SMELL FUEL. CALLED DEALERSHIP AND THEY CAME TO PICK-UP. ACKNOWLEDGED THAT THEY DID NOT TIGHTEN A CLAMP OR SOMETHING. WE PICKED IT UP AGAIN AND THE ODOR WAS PERSISTENT. IMMEDIATELY CALLED THE DEALERSHIP BACK AND WE SUBSEQUENTLY TRADED THE VEHICLE IN. BOTTOM LINE.... I DO NOT THINK THAT A FUEL TANK SHOULD FAIL ON A VEHICLE WITH LESS THAN 80,000 MILES. I HAVE THE OLD TANK AND BELIEVE THAT MB SHOULD REIMBURSEMENT FOR THE COST OF THE TANK.

FUEL TANK LEAK, SMELL GAS

WHILE PARKED, ENGINE WOULD DIE IMMEDIATELY AFTER I STARTED IT. MECHANIC DISCOVERED FUEL SEEPING OUT OF TOP OF FUEL SENDING UNIT IN FUEL TANK.